Bioinspired Structures Made of Silicone Nanofilaments for Upcycling Waste Masks to Reusable N95 Respirators.

The increasing demand for personal protective equipment such as single-use masks has led to large amounts of nondegradable plastic waste, aggravating economic and environmental burdens. This study reports a simple and scalable approach for upcycling waste masks via a chemical vapor deposition technique, realizing a trichome-like biomimetic (TLB) N95 respirator with superhydrophobicity (water contact angle ≥150°), N95-level protection, and reusability. The TLB N95 respirator comprising templated silicone nanofilaments with an average diameter of ∼150 nm offers N95-level protection and breathability comparable to those of commercial N95 respirators. The TLB N95 respirator can still maintain its N95-level protection against particulate matter and viruses after 10 disinfection treatment cycles (i.e., ultraviolet irradiation, microwave irradiation, dry heating, and autoclaving), demonstrating durable reusability. The proposed strategy provides new insight into upcycle waste masks, breaking the existing design and preparation concept of reusable masks.

Interventional Study of Nonpharmaceutical Measures to Prevent COVID-19 Aboard Cruise Ships.

Cruise ships carrying COVID-19-vaccinated populations applied near-identical nonpharmaceutical measures during July-November 2021; passenger masking was not applied on 2 ships. Infection risk for masked passengers was 14.58 times lower than for unmasked passengers and 19.61 times lower than in the community. Unmasked passengers' risk was slightly lower than community risk.

N95 respirators alter facial skin physiological functions and lipidome composition in health care personnel.

BACKGROUND: During the coronavirus disease 2019 pandemic, wearing medical respirators and masks was essential to prevent transmission. OBJECTIVE: To quantify the effects of N95 mask usage by measuring facial skin biophysical characteristics and changes in the lipidome. METHODS: Sixty healthy volunteers wore N95 respirators for 3 or 6 h. Facial images were acquired and physiological parameters were measured in specific facial areas, before and after mask-wearing. Lipidome analysis was also performed. RESULTS: After N95 respirator usage, facial erythema was observed in both the 3 and 6 h groups. Both sebum secretion and trans-epidermal water loss increased significantly in mask-covered cheeks and chins after 6 h of mask wearing compared with before mask wearing (p < 0.05). Principal component analysis revealed significant differences in lipid composition after mask wearing compared with before. The ceramide subclass NS exhibited a positive correlation with stratum corneum hydration, whereas the AP subclass was negatively correlated with trans-epidermal water loss in the 6 h group. CONCLUSION: Prolonged wear of N95 respirators may impair facial skin function and alter lipidome composition.

Respiratory fit test panel representing population of Malaysia.

BACKGROUND: The existing respiratory fit test panels (RFTPs) are based on Bivariate and Principal Component Analysis (PCA) which utilise American and Chinese head and facial dimensions. As RFTPs based on local facial anthropometric data for Malaysia are not available, this study was conducted with the aim to develop new RFTPs using Malaysian data. METHODOLOGY: A cross-sectional study was conducted across Malaysia among 3,324 participants of the study of National Health and Morbidity Survey 2020 aged 18 and above. Ten head and facial dimensions were measured. Face length and face width were used to construct bivariate facial panel, whereas the scores from the first two PCA were used to develop the PCA panel. RESULTS: This study showed that Malaysians have the widest upper limit for facial width. It also found that three factors could be reduced from the PCA analysis. However only 2 factors were selected with PCA 1 representing head and facial size and PCA 2 representing facial shape. Our bivariate panel could accommodate 95.0% of population, while our PCA panel accommodated 95.6%. CONCLUSION: This was the first study to use Malaysian head and facial anthropometry data to create bivariate and PCA panels. Respirators constructed using these panels are likely to fit ≥ 95.0% of Malaysia's population.

Wearing face masks as a potential source for inhalation and oral uptake of inanimate toxins - A scoping review.

