Biosafety in embryos and semen cryopreservation, storage, management and transport.

This chapter summarizes pertinent procedures, data and opinions on the potential hazards of disease transmission through liquid nitrogen (LN)-cryopreserved and banked germplasm and tissues for somatic cell nuclear transfer (SCNT) The importance of applying internationally adopted sanitary washing procedures to germplasm as a crucial step towards their successful microbial-free cryopreservation and storage is emphasised. Special attention is given to the survival of pathogens in LN, variety of vitrification methods, sterility of LN, risks associated with the use of straws and cryovials, and LN Dewars including dry shippers. It was experimentally demonstrated that cross-contamination between LN and embryos may occur, when infectious agents are present in LN and if embryos are not protected by use of a sealed container. It is important, therefore, to prevent direct contact of germplasm and reproductive tissues with LN during cryopreservation and their storage as a mandatory measure for reducing the risk of contamination. This includes the usage of hermetically sealed high quality shatter proof freezing containers and/or the application of a secondary enclosure such as "double bagging or straw in straw". A periodic disinfection of cryo-Dewars should be considered as an additional precaution to diminish the potential for inadvertent cross-contamination. It would be advisable to use separate LN Dewars to quarantine embryos derived from infected donors of valuable genotypes or from unknown health status, extinction-threatened species.

Risk of contamination of germplasm during cryopreservation and cryobanking in IVF units.

Cryopreservation of sperm, embryos and, more recently, oocytes plays an important and increasing role in assisted reproduction, due to improvements of old, and introduction of new technologies. In parallel, concerns are increasing about the technical and biological safety of these procedures. However, published data regarding the confirmed or theoretical hazards of these procedures are sparse and sometimes contradictory. The purpose of this review will summarize data and opinions about one of the most disputed risks, the potential hazard of contamination and disease transmission through cryopreservation. Special attention is concentrated on the weak points of the technology including open vitrification systems, sterilization of liquid nitrogen and safety of commonly used storage tanks including straws and cryovials. Suggestions are also made for practical measures to avoid these dangers while preserving the benefits and perspectives of new cryopreservation technologies.

Transmission of bovine viral diarrhea virus (BVDV) via in vitro-fertilized embryos to recipients, but not to their offspring.

The objective was to assess the potential of Day-7, IVP zona pellucida-intact blastocysts to transmit bovine viral diarrhea virus (BVDV) to embryo recipients. Embryos were exposed (1h) to two non-cytopathic (NCP) biotypes, either NY-1 (type 1) or two concentrations of PA-131 (type 2), washed 10 times, and transferred into recipients (two embryos/recipient) free of BVDV and its antibody. Six (30.0%) of the 20 pregnancies were lost after 30 d following transfer of the embryos exposed to the type 1 strain; none of the recipients or their 18 full term offspring seroconverted. Conversely, following exposure to the type 2 strain, 16 (51.6%) of the 31 pregnancies were lost >30 d after embryo transfer. Furthermore, 18 (51.4%) of 35 recipients receiving embryos exposed to type 2 seroconverted; 11 of those were pregnant at 30 d, but only 2 went to full term and gave birth to noninfected (seronegative) calves. Virus isolation tests were performed on single, virus-exposed, washed embryos (not transferred); 3 of 12 (25%) and 17 of 61 (28%) exposed to type 1 and type 2, respectively, were positive for live BVDV. Embryos exposed to type 2 virus had from 0 to 34 viral copies. In conclusion, a large proportion of recipients that received embryos exposed to BVDV, especially those exposed to a high concentration of type 2 virus, became infected after ET, and their pregnancies failed. However, term pregnancies resulted in calves free of both virus and antibody. Therefore, additional disinfection procedures are recommended prior to transferring potentially infected IVP embryos.

Disinfection procedures for controlling microorganisms in the semen and embryos of humans and farm animals.

