Response surface optimization of sludge dewatering process: synergistic enhancement by ultrasonic, chitosan and sludge-based biochar.

Due to the colloidal stability, the high compressibility and the high hydration of extracellular polymeric substances (EPS), it is difficult to efficiently dehydrate sludge. In order to enhance sludge dewatering, the process of ultrasonic (US) cracking, chitosan (CTS) re-flocculation and sludge-based biochar (SBB) skeleton adsorption of water-holding substances to regulate sludge dewaterability was proposed. Based on the response surface method, the prediction model of the specific resistance to filtration (SRF) and sludge cake moisture content (MC) was established. The US cracking time and the dosage of CTS and SBB were optimized. The results showed that the optimal parameters of the three were 5.08 s, 10.1 mg/g dry solids (DS) and 0.477 g/g DS, respectively. Meantime, the SRF and MC were 5.4125 × 1011 m/kg and 76.8123%, which significantly improved the sludge dewaterability. According to the variance analysis, it is found that the fitting degree of SRF and MC model is good, which also confirms that there is significant interaction and synergy between US, CTS and SBB, and the contribution of CTS and SBB is greater. Moreover, the process significantly improves the sludge's calorific value and makes its combustion more durable.

Quaternization-based graft modification of straw fibers for conditioning the sludge dewatering performance.

Extracellular polymeric substances (EPS) are a critical influencing factor in sludge dewatering. Disrupting such EPS contributes to the release of bound water in sludge, enhancing the sludge dewatering performance. In This study, quaternized straw fibers that are destructive to the EPS structure and components in active sludge were prepared useing heterogeneous free radical graft polymerization. Straw fibers, dimethyl diallyl ammonium chloride (DMDAAC), ammonium persulfate (APS), and acrylamide (AM) were taken as the substrate, grafting monomer, catalyst, and cross-linking agent, respectively.The optimal processing conditions determined for the DMDAAC-based quaternization and graft modification of straw fibers were as follows: reaction temperature of 60 °C, reaction time of 5 h, 0.100 g of catalyst APS dosage per gram of straw, and 3.000 ml of DMDAAC dosage per gram of straw. The optimal processing conditions yielded 1.335 g of modified straw fibers per gram of straw, 33.67% grafting rate, and 31.70% substitution of the quaternary ammonium groups. The capillary suction time (CST) was conditioned from 243.3 ± 22.6 s in the original sludge to 134.5 ± 34.45 s. The specific resistance to filtration (SRF) was reduced from 8.82 ± 0.51 × 1012 m/kg in the original sludge to 4.59 ± 0.23 × 1012 m/kg.

A Multi-Stage Visible and Infrared Image Fusion Network Based on Attention Mechanism.

Pixel-level image fusion is an effective way to fully exploit the rich texture information of visible images and the salient target characteristics of infrared images. With the development of deep learning technology in recent years, the image fusion algorithm based on this method has also achieved great success. However, owing to the lack of sufficient and reliable paired data and a nonexistent ideal fusion result as supervision, it is difficult to design a precise network training mode. Moreover, the manual fusion strategy has difficulty ensuring the full use of information, which easily causes redundancy and omittance. To solve the above problems, this paper proposes a multi-stage visible and infrared image fusion network based on an attention mechanism (MSFAM). Our method stabilizes the training process through multi-stage training and enhances features by the learning attention fusion block. To improve the network effect, we further design a Semantic Constraint module and Push-Pull loss function for the fusion task. Compared with several recently used methods, the qualitative comparison intuitively shows more beautiful and natural fusion results by our model with a stronger applicability. For quantitative experiments, MSFAM achieves the best results in three of the six frequently used metrics in fusion tasks, while other methods only obtain good scores on a single metric or a few metrics. Besides, a commonly used high-level semantic task, i.e., object detection, is used to prove its greater benefits for downstream tasks compared with singlelight images and fusion results by existing methods. All these experiments prove the superiority and effectiveness of our algorithm.

Exploring the role of potassium ferrate and straw fiber in enhancing the strength of cement-based solidified municipal sludge.

