Detecting reproductive system abnormalities of broiler breeder roosters at different ages.

The objective of this study was to detect the reasons of rooster's fertility decrease at 50 weeks of age. Therefore, the reproductive system of broiler breeder roosters was laparoscopic, macroscopic and histopathology evaluated, and a comparison of the anatomical aspect with the sperm analysis and birds' age was realized. Cobb roosters (n = 59) were distributed into two groups (30 and 50 weeks). Evaluations were performed with laparoscopy, macroscopy and histopathology, and seminal quality, blood serum testosterone concentration and weight were also determined. The old roosters presented smaller testicle size, higher intensity epididymal lithiasis and lower testicle sperm production, compared to the young roosters. The use of the endoscope could easily distinguish a normal-sized testicle than an atrophic one. Four old roosters with severe testicular atrophy did not show spermatogenesis, although three still had sperm in the ejaculate. This would falsely indicate a wrong diagnosis of normal fertility before the testicular atrophy took place. In conclusion, in addition to the weight increase with age, the testicular atrophy and impairment of sperm production seemed to be the main reason to the decrease in the rooster's fertility at 50 weeks of age. Therefore, the use of the laparoscopy as a way to detect the roosters with testicular atrophy before 50 weeks of age and their removal from them flock could be useful as a diagnostic tool to prevent the birds' fertility loss.

Bioactive amines and internal quality of commercial eggs.

The physicochemical and microbiological qualities of commercial eggs produced by layer hens of different ages (approximately 30 and 60 wk old) were submitted to storage under room temperature or refrigeration for 28 d. A total of 600 eggs were subjected to microbiological analyses of their inner contents and another 600 to a determination of Haugh units (HU) and bioactive amine content. A decrease in the quality of the inner contents of the eggs was observed during the experiment, mainly in the eggs from the 60-wk-old layers, which presented the worst HU values when stored at room temperature (P < 0.05). Microbiological analyses showed an absence of Salmonella spp., Staphylococcus aureus, and coliforms, either total or thermal-tolerant; however, low counts of other Staphylococcus species, Enterobacter spp., Pseudomonas spp., mesophilic aerobic bacteria, and fungi were also recorded. The chromatographic analysis of bioactive amines detected the presence of phenylethylamine in all albumens (38.0 mg/kg) and spermidine in the yolks (1.02 mg/kg). It was concluded that the age of the hens and the time and temperature of storage influenced the quality parameters of the eggs (P < 0.05). Furthermore, despite the low levels of microbial contamination found, phenylethylamine was detected in the albumen. It was not possible to establish index of quality of eggs using bioactive amines present in the yolk and albumen of eggs.

Effect of egg storage duration and egg turning during storage on egg quality and hatching of broiler hatching eggs.

In commercial hatcheries, it is common to store eggs before incubation. One practice to improve hatchability consists in egg turning during this storage. This work aims to highlight the effects of turning on the physicochemical aspects of eggs and, consequently, how this turning can influence the hatching of chicks. An experiment was conducted to evaluate the effects of storage duration and egg turning during storage on egg quality, hatchability, and residual analysis. A total of 7 500 hatching eggs were collected from a 55-week-old commercial Cobb500 breeder flock and storage according to the treatments. The experiment was completely randomized in a 3×2 factorial design with three storage periods (4, 8, and 12 days) and egg turning (180° turn of eggs once a day) or no turning during storage, totaling six treatments. Regardless of turning, eggs stored for 4 days weighed more than turned eggs stored for 8 and 12 days, which were similar (P < 0.05). Non-turned eggs experienced an increase in relative shell weight with increased storage duration, and non-turned eggs stored for 4 and 8 days differed from non-turned eggs stored for 12 days (P < 0.05). Albumen pH of turned eggs stored for 4 and 8 days was lower than that of non-turned eggs stored for the same durations (P < 0.05). Albumen pH of turned eggs increased as storage duration increased (P < 0.05). Egg turning increased hatching by 2.02% over that of non-turning (P < 0.05). Eggs stored for 12 days, irrespective of turning, had higher late embryonic mortality (P < 0.05) compared to the other treatments. It was concluded that turning eggs during pre-incubation storage was adequate to improve hatchability of fertile eggs. Storing fertile eggs for 12 days is harmful to egg quality and increases embryo mortality even if eggs were turned.

Effects of lipid sources in the diet of laying hens on the fatty acid profiles of egg yolks.

The effects of different dietary lipids on the fatty acid profiles of eggs produced by 20- and 54-wk-old Dekalb laying hens were investigated. The 4 treatments were based on the lipid source added to the diet: soybean oil, sunflower oil, linseed oil, or control (no added oil). The experimental design was a simple random-sample design using a 4 × 2 factorial arrangement (4 treatments and 2 ages). The fatty acid composition of the yolks of eggs produced by the laying hens was analyzed. The fatty acid profiles found in the egg yolks were the same as those provided in each diet. Eggs laid by hens fed the diet containing soybean oil had a large amount of n-6 polyunsaturated fatty acids (PUFA), whereas eggs laid by hens fed the diet containing linseed oil had the highest percentage of n-3 PUFA. A decrease in PUFA deposition in egg yolks was observed as the laying hens got older. Eggs of hens fed the diet containing linseed oil presented an n-6:n-3 ratio of 2.01 in younger chickens and 2.17 in older ones. The trans fat percentages found in the egg yolks of all treatments were very low. It was concluded that the quantity of fatty acids present in the egg yolk may be altered according to the source of lipids in the diets; the addition of linseed oil to the ration of laying hens resulted in the production of n-3-enriched eggs and excellent n-6:n-3 ratios, and the egg yolks had insignificant amounts of trans fat, irrespective of the different lipid sources added to the diets or the age of the chickens.

