Bubble Turbulent Gas-Permeable Membrane for Ammonia Recovery from Swine Wastewater: Mass Transfer Enhancement and Antifouling Mechanisms.

Recovering ammonium from swine wastewater employing a gas-permeable membrane (GM) has potential but suffers from the limitations of unattractive mass transfer and poor-tolerance antifouling properties. Turbulence is an effective approach to enhancing the release of volatile ammonia from wastewater while relying on interfacial disturbance to interfere with contaminant adhesion. Herein, we design an innovative gas-permeable membrane coupled with bubble turbulence (BT-GM) that enhances mass transfer while mitigating membrane fouling. Bubbles act as turbulence carriers to accelerate the release and migration of ammonia from the liquid phase, increasing the ammonia concentration gradient at the membrane-liquid interface. In comparison, the ammonium mass transfer rate of the BT-GM process applied to real swine wastewater is 38% higher than that of conventional GM (12 h). Through a computational fluid dynamics simulation, the turbulence kinetic energy of BT-GM system is 3 orders of magnitude higher than that of GM, and the effective mass transfer area is nearly 3 times that of GM. Seven batches of tests confirmed that the BT-GM system exhibits remarkable antifouling ability, broadens its adaptability to complex water quality, and practically promotes the development of sustainable resource recycling.

Lead Isotope Signatures and Source Identification of Heavy Metals in Vegetable Soils Irrigated with Swine Wastewater of Jiangxi Province, China.

The rapid development of livestock and poultry industry in China has caused serious environment pollution problems. To understand the heavy metals accumulation and identify their sources, 7 heavy metals contents and lead isotope ratios were determined in 24 soil samples from vegetable fields irrigated with swine wastewater in Dongxiang County, Jiangxi Province, China. The results showed that the concentration of Cr, Ni, Cu, Zn, As, Cd and Pb in the swine wastewater irrigated vegetable soils varied from 38.5 to 86.4, 7.57 to 30.6, 20.0 to 57.1, 37.5 to 174, 9.18 to 53.1, 0.043 to 0.274 and 12.8 to 37.1 mg/kg, respectively. The soils were moderately to heavily polluted by As, moderately polluted by Cr, Ni, Cu, Zn and Cd, and unpolluted to moderately polluted by Pb. Sampling soils were classified as moderately polluted according to the Nemerow comprehensive pollution index. Lead isotope and Principal Component Analysis (PCA) analysis indicated that swine wastewater irrigation and atmospheric deposition were the primary sources of the heavy metals.

Synthesis of NaA zeolite from foundry dust and its adsorption capacity of ammonia.

Eutrophication of water bodies due to excess ammonia nitrogen (NH4+-N) is harmful to aquatic organisms and human health. In this study, foundry dust (FD) from foundry industry was used to synthesize NaA zeolite to use as an adsorbent to remove NH4+-N from wastewater. Results demonstrate that FD could be successfully synthesized to form a foundry dust-based NaA zeolite (FZA) through adjustment of the silica-alumina ratio of n (SiO2)/n (Al2O3) at 2 at 95 °C. Specific surface area, total pore volume, and cation exchange capacity (CEC), and maximum adsorption NH4+-N of FZA was respectively 43.185 cm2/g, 0.0364 cm3/g, 212.35 mmol/100 g and 37.81 mg/g, which was 4.74, 1.54, 1.52 and 1.62 times as much as the NaA zeolite (SZA). FZA with higher adsorption NH4+-N capacity was related to higher specific surface area and CEC. The NH4+-N adsorption amount of 28.57 mg/g by FZA was obtained after the fourth regeneration, which was notably higher than that of SZA (23.27 mg/g). The desorption rate of NH4+-N from FZA was 87% by the fourth regeneration. FZA effectively removed NH4+-N from swine wastewater containing 153.32 mg/L NH4+-N. Results suggest that FZA could be used as absorbent to removal NH4+-N from wastewater.

Comparative study on the treatment of swine wastewater by VFCW-MFC and VFCW: Pollutants removal, electricity generation, microorganism community.