The effect of potassium ferrate (PF) and straw fiber (SF) on the strength of cement-based solidified municipal sludge, including the influence of reducing the organic matter in the sludge on the efficiency of the hydration of the cement, was studied. Single-factor tests, orthogonal tests, and linear weighted optimization methods were used to obtain suitable ratios to meet practical requirements, and then SEM and XRD analyses were used to explore the solidification mechanism. The results showed that PF and SF had significant influence on the strength, with SF having the greatest influence and the strength increasing with the amount of both admixtures, and cement had no significant influence on the strength. After linear weighting optimization, the ideal dosage was found to be 20% cement, 20% PF, and 5% SF, which produced a solidified sludge that had an strength of 126.87 kPa, far higher than the 50 kPa required to qualify for disposal in landfills. Analysis of the mineral content and microstructure showed that PF and SF could promote cement hydration and produce more hydration products, and the density of the optimized sample was much higher than that of the raw sludge and a sludge sample mixed with 20% cement alone.

The influence of different sludge concentrations on its dewaterability during bioleaching.

Bioleaching, a technologically and economically feasible technology, is considered as the high efficiency method to improve dewaterability in sewage sludge. The objective of this study was to investigate the effect of different sludge concentrations on bioleaching dewaterability and understand the mechanism of the effect of bioleaching on sludge dewaterability. Variation in pH, oxidation-reduction potential (ORP), capillary suction time (CST), specific resistance to filtration (SRF) and different fractions of extracellular polymeric substances (EPS) including slime EPS (S-EPS), loosely bound EPS (LB-EPS), and tightly bound EPS (TB-EPS) were determined. Different sludge concentrations (5, 10, 15, 20 and 30 g·L-1) were selected to investigate during bioleaching. Results indicated that sludge buffering capacity significantly inhibited bioleaching efficiency as sludge concentrations increased. Optimum enhancements in sludge dewaterability were observed during the 10 g·L-1 sludge concentration treatment, and reached a maximum when the pH was 2.11. The variation of different fractions of EPS revealed that the ratio of S-EPS/TB-EPS significantly affected sludge dewaterability. Principal component analysis and Pearson's correlation analysis both provided evidence that the higher TB-EPS followed by a very large reduction was positively correlated with sludge dewaterability. However, the increase of protein and DNA in S-EPS content was negatively correlated with sludge dewaterability.

Effect of using different proportions of inoculum during bioleaching on sludge dewaterability.

Bioleaching, the addition of bacteria to geological materials, has been applied to sludge to remove metals and improve upon sludge dewaterability. This paper investigates the effect of using different quantities of inoculum (bacteria) during bioleaching on sludge dewaterability. The analysis was based on bioleaching experiments conducted in a 20 L bio-reactor using different quantities of inoculum (20%, 10%, 5%, 2%, 0%). Changes in pH, oxidation reduction potential (ORP), capillary suction time (CST), specific resistance to filtration (SRF) and extracellular polymeric substances (EPS) were determined to gauge sludge dewatering. Results indicate that sludge dewaterability during the 2%, 10%, and 20% inoculum experiments declined through time. Decreased dewaterability is attributed to increases in the quantity of proteins and polysaccharides in slime EPS. Dewaterability improved during the 5% inoculum experiment, and reached a maximum when pH was 2.3. During this latter experiment, CST and SRF were reduced by 74% and 62%, respectively, in comparison to control conditions, while total EPS content decreased by 71%. The decrease in total EPS was primarily due to a decrease in proteins associated with tightly bound EPS (TB-EPS). Thus, changes in the amount of proteins in TB-EPS and sludge pH played a crucial role in sludge dewaterability.

Study on biodegradability of terephthalic acid in polyester fabric alkali-peeling process wastewater.

Terephthalic acid (TA) and ethylene glycol (EG) are the main pollutants in polyester fabric alkali-peeling process wastewater (PAP-wastewater). The biodegradability of TA is crucial to the deep treatment of PAP-wastewater. Batch and continuous experiments were adopted to study the biodegradation of TA in synthetic wastewater. In anoxic batch experiments TA began to degrade gradually after EG was depleted completely. However, in aerobic batch experiments the biodegradation curves of TA in the presence of EG were almost identical to those of TA in the absence of EG. The combined process of anoxic hydrolysis-acidification bioreactor (HABR) and aerobic hybrid membrane bioreactor (HMBR) was employed to treat synthetic PAP-wastewater in continuous experiments. When TA was fed as sole substrate, about 6.1% was removed in the anoxic HABR and 92.1% was biodegraded in the aerobic HMBR. When TA and EG were fed as substrate, only 1.9% of TA was biodegraded in the anoxic HABR and 96.6% of TA was removed in the aerobic HMBR. By contrast, most EG was removed in the anoxic HABR. The experimental results revealed that the combined process of anoxic HABR and aerobic HMBR was an attractive alternative for the treatment of PAP-wastewater and other similar wastewater.