An evaluation of alternative methods for sanitizing hatching eggs.

Different sanitization methods were evaluated as alternatives to formaldehyde fumigation for the reduction of eggshell and yolk sac microbiological counts, improvement of eggshell quality, incubation parameters, and day-old chick quality. A total of 10,080 hatching eggs were collected from a 70-wk-old commercial broiler breeder flock and distributed in a completely randomized block design with seven treatments: fumigation with paraformaldehyde (5.03 g/m3/30 min), fumigation with ozone (5-15 ppm/30 min), ultraviolet light-C irradiation (8.09 mW/cm2; 120 s; UV-C), hydrogen peroxide spraying (3%; 0.69 mL/egg), peracetic acid spraying (0.3%; 0.69 mL/egg; PAA), water spraying (0.69 mL/egg; water control), and without disinfection (dry control-DC). Spraying eggs with PAA and UV-C significantly reduced aerobic bacteria plate counts compared to the DC group. In addition, eggs disinfected with PAA had lower Enterobacteriaceae counts than the DC and water control groups. Eggshell quality, incubation parameters, and microbiological counts for yolk sac did not differ (P > 0.05) among treatments. This study demonstrated the potential for the application of PAA and UV-C for eggshell disinfection instead of formaldehyde; however, an electronic microscopic evaluation of the eggshell is necessary to determine if these methods cause any damage to the cuticle.

Digestible methionine+cysteine in the diet of commercial layers and its influence on the performance, quality, and amino acid profile of eggs and economic evaluation.

This work aimed at evaluating the effects of 4 digestible Met+Cys levels on the diet of commercial layers and their influence on the productive performance, quality, and amino acid profile of eggs and economic viability of the activity. A total of 576 white Lohmann LSL-Lite layers was distributed into 6 replicates of 24 birds for each diet. The experimental design was completely randomized, with 4 treatments defined by levels evaluated in the feed (0.465, 0.540, 0.581, and 0.647%). The productive performance was measured for 30 weeks. The quality (34 and 50 wk old) and the amino acid profile of eggs (43 wk old) also were evaluated. A linear positive response was observed at higher Met+Cys levels for feed intake, number of eggs per housed bird, and digestible Met+Cys intake. Egg production, egg weight, egg mass, feed efficiency, and weight gain had their optimal values determined by the quadratic regression model at 0.638, 0.654, 0.647, 0.644, and 0.613% digestible Met+Cys, respectively. In the 34th wk, eggshell thickness decreased linearly at higher Met+Cys levels. In the 50th week, the optimal levels detected for eggshell thickness and percentage were 0.571 and 0.570% digestible Met+Cys, respectively. The percentages of proteins, branched-chain amino acids (leucine, isoleucine, and valine), histidine, and proline in eggs (albumen+yolk) showed a linear negative response in function of higher Met+Cys levels. Higher digestible Met+Cys levels (>0.630%) led to a good performance of layers, while lower Met+Cys levels improved the eggshell quality of layers in peak production. Optimal Met+Cys levels may change according to the price of the synthetic amino acid.

Comb, cloaca and feet scores and testis morphometry in male broiler breeders at two different ages / Escores de crista, cloaca e de pé e morfometria testicular em galos de matriz pesada em duas diferentes idades

In broiler breeder roosters, the weight of the testes is positively associated with daily sperm production and fertility. In birds, the testes are located in the coelomic cavity, not being accessible to reproductive evaluation as mammalian testes. The reproductive evaluation of roosters is based on phenotypic traits. Any changes on testes will be reflected on fertility levels. The aim of this paper was to evaluate the potential of association of phenotypic traits as body weight (BW), comb scores (COS), cloaca scores (CLS) and feet scores (FS) with testicular morphometric parameters in adult Cobb® Mx roosters in two ages (25 and 45 weeks of age). The low BW roosters had lower testes weight (TW), smaller seminiferous tubule diameter (STD) and lower comb and cloaca scores than the medium and high BW roosters (P≤0.05). Heavy roosters had the highest COS and bigger seminiferous epithelium height (SEH). There was no statistical difference between the BW categories in FS and volumetric proportion of seminiferous tubule (ST) and interstitial tissue (IT). Considering the age effect, roosters with 45 weeks of age had lower TW and ST than 25-week roosters. Positive, moderate and significant correlation was found between testes weight and phenotypic characteristics as BW, COS and CLS in 45week roosters. A positive, moderate and significant correlation was found between body weight and histologic testicular characteristics as STD and SHE in both evaluated ages. In conclusion, there is a regression in the testes weight with age and it is more intense in Cobb® Mx roosters with lower BW. Furthermore, it is concluded that the BW positively influences the testes weight and histological quality of the testes. COS and CLS can be used with moderate potential prediction to identify roosters with low testes weight at 45 weeks of age.(AU)