BACKGROUND: From 2020 to 2023 many people around the world were forced to wear masks for large proportions of the day based on mandates and laws. We aimed to study the potential of face masks for the content and release of inanimate toxins. METHODS: A scoping review of 1003 studies was performed (database search in PubMed/MEDLINE, qualitative and quantitative evaluation). RESULTS: 24 studies were included (experimental time 17 min to 15 days) evaluating content and/or release in 631 masks (273 surgical, 228 textile and 130 N95 masks). Most studies (63%) showed alarming results with high micro- and nanoplastics (MPs and NPs) release and exceedances could also be evidenced for volatile organic compounds (VOCs), xylene, acrolein, per-/polyfluoroalkyl substances (PFAS), phthalates (including di(2-ethylhexyl)-phthalate, DEHP) and for Pb, Cd, Co, Cu, Sb and TiO2. DISCUSSION: Of course, masks filter larger dirt and plastic particles and fibers from the air we breathe and have specific indications, but according to our data they also carry risks. Depending on the application, a risk-benefit analysis is necessary. CONCLUSION: Undoubtedly, mask mandates during the SARS-CoV-2 pandemic have been generating an additional source of potentially harmful exposition to toxins with health threatening and carcinogenic properties at population level with almost zero distance to the airways.

Microscopy of Woven and Nonwoven Face Covering Materials: Implications for Particle Filtration.

A suite of natural, synthetic, and mixed synthetic-natural woven fabrics, along with nonwoven filtration layers from a surgical mask and an N95 respirator, was examined using visible light microscopy, scanning electron microscopy, and micro-X-ray computed tomography (µXCT) to determine the fiber diameter distribution, fabric thickness, and the volume of solid space of the fabrics. Nonwoven materials exhibit a positively skewed distribution of fiber diameters with a mean value of ≈3 µm, whereas woven fabrics exhibit a normal distribution of diameters with mean values roughly five times larger (>15 µm). The mean thickness of the N95 filtration material is 1093 µm and is greater than that of the woven fabrics that span from 420 to 650 µm. A new procedure for measuring the thickness of flannel fabrics is proposed that accounts for raised fibers. µXCT allowed for a quantitative nondestructive approach to measure fabric porosity as well as the surface area/volume. Cotton flannel showed the largest mean isotropy of any fabric, though fiber order within the weave is poorly represented in the surface electron images. Surface fabric isotropy and surface area/volume ratios are proposed as useful microstructural quantities to consider for future particle filtration modeling efforts of woven materials.

Best practices for communication while wearing facemasks: A scoping review.

INTRODUCTION: Facemasks are an important piece of personal protective equipment (PPE) to mitigate the spread of respiratory illnesses, but they can impede communication between patients and healthcare providers. The purpose of this scoping review is to identify effective communication practices while wearing facemasks. DESIGN: Scoping review using a systematic search of articles from the PubMed, CINAHL, and Embase databases. METHODS: The PEO (population, exposure, outcome) methodology was selected for this systematic scoping review. The population of interest (P) includes humans of all ages (children, adults, and older adults); the exposure of interest (E) is PPE that covers the mouth (i.e., facemasks); and the outcome of interest (O) is successful or unsuccessful communication practices. The Johns Hopkins Evidence-Based Practice for Nurses and Healthcare Professionals appraisal guidelines were used to determine the level and quality of the research. RESULTS: Thirty-nine articles met the inclusion criteria. Seventeen of these were high- or good-quality research studies, and the remaining 22 were non-research articles included with separate analysis as part of the scoping review. The 17 articles encompassed 2656 participants. The highest quality evidence indicated that standard surgical masks have the least impact on speech perception compared to other non-transparent mask types, and that recognizing emotions is less accurate with facemasks, necessitating compensatory actions (i.e., reducing extraneous noise, using a microphone to amplify voice, and employing clear speech). Evidence was contradictory regarding the use of transparent masks. Evidence was of limited quality for other non-verbal and verbal communication strategies. CONCLUSION: Awareness of communication challenges is crucial when wearing facemasks. More high-quality studies are needed to evaluate communication techniques when speakers are wearing facemasks. Basic strategies such as selecting an appropriate mask type, reducing extraneous noise, using microphones, verbalizing emotions, and employing clear speech appear to be beneficial. CLINICAL RELEVANCE: The findings of this scoping review highlight the importance of considering communication challenges while wearing facemasks in the healthcare settings. The review suggests that selecting an appropriate mask type, reducing extraneous noise, verbalizing emotions, and employing clear speech are some strategies that may be effective in mitigating the impact of facemasks on communication between patients and healthcare providers.