Swine wastewater, characterized by high organic and nutrient content, poses significant environmental challenges. This study aims to compare the effectiveness of two treatment technologies, namely Vertical Flow Constructed Wetland-Microbial Fuel Cell (VFCW-MFC) and Vertical Flow Constructed Wetland (VFCW), in terms of pollutant removal, electricity generation, and microorganism community dynamics. The results showed that the average removal efficiencies of chemical oxygen demand (COD), ammonia nitrogen, total nitrogen (TN), total phosphorus (TP) and sulfadiazine antibiotics (SDZ) by VFCW-MFC were as high as 94.15%, 95.01%, 42.24%, 97.16% and 82.88%, respectively, which were all higher than that by VFCW. Both VFCW-MFC and VFCW have good tolerance to SDZ. In addition, VFCW-MFC has excellent electrical performance, with output voltage, power density, coulombic efficiency and net energy recovery up to 443.59 mV, 51.2 mW/m3, 52.91% and 2.04 W/(g·s), respectively, during stable operation. Moreover, the microbial community diversity of VFCW-MFC was more abundant, and the species abundance distribution in cathode region was more rich and even than in anode region. At phylum level, the dominant microorganisms in VFCW-MFC included Proteobacteria, Bacteroidota, Firmicutes and Actinobacteriota, which showed good degradation effect on SDZ. Proteobacteria and Firmicutes are also involved in electricity production. Chloroflexi, Proteobacteria and Bacteroidota play a major role in nitrogen reduction.

Linking the shifts in the metabolically active microbiota in a UASB and hybrid anaerobic-aerobic bioreactor for swine wastewater treatment.

Due to the high concentration of pollutants, swine wastewater needs to be treated prior to disposal. The combination of anaerobic and aerobic technologies in one hybrid system allows to obtain higher removal efficiencies compared to those achieved via conventional biological treatment, and the performance of a hybrid system depends on the microbial community in the bioreactor. Here, we evaluated the community assembly of an anaerobic-aerobic hybrid reactor for swine wastewater treatment. Sequencing of partial 16S rRNA coding genes was performed using Illumina from DNA and retrotranscribed RNA templates (cDNA) extracted from samples from both sections of the hybrid system and from a UASB bioreactor fed with the same swine wastewater influent. Proteobacteria and Firmicutes were the dominant phyla and play a key role in anaerobic fermentation, followed by Methanosaeta and Methanobacterium. Several differences were found in the relative abundances of some genera between the DNA and cDNA samples, indicating an increase in the diversity of the metabolically active community, highlighting Chlorobaculum, Cladimonas, Turicibacter and Clostridium senso stricto. Nitrifying bacteria were more abundant in the hybrid bioreactor. Beta diversity analysis revealed that the microbial community structure significantly differed among the samples (p < 0.05) and between both anaerobic treatments. The main predicted metabolic pathways were the biosynthesis of amino acids and the formation of antibiotics. Also, the metabolism of C5-branched dibasic acid, Vit B5 and CoA, exhibited an important relationship with the main nitrogen-removing microorganisms. The anaerobic-aerobic hybrid bioreactor showed a higher ammonia removal rate compared to the conventional UASB system. However, further research and adjustments are needed to completely remove nitrogen from wastewater.

Nitrogen removal of decentralized swine wastewater by pilot-scale source reduction - anaerobic baffled reactor - zoning constructed wetlands at low temperatures.

The study developed a cost-effective integrated technology to treat swine wastewater at the pilot-scale small pigsty. The swine wastewater, which was separated rinse water after flowing through the slatted floor and the innovatively constructed liquid-liquid separate collection device, was subsequently pumped into an anaerobic baffled reactor (ABR) and then through zoning constructed wetlands (CWs) comprised of CW1, CW2, and CW3. The liquid-liquid separate collection device effectively reduced COD, NH4-N, and TN by 57.82%, 52.39%, and 50.95%, respectively. The CW1 and CW2 enhanced TN removal and nitrification, respectively, through rapid adsorption-bioregeneration of zeolite. Moreover, rice straws were used as solid carbon sources in CW3 to successfully promote denitrification at 16.0 g/(m3·d). The integrated technology (slatted floor-liquid liquid separate collection-ABR-CWs) reduced COD, NH4-N, and TN by 98.17%, 87.22%, and 87.88%, respectively, at approximately 10 °C. Microbial analysis results confirmed that the CWs exhibited apparent functional zoning, with denitrifiers dominating in CW3, nitrifiers dominating in the zeolite layers of CW1 and CW2, and denitrifiers dominating in the brick slag layers of CWs. This cost-effective integrated technology demonstrated significant potential for treating swine wastewater at low temperatures.