Em galos de matriz pesada sabe-se que o peso dos testículos pode ser associado positivamente com a produção diária de espermatozoides e que alterações nos testículos irão refletir na fertilidade. Nas aves, os testículos estão localizados dentro da cavidade celomática, e, portanto, não são acessíveis para exame andrológico direto, como em mamíferos. A avaliação reprodutiva de galos se baseia principalmente em características fenotípicas. Buscou-se avaliar o potencial de associação de alguns parâmetros fenotípicos, como peso corporal (PC), escores de crista (ECR), escores de cloaca (ECL) e escores de pés (EP), com parâmetros morfológicos de testículos em galos Cobb® Mx em duas idades (25 e 45 semanas de idade). Galos leves apresentaram menor peso testicular (PT), menor diâmetro de túbulo seminífero (DT), e menores ECR e ECL que galos médios e pesados (P≤0.05). Galos pesados apresentaram os maiores ECR e maiores valores para altura do epitélio seminífero (AE), e DT. Não houve diferença estatisticamente significativa entre as categorias de peso para escores de pé e proporções de túbulo seminífero (TS) e interstício (INT). Considerando-se o efeito da idade, galos com 45 semanas de idade apresentaram menores PT e TS que galos com 25 semanas de idade. Correlação positiva, moderada e significativa foi encontrada entre peso de testículo e características fenotípicas como ECR, ECL e PC em galos de 45 semanas de idade. Foi encontrada correlação positiva, moderada e significativa entre PC e características testiculares como DT e AE nas duas idades avaliadas. Conclui-se que em galos Cobb® Mx ocorre regressão do testículo com o avanço da idade, e ela é mais intensa em galos com menor peso corporal. Conclui-se que o PC tem influência positiva no peso e índices histomorfométricos dos testículos, e que escores de crista e de cloaca podem ser utilizados com potencial moderado de predição para identificar galos com baixo peso de testículos em galos com 45 semanas de idade.(AU)

Avaliação da correção da energia pelo balanço de nitrogênio em alimentos para frangos de corte / Evaluation of the energy correction for nitrogen balance in feed for broiler chickens

Com o objetivo de determinar valores de energia metabolizável aparente e de energia metabolizável aparente corrigida pelo balanço de nitrogênio de alimentos para frangos de corte, bem como avaliar os efeitos da correção da energia sobre seu desempenho, foram conduzidos dois experimentos: I) determinação da energia do milho, do farelo de soja, da farinha de carne e ossos, da farinha de vísceras e da farinha de penas, pelo método de coleta total de excretas, utilizando-se 450 pintos de corte com um dia de idade, distribuídos em delineamento inteiramente ao acaso, sendo seis tratamentos e cinco repetições; II) desempenho de 960 frangos de corte, distribuídos ao acaso, em cinco tratamentos e seis repetições. As aves que receberam os tratamentos A (matriz energética de acordo com Rostagno et al. (2011)) e E (energia sem correção com ajuste pela idade) apresentaram melhor desempenho, e as aves do tratamento E tiveram melhor conversão alimentar. Portanto, formulações com energia sem correção pelo balanço de nitrogênio e ajustadas pela idade são viáveis tanto sob o ponto de vista zootécnico, quanto econômico.

In order to determine apparent metabolizable energy and apparent metabolizable energy corrected by nitrogen balance of feed ingredients and to evaluate the effects of this correction on performance of broiler chickens, two experiments were conducted: I) energy determination of corn, soybean meal, meat and bone meal, poultry by-products meal and feather meal by total excreta collection method, using 450 chicks randomly distributed in 30 cages, with 6 treatments and 5 replications; II) performance of 960 broilers, distributed in a completely randomized design, with 5 treatments and 6 replications. Birds that received treatments A (energy matrix from literature) and E (energy without correction adjusted by age) showed better performance with the best feed cost, and treatment E had smaller feed conversion ratio. Therefore, the use of formulations based on metabolizable energy adjusted for age and without correction by nitrogen balance is feasible, both from a zootechnical and economic point of view.

Efeitos da granulometria e da forma física da ração sobre o desempenho de frangos de corte / Effects of particle size and physical form of diets on broiler performance

Foram utilizados 936 pintos de corte machos e 1008 fêmeas da linhagem Cobb(r) criados no período de um a 45 dias. Os tratamentos foram compostos por duas formas físicas da ração (farelada e peletizada) e duas granulometrias do milho (3,8mm e 7,0mm). O delineamento experimental foi inteiramente ao acaso, em arranjo fatorial 2 x 2 (duas granulometrias x duas formas físicas), com seis repetições de 39 aves cada para os machos e seis repetições de 42 aves cada para as fêmeas. A ração peletizada produzida com moagem 3,8mm apresentou melhor PDI (P≤0,05). Aves fêmeas alimentadas com ração peletizada apresentaram maior consumo de ração, ganho de peso e melhor conversão alimentar que aquelas que receberam ração farelada. Não foi observada diferença significativa (P>0,05) entre os tratamentos para as variáveis ganho de peso, conversão alimentar e consumo de ração dos machos. Não houve influência da forma física e da granulometria sobre a viabilidade das aves em nenhuma fase de criação (P>0,05).

