Genetic regulation of aflatoxin, ochratoxin A, trichothecene, and fumonisin biosynthesis: A review.

Mycotoxins are a significant food safety concern. Aflatoxins, trichothecenes, fumonisins, and ochratoxin A are considered the most important mycotoxins due to their frequent occurrence in food products and their well-known toxicity. The regulation of mycotoxin biosynthesis occurs mainly at transcriptional level, and specific regulators have been described in every biosynthetic cluster. Secondary metabolite production, including mycotoxin synthesis, is also regulated by general regulator pathways affected by light, osmotic stress and oxidative stress, among others. This review is focused on this genetic regulation of mycotoxin biosynthesis by specific genes and global regulators.

Significance of Aspergillus niger aggregate species as contaminants of food products in Spain regarding their occurrence and their ability to produce mycotoxins.

The Aspergillus niger aggregate contains 15 morphologically indistinguishable species which presence is related to ochratoxin A (OTA) and fumonisin B2 (FB2) contamination of foodstuffs. The taxonomy of this group was recently reevaluated and there is a need of new studies regarding the risk that these species might pose to food security. 258 isolates of A. niger aggregate obtained from a variety of products from Spain were classified by molecular methods being A. tubingensis the most frequently occurring (67.5%) followed by A. welwitschiae (19.4%) and A. niger (11.7%). Their potential ability to produce mycotoxins was evaluated by PCR protocols which allow a rapid detection of OTA and FB2 biosynthetic genes in their genomes. OTA production is not widespread in A. niger aggregate since only 17% of A. niger and 6% of A. welwitschiae isolates presented the complete biosynthetic cluster whereas the lack of the cluster was confirmed in all A. tubingensis isolates. On the other hand, A. niger and A. welwitschiae seem to be important FB2 producers with 97% and 29% of the isolates, respectively, presenting the complete cluster. The genes involved in OTA and FB2 were overexpressed in producing isolates and their expression was related to mycotoxin synthesis.

Aspergillus steynii and Aspergillus westerdijkiae as potential risk of OTA contamination in food products in warm climates.

Aspergillus steynii and Aspergillus westerdijkiae are the main ochratoxin A (OTA) producing species of Aspergillus section Circumdati. Due to its recent description, few data are available about the influence of ecophysiological factors on their growth and OTA production profiles. In this work, the effect of temperature (20, 24 and 28 °C) and water activity (aw) (0.928, 0.964 and 0.995) on growth, sporulation and OTA production by these fungi was examined in CYA and media prepared from paprika, green coffee, anise, grapes, maize and barley. Growth was positively affected by the highest temperature and aw values indicating that both species might be expected in warm climates or storage conditions. However, optimal growth conditions showed differences depending on the medium. OTA production was markedly affected by substrate and showed qualitative and quantitative differences. Both species, especially A. steynii, represent a great potential risk of OTA contamination due to their high production in a variety of conditions and substrates, in particular in barley and paprika-based media. Additionally, neither growth nor sporulation did result good indicators of OTA production by A. steynii or A. westerdijkiae; therefore, specific and highly-sensitive detection methods become essential tools for control strategies to reduce OTA risk by these species.

Structural variation and dynamics of the nuclear ribosomal intergenic spacer region in key members of the Gibberella fujikuroi species complex.

The intergenic spacer (IGS) region of the ribosomal DNA was cloned and sequenced in eight species within the Gibberella fujikuroi species complex with anamorphs in the genus Fusarium, a group that includes the most relevant toxigenic species. DNA sequence analyses revealed two categories of repeated elements: long repeats and short repeats of 125 and 8 bp, respectively. Long repeats were present in two copies and were conserved in all the species analyzed, whereas different numbers of short repeat elements were observed, leading to species-specific IGS sequences with different length. In Fusarium subglutinans and Fusarium nygamai, these differences seemed to be the result of duplication and deletion events. Here, we propose a model based on unequal crossing over that can explain these processes. The partial IGS sequence of 22 Fusarium proliferatum isolates was also obtained to study variation at the intraspecific level. The results revealed no differences in terms of number or pattern of repeated elements and detected frequent gene conversion events. These results suggest that the homogenization observed at the intraspecific level might not be achieved primarily by unequal crossing-over events but rather by processes associated with recombination such as gene conversion events.

Phylogenetic analyses and toxigenic profiles of Fusarium equiseti and Fusarium acuminatum isolated from cereals from Southern Europe.

