Optimization of Antifungal Properties of Hop Cone Carbon Dioxide Extracts Based on Response Surface Methodology.

Response surface methodology (RSM) was employed to optimize the process parameters of the supercritical carbon dioxide extraction of hop cones in terms of their antifungal properties against Fusarium culmorum and Aspergillus niger. The effects of temperature (40-50 °C), pressure (200-300 bar), and CO2 consumption (25-75 kgCO2/kg) on the extraction yield, content of α- and ß-acids, as well as pathogens' growth inhibition were investigated. Both pressure and CO2 consumption had a significant effect on antifungal properties. It was observed that the best results for antifungal properties were obtained when hop cones were extracted with pure carbon dioxide at the temperature of 50 °C, under the pressure of 300 bar with CO2 consumption at the level of 75 kgCO2/kg of feed for extraction. The highest antifungal properties of hop cone supercritical carbon dioxide extracts were analyzed as 100% for Fusarium culmorum and 68% for Aspergillus niger, calculated as the growth inhibition of tested pathogens. The aim of the study was to determine the optimum values of extraction parameters to achieve the maximum response and enable us to investigate the interaction of these parameters on the antifungal properties of hop cone extracts.

Multi-Residue Method for Pesticides Determination in Dried Hops by Liquid Chromatography Tandem Mass Spectrometry.

In this study a multi-residue determination method for 36 pesticides in dried hops was reported. The sample preparation procedure was based on the acetate buffered QuEChERS method. A few mixtures of dispersive solid phase extraction (dSPE) sorbents consisting PSA, C18, GCB, Z-Sep and Z-Sep+ were investigated to clean-up the supernatant and minimize matrix co-extractives. The degree of clean-up was assessed by gravimetric measurements, which showed the best results for mixtures containing the Z-Sep+ sorbent. This is the first study to apply Z-Sep+ sorbent for hops material and the first to improve the method for pesticide residues determination in hops. Samples were analysed using liquid chromatography coupled with tandem mass spectrometry (LC-MS/MS) and the procedure was validated according to the SANTE/11813/2017 document at four concentration levels: 0.02, 0.05, 0.1 and 1 mg/kg. The limits of quantification (LOQ) were in the range of 0.02-0.1 mg/kg. For all active substances, the trueness (recovery) ranged from 70 to 120% and the precision (RSDr) value was <20%. Specificity, linearity and matrix effect were also evaluated. The validated method was applied to the analysis of 15 real dried hop samples and the relevant data on detected residues were included.

Molecular Distillation of Lavender Supercritical Extracts: Physicochemical and Antimicrobial Characterization of Feedstocks and Assessment of Distillates Enriched with Oxygenated Fragrance Components.

Lavandula angustifolia is one of the most widely cultivated non-food crops used in the production of essential oil; it is used in perfumery, aromatherapy, pharmaceutical preparations, and food ingredients. In this study, supercritical fluid extraction (SFE) and molecular distillation (MD) were combined, primarily to enrich scCO2 extracts with lavender oxygenated monoterpenes, avoiding thermal degradation, hydrolysis, and solvent contamination, and maintaining the natural characteristics of the obtained oils. Molecular distillation was developed for the first time for the extraction of crucial lavender fragrance ingredients, i.e., from two scCO2 extracts obtained from dry flower stems of lavender cultivated in Poland and Bulgaria. The best results for high-quality distillates were obtained at 85 °C (EVT) and confirmed that linalyl acetate content increased from 51.54 mg/g (initial Bulgarian lavender extract, L-Bg-E) and 89.53 mg/g (initial Polish lavender extract, L-Pl-E) to 118.41 and 185.42 mg/g, respectively, corresponding to increases of 2.3 and 2.1 times in both distillate streams, respectively. The distillates, light oils, and extracts from lavender were also evaluated for their antimicrobial properties by determining the minimum inhibitory concentration (MIC) by the broth microdilution method. Generally, Gram-positive bacteria and Candida spp. were more sensitive to all distilled fractions and extracts than Escherichia coli (Gram-negative bacteria).