Mechanistic study of the effect of potassium ferrate and straw fiber on the enhancement of strength in cement-based solidified municipal sludge.

The high content of organic matter in sludge is the primary reason for the poor solidifying effect and excessive dosage of the cement base. In this study, potassium ferrate and straw fiber are utilized to synergistically enhance the solidifying effect of the cement and elaborate the strength mechanisms. Among them, potassium ferrate was selected to oxidize and crack the structure of organic matter in sludge and consume part of organic matter; straw fiber was used as an adsorption material to absorb some of the organic material and reduce its interference with the cement hydration reaction; the skeleton function of straw fiber in solidified sludge was used to improve the final solidified sludge strength. It is shown that the presence of these two additives significantly improved the cement solidification strength and reduced the moisture content of the solidified body. Moreover, the moisture content and strength followed an obvious linear relationship (adjusted R2 = 0.92), with the strength increasing as the moisture content decreased. After pretreatment with potassium ferrate, the free water content in the dewatered sludge increased by 4.5%, which was conducive to the adequate hydration reaction with cement. The analysis using X-ray diffraction (XRD), scanning electron microscopy with energy dispersive X-ray spectroscopy (SEM/EDS), and mercury intrusion porosimetry (MIP) revealed potassium ferrate synergizes with straw fibers to promote the production of hemihydrate gypsum and gismondine. However, hemihydrate gypsum, calcium carbonate, and gismondine resulted in structural swelling, which was confirmed by the microscopic morphology and pore structure analysis. However, the adverse effects due to swelling were offset by the increase in strength brought by the above crystalline substances.

Determination of Phosphorus in Soil by ICP-OES Using an Improved Standard Addition Method.

In this study, an improved standard addition method (ISAM) was developed for the determination of phosphorus in soil by ICP-OES based on the conventional standard addition method (CSAM) and calibration curve method (CCM). Certified standard soils were analyzed by the proposed ISAM method. The values obtained by ISAM method agreed with the certified values. Additionally, the results obtained by ISAM method were compared with those determined by the other two methods (CSAM and CCM). All the values obtained by the ISAM agreed with those from the other two methods. The detection limit, quantification limit, and recovery rate of each method were calculated, and the recovery rates of soil samples and the blank were all within the range of 90%-110%. Finally, the proposed method was applied to determine phosphorous in soil samples from Guangnan County, Yunnan Province, China, and the meadow soil from Qinghai-Tibet Plateau, China. The relative errors between the results from ISAM and CCM were all within 10%, and t-test showed that the results between ISAM and CCM had no significant difference (P > 0.05). Therefore, the proposed method overcame the matrix effect in some extent and was an acceptable method for the rapid and accurate batch analysis of P content in soil sample, especially batch samples with obvious matrix effect.

Comparative transcriptome analyses of oleaginous Botryococcus braunii race A reveal significant differences in gene expression upon cobalt enrichment.