Fusarium equiseti and Fusarium acuminatum are toxigenic species that contaminate cereal crops from diverse climatic regions. They are common in Spanish cereals. The information available on their phylogenetics and toxigenic profiles is, however, insufficient to assist risk evaluation. In this work, phylogenetic analyses were performed using partial sequences of the translation elongation factor gene (EF-1α) of F. equiseti and F. acuminatum strains isolated from barley and wheat from Spain and other countries. The Northern and Southern European F. equiseti strains largely separated into two phylogenetically distinct clusters. This suggests the existence of two distinct populations within this species, explaining its presence in these regions of markedly different climate. Production of type A and B trichothecenes by the Spanish strains, examined in wheat cultures using a multitoxin analytical method, indicated that F. equiseti could produce deoxynivalenol and nivalenol and other trichothecenes, at concentrations that might represent a significant risk of toxin contamination for Southern European cereals. F. acuminatum showed low intraspecific genetic variability and 58% of the strains could produce deoxynivalenol at low level. Neither species was found to produce T-2 or HT-2 toxins. The present results provide important phylogenetic and toxigenic information essential for the accurate prediction of toxigenic risk.

Searching for the Fusarium spp. Which Are Responsible for Trichothecene Contamination in Oats Using Metataxonomy to Compare the Distribution of Toxigenic Species in Fields from Spain and the UK.

The contamination of oats with Fusarium toxins poses a high risk for food safety. Among them, trichothecenes are the most frequently reported in European oats, especially in northern countries. The environmental conditions related to the climate change scenario might favour a distribution shift in Fusarium species and the presence of these toxins in Southern European countries. In this paper, we present an ambitious work to determine the species responsible for trichothecene contamination in Spanish oats and to compare the results in the United Kingdom (UK) using a metataxonomic approach applied to both oat grains and soil samples collected from both countries. Regarding T-2 and HT-2 toxin producers, F. langsethiae was detected in 38% and 25% of the oat samples from the UK and Spain, respectively, and to the best of our knowledge, this is the first report of the detection of this fungus in oats from Spain. The relevant type B trichothecene producer, F. poae, was the most frequently detected Fusarium species in oats from both origins. Other important trichothecene producers, such as the Fusarium tricinctum species complex or Fusarium cerealis, were also frequently detected in oat fields. Many Fusarium toxins, including T-2 and HT-2 toxins, deoxynivalenol, or nivalenol, were detected in oat samples. The results obtained in this work revealed a clear change in the distribution of trichothecene producers and the necessity to establish the potential of these species to colonize oats and their ability to produce mycotoxins.

Biocontrol of Mycotoxigenic Fungi Using Bacteria Isolated from Ecological Vineyard Soils.

The presence of mycotoxin-producing Aspergillus species in vineyards is a problem for food safety and the economy. In addition, rising temperatures due to climate change are modifying microbial communities, causing the replacement of some fungal species and the rise of mycotoxins such as aflatoxins. The use of microorganisms as biological control agents (BCAs) is one of the most promising strategies to prevent fungal growth and toxin production. In this study, 513 microorganisms were isolated from organic vineyard soils in different regions of Spain. The 480 bacteria and 33 yeasts isolated were sequentially screened to select those with the most suitable characteristics to be used as BCAs. After identifying 16 isolates meeting all requirements, six bacterial isolates were selected to test their potential to control three relevant toxigenic grape fungi in vitro: A. carbonarius, A. niger and A. flavus. Isolates of Arthrobacter sp., Rhodococcus sp. and Bacillus mycoides showed an excellent ability to reduce the growth and mycotoxin concentration of the above-mentioned fungi and represent potential candidates for further study regarding their possible industrial application as a BCA.

Diversity of Mycobiota in Spanish Grape Berries and Selection of Hanseniaspora uvarum U1 to Prevent Mycotoxin Contamination.

The occurrence of mycotoxins on grapes poses a high risk for food safety; thus, it is necessary to implement effective prevention methods. In this work, a metagenomic approach revealed the presence of important mycotoxigenic fungi in grape berries, including Aspergillus flavus, Aspergillus niger aggregate species, or Aspergillus section Circumdati. However, A. carbonarius was not detected in any sample. One of the samples was not contaminated by any mycotoxigenic species, and, therefore, it was selected for the isolation of potential biocontrol agents. In this context, Hanseniaspora uvarum U1 was selected for biocontrol in vitro assays. The results showed that this yeast is able to reduce the growth rate of the main ochratoxigenic and aflatoxigenic Aspergillus spp. occurring on grapes. Moreover, H. uvarum U1 seems to be an effective detoxifying agent for aflatoxin B1 and ochratoxin A, probably mediated by the mechanisms of adsorption to the cell wall and other active mechanisms. Therefore, H. uvarum U1 should be considered in an integrated approach to preventing AFB1 and OTA in grapes due to its potential as a biocontrol and detoxifying agent.