Supercritical Carbon Dioxide (scCO2) Extraction of Phenolic Compounds from Lavender (Lavandula angustifolia) Flowers: A Box-Behnken Experimental Optimization.

Due to their numerous health benefits associated with various diseases and anti-oxidation properties, the phenolic compounds collectively referred to as phytochemicals have attracted a lot of interest, however, a single extraction method for polyphenols has not been developed yet. Supercritical fluid extraction, a green extraction method, provides the final product without organic solvent residues. In this work the extraction of lavender was performed using supercritical carbon dioxide. A statistical experimental design based on the Box-Behnken (B-B) method was planned, and the extraction yields and total phenolic contents were measured for three different variables: pressure, temperature and extraction time. The ranges were 200-300 bar, 40-60 °C and 15-45 min. The extracts yields from scCO2 extraction were in the range of 4.3-9.2 wt.%. The highest yield (9.2 wt.%) was achieved at a temperature of 60 °C under the pressure of 250 bar after 45 min. It also corresponded to the highest total phenolic content (10.17 mg GAE/g extract). Based on the study, the statistically generated optimal extraction conditions to obtain the highest total phenolic compounds concentration from flowers of Lavandula angustifolia were a temperature of 54.5 °C, pressure of 297.9 bar, and the time of 45 min. Based on the scavenging activity percentage (AA%) of scCO2 extracts, it is concluded that the increase of extraction pressure had a positive influence on the increase of AA% values.

Antifungal Properties of Fucus vesiculosus L. Supercritical Fluid Extract Against Fusarium culmorum and Fusarium oxysporum.

In this study, potential antifungal properties of a brown alga Fucus vesiculosus were evaluated. The algal extract was obtained with the use of supercritical fluid extraction (scCO2) at a temperature of 50 °C under a pressure of 300 bar. The aqueous solution of the extract at the concentration of 0.05%, 0.2%, 0.5% and 1.0% was studied against pathogenic fungi on a liquid RB medium. This study is the first report on antifungal properties of the brown algae F. vesiculosus scCO2 extract against Fusarium culmorum and Fusarium oxysporum phytopathogens. The concentrations of the studied extract (0.5% and 1.0%) were demonstrated to have an ability to inhibit 100% growth of macroconidia within 144 h, as well as an ability to cause their total degradation. As a result of the study, the antifungal effect of fucosterol against F. culmorum was also indicated. The total macroconidia growth was inhibited by 1.0% fucosterol. Moreover, at lower concentrations (0.05-0.2%) of fucosterol, macroconidia were characterized by shorter length and structural degradation was observed. The mycelial growth of Fusarium oxysporum (Fo38) by 1% scCO2 F. vesiculosus extract was analyzed at the level of 48% after 168 h of incubation, whereas 100% extract was found to be effective in F. culmorum (CBS122) and F. oxysporum (Fo38) growth inhibition by 72% and 75%, respectively after 168 h of incubation.

The Application of Supercritical Fluid Extraction in Phenolic Compounds Isolation from Natural Plant Materials.

The separation of phenolic compounds by supercritical fluid extraction has been widely studied throughout the last two decades. This is evidenced by a number of publications and articles. Supercritical fluid extraction (SFE) has become thus the effective method of separating the mentioned group of compounds. On the other hand, SFE is a beneficial approach in plant waste materials utilization and reduction of environmental burdens caused by the wastes. The aim of the study is to gather and systematize available information on the phenolic compounds separation that have been reported so far as well as to evaluate whether there is one optimal supercritical fluid extraction method for the phenolic compounds.

Essential Oils from Humulus Lupulus scCO2 Extract by Hydrodistillation and Microwave-Assisted Hydrodistillation.

