RESUMEN
A survey at five pigs' slaughterhouses was performed to investigate the effect of a quality assurance system, pre-slaughter conditions and slaughterhouse facilities on pork quality. Totally, 2246 pigs were included over four transports per slaughterhouse, i.e. two transports were produced according to a quality assurance system and the other two were conventional pigs. Meat quality was measured on 446 pigs. The pH in the longissimus dorsi muscle and the electrical conductivity in the semimembranosus muscle were measured 30min post-mortem. Twenty-four hours later pH and electrical conductivity in both the longissimus dorsi and the semimembranosus muscle were measured. Pigs managed according to a chain quality protocol showed an overall higher potential for improved meat quality. Differences in meat quality between the different slaughterhouses were also found, however they were dependent on muscle type and time of measuring. Influencing factors on pork quality seemed to be stocking density during transport, the handling during offloading the pigs from the truck, stocking density, and air temperature during lairage.
RESUMEN
A total of 180 pigs was slaughtered in the same slaughterhouse, but divided in six different trials distributed over Winter (December-March) and Summer (April-September). Meat quality measurements (pH, electrical conductivity, color and/or water-holding capacity) were carried out 30 min, 24 and/or 35h after slaughter in three different muscles: M. gracilis, M. semimembranosus and M. longissimus dorsi. A tendency towards a higher proportion of PSE meat during Summer was found in the examined muscles. Moreover a higher protein, higher dry matter content, a lower water/protein ratio and a lower slicing yield were found for the cooked hams suggesting a higher PSE prevalence in the Summer. A lairage time between 2 and 4h during Summer and less than 2h during Winter was related to a lower proportion of PSE meat. The correlation coefficients between the individual meat quality variables were moderate, but showed the predictive power of the pH measured 24h post-mortem in the M. gracilis for meat quality.