Semen and embryos generated by assisted reproductive techniques (ARTs) may be contaminated with numerous microorganisms. Contamination may arise from systemic or local reproductive tract infections in donors or the inadvertent introduction of microorganisms during ARTs, and may lead to disease transmission. This review describes sanitary procedures which have been investigated to ascertain whether they are effective in rendering semen and embryos free of pathogenic microorganisms, including internationally adopted washing procedures, which can be supplemented by antibiotics and enzymatic treatments. Other methods include treatment with antibodies or ozone, photoinactivation, acidification, and the use of novel antiviral compounds. In conclusion, despite the wide range of antimicrobial procedures available, none can be recommended as a universal disinfection method for rendering semen and embryos free from all potentially pathogenic microorganisms. However, some procedures are unsuitable, as they can compromise the viability of semen or embryos. In humans, washing by the gradient centrifugation method appears to be effective for reducing the microbial population in semen and is harmless to the spermatozoa. A useful procedure for embryos involving multiple washes in sterile medium has much to commend it for the prevention of disease transmission; furthermore, it is recommended by the International Embryo Transfer Society (IETS).

Risk of transmission of Mycobacterium avium ssp. paratuberculosis by embryo transfer of in vivo and in vitro fertilized bovine embryos.

Over a 5-year interval, experiments were conducted to determine if Mycobacterium avium ssp. paratuberculosis (Map) is associated with in vivo and in vitro fertilized (IVF) embryos and whether it can be transmitted by embryo transfer. The present studies included: collection of embryos from five asymptomatic, naturally infected donors and transfer to uninfected recipients; collection of oocytes from two naturally infected donors with overt clinical signs; exposure of in vivo and IVF embryos to Map and transfer to uninfected recipients; and the inoculation (transfer) of "clean" IVF embryos to the uterine lumen of infected cows. The presence of Map was confirmed in the uterine horns of all asymptomatic, infected donors. None of the tested embryos, which were not used for embryo transfer, or unfertilized ova (two per batch), were positive for Map, as determined by culture (n = 19) or by PCR (n = 13). However, all in vivo fertilized embryos exposed to Map in vitro (and subsequently sequentially washed) tested positive for Map, by both culture (12 batches) and PCR (15 batches), whereas IVF embryos treated in the same manner tested positive on culture (51%, 18/35 batches) and by PCR (28%, 20/71 batches). Transferring both in vivo embryos and IVF embryos potentially contaminated with Map into 28 recipients resulted in 13 pregnancies and eight calves born without evidence of disease transmission to either the recipients or the offspring over the following 5-year period. In samples collected from one of the clinically infected animals, two of seven (28%) cumulus oocyte complexes (COC) and follicular fluid tested positive by PCR and 10/10 cumulus oocyte complexes on culture for Map. From the second clinically infected cow, three of five batches of IVF embryos (n = 20) were positive on PCR and two of four batches containing unfertilized oocytes and embryos were positive on culture. Only 10% of embryos reached the morula and blastocyst stage 10 days after fertilization. In conclusion, Map is unlikely to be transmitted by embryo transfer when the embryos have been washed as recommended by the International Embryo Transfer Society.

Experimental microbial contamination and disinfection of dry (vapour) shipper dewars designed for short-term storage and transportation of cryopreserved germplasm and other biological specimens.

Cryopreservation, storage and transport of cryopreserved germplasm without the risk of disease transmission is of great concern to animal and human health authorities. Here we report on the efficacy of microbial decontamination of the liquid nitrogen (LN) dry (vapour) shippers used for short-term storage and transportation of germplasm and other biological specimens. Dry shippers containing either a hydrophobic or a non-hydrophobic LN absorbent were experimentally contaminated with high titers of cultures of Pseudomonas aeruginosa, Escherichia coli, Staphylococus aureus, bovine viral diarrhea virus (BVDV) and bovine herpesvirus-1 (BHV-1). Biocidals with broad spectrum antimicrobial activity and gas vapours of formalin and ethylene oxide were used for disinfection of the dewars. Among the biocidals used, treatment with sodium hypochlorite solution, the quaternary ammonium-based disinfectants and peracetic acid were the most effective and useful for dry shippers with a hydrophobic LN absorbent. None of the bacterial or viral microorganisms were detected in samples of semen and embryos stored in dry shippers following their disinfection with these biocides. An application of some other disinfectants, due to their foaming properties or to the permeability of the absorbent hydrophobic membrane (HM) was not effective or may have caused irreversible damage to the LN absorbent. Gas sterilization by ethylene oxide in contrast to formalin was fully effective for both types of dry shippers.