Two different extraction methods were used for a comparative study of essential oils obtained from the Humulus lupulus scCO2 (sc-supercritical) extract: microwave-assisted hydrodistillation (MAHD) and conventional hydrodistillation (HD). As a result, the best conditions for the maximum essential oil production were determined for the MAHD method at 335 W microwave power for 30 min at water to raw material ratio of 8:3. The obtained essential oils were enriched in ß-myrcene in the amount of 74.13%⁻89.32% (wt%). Moreover, the first application for determination of the above-mentioned volatile compounds by supercritical fluid chromatography (SFC) with photo-diode array detection (PDA) is presented, which in comparison with gas chromatography coupled with mass spectrometry (GC-MS/MS) resulted in similar values for ß-myrcene and α-humulene in obtained samples within less than 1 min.

A Novel Strategy for the Separation of Functional Oils from Chamomile Seeds.

The main aim of this study was to evaluate the oils from chamomile seeds as a new source of bioactive compounds suitable for human consumption. A green extraction technique with supercritical carbon dioxide (sc-CO2) at pressures up to 450 bar and temperatures up to 60 °C was employed for the production of a high amount of biologically active oil. Additionally, exhausted waste material was re-extracted using sc-CO2 with the addition of ethanol. By optimization in operating pressure, temperature, production cost, fraction of milled seeds, and co-solvent addition, the amount of separated chamomile oil increased from 2.4 to 18.6% and the content of unsaturated fatty acids up to 88.7%. Oils contained α-bisabolol oxide A and B in amounts up to 1.4%. Linoleic acid was detected in an amount up to 711.1 mg/g and α-linolenic acid up to 27.5 mg/g. The total phenolic content in separated oil reached 80.4 mg GAE/g while the total flavonoid content reached 11.6 mg QE/g. The obtained chamomile oils showed antioxidant activity with an IC50 of up to 3.9 mg/mL. Among the 23 tested microorganisms, the antimicrobial activity of oils was the most pronounced against Gram-positive bacteria. The cytotoxic activity of oils was tested on normal and cancer-derived cell lines. Results indicated a significant potential for oil from chamomile seeds, produced in an eco-friendly manner, as a functional food. Supplementary Information: The online version contains supplementary material available at 10.1007/s11947-023-03038-9.

Rare-earth metal alkyl and hydride complexes stabilized by a cyclen-derived [NNNN] macrocyclic ancillary ligand.

A trinuclear rare-earth metal hydride complex was synthesized from the dialkyl complex supported by a monoanionic [NNNN] macrocycle and shown to catalyze the hydrosilylation of olefins efficiently.

Lutetium alkyl and hydride complexes in a non-cyclopentadienyl coordination environment.

Lutetium alkyl complexes [Lu(L)(CH(2)SiMe(3))(THF)(n)], which contain a sulfur-linked bis(phenolato) ligand such as 2,2'-thiobis(6-tert-butyl-4-methylphenolate) (L=tbmp, 1) or 1,4-dithiabutanediyl-bis(6-tert-butyl-4-methylphenolate) (L=etbmp, 2), were isolated from the reaction of the lutetium tris(alkyl) complex [Lu(CH(2)SiMe(3))(3)(THF)(2)] with H(2)L. The monomeric structures of these complexes were confirmed by X-ray diffraction studies, showing distorted octahedral geometry around the metal centre. The reaction of [Lu(tbmp)(CH(2)SiMe(3))(THF)(2)] (1) with alcohols ROH (R=iPr, CHPh(2), CPh(3)) results in the formation of the corresponding alkoxide complexes [Lu(tbmp)(OR)(THF)(n)] (4-6). With PhSiH(3) hydride complexes [Lu(L)(mu-H)(THF)(n)](2) (L=tbmp, 7; etbmp, 8) have been prepared in moderate to good yields. They adopt a dimeric form in the solid state as revealed by the X-ray crystal structure of 7. The reactivity of the hydride complexes and their catalytic activity in the ring-opening polymerisation of L-lactide and the hydrosilylation of alkenes are also discussed.