Genetic variability and Fumonisin production by Fusarium proliferatum.

Fusarium proliferatum is together with Fusarium verticillioides the main source of fumonisins, a health risk mycotoxin, contaminating agro-products. Contrary to F. verticillioides, it colonizes a wide range of host plants besides maize, such as wheat or barley among others, in particular in certain regions (Southern Europe). The phylogenetic study performed in this work using a wide sample of isolates from diverse hosts and origins revealed a high variability, while no host preferences could be sustained. A real time RT-PCR assay was also developed specific for F. proliferatum on the basis on fumonisin biosynthetic gene, FUM1, which allowed discrimination from F. verticillioides. FUM1 gene expression showed a high and significant correlation (0.77) with fumonisin production, representing a valuable tool for specific and sensitive diagnosis of metabolically active fumonisin-producing F. proliferatum isolates and for evaluating the influence on environmental conditions on FUM1 gene regulation. The ability to produce fumonisins was also widely distributed indicating that F. proliferatum can represent a risk for health similarly to F. verticillioides. Moreover, the wide range of plants susceptible to colonization by F. proliferatum suggests that the impact of fumonisin risk in a number of commodities might need a revision.

The Genomic Regions That Contain Ochratoxin A Biosynthetic Genes Widely Differ in Aspergillus Section Circumdati Species.

Aspergillus section Circumdati includes 27 species, some of which are considered ochratoxin A (OTA) producers. However, there is considerable controversy about their potential OTA synthesis ability. In this work, the complete genomes of 13 species of Aspergillus section Circumdati were analyzed in order to study the cluster of OTA biosynthetic genes and the region was compared to those previously reported in A. steynii and A. westerdijkiae. The results obtained reveal that the genomes of some species in this section, including A. affinis, A. cretensis, A. elegans, A. muricatus, A. pulvericola, A. roseoglobulosus, and A. subramanianii, contain a potentially functional OTA biosynthetic cluster. Therefore, they might be able to synthesize the toxin. On the contrary, A. melleus, A. ochraceus, A. ostianus, A. persii, A. sclerotiorum, A. sesamicola, and A. westlandensis contain a truncated version of the cluster that lacks many of the genes involved in OTA biosynthesis, which might be related to their inability to produce OTA. The gain/loss pattern is different in all species, which suggests that the genetic evolution of this region might be due to independent events.

A Comprehensive Study on the Occurrence of Mycotoxins and Their Producing Fungi during the Maize Production Cycle in Spain.

Mycotoxin contamination is one of the main problems affecting corn production, due to its significant risk to human and animal health. The Fusarium and Aspergillus species are the main producers of mycotoxins in maize, infecting both pre-harvest and during storage. In this work, we evaluated the presence of mycotoxins and their producing species along maize production cycles in three different stages (anthesis, harvest, and storage) during three consecutive seasons (2016-2018). Fungal occurrences were studied using species-specific PCR protocols, whereas mycotoxin levels were determined by LC-MS/MS. Fumonisin-producing Fusarium species (F. verticillioides and F. proliferatum), as well as the aflatoxin producer Aspergillus flavus, were the most predominant species at all stages; although, during some seasons, the presence of F. graminearum and A. niger aggregate species were also identified. Contrastingly, fumonisins were the only mycotoxins detected and levels were always under legal regulations. The results presented here demonstrate that even when fungal contamination occurs at the early stages of the maize production cycle, the application of good agricultural and storage practices might be crucial to ensure mycotoxin-free grains.

A Novel Niosome-Encapsulated Essential Oil Formulation to Prevent Aspergillus flavus Growth and Aflatoxin Contamination of Maize Grains During Storage.

Aflatoxin (AF) contamination of maize is a major concern for food safety. The use of chemical fungicides is controversial, and it is necessary to develop new effective methods to control Aspergillus flavus growth and, therefore, to avoid the presence of AFs in grains. In this work, we tested in vitro the effect of six essential oils (EOs) extracted from aromatic plants. We selected those from Satureja montana and Origanum virens because they show high levels of antifungal and antitoxigenic activity at low concentrations against A. flavus. EOs are highly volatile compounds and we have developed a new niosome-based encapsulation method to extend their shelf life and activity. These new formulations have been successfully applied to reduce fungal growth and AF accumulation in maize grains in a small-scale test, as well as placing the maize into polypropylene woven bags to simulate common storage conditions. In this latter case, the antifungal properties lasted up to 75 days after the first application.