BACKGROUND: Botryococcus braunii is known for its high hydrocarbon content, thus making it a strong candidate feedstock for biofuel production. Previous study has revealed that a high cobalt concentration can promote hydrocarbon synthesis and it has little effect on growth of B. braunii cells. However, mechanisms beyond the cobalt enrichment remain unknown. This study seeks to explore the physiological and transcriptional response and the metabolic pathways involved in cobalt-induced hydrocarbon synthesis in algae cells. RESULTS: Growth curves were similar at either normal or high cobalt concentration (4.5 mg/L), suggesting the absence of obvious deleterious effects on growth introduced by cobalt. Photosynthesis indicators (decline in Fv/Fm ratio and chlorophyll content) and reactive oxygen species parameters revealed an increase in physiological stress in the high cobalt concentration. Moreover, cobalt enrichment treatment resulted in higher crude hydrocarbon content (51.3% on day 8) compared with the control (43.4% on day 8) throughout the experiment (with 18.2% improvement finally). Through the de novo assembly and functional annotation of the B. braunii race A SAG 807-1 transcriptome, we retrieved 196,276 non-redundant unigenes with an average length of 1086 bp. Of the assembled unigenes, 89,654 (45.7%), 42,209 (21.5%), and 32,318 (16.5%) were found to be associated with at least one KOG, GO, or KEGG ortholog function. In the early treatment (day 2), the most strongly upregulated genes were those involved in the fatty acid biosynthesis and metabolism and oxidative phosphorylation, whereas the most downregulated genes were those involved in carbohydrate metabolism and photosynthesis. Genes that produce terpenoid liquid hydrocarbons were also well identified and annotated, and 21 (or 29.2%) were differentially expressed along the cobalt treatment. CONCLUSIONS: Botryococcus braunii SAG 807-1 can tolerate high cobalt concentration and benefit from hydrocarbon accumulation. The time-course expression profiles for fatty acid biosynthesis, metabolism, and TAG assembly were obtained through different approaches but had equally satisfactory results with the redirection of free long-chain fatty acid and VLCFA away from TAG assembly and oxidation. These molecules served as precursors and backbone supply for the fatty acid-derived hydrocarbon accumulation. These findings provide a foundation for exploiting the regulation mechanisms in B. braunii race A for improved photosynthetic production of hydrocarbons.

Effects of total solids content on performance of sludge mesophilic anaerobic digestion and dewaterability of digested sludge.

The role of total solids (TS) content on sludge mesophilic anaerobic digestion (AD) was investigated in batch reactors. A range of TS below 10% was evaluated with two replicates. The volumetric biogas production rate (VBPR) increased with increasing initial TS. On day 5, VBPR increased from 133.2±11.2mLL-1d-1 at TS 2% to 1111.7±58.1mLL-1d-1 at TS 10%. The ultimate biogas yield (P) firstly increased and then decreased with the increasing TS. The greatest P was 246.8mLg-1-VSadded at TS 8%. The corresponding free ammonia nitrogen (FAN) and total ammonia nitrogen (TAN) were 84.0±16.1 and 1163.0±108.6mgL-1, respectively. Normalized capillary suction time (NCST) and solid content of thickened sludge obtained by centrifuging sludge increased with increasing TS. On day 49, NCST were 1.2±0.2 (TS=2%) and 13.2±1.1 (TS=10%)sg-1-TS. Meanwhile, solid content of thickened sludge was 7.5±0.5 (TS=2%) and 15.4±0.0% (TS=10%). In summary, high VBPR and dewatering effects were obtained after TS content optimization.

[Coupling of Hydrocarbon Accumulation and Cobalt Removal During Treatment of Cobalt Enriched Industrial Wastewater with Botryococcus braunii Biofilm Attached Cultivation].

Industrial wastewater pollution is an increasing problem. The wastewater infiltrated cobalt is a key to purify wastewater because it is seriously hazardous and hard to treat. Traditional management method of heavy metals in industrial wastewater is difficult to apply. To seek for "green ecological" feasible approaches of industrial wastewater treatment, this paper studied the effect of industrial wastewater containing cobalt on the growth and hydrocarbon accumulation of Botryococcus braunii SAG 807-1 with biofilm attached cultivation. The research results obtained were as follows:B.braunii with biofilm attached cultivation could treat industrial wastewater, and 4.5 mg·L-1 cobalt could accelerate the accumulation of hydrocarbon while having little influence on the growth of B.braunii, the ability of B.braunii with biofilm attached cultivation to remove Co2+ from industrial wastewater was 1473.9 µmol·g-1, which was much higher than the report of P. littoralis culture. Through the study in this paper, the theoretical basis for the coupling of production of green high energy fuel hydrocarbon and industrial wastewater treatment was established.

Neuropsychological dysfunction in adults with early-onset obsessive-compulsive disorder: the search for a cognitive endophenotype.