A total of 936 male chickens and 1008 female Cobb(r) were used from 1 to 45 days old. Treatments consisted of two physical forms (mash and pelleted diets) and two particle sizes ( corn ground through 3.8mm and 7.0mm sieves). The experimental design was completely randomized in a 2 x 2 factorial design (two particle sizes x two physical forms), with six replicates of 39 birds each for males and six replicates of 42 birds each for females. PDI from the pelleted physical form that was produced with 3.8mm grinding showed better results (P≤0.05). Female birds fed pelleted diets had greater feed intake, weight gain and better feed conversion than those fed mash diet. No significant difference (P>0.05) was observed between the treatments for male feed intake, weight gain and feed conversion from 1 to 45 days of age. There was no influence of the physical form and particle size on the feasibility of birds in any phase (P>0.05).

Avaliação da suplementação antioxidante na dieta para galos de matrizes pesadas em idade avançada sobre parâmetros reprodutivos / Evaluation of antioxidant supplementation in diet for aging broiler breeder roosters on reproductive parameters

Objetivou-se avaliar os efeitos de antioxidantes suplementados às dietas de galos de matrizes pesadas em idade avançada sobre as características reprodutivas. Foram utilizados galos da linhagem Cobb com 47 semanas de idade. Estes foram distribuídos em quatros tratamentos, de acordo com a adição de antioxidante à dieta, sendo: A = grupo controle (sem suplementação antioxidante); B = suplementação de 9ppm de citranaxantina; C = suplementação de 6ppm de cantaxantina e D = 150ppm de vitamina E. Foram avaliadas as características seminais, tais como volume, vigor, motilidade e concentração, a composição de ácidos graxos do sêmen (saturados, insaturados, monoinsaturados, poli-insaturados, ômega 3, ômega 6 e ômega 9) e a correlação entre o peso dos testículos e o peso dos galos. Não foram observados efeitos das substâncias antioxidantes testadas sobre os parâmetros reprodutivos avaliados. Os antioxidantes avaliados não influenciam as respostas reprodutivas de machos reprodutores de matrizes pesadas em idade avançada.(AU)

This study aimed to evaluate the effect of antioxidant supplementation in diets of aging broiler breeder roosters on reproductive characteristics. Cobb roosters were divided into four groups, according to antioxidant addition, where: A = control group (without antioxidant supplementation); B = 9ppm of citranaxanthin; C = 6ppm of canthaxanthin, and D = 150ppm of vitamin E. Seminal characteristics (volume, force, motility and concentration), semen fatty acid composition (saturated, unsaturated, monounsaturated, polyunsaturated, ω3, ω6 and ω9), and the correlation between testis weight with rooster weight were evaluated. No effects of the antioxidants tested were observed. The antioxidants do not influence the reproductive responses of aging male broiler breeder.(AU)

Efeitos da umidade relativa do ar na incubação e da idade da matriz leve sobre a eclodibilidade, qualidade dos pintos recém-eclodidos e desempenho da progênie / Effects of relative air humidity in the incubator and breeder hen age on hatchability, hatchling quality and progeny performance

Objetivou-se avaliar os efeitos da umidade relativa do ar nas incubadoras (URI) e da idade da matriz leve sobre a eclodibilidade, qualidade dos pintos recém-eclodidos e o desempenho da progênie. Foram incubados 10.840 ovos, sendo os tratamentos definidos pela idade das matrizes Lohmann LSL(r) (26, 41 e 56 semanas) e pelos níveis de URI (48, 56 e 64%). Após a incubação, 1.620 pintos fêmeas foram alojados em galpão experimental convencional, de acordo com os tratamentos, até as 12 semanas de idade. Para a avaliação de eclodibilidade sobre ovos férteis e fêmeas refugos, o delineamento experimental foi em blocos ao acaso no arranjo em parcelas subdivididas. A parcela foi a URI (três níveis) e a subparcela foi a idade da matriz (três idades). Os blocos foram constituídos pelos andares dos carrinhos de incubação, em que cada andar continha uma repetição de cada idade da matriz. Os nove tratamentos foram constituídos por 14 repetições cada. As repetições foram bandejas de incubação, constituindo 1.204 ovos por tratamento. Para a avaliação do desempenho das frangas, o delineamento experimental foi inteiramente ao acaso, constituído por um esquema fatorial 3x3 (três níveis de URI e três idades), com seis repetições de 30 aves em cada tratamento. A eclodibilidade sobre ovos férteis foi maior (P<0,05) com a utilização de 56% de umidade relativa do ar durante a incubação, independentemente da idade da matriz; e ovos de matrizes mais velhas (56 semanas) apresentaram eclodibilidade menor (P<0,05), independentemente do nível de umidade relativa do ar no interior das incubadoras. Não foram constatados efeitos da idade da matriz e URI sobre o percentual de pintos refugos. A URI ou a idade da matriz leve não afetam o desempenho da progênie.

The aim of this study was to evaluate the effects of relative humidity in incubators (RHI) and breeder hen age on hatchability, hatchling quality and performance of progeny. 10,840 eggs were incubated, and the treatments were defined by the Lohmann LSL(r) breeder age (26, 41 and 56 weeks) and the levels of RHI (48, 56 and 64%). After incubation, 1,620 female chicks were raised in a conventional experimental shed, according to the treatments, until 12 weeks of age. To assess the hatchability of fertile eggs and unviable female chicks, the experimental design was randomized blocks in split plots design. The plot factor was the RHI and the subplot was the age of the breeder hens. The blocks were made by the floors of the incubation carriages, where each floor contained a repetition of each breeder age. The nine treatments consisted of 14 repetitions each. The repetitions were trays of incubation, with 1,204 eggs per treatment. To evaluate the performance of the progeny, the experimental design was completely randomized, consisting of a 3x3 factorial scheme with six replicates of 30 birds in each treatment. Hatchability of fertile eggs was higher (P<0.05) with the use of 56% relative humidity during incubation, regardless of breeder age, and the eggs from the oldest breeder hens (56 weeks) had lower hatchability (P<0.05), regardless of the level of relative humidity inside the incubator. No effects of breeder age and RHI on the percentage of unviable chicks were observed. The RHI or the age of the breeder hen does not affect the performance of progeny.