Study on the relationship between the fitness of three types of N95 respirators and facial dimensions.

N95 respirators are the core equipment used by healthcare workers to prevent the spread of respiratory diseases. The protective effect of N95 against infection spread depends on the fit of the N95 to the wearer, which is related to the wearer's facial dimensions. The purpose of this cross-sectional study was to assess the relationship between the fit of three types of N95 and facial dimensions. A total of 305 healthcare workers from ten hospitals in Beijing were recruited for this study. Facial dimensions of workers were measured using Intel RealSense Depth Camera D435. Fit testing was conducted on three types of N95 using the TSI-8038 Porta Count Pro + Respirator Fit Tester. Possible associations between the fit test results and facial dimension data were examined. A Porta Count reading of 100 was used as the criterion for an acceptable fit. The fit of the folding respirators was positively correlated with nose length (r = 0.13, p = 0.02), nose height (r = 0.14, p = 0.02), and face width (r = 0.12, p = 0.03), whereas that of flat respirators was correlated with nose width (r = 0.16, p < 0.01), chin length (r = 0.18, p < 0.01), and pro-face width (r = 0.13, p = 0.02), and that of arched respirators was correlated with the nose length (r = 0.13, p = 0.03). The fit of N95 for wearers depends on their facial features. The results of this study can provide advice for medical workers to choose the appropriate N95. Medical staff should fully consider their facial dimensions when choosing an appropriate N95 to improve the protective efficacy of respirators and to reduce the risk of infection by respiratory diseases.

Impact of Concurrent Use of N95 and Surgical Masks on Peripheral Oxygen Saturation and Heart Rate Frequency-A Prospective Study during the COVID-19 Outbreak.

Background and Objectives: The COVID-19 outbreak has necessitated the prolonged use of N95 facemasks in addition to traditional surgical facemasks by healthcare workers. The aim of this study was to investigate the effect of wearing N95 facemasks in addition to surgical facemasks on peripheral oxygen saturation (SpO2) and heart rate (HR) among dental professionals during routine care. Materials and Methods: This prospective study compared SpO2 and HR between dental providers wearing N95 + surgical facemasks vs. wearing a surgical facemask only. SpO2 and HR were recorded using a portable pulse oximeter before wearing the facemask (T0); at 30 min (T1); at 1 h (T2); and at the end of clinical activity (T3). Inter-group and intra-group differences were assessed with independent t tests and repeated measures ANOVA, respectively. Results: A total of 88 participants (57 wearing N95 + surgical facemasks, and 31 wearing a surgical facemask only) completed the study. The two groups did not statistically differ in SpO2 at different timepoints nor showed any intra-group differences. The participants wearing N95 + surgical facemasks exhibited a statistically higher HR at T0 (p = 0.007), T2 (p = 0.010), and T3 (p = 0.014) compared to those wearing a surgical facemask only. A statistically significant decrease was observed in HR between T0 and T3 in those wearing N95 + surgical facemasks (p = 0.012). No intra-group differences were seen in HR over time in those wearing a surgical facemask only. Conclusions: The continuous use of an N95 in addition to a surgical facemask did not show any significant effects in SpO2 during routine care; however, the concurrent use of an N95 and a surgical facemask seemed to be accompanied by a decrease in HR, although the values remained within the normal range.

N95 respirator seal integrity following extended-use by healthcare workers in the intensive care unit: A cohort study.