OBJECTIVE: Evidence suggests that early-onset obsessive-compulsive disorder (OCD) is an etiologically distinct subtype of OCD. The objective of the present work was to search for neurocognitive endophenotypes of early-onset OCD based on assessments of attention, memory, and executive function in patients with the disorder and their unaffected siblings. METHODS: We compared the performance of 40 adult patients with early-onset OCD, 40 of their unaffected siblings, and 40 unrelated healthy controls on a neuropsychological battery designed for this study. We searched for associations among test performance, demographic variables (age, sex and years of education) and clinical symptoms of early-onset OCD. RESULTS: Patients performed significantly worse than healthy controls on the Tower of Hanoi, and the Stroop and Wisconsin tests, indicating impairments in planning, mental flexibility and inhibitory control. The performance of the unaffected first-degree siblings of patients with early-onset OCD on the Stroop and Wisconsin tests also differed from that of healthy controls. Symptom severity in early-onset OCD was strongly correlated with performance on the Tower of Hanoi. CONCLUSIONS: Our findings support the existence of specific executive function deficits in patients with early-onset OCD. Relatives presented an intermediate phenotype between patients and controls, suggesting that executive functions such as mental flexibility and response inhibition may be considered candidate endophenotypes of early-onset OCD.

[Kriging analysis of vegetation index depression in peak cluster karst area].

In order to master the spatial variability of the normal different vegetation index (NDVI) of the peak cluster karst area, taking into account the problem of the mountain shadow "missing" information of remote sensing images existing in the karst area, NDVI of the non-shaded area were extracted in Guohua Ecological Experimental Area, in Pingguo County, Guangxi applying image processing software, ENVI. The spatial variability of NDVI was analyzed applying geostatistical method, and the NDVI of the mountain shadow areas was predicted and validated. The results indicated that the NDVI of the study area showed strong spatial variability and spatial autocorrelation resulting from the impact of intrinsic factors, and the range was 300 m. The spatial distribution maps of the NDVI interpolated by Kriging interpolation method showed that the mean of NDVI was 0.196, apparently strip and block. The higher NDVI values distributed in the area where the slope was greater than 25 degrees of the peak cluster area, while the lower values distributed in the area such as foot of the peak cluster and depression, where slope was less than 25 degrees. Kriging method validation results show that interpolation has a very high prediction accuracy and could predict the NDVI of the shadow area, which provides a new idea and method for monitoring and evaluation of the karst rocky desertification.

[Scale-dependency of spatial variability of soil available nutrients].

With the support of GIS and by using classical statistics and geostatistics methods, the spatial variability of soil available P (AP) and available K (AK) in cultivated lands in Yucheng City of Shandong Province was approached at county and township scales. The results showed that both the soil AP and AK followed the logarithmic normal distribution, with the coefficient of variation (CV) at the two scales being 26.5% - 36.6% and presenting a moderate variation. With the decrease of the scale, the CV of the soil AP and AK increased. Both the soil AP and AK were spatially correlated with scale. At county scale, the soil AP and AK had a larger spatial correlation distance, being 9.0 km and 26.5 km, respectively; while at township scale, the soil AP and AK had a smaller spatial correlation distance, being 1.7 km and 2.8 km, respectively. The spatial distribution of the soil AP and AK at the two scales was obviously different, which was mainly affected by structural factors and random factors.

Neuropsychological dysfunction in adults with early-onset obsessive-compulsive disorder: the search for a cognitive endophenotype

Objective: Evidence suggests that early-onset obsessive-compulsive disorder (OCD) is an etiologically distinct subtype of OCD. The objective of the present work was to search for neurocognitive endophenotypes of early-onset OCD based on assessments of attention, memory, and executive function in patients with the disorder and their unaffected siblings. Methods: We compared the performance of 40 adult patients with early-onset OCD, 40 of their unaffected siblings, and 40 unrelated healthy controls on a neuropsychological battery designed for this study. We searched for associations among test performance, demographic variables (age, sex and years of education) and clinical symptoms of early-onset OCD. Results: Patients performed significantly worse than healthy controls on the Tower of Hanoi, and the Stroop and Wisconsin tests, indicating impairments in planning, mental flexibility and inhibitory control. The performance of the unaffected first-degree siblings of patients with early-onset OCD on the Stroop and Wisconsin tests also differed from that of healthy controls. Symptom severity in early-onset OCD was strongly correlated with performance on the Tower of Hanoi. Conclusions: Our findings support the existence of specific executive function deficits in patients with early-onset OCD. Relatives presented an intermediate phenotype between patients and controls, suggesting that executive functions such as mental flexibility and response inhibition may be considered candidate endophenotypes of early-onset OCD. .