Desempenho de frangos de corte alimentados com diferentes níveis de suplementação de vitamina E / Effect of vitamin E supplementation on the performance of broiler chickens

Objetivou-se a avaliação dos efeitos dos níveis de suplementação de vitamina E na ração para frangos de corte sobre o desempenho na fase inicial (um a 21 dias de idade) e de crescimento (21 a 39 dias de idade). Os tratamentos foram definidos pelos níveis de suplementação de vitamina E (DL-α tocoferol). As quantidades adicionadas às rações foram: 10; 30; 50; 75 e 100mg de vitamina E para cada kg de ração. Na fase inicial (experimento I), o menor nível de suplementação de vitamina E mostrou-se superior aos demais, apresentando efeito significativo (P≤0,05) sobre o peso médio aos 21 dias de idade e ganho de peso de um a 21 dias de idade. Na fase de crescimento (experimento II), não houve efeito significativo (P>0,05) dos níveis de suplementação de vitamina E sobre as variáveis estudadas. O nível mínimo de suplementação de vitamina E testado (10mg/kg) é suficiente para atender às exigências dos frangos de corte machos sobre o desempenho.(AU)

This study aimed to evaluate the effect of vitamin E supplementation on the performance of broiler chickens in the initial and growth phase, from one to 21 and 21 to 39 days of age, respectively. Five increasing levels of DL-α tocopherol supplementation (10, 30, 50, 75 and 100mg to each kg of diet) were added to the diet. In the initial phase (experiment I), the lowest vitamin E level was superior by presenting significant effect (P≤0.05) on body weight at 21 days of age and weight gain from one to 21 days old. In the growth phase (experiment II), there was no significant effect (P>0.05) of vitamin E supplementation on the variables studied. The minimum level of vitamin E supplementation tested is sufficient to attend the requirements of male broiler chickens.(AU)

Efeito da protease sobre o coeficiente de metabolizabilidade dos nutrientes em frangos de corte / Effect of protease on the metabolization coefficient of nutrients in broilers

Avaliaram-se os efeitos da protease sobre o coeficiente de metabolizabilidade dos nutrientes em dietas contendo farinha de penas (2,0% na fase inicial e 3,0% na fase de crescimento) para frangos de corte machos, Cobb(r), de um a 32 dias de idade. Foram alojadas 336 aves em gaiolas metálicas equipadas com bandeja para coleta total de excretas. Foi utilizado delineamento inteiramente ao acaso, em arranjo fatorial 2x2 (com e sem adição da enzima protease 0,05% e duas valorizações da matriz nutricional da enzima), sendo sete repetições por tratamento, de 12 aves cada. Observou-se, na fase inicial, maior CMPB (P≤0,05) para as aves que, independentemente da adição de protease, consumiram ração com valorização da matriz nutricional da enzima. Não houve efeito dos tratamentos sobre o CMMS e o CMEE (P>0,05). Na fase de crescimento, houve interação entre os tratamentos para as variáveis CMPB e CMEE. Os frangos alimentados com dieta valorizada sem adição de enzima (controle negativo) apresentaram melhores resultados (P≤0,05) para CMPB e CMEE. Nos tratamentos com enzima, o melhor CMEE (P≤0,05) foi obtido com o tratamento sem valorização da matriz nutricional (over the top). Conclui-se que níveis reduzidos e enzima sem valorização melhoram os coeficientes de metabolizabilidade dos nutrientes na fase adulta de frangos de corte.(AU)

This experiment aimed to evaluate the effects of protease on metabolization coefficient of nutrients, performance and slaughter yield from male Cobb(r) broilers fed diets with feather meal. Two experiments were carried out in a completely randomized design in a 2x2 factorial arrangement - with (0.05%) or without enzyme addition x considering or not the improvement of the nutritional value by protease, with seven replicates per treatment group. In experiment 1 the metabolization coefficient of dry matter (MCDM), crude protein (MCCP) and ether extract (MCEE) in initial (9-12-d-old) and growth (29-32-d-old) phase was evaluated. In the initial phase it was observed that regardless of enzyme addition, broiler chickens fed a diet considering improvement in nutritional value had higher MCCP (P≤0.05). However, MCDM and MCEE were not affected (P>0.05). In the growth phase, there were interactions between treatments for the variables MCCP and MCEE. The birds fed diets considering the improvement in nutritional value without enzyme (negative control) showed better results (P≤0.05) for MCCP and MCEE. In the treatments with enzyme, the best MCEE (P≤0.05) was observed in the treatment not considering the improvement in the nutritional value (over the top). Therefore, considering the improvement in the nutritional value and enzyme without considering the improvement in the nutritional value improves the coefficients of metabolization of nutrients in broiler chickens.(AU)