Description of an orthologous cluster of ochratoxin A biosynthetic genes in Aspergillus and Penicillium species. A comparative analysis.

Ochratoxin A (OTA) is one of the most important mycotoxins due to its toxic properties and worldwide distribution which is produced by several Aspergillus and Penicillium species. The knowledge of OTA biosynthetic genes and understanding of the mechanisms involved in their regulation are essential. In this work, we obtained a clear picture of biosynthetic genes organization in the main OTA-producing Aspergillus and Penicillium species (A. steynii, A. westerdijkiae, A. niger, A. carbonarius and P. nordicum) using complete genome sequences obtained in this work or previously available on databases. The results revealed a region containing five ORFs which predicted five proteins: halogenase, bZIP transcription factor, cytochrome P450 monooxygenase, non-ribosomal peptide synthetase and polyketide synthase in all the five species. Genetic synteny was conserved in both Penicillium and Aspergillus species although genomic location seemed to be different since the clusters presented different flanking regions (except for A. steynii and A. westerdijkiae); these observations support the hypothesis of the orthology of this genomic region and that it might have been acquired by horizontal transfer. New real-time RT-PCR assays for quantification of the expression of these OTA biosynthetic genes were developed. In all species, the five genes were consistently expressed in OTA-producing strains in permissive conditions. These protocols might favour futures studies on the regulation of biosynthetic genes in order to develop new efficient control methods to avoid OTA entering the food chain.

Characterization of a novel cysteine-rich antifungal protein from Fusarium graminearum with activity against maize fungal pathogens.

Filamentous fungi are an invaluable source for biocontrol strategies and for production and development of different antifungal polypeptides. Within this context, cysteine-rich antifungal AFP-like peptides stand out among many different antimicrobial compounds given their production easiness, stability, versatility, and efficacy. AFP from Aspergillus giganteus represents the hallmark of this still increasing family of antifungal polypeptides. Close in silico analyses of the Fusarium graminearum genome revealed the presence of an AFP-like peptide, here designated as FgAFP. This new peptide was cloned, produced in the yeast Pichia pastoris, and characterized. The results obtained showed its strong and specific antifungal activity against several well-recognized maize pathogens, but inefficacy against F. oxysporum, which has not been described as a natural biological competitor of other fungal pathogens assayed. All results together suggest that this small peptide is an important factor for the fungal interplays involved in maize infection and reveals unforeseen potential biotechnological applications for FgAFP in maize production and storage.

Educating in antimicrobial resistance awareness: adaptation of the Small World Initiative program to service-learning.

The Small World Initiative (SWI) and Tiny Earth are a consolidated and successful education programs rooted in the USA that tackle the antibiotic crisis by a crowdsourcing strategy. Based on active learning, it challenges young students to discover novel bioactive-producing microorganisms from environmental soil samples. Besides its pedagogical efficiency to impart microbiology content in academic curricula, SWI promotes vocations in research and development in Experimental Sciences and, at the same time, disseminates the antibiotic awareness guidelines of the World Health Organization. We have adapted the SWI program to the Spanish academic environment by a pioneering hierarchic strategy based on service-learning that involves two education levels (higher education and high school) with different degrees of responsibility. Throughout the academic year, 23 SWI teams, each consisting of 3-7 undergraduate students led by one faculty member, coordinated off-campus programs in 22 local high schools, involving 597 high school students as researchers. Post-survey-based evaluation of the program reveals a satisfactory achievement of goals: acquiring scientific abilities and general or personal competences by university students, as well as promoting academic decisions to inspire vocations for science- and technology-oriented degrees in younger students, and successfully communicating scientific culture in antimicrobial resistance to a young stratum of society.

Real-Time RT-PCR assay to quantify the expression of fum1 and fum19 genes from the Fumonisin-producing Fusarium verticillioides.

