Sensitivity of Echinochloa muricata and Echinochloa crus-galli to HPPD- and ALS-inhibiting herbicides in corn.

Until recently Echinochloa muricata var. microstachya Wiegand (rough barnyardgrass), an alien species native to North America, was completely overlooked in Belgium due to its close morphological resemblance to Echinochloa crus-galli (L.) P. Beauv. (barnyardgrass). E. muricata var. microstachya has gradually spread and is now locally naturalized and abundant in and along maize fields. One of the possible reasons for its expansion in maize fields, besides e.g. the lack of crop rotation, might be a lower sensitivity to postemergence herbicides acting against panicoid grasses, in particular 4-hydroxyphenyl pyruvate dioxygenase (HPPD)-inhibiting herbicides and acetolactate synthase (ALS) inhibiting herbicides. Dose-response pot experiments were conducted in the greenhouse to evaluate the effectiveness of four HPPD-inhibitor herbicides [topramezone (ARIETTA), mesotrione (CALLISTO), tembotrione (LAUDIS), sulcotrione (MIKADO) and the ALS-inhibitor herbicide nicosulfuron (KELVIN) for controlling local populations of E. crus-galli and E. muricata. Pots were planted with 25 seeds, thinned afterwards to 5 plants (one week after sowing) and irrigated by overhead sprinklers. Herbicides were applied at the 3-4 leaf stage (BBCH stage 13-14). Fresh biomass was harvested 28 d after treatment. In another dose-response pot experiment, the influence of leaf stage at time of herbicide application on efficacy of topramezone for (rough) barnyardgrass control was evaluated. Sensitivity to HPPD-inhibitor herbicides topramezone and sulcotrione was significantly lower for E. muricata populations than for E. crus-galli populations. However, nicosulfuron sensitivity of both species was similar. Compared to E. crus-galli, sensitivity of E. muricata to topramezone was more dependent on leaf stage. Due to the intragenus variability in sensitivity to HPPD-inhibitor herbicides, higher awareness is required for presence of E. muricata plants in maize fields in order to avoid insufficient "barnyardgrass" control.

Effect of washing conditions on the recovery of milk fat globule membrane proteins during the isolation of milk fat globule membrane from milk.

During the isolation of milk fat globule membrane (MFGM) from milk, washing is considered the most critical stage in which loss of MFGM components occurs. In this study, using a cream separator, the influence of washing on the recovery of MFGM proteins was investigated. The residue of non-MFGM proteins in the MFGM material obtained after washing was quantitatively determined using densitometric analysis of one-dimensional sodium dodecyl sulfate-PAGE after silver staining of the gel. Using deionized water as the washing solution did not increase the loss of MFGM proteins compared with other common salt solutions in terms of recovery of MFGM proteins and contamination with non-MFGM proteins. The increase in wash temperature from 38 to 46 degrees C did not show a significant decrease in yield of MFGM proteins because of variation between the experimental replicates. Coalescence of fat globules occurs during isolation. To increase MFGM purity while maintaining a high MFGM protein recovery, using larger volumes of wash solution is more advisable rather than increasing the number of washings from 2 to 3.

Thermocalcic aggregation of milk fat globule membrane fragments from acid buttermilk cheese whey.

Fragments originating from the milk fat globule membrane (MFGM), which is rich in polar lipids and membrane-specific proteins, are gaining interest for their functional and nutritional properties. Acid buttermilk cheese whey was used as a source for MFGM purification, because its MFGM content is more than 5 times higher than that of standard rennet whey. Because polar lipids are the main constituent of the MFGM and only occur in membranous structures, the polar lipid content was taken as a parameter for the total MFGM fragment content. The process of thermocalcic aggregation was evaluated on its recovery of MFGM fragments in the pellet. This method, originally intended for whey clarification and defatting, is a combination of calcium addition, a pH increase, and a thermal treatment. The influence of pH (6.5 to 8), temperature (40 to 70 degrees C), and calcium concentration (0.1 to 0.24 g/100 g) on the pellet mass and dry matter (DM) content and on recovery of protein and polar lipids (and thus indirectly on MFGM fragments) was investigated by means of a response surface Box-Behnken orthogonal design. Reduced quadratic models were fit to the experimental data and were found to be highly significant. No outliers were observed. The recovery of MFGM fragments was found to be highly dependent on the pH, and less dependent on temperature and calcium addition. Next to MFGM proteins, whey proteins were also found to be involved in the formation of aggregates. Optimal conditions were found at 55 degrees C, pH 7.7, and 0.205 g of calcium/L of whey. Under these conditions, 91.0% of the whey polar lipids were recovered in a firm and compact pellet of only 7.86% of the original whey mass, with a polar lipid concentration of 8.34% on pellet DM. Washing with water and centrifugation of the pellet was successful because after one washing step, virtually all sugars were removed, whereas 75.9% of the whey polar lipids could still be recovered. As such, the polar lipid content of the washed pellet increased to 10.70% on a DM basis. However, a second washing step resulted in serious losses of MFGM material.