AIM/OBJECTIVES: Fit testing of N95/FFP2 respirators is universally recommended before exposure to airborne infectious diseases such as COVID-19. Respirator supply shortage in the COVID-19 pandemic encouraged extended-use for up to 4 h, despite uncertainty about seal integrity over time. The aim of our study was to assess N95 seal integrity after at least 2 h of continuous clinical use in the intensive care unit (ICU). We hypothesised that seal integrity would deteriorate over time, with variability between respirator shapes. METHODS: A prospective cohort study of healthcare workers in a metropolitan ICU setting in Australia between April 2021 and August 2022. Following consent and screening, participants underwent qualitative fit testing in the ICU, and fit tests were repeated following a continuous period of at least 2-h usage. The primary outcome was N95 fit-test failure rate measured by qualitative fit testing of >2 h compared to baseline. Secondary outcomes evaluated effects of respirator shape, demographic characteristics, and duration of respirator use on respirator fit after 2 h use. RESULTS: Fifty-one participants were recruited and consented. Six participants were excluded; four failed baseline fit test, one could not taste saccharin, and one did not complete 2 h of usage. Fourteen of 45 participants (∼31%) failed the extended-use fit test (median duration: 2 h 10 min [interquartile range: 2:07-2:20]). Fit-test rates differed between respirator shapes; three-piece flat-fold respirators had lower failure rates (6/32; 19%) than duckbill-shaped respirators (6/11; 55%) p = 0.046. No other demographic characteristic or respirator shape was significantly associated with increased failure rate. CONCLUSIONS: Following 2 h of use, approximately 30% of participants failed repeat fit testing, suggesting incomplete respiratory protection. Three-piece flat-fold respirators outperformed duckbill respirators. Extended use of respirators, even without respirator reuse, may put healthcare workers at risk of inadequate respiratory protection, in particular when using duckbill-shaped respirators.

Evaluation of eyelid features' changes before and after COVID-19 pandemic amongst healthcare and home office workers.

PURPOSE: To evaluate the eyelid features' changes after N95 face mask (FM) usage in healthcare workers through the new type of Coronavirus Disease 2019 (COVID-19) pandemic and make a comparison with home-office workers as a control group with a computer vision algorithm. MATERIALS AND METHODS: Sixty healthcare workers and forty control participants with similar demographic features included. Standardized biometric photographs which were taken before and after the COVID-19 pandemic, analyzed by the ImageJ program (NIH, Bethesda, Md.) software. The distances between the central light reflex on the cornea and the upper (UE) and lower eyelid (LE) were recorded as the marginal reflex distances. (MRD1, MRD2 respectively) Parameters of pretarsal show (PTS) of UE and brow pupil diameter (BPD) were analyzed for both of the eyes. RESULTS: There were no significant differences among the groups' measurements before the COVID-19 pandemic. In healthcare workers' group after the pandemic, values of MRD1, PTS, BPD showed a significant decrease in their right eye (p = 0.001, p = 0.002, p = 0.001 respectively) and same values reduced in the left eyes as well when compared with pre-pandemic measurements. (p = 0.048, p = 0.001, p = 0.001 respectively) PTS and BPD values were decreased for both right and left eyes of the controls. (p = 0.044, p = 0.001 and p = 0.001, p = 0.001 respectively) MRD1 measurements after the pandemic showed no difference either in the right or left eyes of the control group after the pandemic. (p = 0.071 and p = 0.065 respectively). DISCUSSION: Results showed that both BPD and PTS values decreased independently from the previous FM usage in both of the groups. Even though MRD1 values remained within the normal values, a significant decrease was detected in the healthcare workers group which suggested the cause was newly developed upper eyelid (UE) dermatochalasis after long hours of FM usage. Although it is hard to make a truly objective evaluation both usage of standardized biometric photographs and a computer-based measurement system makes the results reliable.

Effect of surgical mask and N95 respirator mask use on cerebrovascular reactivity.

Background and purpose:

Face masks are crucial parts of personal protective equipment (PPE) to reduce the risk of respiratory infections. The COVID-19 outbreak has increased healthcare workers’ use of face masks. This study aimed to evaluate changes in cerebrovascular response among healthcare workers using surgical and N95 respirator masks. 

90 healthcare workers: 30 wearing surgical masks, 30 wearing N95 respirators, and 30 without masks were included. After two-hour of face mask use, the baseline mean flow velocity (MFV) and the mean breath-holding index (BHI) of the bilateral middle cerebral arteries (MCAs) were evaluated with transcranial Doppler ultrasound. The presence of de-novo headache was recorded. BHI values ​​below 0.69 were evaluated as a sign of impaired cerebrovascular reactivity (CVR). 

The rate of de-novo headache was significantly higher in the N95 respirator mask group (p = 0.004). Compared to the control and surgical mask groups, the N95 respirator mask group had significantly lower values of the baseline MFV of the right MCA (p = 0.003 and p = 0.021, respectively) and mean BHI (p = 0.003 and p = 0.012, respectively). Still, only one N95 respirator mask user had a mean BHI value below 0.69.