Escores de cloaca e de crista e morfometria testicular em galos de matriz pesada com 71 semanas de idade e três categorias de peso corporal / Cloaca and comb scores and testicular morphometry in broiler breeder roosters at 71 weeks of age and three body weight categories

Em galos de matriz pesada, o peso dos testículos se associa positivamente com a produção diária de espermatozoides e com a fertilidade. Contudo, os testículos de aves se localizam na cavidade abdominal, não sendo acessíveis para exame andrológico como os testículos de mamíferos. A avaliação reprodutiva de galos de matriz pesada é subjetiva e se baseia em características como peso corporal (PC), qualidade de pés e pernas e morfologia de cloaca e crista. Estudos que validem o potencial de associação dessas características fenotípicas com parâmetros da morfometria testicular são raros, principalmente quando se consideram galos de matriz pesada manejados em lotes comerciais. Escores de cloaca e de crista e parâmetros da morfometria testicular foram avaliados em galos Cobb 500 Slow adultos das categorias de PC leve (<4,300kg), médio (entre 4,300 e 5,250kg) e pesado (≥5,250kg). O coeficiente de variação para PC foi de 12%. Os galos da categoria de PC pesado apresentaram testículos mais pesados e maiores escores de cloaca e de crista do que os galos da categoria de PC leve. Não houve diferença estatística entre as categorias de PC, considerando-se índice gonadossomático, porcentagens de túbulo seminífero e de tecido intersticial, diâmetro de túbulo seminífero e altura de epitélio seminífero. Correlação positiva, moderada e significativa foi observada entre peso de testículo e características de PC, escores de cloaca e de crista, diâmetro de túbulo seminífero e altura de epitélio seminífero. Um dos seis galos da categoria de PC leve avaliados quanto à histologia de testículo apresentou atrofia testicular. Em galos Cobb 500 Slow, conclui-se que o PC influencia o peso e a qualidade histológica de testículos e que os escores de cloaca e de crista podem ser utilizados com potencial moderado de predição para identificar galos com baixo peso de testículos...

In broiler breeder roosters the weight of the testes is positively associated with daily sperm production and fertility. However, the avian testes are located in the abdominal cavity, not being accessible for reproductive evaluation as mammalian testes. The reproductive evaluation of broiler breeder roosters is subjective and is based on characteristics such as body weight (BW), quality of feet and legs and morphology of cloaca and comb. Studies that validate the potential of associating these phenotype characteristics with testicular morphometric parameters are rare, especially when broiler breeder roosters of commercial flocks are considered. Cloaca and comb scores and testicular morphometric parameters were evaluated in adult Cobb 500 Slow roosters with low (<4.300kg), medium (between 4.300 and 5.250kg) and high (≥5.250kg) BW categories. The coefficient of variation for BW was 12%. The high BW roosters have heavier testes and higher cloaca and comb scores than the low BW roosters. There was no statistical difference between the BW categories in gonadosomatic index, percentage of seminiferous tubule and interstitial tissue, diameter of the seminiferous tubule and height of the seminiferous epithelium. Testis weight is positive, moderate and significantly correlated with BW, cloaca and comb scores, diameter of seminiferous tubule and height of seminiferous epithelium. One of six low BW roosters evaluated for histology of the testis had testicular atrophy. We conclude that in Cobb 500 Slow roosters BW influences the weight and histological quality of the testes. Besides this, cloaca and comb scores can be used with moderate prediction potential to identify roosters with underweight testes...

Influência do aquecimento artificial de ovos de matrizes pesadas sobre o rendimento de incubação / Influence of artificial heating on hatchability of broiler breeder eggs

O desenvolvimento embrionário nas aves tem início antes mesmo da postura. A variabilidade do estágio de desenvolvimento embrionário no momento da oviposição é conhecida e influencia a taxa de eclosão, uma vez que estágios muito avançados ou muito precoces são prejudiciais por tornarem os embriões mais sensíveis ao estresse do armazenamento. O aquecimento de ovos férteis no período entre a postura e o armazenamento vem sendo estudado como forma de reduzir os efeitos negativos do armazenamento sobre o rendimento de incubação por permitir que os embriões progridam até um estágio em que são mais aptos a suportar o estresse do armazenamento. Este experimento teve como objetivo avaliar os efeitos do aquecimento artificial de ovos de matrizes pesadas no período entre a coleta e o armazenamento sobre o rendimento de incubação e o peso do pinto ao nascimento. Foram utilizados 5.760 ovos de matrizes pesadas Cobb(r) com 57 semanas de idade. O delineamento experimental foi inteiramente ao acaso, constituído por quatro tratamentos definidos com base no tempo de aquecimento dos ovos (zero, três, seis e nove horas). O aquecimento foi feito em câmara de fumigação a 30°C, e os ovos foram armazenados por três dias. O aquecimento artificial no período entre a coleta e o armazenamento não influenciou a eclodibilidade, a mortalidade embrionária e o peso do pinto ao nascimento, tendo sido, nessas circunstâncias, uma prática injustificada...