A review on disease transmission studies in relationship to production of embryos by in vitro fertilization and to related new reproductive technologies.

This paper addresses the circumstances of germplasm contamination and updates on transmission of pathogenic agents by embryos produced in vitro and by associated techniques. It has been shown that some pathogenic agents might have been associated with the follicular oocytes and oviductal cells, collected for in vitro fertilization (IVF), resulting in infected embryos. Experimental introduction of pathogenic agent with oocytes or infected semen into the IVF system allows, in most cases, for the fertilization of eggs and for the production of some transferable quality embryos. Rendering of oocytes and embryos free of infectious pathogens, using the standard sequential washing or enzymatic treatment, is inconsistent and more difficult in the presently used in vitro fertilization system as compared to in vivo produced embryos.

Studies on inactivation of pathogenic microorganisms in culture media and in bovine semen by photosensitive agents.

The application of three photosensitive agents for disinfection of bovine semen was investigated. Bovine microbial pathogens suspended in tissue culture medium and/or PBS and also added to bovine semen were exposed to the photosensitive agents followed by irradiation. Hematoporphyrin, hematoporphyrin derivative and thiopyronine were effective against bovine herpes virus-1, bovine viral diarrhoea virus, Mycoplasma bovigenitalium, Mycoplasma canadense, and Ureaplasma diversum in culture media. In addition, thiopyronine was effective against Leptospira pomona. Similar treatments were not effective against Leptospira hardjo, Mycoplasma bovis, or Campylobacter fetus subsp. venerealis. When microorganisms were added to bovine semen, only bovine herpes virus-1 was controlled by the photosensitive agents used at concentrations which did not appear harmful to sperm cells.

The efficacy of trypsin for disinfection of in vitro fertilized bovine embryos exposed to bovine herpesvirus 1.

Bovine cumulus-oocyte complexes (COC) or in vitro fertilized (IVF) embryos were exposed to bovine herpesvirus 1 (BHV-1) during in vitro maturation or co-culture with uterine tubal cells, respectively. Trypsin, at a concentration of 0.25%, was applied (for approximately 90 s) to disinfect either COC or cumulus-free oocytes (CFO) 18 h after insemination, or on day 7 to embryos resulting from infected oocytes. In total, virus was not detected in 71% of 93 samples containing 233 embryos exposed to BHV-1 and trypsin treatment. BHV-1 was detected in 14% and 54% of samples containing a single embryo and five embryos, respectively. In corresponding groups of embryos exposed to BHV-1, then washed but not treated with trypsin (70 samples), 85% and 96% of samples containing one embryo and pooled embryos, respectively, were positive for the virus. There was no effect of trypsin treatment on the development of IVF-embryos. It is concluded that IVF-generated embryos have a greater tendency to carry BHV-1 after experimental exposure to the virus than IVF uterine stage embryos, and that they are more difficult to disinfect by means of the standard trypsin treatment use.

Sanitary status of oocytes and embryos collected from heifers experimentally exposed to Leptospira borgpetersenii serovar hardjobovis.

In a preliminary trial and three experiments, a total of 30 Holstein heifers were experimentally infected with a culture of Leptospira borgpetersenii serovar hardjobovis via one or more routes (uterine, cervical supraconjunctival, intranasal) and oviductal and uterine fluids recovered post-mortem or in vivo following superovulation with FSH. All routes of administration were effective in establishing Leptospira infection in the reproductive tract and Leptospira were identified in the oviductal and uterine fluids of all 30 heifers by microscopy. The incidence of infection was confirmed by positive identification of serum antibodies by the microscopic agglutination test (MAT). Twenty-one samples of the embryos (n = 59) recovered were cultured using bacteriological procedures and all tested negative for the infectious microorganism. Using polymerase chain reaction (PCR) assay, however, showed that 29% (7/24) of morula and blastocyst stage embryos, and one out of 29 oocytes tested positive for the presence of leptospiral DNA. A single oocyte or embryo collected from the infected heifers was inoculated intravenously to 26 test heifers. None of the test heifers developed antibody titers to Leptospira. It was concluded that, despite the presence of leptospires in the reproductive tract of donor animals and the association of leptospiral DNA with uterine stage embryos, the transmission of this disease is unlikely to occur by transfer of in vivo produced embryos in the bovine.