Surgical masks did not signi­fi­cantly affect cerebral hemodynamics. Although N95 respirator mask use significantly decreased BHI values, the CVR is still within normal limits, and the development of de-novo headache is not directly associated with low CVR. 

Protecting healthcare personnel and patients over 3 years of COVID-19 : Effective protection by masks and hygiene: What else was effective?

Healthcare professionals, particularly those in test centers, laboratories, or specialized COVID-19 wards, are in danger of becoming infected. Patients with special underlying health conditions are at an increased risk of getting very sick, being hospitalized, or dying from COVID-19. Age is a leading risk factor in this context. Currently, FFP2 (Filtering Facepiece 2, European standard), N95 (US standard), and KN95 (Chinese standard) face masks remain the simplest measure of protection. Coronavirus warning apps installed on smartphones have been recommended for anonymous contact tracing and quickly disrupting chains of infection. Preventive testing two to three times per week for healthcare personnel, on the day of hospital admission for patients, and upon facility entry for visitors has been routinely performed or has been requested from external test centers in most medical institutions. However, vaccination is regarded the most effective protective measure against COVID-19. The general recommendation of the World Health Organization is that countries continue to work toward vaccinating at least 70% of their populations, prioritizing the vaccination of 100% of healthcare workers and 100% of the most vulnerable groups, including people who are over 60 years of age and those who are immunocompromised or have underlying health conditions. The most vulnerable individuals among patients and healthcare workers should be identified and then their vaccination status should be checked and, if necessary, optimized by booster administration. In Germany, seasonal and institutional recommendations for individual protection by face masks, for hygiene measures, and for preventive testing must follow the updated coronavirus protection regulations (Coronavirus-Schutzverordnungen).

Health effects of filtering facepiece respirators: Systematic review of pulmonary and cardiovascular effects.

Filtering facepiece respirators (FFRs) were introduced to protect the wearer by removing small particles from inspired air. FFRs are now also used to reduce the spread of transmissible agents from the wearer and are worn outside traditional healthcare and other workplaces. The COVID-19 pandemic increased concerns about potential adverse effects on wearers. A PUBMED query retrieved articles through June 2022. Abstracts and selected full-text articles were systematically reviewed by the authors. This article focuses upon cardiopulmonary physiologic effects (e.g., ventilation, CO2 elimination, oxygen uptake, and respiratory control) with emphasis upon current and potential research methods as well as summarizing results. 1985 records were identified, of which only 26% were published before 2020. FFR effects on CO2 elimination appear more likely to be significant than effects on oxygenation or cardiovascular function. While FFRs appear well tolerated by healthy persons, more research is needed for those with pulmonary or cardiac disorders, and for children. Many traditional pulmonary exercise study methods require special care when applied to filtering facepiece respirators. Studying additional parameters may explain the paradox of many subjective discomfort reports despite very limited physiologic effects.

Elastomeric half-mask respirator disinfection practices among healthcare personnel.

BACKGROUND: Disposable N95 respirator shortages during the COVID-19 and 2009 H1N1 influenza pandemics highlighted the need for reusable alternatives, such as elastomeric half-mask respirators (EHMRs). Two US medical organizations deployed reusable EHMRs during the COVID-19 response. In addition to wipe-based disinfection following patient care episodes expected per local policies at both organizations, postshift centralized cleaning and disinfection (C&D) was expected at one site (A), permitting shared-pool EHMR use, and optional at the other (Site B), where EHMRs were issued to individuals. Using a survey, we evaluated disinfection practices reported by EHMR users and predictors of disinfection behaviors and perceptions. METHODS: Surveys assessed EHMR disinfection practices, occupational characteristics, EHMR use frequency, training, and individual-issue versus shared-pool EHMR use. RESULTS: Of 1080 EHMR users completing the survey, 76% reported that they disinfect the EHMR after each patient encounter, which was the expected practice at both sites. Increasing EHMR use, recall of disinfection training, and work in intensive care or emergency settings significantly influenced higher reporting of this practice. 36% of respondents reported using centralized C&D, although reporting was higher at the site (A) where this was expected (53%). Confidence in cleanliness of the EHMR following centralized C&D was not influenced by individual versus shared-pool EHMR issue. CONCLUSIONS: Most EHMR users reported adherence with expected post-care individual-based disinfection of EHMRs but did not necessarily use standardized, centralized C&D. Future efforts to limit reliance on behavior related to respirator disinfection may improve EHMR implementation in healthcare to avert dependence on single-use, disposable N95 respirators.