Fumonisins are a group of mycotoxins produced by Fusarium species of the Gibberella fujikuroi species complex that contaminate food and feed products, and represent a risk for human and animal health. In this work, we have developed a specific real-time reverse transcription-PCR (RT-PCR) assay to quantify the level of expression of two genes of the fumonisin biosynthetic cluster in F. verticillioides: fum1 (that encodes a polyketide synthase enzyme) and the ABC transporter encoding gene fum19. The level of expression of both genes was compared with the amount of fumonisin B(1) (FB(1)), measured by HPLC, produced by several strains of F. verticillioides in liquid culture. The results indicated a good correspondence between the levels of fum1 and fum19 expression and the production of fumonisin B(1). The analysis described provides a good approach for the rapid and specific detection and characterization of the potential ability of F. verticillioides strains to produce fumonisins.

Targeting Conserved Genes in Fusarium Species.

Fumonisins are important mycotoxins contaminating foods and feeds which are mainly produced by F. verticillioides and F. proliferatum. Additionally, both are pathogens of maize and other cereals. We describe two highly sensitive, rapid, and species-specific PCR protocols which enable detection and discrimination of these closely related species in cereal flour or grain samples. The specific primer pairs of these assays were based on the intergenic spacer region of the multicopy rDNA unit which highly improves the sensitivity of the PCR assay in comparison with single-copy target regions.

PCR-based strategy to detect contamination with mycotoxigenic Fusarium species in maize.

Contamination of cereals with mycotoxigenic species of Fusarium is an important source of trichothecenes, fumonisins and other mycotoxins which cause serious diseases in human and animals. In addition, these species are phytopathogenic and produce severe losses in cereal yield. Methods for early detection of these Fusarium species are crucial to prevent toxins entering the food chain and are a useful tool in disease management practices. We have developed an integrated protocol for diagnosis of mycotoxigenic Fusarium contamination in maize which can also be used for other cereals. The protocol consisted in an easy and rapid DNA extraction from maize samples (grain and germ), and subsequent group-specific polymerase chain reaction (PCR) assays for genus Fusarium, Gibberella fujikuroi complex, and trichothecene-producing species of Fusarium, that orientate the search of the critical species. We have additionally developed a PCR assay for the identification of F. proliferatum. The primers were designed on the basis of IGS sequence (Intergenic Spacer of rDNA), a multi-copy region in the genome that permits to enhance the sensitivity of the assay in comparison with PCR assays based on single-copy sequences. The suitability of the protocol and the relative efficacy of single and multi-copy sequence-based PCR assays have been tested in a wide range of fumonisin-contaminated maize samples.

A Methodology for the Analysis of Spontaneous Reactions in Automated Hearing Assessment.

Audiology is the science of hearing and auditory processes study. The evaluation of hearing capacity is commonly performed by an audiologist using an audiometer, where the patient is asked to show some kind of sign when he or she recognizes the stimulus. This evaluation becomes much more complicated when the patient suffers some type of cognitive decline that hinders the emission of visible signs of recognition. With this group of patients, a typical question-answer interaction is not applicable, so the audiologist must focus his attention on the patient's spontaneous gestural reactions. This manual evaluation entails a number of problems: it is highly subjective, difficult to determine in real time (since the expert must pay attention simultaneously to the audiological process and the patient's reactions), etc. Considering this, in this paper, we present an automatic methodology for processing video sequences recorded during the performance of the hearing test in order to assist the audiologist in the detection of these spontaneous reactions. This screening method analyzes the movements that occur within the eye area, which has been pointed out by the audiologists as the most representative for these patients. By the analysis of these movements, the system helps the audiologist to determine when a positive gestural reaction has taken place increasing the objectivity and reproducibility.

Discrimination of Aspergillus niger and other Aspergillus species belonging to section Nigri by PCR assays.

Aspergillus species included in section Nigri are common in plant products and processed food, such as grapes, cereals, coffee and derivatives, particularly in warm and tropical climates. Two of these species, A. carbonarius and A. niger, are known to produce ochratoxin A (OTA), a potent nephrotoxin and carcinogenic to human (group 2B). Recognition of the several species of this section is difficult and requires considerable expertise using conventional methods based on morphological features. In this work we describe rapid, sensitive and robust assays based on the PCR technique to discriminate the main species included in section Nigri: A. japonicus, A. heteromorphus, A. ellipticus and the two morphologically indistinguishable species of the A. niger aggregate: A. niger and A. tubingensis. The species-specific primers have been designed on the basis of ITS (internal transcribed spacers of rDNA units) sequence comparisons obtained from several Aspergillus strains and have been tested in a number of strains from different origins and hosts. These PCR assays, based on multi-copy sequences, are highly sensitive and specific and represent a good tool for an early detection of OTA-producing Aspergillus species in order to prevent OTA from entering the food chain.