The effect of high concentrations of cryoprotectants on the passage of bovine viral diarrhea virus through the zona pellucida of in vitro fertilized embryos.

The effect of high concentrations of cryoprotectants on the passage of bovine viral diarrhea virus (BVDV) through the zona pellucida (ZP) of intact bovine embryos during the pre-freezing step of cryopreservation was investigated in a series of experiments. In vitro fertilized (IVF) embryos at the blastocyst stage were exposed to 10(6) TCID50 BVDV (non-cytopathic NY-1 strain) in a 30% suspension of either ethylene glycol, glycerol, DMSO, or 2 M sucrose in physiological saline for 10 min at 20 degrees C. Subsequently, the embryos were washed free of residual unbound viral particles, and the ZP of some embryos were removed by micromanipulation. Groups of ZP-intact embryos, ZP-free embryonic cells and their respective ZP were then tested separately for the presence of virus. The infectious virus was detected in association with 81% (17/21) of samples containing non-micromanipulated ZP-intact embryos which were exposed to the virus and cryoprotectants and then washed 10 times and in 83% (43/53) of the samples containing only ZP from micromanipulated embryos (P > 0.05). The virus was not found in the samples containing the corresponding embryonic cells of embryos exposed previously to the virus and cryoprotectants. It was concluded that the transfer of embryos from the isotonic PBS solution into a highly hypertonic cryoprotectant solution did not cause the passage of BVDV through ZP and its entry to embryonic cells.

In vitro fertilization and culture of ova from heifers infected with bovine herpesvirus-1 (BHV-1).

Oocytes collected from heifers infected experimentally with bovine herpesvirus-1 (BHV-1, 10(8) TCID(50)/ml) and from dexamethasone-treated (stressed) BHV-1 seropositive animals were matured, fertilized and co-cultured in vitro for 7 d prior to being tested for the presence of the virus. Nineteen of the 21 infected donors yielded embryos and follicular fluids that were BHV-1 positive. Oviductal cells (17 21 ) and uterine fluids (14 21 ) were also positive. Titers for the positive samples ranged 10(1.6)-10(9.6) TCID(50)/ml. The cleavage rate and the proportion of blastocysts that developed from oocytes of BHV-1 infected animals were 26% (n=361) and 6% compared with 56% (n=112) and 26% for uninfected control donors (P<0.05). In contrast, embryos produced from dexamethasone-treated animals tested negative for BHV-1 and yielded 11% blastocysts as compared with 25% for the control group. The results indicate that transferable-stage embryos can be produced by IVF from infected BHV-1 animals and that such embryos are associated with the virus, and might have potential for disease transmission.

The in vitro exposure to bovine rhinotracheitis virus of zona pellucida-micromanipulated bovine embryos with the zona pellucida damaged or removed.

One hundred and eighty-five embryos were collected from 29 superovulated donors 6 to 8 d post estrus. The zona pellucida (ZP) of these embryos was either cracked, removed mechanically or removed with acidified Tyrode's solution, or left intact. Forty-eight of 103 (47%) ZP-cracked and ZP-free embryos, exposed for 24 h to infectious bovine rhinotracheitis virus (IBRV), survived. No significant difference was found in the embryonic survival of the ZP-cracked embryos exposed to IBRV and control embryos not exposed to IBRV. However, there was a significant (P < 0.001) difference in the survival of ZP-free embryos exposed to IBRV and ZP-free embryos not exposed to IBRV (30% vs 80%).

Observations on the fertilization and development of preimplantation bovine embryos in vitro in the presence of Tritrichomonas foetus.