Electron beam technology for Re-processing of personal protective equipment.

Beginning with the outbreak of COVID-19 at the dawn of 2020, the continuing spread of the pandemic has challenged the healthcare market and the supply chain of Personal Protective Equipment (PPE) around the world. Moreover, the emergence of the variants of COVID-19 occurring in waves threatens the sufficient supply of PPE. Among the various types of PPE, N95 Respirators, surgical masks, and medical gowns are the most consumed and thus have a high potential for a serious shortage during such emergencies. Considering the unanticipated demand for PPE during a pandemic, re-processing of used PPE is one approach to continue to protect the health of first responders and healthcare personnel. This paper evaluates the viability and efficacy of using FDA-approved electron beam (eBeam) sterilization technology (ISO 11137) to re-process used PPE. PPEs including 3M N95 Respirators, Proxima Sirus gowns, and face shields were eBeam irradiated in different media (air, argon) over a dose range of 0-200 kGy. Several tests were then performed to examine surface properties, mechanical properties, functionality performance, discoloration phenomenon, and liquid barrier performance. The results show a reduction of filtration efficiency to about 63.6% in the N95 Respirator; however, charge regeneration may improve the re-processed efficiency. Additionally, mechanical degradation was observed in Proxima Sirus gown with increasing dose up to 100 kGy. However, no mechanical degradation was observed in the face shields after 10 times donning and doffing. Apart from the face shield, N95 Respirators and Proxima Sirus gown both show significant mechanical degradation with ebeam dose over sterilization doses (>25 kGy), indicating that eBeam technology is not appropriate for the re-processing these PPEs.

Effect of an N95 respirator and a surgical mask-covered N95 on the cardiovascular responses of dentists treating paediatric patients: A crossover clinical trial.

BACKGROUND: The studies on cardiovascular alterations when using an N95 respirator or surgical mask-covered N95 during dental treatments are limited. AIM: To investigate and compare the cardiovascular responses of dentists treating paediatric patients while wearing an N95 respirator or a surgical mask-covered N95. DESIGN: This was a crossover clinical trial in 18 healthy dentists wearing an N95 respirator or surgical mask-covered N95 during the dental treatment of paediatric patients. Oxygen saturation (SpO2 ), heart rate (HR), systolic blood pressure (SBP), diastolic blood pressure (DBP), and mean arterial pressure (MAP) were monitored at baseline, intraoperation, and postoperation. The data were analyzed using the generalized estimating equation. RESULTS: The mean SpO2 , HR, SBP, DBP, and MAP significantly changed from baseline up to the end of the procedures after wearing an N95 by 3.1%, 19.3%, 11.5%, 17.7%, and 13.8% and after wearing a surgical mask-covered N95 by 3.0%, 20.2%, 5.3%, 13.9%, and 8.8%, respectively (p < .05). No significant differences in these values were found between groups (p > .05). CONCLUSIONS: N95 respirators and surgical mask-covered N95s significantly impact the cardiovascular responses of dentists treating paediatric patients with no differences between the two types of masks.

Headache Associated with PPE During COVID-19 Pandemic in Health Care Workers.

PURPOSE: In the pandemic coronavirus disease 2019 (COVID-19), health care workers (HCWs) are at very high risk. Personal protective equipment (PPE) and masks are not only difficult to wear while working but also causes various complications. The present self-administered questionnaire- based study aimed to explore the headache and complications in HCWs on wearing PPE during the COVID-19 pandemic. METHODS: The present study was performed by obtaining a self-administered questionnaire from HCWs, which provides evidence of various complications due to the use of a PPE and mask. RESULTS: Out of a total of 329 respondents, 189(57.45%), 67(20.36%), 238(72.34%), 213(64.74%), 177(53.80%), and 34(10.33%) reported headache, breathlessness, suffocation, nose pain, ear pain, and leg pain respectively. Out of 329 respondents, 47(14.29%) had pre-existing headaches. Headache was significantly high for those who wore PPE for 4-6h (121/133; 87.05%) than that of those who wore up to 4h (18/26; 69.23%). Of the 34(24.46%) required medication who reported headaches wearing PPE. Acetaminophen is quite helpful in most health care workers to decrease headaches. Nose-related complications occur frequently in health care workers after regular shifts for more than 6 days. Gelatinous adhesives patch was a wonderful prophylactic remedy as it was helpful to prevent nose- related complications in 24 HCWs out of 25(96%). CONCLUSIONS: More than half of the HCWs reported headache, suffocation, nose pain, and ear pain. Duration of PPE use of more than 4h is significantly associated with headache. Short duration PPE use prevent HCWs from headache and various ill effects.