Filtration of milk fat globule membrane fragments from acid buttermilk cheese whey.

The proteins and polar lipids present in milk fat globule membrane (MFGM) fragments are gaining attention for their technological and nutritional properties. These MFGM fragments are preferentially enriched in side streams of the dairy industry, like butter serum, buttermilk, and whey. The objective of this study was to recover MFGM fragments from whey by tangential filtration techniques. Acid buttermilk cheese whey was chosen as a source for purification by tangential membrane filtration because it is relatively rich in MFGM-fragments and because casein micelles are absent. Polyethersulfone and cellulose acetate membranes of different pore sizes were evaluated on polar lipid and MFGM-protein retention upon filtration at 40 degrees C. All fractions were analyzed for dry matter, ash, lipids, proteins, reducing sugars, polar lipid content by HPLC, and for the presence of MFGM proteins by sodium dodecyl sulfate-PAGE. A fouling coefficient was calculated. It was found that a thermocalcic aggregation whey pretreatment was very effective in the clarification of the whey, but resulted in low permeate fluxes and high retention of ash and whey proteins. By means of an experimental design, the influence of pH and temperature on the fouling and the retention of polar lipids (and thus MFGM fragments), proteins, and total lipids upon microfiltration with 0.15 microM cellulose acetate membrane was investigated. All models were highly significant, and no outliers were observed. By increasing the pH from 4.6 to 7.5, polar lipid retention at 50 degrees C increased from 64 to 98%, whereas fouling of the filtration membrane was minimized. A 3-step diafiltration of acid whey under these conditions resulted in a polar lipid concentration of 6.79 g/100 g of dry matter. As such, this study shows that tangential filtration techniques are suited for the purification of MFGM fragments.

Microfiltration of butter serum upon casein micelle destabilization.

The gross composition of butter serum, the aqueous phase of butter, is comparable to that of buttermilk, except that it has a higher content of material derived from the milk fat globule membrane (MFGM). As such, butter serum is a good source for further purification of MFGM material. The purified fraction could be of interest for its emulsifying and nutritional properties. The effect of sodium citrate and ethanol on the dissociation of butter serum casein micelles, and their effect on casein retention upon tangential microfiltration were investigated. Optimal conditions of casein micelle dissociation were assessed by using an experimental design (response surface full central composite orthogonal design) with temperature and ethanol or sodium citrate concentration as design variables and the Hunter L* value as response variable. For both dissociating agents, a highly significant reduced quadratic model was fit to the data. Microfiltration tests were performed on pure butter serum, and on butter serum in the presence of sodium citrate, under optimal dissociation conditions (50 degrees C, 80 mM). A cellulose acetate membrane with a pore size of 0.15 microm was used. From the filtration curves and fouling coefficients it was clear that the addition of sodium citrate improved the permeation flux, and minimized fouling. All fractions were analyzed for dry matter, protein, lactose, lipid, and polar lipid contents. The protein fraction was further characterized by sodium dodecyl sulfate-PAGE. It was shown that sodium citrate greatly enhanced casein transmission through the membrane, but at the expense of substantial losses of polar lipids.

Analysis of phospho- and sphingolipids in dairy products by a new HPLC method.

Dairy phospho- and sphingolipids are gaining interest due to their nutritional and technological properties. A new HPLC method, using an evaporative laser light-scattering detector, was developed, which enabled excellent separation of glucosylceramide, lactosylceramide, phosphatidic acid, phosphatidylethanolamine, phosphatidylinositol, phosphatidylserine, phosphatidylcholine, sphingomyelin, and lysophosphatidylcholine in less than 21 min, including the regeneration of the column. No loss of column performance was observed after 1500 runs because an acid buffer was used. The output signal of the evaporative laser light scattering detector was highly dependent of the flow of the carrier gas and the temperature of the nebulizer, and was maximized by means of a response surface experimental design. Finally, raw milk, cream, butter, buttermilk, Cheddar whey, quarg, and Cheddar cheese were analyzed for their polar lipid content. The absolute values varied substantially (0.018 to 0.181 g/100 g of product). Significant differences were found in the relative content of each polar lipid class among the analyzed products.