Tritrichomonas foetus, a world-wide distributed parasitic protozoan is a cause of infertility and abortion. There is no documented information on the susceptibility of bovine embryos to the parasite. To determine the effect of T. foetus on fertilization and embryonic development of preimplantation bovine embryos, we added approximately 10(4)/ml or 10(6)/ml T. foetus (Belfast strain) to sperm cells and oocytes prior to in vitro fertilization (IVF) or to presumptive zygotes 24 h post-fertilization. Light and scanning electron microscopy (SEM) revealed that exposure of oocytes or embryos at any stage of development to T. foetus caused rapid adhesion of the trichomonads to the embryonic intact zona pellucida (ZP) and to trophoblastic cells of hatched blastocysts. Treatment of contaminated embryos with 0.25% trypsin for 3 min did not render them free from T. foetus. Motile parasites were not observed after 18 h incubation in IVF medium, or after 72 h in synthetic oviductal fluid (SOF) embryo culture medium. The percentages of cleaved zygotes, blastocysts and hatched embryos resulting from culture of experimental and uninfected control groups of embryos were not different (P > 0.05). Tritrichomonas foetus was not detected in embryonic cells of ZP-intact or hatched embryos when examined by transmission electron microscopy (TEM). In conclusion, T. foetus has no detrimental effect on the fertilization and development of IVF embryos and the potential risk of transmission of trichomonosis is unlikely, due to the limited survival of the parasite in IVF culture conditions.

Inactivation of bovine herpesvirus-1 (BHV-I) from in vitro infected bovine semen.

Frozen-thawed bovine semen, experimentally infected with bovine herpesvirus-1 (BHV-1) at levels of 10(3) TCID(50)/ml and 10(4) TCID(50)/ml, was treated with a 0.3% trypsin solution to determine the effect of trypsin on the virus and on fertilization using superovulated animals. Virus was not isolated from any trypsin-treated samples using a cell culture assay system. Nor did two calves develop antibodies to BHV-1 following inoculation with trypsin-treated semen pooled from six bulls. Nonsurgical flushing of eight heifers inseminated with trypsin-treated frozen-thawed semen yielded 28 transferable-quality embryos.

Effect of dexamethasone and hydrocortisone on the course of superovulation in cattle.

The effect of hydrocortisone and dexamethasone on superovulation was examined in 12 cows. On the day PMSG was given, each animal received either the first of five daily doses of 250 mg succinate hydrocortisone or one injection of 30 mg dexamethasone. In the 48-hr interval between the injection of PMSG and PGF(2)alpha, the concentration of progesterone rose from 6.97 to 10.22 ng/ml in the experimental groups and only to about 2.8 ng/ml in the control group. In the following days progesterone increased even more, from 15.7 to 26.0 ng/ml seven days after estrus in the experimental group and to 19.25 ng/ml in the control group. The group which received dexamethasone had an average of 4.7 corpora lutea and one embryo flushed per animal. The hydrocortisone group had an average of 2.5 corpora lutea and one cow had two embryos. The control group had 6.2 corpora lutea and 5.2 embryos per animal.

Transitory acidification of semen as a potential method for the inactivation of some pathogenic microorganisms. Effect on fertilization and development of ova in superovulated heifers.

The fertilizing capacity of transitorily acidified semen was investigated with respect to using acidification as a method for destroying or inactivating acid labile pathogenic microorganisms in semen prior to freezing. Ejaculates diluted 1:1 with phosphate buffered saline (PBS) were acidified to pH 5.0 for 2 or 5 minutes before being returned to their original pH. They were then frozen by commercial methods and used to artificially inseminate superovulated heifers. A total 739 ova and embryos was collected from 119 inseminated donors. The fertilization rate was 88%, and 78% of the embryos were of transferable quality. Semen acidification had no apparent effect on the post-thaw percentage of intact acrosomes.

Association of bovine embryos produced by in vitro fertilization with a noncytopathic strain of bovine viral diarrhea virus type II.