Total outward leakage of half-mask respirators and surgical masks used for source control.

Both respirators and surgical masks (SM) are used as source control devices. During the COVID-19 pandemic, there was much interest in understanding the extent of particle total outward leakage (TOL) from these devices. The objective of this study was to quantify the TOL for five categories of devices: SMs, National Institute for Occupational Safety and Health (NIOSH) Approved N95 filtering facepiece respirators (FFRs) without exhalation valves, NIOSH Approved N95 FFRs with exhalation valves (N95 FFRV), NIOSH Approved elastomeric half-mask respirators (EHMRs) with exhalation valves, and NIOSH Approved EHMRs with an SM covering the exhalation valve (EHMRSM). A benchtop test system was designed to test two models of each device category. Each device was mounted on a headform at three faceseal levels (0% faceseal, 50% faceseal, and 100% faceseal). At each faceseal level, the TOL was assessed at three flow rates of minute ventilations of 17, 28, and 39 L/min. The experimental design was a split-split-plot configuration. Device type, faceseal level, flow rate, and the interaction of device type and faceseal level were found to have a significant effect (p-value < 0.05) on the TOL. This study found that the N95 FFRs without exhalation valves had the lowest mean TOL. The SMs had about three times higher TOL than the N95 FFRs without exhalation valves. The TOL of the N95 FFRV was comparable to that of the SM at 0% and 50% faceseal on average overall conditions, but the N95 FFRV had a significantly higher TOL than the SM at a 100% faceseal. The EHMRs had the highest TOL because of the exhalation valve. Using an SM to cover the exhalation valve did not improve the EHMRs' efficiency in mitigating the TOL. Caution should be exercised when using N95 FFRVs as a source control measure against respiratory activities with heavy work rates, such as performing CPR. Results of this study showed that reduced faceseal leakage for N95 FFRs and SMs improves source control.

Fit evaluation of NIOSH approved N95 filtering facepiece respirators with various skin protectants: A pilot study.

Widespread disease outbreaks can result in prolonged wear times of National Institute for Occupational Safety and Health Approved N95 filtering facepiece respirators by healthcare personnel. Prolonged wear times of these devices can cause the development of various adverse facial skin conditions. Healthcare personnel have been reported to apply "skin protectants" to the face to reduce the pressure and friction of respirators. Because tight-fitting respirators rely on a good face seal to protect the wearer, it is important to understand if the fit is affected when skin protectants are used. This laboratory pilot study included 10 volunteers who performed quantitative fit tests to evaluate respirator fit while wearing skin protectants. Three N95 filtering facepiece respirator models and three skin protectants were evaluated. Three replicate fit tests were performed for each combination of subject, skin protectant (including a control condition of no protectant), and respirator model. Fit Factor (FF) was affected differently by the combination of the protectant type and respirator model. The main effects of the protectant type and respirator model were both significant (p < 0.001); additionally, their interaction was significant (p = 0.02), indicating FF is affected by the combined effects of the protectant type and respirator model. Compared to the control condition, using a bandage-type or surgical tape skin protectant decreased the odds of passing the fit test. Using a barrier cream skin protectant also decreased the odds of passing the fit test across all models compared to the control condition; however, the probability of passing a fit test was not statistically significantly different from the control condition (p = 0.174). These results imply that all three skin protectants reduced mean fit factors for all N95 filtering facepiece respirator models tested. The bandage-type and surgical tape skin protectants both reduced fit factors and passing rates to a greater degree than the barrier cream. Respirator users should follow respirator manufacturers' guidance on the use of skin protectants. If a skin protectant is to be worn with a tight-fitting respirator, the fit of the respirator should be evaluated with the skin protectant applied before use in the workplace.