In birds, embryonic development begins before laying. The embryonic development variability at the time of egg laying is known and influences hatching rate, since very early or advanced stages are detrimental for embryos because they become more sensitive to stress storage. The heating of fertile eggs in the period between posture and storage has been studied as a way to reduce the negative effects of storage on hatchability since it allows embryos to progress to a stage where they are more able to survive during storage. This experiment aimed to evaluate the effects of artificial heating of fertile broiler breeder eggs in the period between the collection and storage on hatchability and chick weight at birth. For this, 5760 eggs from Cobb(r) broiler breeders, 57 weeks old, were used. The experimental design was completely randomized. It consisted of four defined treatments based on the heating time of eggs (zero, three, six and nine hours). Heating was done in a fumigation chamber at 30°C, and eggs were stored for three days. The artificial heating in the period between collection and storage didn't affect hatchability, embryo mortality and chick weight at birth, being, in this case, an unjustified practice...

Efeito do transporte de péletes sobre sua qualidade / Effect of pellets transport on its quality

The objective of this study was to evaluate the quality of pellets from the end of the pelletizer machine until the end of the line feed plate, using two methods of analysis: pellet durability index (PDI) and EMBRAPA pelletizing method (MEP). Furthermore, the effect of the discharging methods at the broiler farm on the physical quality of pellets using MEP as a method of analysis was evaluated. The first phase of the experiment was a randomized block with six treatments: A - pellets at the end of the pelletizer machine; B - pellets inside the truck; C - truck's discharging at the feed silo; D - place inside the warehouse after the feed silo; E - the middle of the feed plate line and F - the end of the feed plate line. The experiment was carried out in seven replicates (blocks). The second phase of the experiment was a randomized block with two treatments: A - smaller discharge opening (for pellets feed); B - bigger discharge opening (for mashed feed). The experiment was performed with twelve replicates (blocks). The discharge of the pellets feed at broilers farm is the point that worsens the pellets quality. The discharge of pellets feed by the truck should be done with the bigger discharge opening. Moreover, MEP showed to be a better method than PDI to evaluate the integrity of the pellets for broiler chickens.(AU)

Equilíbrio ácido-básico de embriões e pintos de corte em momentos críticos da incubação e submetidos a diferentes períodos de transferência para o nascedouro / Acid-base balance of embryos and broiler chicks in critical moments of incubation and submitted to different periods of transfer to the hatcher

Foram analisados os níveis de pCO2, pO2, pH e HCO3 - de embriões e pintos de corte provenientes de matrizes novas e velhas, nos momentos anteriores à bicagem interna e externa da casca e ao nascimento, submetidos a diferentes períodos de transferência para as condições ambientais dos nascedouros. Os tratamentos foram definidos pela idade da matriz (33 e 63 semanas) e pela transferência para o nascedouro (aos 15, 17 e 19 dias). O delineamento experimental foi em parcelas subdivididas, sendo a parcela os três momentos de transferência e a subparcela as duas idades das matrizes. Foram utilizadas seis repetições para cada tratamento, e o embrião ou o pinto foi considerado uma repetição. Os dados normais e homogêneos foram submetidos às análises de variância, e as médias comparadas pelos testes F, de Tukey e SNK. Embriões cujos ovos foram transferidos aos 15 dias para o nascedouro apresentaram melhor equilíbrio ácido-básico durante as fases pré-natal e perinatal. Durante o último terço da incubação, independentemente das diferentes condições ambientais às quais os embriões são submetidos e da idade da matriz, há capacidade de resposta fisiológica que permite uma estabilidade no equilíbrio ácido-básico dos pintos após a eclosão...

We analyzed the levels of pCO2, pO2, pH and HCO3 - in embryos and chicks from young and older breeders, in the moments before internal pipping, external pipping and at hatch and submitted to different periods in the environmental conditions of hatchers. The treatments were defined by breeder age (33 and 63 weeks) and transfer to the hatcher (at 15, 17 and 19 days). The experimental design was split plots with three periods in the hatcher and the plots were the two breeder ages. We used six replicates per treatment and the embryo or chick was considered a repetition. The normal data forms were submitted to analysis of variance and means were compared by F, Tukey and SNK tests. Embryos transferred at 15 days to the hatcher had better acid-base balance during the pre-and perinatal phases. During the last third of incubation, regardless of the different environmental conditions which the embryos are subjected and breeder age, there is physiological responsiveness that allows for stability in acid-base balance of the chicks after hatching...

Efeito dos níveis de energia para poedeiras comerciais no período final de produção sobre o desempenho, a conversão alimentar e energética e a qualidade de ovos / Effect of energy levels for old layers on performance, feed and energy conversion ratios and egg quality

Foram utilizadas 1200 poedeiras comerciais da linhagem Lohmann LSL, com 64 semanas, em gaiolas convencionais. Estas foram divididas em cinco grupos, de acordo com o nível de energia metabolizável aparente corrigida pelo nitrogênio (EMAn) presente em sua dieta: 2700kcal/kg; 2775kcal/kg; 2850kcal/kg; 2925kcal/kg; e 3000kcal/kg, com seis repetições. As aves receberam as rações, á base de milho e farelo de soja, por 16 semanas. O delineamento experimental foi inteiramente ao acaso, e as médias foram submetidas à regressão polinomial e ao teste de Kruskal-Wallis. O aumento de EMAn não exerceu efeito sobre a produção, a massa e o peso de ovos, bem como sobre o peso das aves e a viabilidade. O consumo de ração diminuiu de acordo com o aumento na energia da dieta, porém a conversão energética foi pior com esse aumento. Em contrapartida, a conversão alimentar melhorou o aumento dos níveis de EMAn. O consumo de EMAn é constante independentemente do seu nível dietético. Não há diferença nas unidades Haugh, nos sólidos da gema e na porcentagem dos componentes do ovo. O peso específico melhora com o aumento dos níveis de EMAn. Os níveis nutricionais para poedeiras velhas podem estar sendo superestimados.