In the first experiment, heifers were infected experimentally with bovine viral diarrhea virus type II (BVDV-type II, strain CD87; characterized by high morbidity and mortality). Subsequently, in vitro fertilized embryos were produced from oocytes collected on Day 4, 8, and 16 post infection. In a total of 29 heifers, the infectious virus was detected in 55% of the samples of the follicular fluid, in 10% of the oviductal cells, in 10% of the uterine flushes and in 41% of the in vitro fertilized embryos. The highest number of embryos associated with the virus was detected in the group of animals slaughtered on Day 8 post infection (58%). The amount of the virus (10(1.5-2.0) TCID50/mL) associated with the washed single embryos generated from oocytes of heifers 8 and 16 d post infection was sufficient for disease transmission by intravenous inoculation to the seronegative recipients (6/15). In the second experiment, uninfected oocytes were exposed in vitro to BVDV (10(5) TCID50/mL) in the maturation medium and then fertilized and cultured prior to viral assay. Virus was detected in 4 of 7 samples containing embryos but not in samples of embryos produced from the control group of uninfected oocytes. The presence of BVDV in the IVF system did not affect embryonic development in vitro. In conclusion, it appears that BVDV-type II has the ability to be transferred with oocytes through the IVF system, resulting in infectious embryos with normal morphological appearance which may have a potential for disease transmission.

Effect of Mycoplasma bovis and Mycoplasma bovigenitalium in semen on fertilization and association with in vitro produced morula and blastocyst stage embryos.

Frozen-thawed bovine semen contaminated with Mycoplasma bovis (M. bovis) or Mycoplasma bovigenitalium (M. bovigenitalium) at either a high (10(6) CFU/mL) or low (10(4) CFU/mL) concentration was used for bovine oocyte insemination. The resulting embryos were washed 10 times as recommended by the International Embryo Transfer Society (IETS) prior to isolation of agent. A total of 1494 oocytes was inseminated with contaminated sperm cells and 855 oocytes with uninfected control semen. There was a significantly higher proportion of embryos that developed to the blastocyst stage in control than in the mycoplasma exposed groups (P<0.05). Isolation of motile spermatozoa by swim-up procedure prior to insemination did not render sperm cells free of Mycoplasma spp. Although M. bovis was isolated from all washed embryos after the high exposure level, it was found in only 60% of the samples after the low exposure level. In contrast, M. bovigenitalium was isolated from 70 and 12% of washed embryos exposed to the high and low levels of microorganism, respectively. Using scanning electron microscopy, both microorganisms were detected in association with the surface of zona pellucida-intact embryos and with sperm cells. These results indicate that mycoplasmas present in semen can be transmitted through the IVF system and infect embryos. Furthermore, the experiments showed that supplementation of culture media with standard antibiotics and washing embryos as recommended by IETS were not effective in rendering IVF embryos free from M. bovis and M. bovigenitalium.

Factors affecting survival of deep frozen bovine embryos in vitro: The effect of freezing container and method of removing cryoprotectant.

The effect of freezing container and method of glycerol removal on in vitro survival of frozen-thawed Day 7 bovine embryos was investigated. Two hundred and fifteen embryos were frozen in ampules or straws, in either vertical or horizontal position and at a cooling rate of 0.3 degrees C/minute from -7 degrees C to -35 degrees C, before being plunged into liquid nitrogen. Samples were thawed in a water bath at +35 degrees C and glycerol was removed by either step-wise dilution (increments 0.25 M) or by exposure to 1.0 M sucrose for 10 minutes. A total of 197 embryos was recovered post-thaw (91%) with an overall survival after 1, 3, 6 and 24 hours in culture of 87, 81, 71, and 23%, respectively. Embryonic quality and percent survival, as assessed morphologically, did not change significantly between 1 and 3 hours but decreased significantly between 6 and 24 hours in culture (p < 0.05). Survival at 24 hours was significantly higher after removal of the cryoprotectant with sucrose when compared to the step-wise glycerol dilution (p < 0.05). Overall, embryonic survival in straws equaled that in ampules; freezing orientation of straws did not affect results. Further, glycerol removal with sucrose tended to yield survival superior to that provided by a step-wise dilution technique.