A total of 1200 Lohmann LSL laying hens, with 64 weeks of age in conventional cages was used. These were divided into five groups according to the level of apparent metabolizable energy corrected for nitrogen retention (AMEn) present in the diet: 2700kcal/kg; 2775kcal/kg; 2850kcal/kg; 2925kcal/kg and 3000kcal/kg, with six replicates. The birds received the diets based on corn and soybean meal for 16 weeks. The experimental design was completely randomized and the means were submitted to polynomial regression and the Kruskal-Wallis test. The increased level of AMEn had no effect on production, egg mass and weight. There was no influence of AMEn on bird weight, egg weight and viability. Feed intake decreased with increasing levels, however, and the conversion of AMEn was worse with its increase, and in return feed conversion worsened with increasing consumption. AMEn is constant regardless of the level of the feed. There is no difference in Haugh units, yolk solids and percentage of egg components. The specific gravity improves with increasing levels of AMEn. The nutritional levels for older laying hens may be overestimated.

Efeitos da suplementação de colina sobre o desempenho de poedeiras comerciais / The effects of choline supplementation on the performance of laying hens

Os efeitos da suplementação de colina em dietas para poedeiras (Dekalb White) foram avaliados nas fases de cria/recria e de postura. O delineamento foi em esquema fatorial 2x5 (duas suplementações de colina de uma a 16 semanas de idade x cinco níveis de colina suplementada de 18 a 44 semanas de idade). Os níveis de colina utilizados foram 0, 200, 400, 600 e 800mg/kg para cada grupo. A suplementação de colina em frangas com uma a 16 semanas de idade não afeta o desempenho nem as características macroscópicas e histopatológicas dos fígados durante essa fase. Os efeitos dos níveis de suplementação de colina sobre o desempenho das galinhas na fase de postura dependem da suplementação ou não dessa vitamina nas fases de cria/recria; ou seja, as aves que recebem suplemento de colina nessas fases apresentam maior exigência no período de postura.

The effects of choline supplementation in diets for laying hens (Dekalb White) were evaluated from 1 to 44 weeks-old. The experimental design was a 2x5 factorial arrangement (two choline supplementations from one to 16 weeks of age - with and without choline supplementation vs. five levels of choline supplementation from 18 to 44 weeks old. The choline level used in the diet for each group was 0, 200, 400, 600 and 800mg/kg). Choline supplementation used in birds with 1 to 16 weeks of age does not affect the performance of pullets and no gross and histological changes were observed in the liver during this phase. The effects of the choline supplementation levels in the laying phase on the hens' performance depend on the supplementation with this vitamin from 1 to 16 weeks old. The results of the experiment showed that birds reared for laying need a higher level of choline supplementation from 1 to 16 weeks old or birds reared for laying receiving higher levels of choline supplementation during 1 to 16 weeks old will need a higher level of choline supplementation in the laying phase.

Suplementação de colina em dietas para frangos de corte machos em fase de crescimento / Choline supplementation in diets for male broilers in the growing phase

Avaliaram-se os efeitos dos níveis de suplementação de colina em dietas para frangos de corte, de 22 a 40 dias de idade, sobre o desempenho, a composição de carcaças e fígados, bem como as características macroscópicas e histopatológicas dos fígados. O período de criação foi de um a 40 dias de idade, sendo que o período experimental foi de 22 a 40 dias de idade. Até o 21º dia de idade, todas as aves receberam a mesma ração à qual foram adicionados 400mg colina/kg. No 22º dia, os frangos foram distribuídos em cinco tratamentos, nos quais os níveis testados de suplementação de colina foram: zero, 400, 800, 1.200 e 1.600mg/kg, com seis repetições de 30 aves cada. As rações experimentais, formuladas à base de milho, farelo de soja e farinha de carne/ossos, foram isonutritivas, com exceção dos níveis de colina. O delineamento experimental foi o inteiramente ao acaso, e a estimativa da suplementação de colina foi avaliada pelos modelos de regressão. Os níveis de suplementação de colina apresentaram efeito linear pelo teste F (P<0,05) para o consumo de ração. Os demais parâmetros avaliados não sofreram influência da suplementação (P>0,05). O nível de 1.600mg colina/kg de ração resulta em maior consumo de ração de frangos de corte aos 40 dias de idade.

The effects of choline supplemental levels were evaluated in diets for broilers on performance, carcass and liver composition and liver histopathology characteristics from 22 to 40 days-old. The period of creation was one to 40 days of age, and the experimental period was 22 to 40 days-old. Until 21 days of age all birds received the same diet added to 400mg choline/kg. On day 22, broilers were allotted to five treatments (zero, 400, 800, 1200 and 1600 mg/kg), with six repetitions of 30 birds each. The experimental diets formulated based on corn, soybean meal and meat/bones meal were isonutritive, except for the choline levels. The experimental design was completely randomized and the estimation of choline supplementation was evaluated by regression models. The levels of choline supplementation showed a significant linear effect for the F test (P<0.05) for feed intake. The other evaluated parameters were not influenced by supplementation (P>0.05). The supplementation of 1600mg choline/kg in the diet results in higher feed intake of broilers at 40 days old.