Impact of influent strengths on nitrous oxide emission and its molecular mechanism in constructed wetlands treating swine wastewater.

Constructed wetlands (CWs) can remove nitrogen (N) through plant assimilation and microbial nitrification and denitrification, while it also releases large greenhouse gas nitrous oxide (N2O) into the atmosphere. However, N2O emissions and the underlying microbial mechanisms of CWs when treating high-strength wastewater have not been systematically surveyed. Here, the effect of three influent strengths on N2O emissions in a pilot-scale CW treatment of swine wastewater was determined and the underlying microbial mechanisms were explored. The results showed that the removal rates of ammonium (NH4+) and total nitrogen (TN) increased significantly with the increasing influent strengths, however, the ratio of N2O emission/TN removal rose by 1.5 times at the same time. Quantitation of microorganisms responsible for N-cycle in the sediment indicated that the abundance of ammonia-oxidizing bacteria (AOB) in high influent strengths (COD, 962.38 ± 3.05 mg/L; NH4+, 317.89 ± 4.24 mg/L) was 51.6-fold compared with that in low influent strengths (COD, 516.94 ± 4.18 mg/L; NH4+, 100.65 ± 2.65), and AOB gradually replaced ammonia-oxidizing archaea (AOA) to dominate ammonia oxidizers. Structural equation models demonstrated that NO2- accumulations promoted the ratio of AOB/AOA, which further led to an increase in the ratio of N2O emission/TN removal. It is worth noting both the N removal rates and N2O emissions increased with the increasing influent strength. To obtain reduced N2O emissions, pretreatment technology for strength reduction should be supplemented before high-strength wastewater enters the CWs. This study may shed new light on the sustainable operation and application of CWs.

Determination of 38 antibiotics in raw and treated wastewater from swine farms using liquid chromatography-mass spectrometry.

The present study firstly aimed at developing a multi-residue method to identify and quantify 38 veterinary antibiotics (belonging to five different classes) not only for raw swine wastewater but also for wastewater differently treated by different units. The proposed method is based on a solid-phase extraction procedure and ultra high performance liquid chromatography with mass spectrometry. For sample preparation, the optimal loading sample volume was selected as 50 mL, the pH of which was adjusted to approximately 3.0 using formic acid. Then 0.1 g/L ethylenediaminetetraacetic acid disodium salt was added. The recovery rates for different types of wastewaters were in the range of 35.94-124.51% and the relative standard deviations were in the range of 0.36-14.62%. All the matrix standard curves exhibited high linearity (0.9956-0.9999). The matrix effects for the target antibiotics ranged from -61.73 to +148.75%. To ensure the practicality of the method, we performed the detection of the actually added concentration to determine method detection limits and quantitation limits. The quantitation limits of most of the target antibiotics were 0.04 µg/L, except for spiramycin (0.1 µg/L) and roxithromycin (0.2 µg/L). This optimized and validated method was applied to analyze antibiotic residues in swine water samples from four swine farms.

Integration of swine manure anaerobic digestion and digestate nutrients removal/recovery under a circular economy concept.

The application of the circular economy concept should utilize the cycles of nature to preserve materials, energy and nutrients for economic use. A full-scale pig farm plant was developed and validated, showing how it is possible to integrate a circular economy concept into a wastewater treatment system capable of recovering energy, nutrients and enabling water reuse. A low-cost swine wastewater treatment system consisting of several treatment modules such as solid-liquid separation, anaerobic digestion, biological nitrogen removal by nitrification/denitrification and physicochemical phosphorus removal and recovery was able to generate 1880.6 ± 1858.5 kWh d-1 of energy, remove 98.6% of nitrogen and 89.7% of phosphorus present in the swine manure. In addition, it was possible to produce enough fertilizer to fertilize 350 ha per year, considering phosphorus and potassium. In addition, the effluent after the chemical phosphorus removal can be safely used in farm cleaning processes or disposed of in water bodies. Thus, the proposed process has proven to be an environmentally superior swine waste management technology, with a positive impact on water quality and ensuring environmental sustainability in intensive swine production.

Effect of time and temperature of pretreatment and anaerobic co-digestion of rice straw and swine wastewater by domesticated paddy soil microbes.

Rice straw and swine wastewater are abundant, easy to obtain, and inexpensive biomass materials. Anaerobic digestion of rice straw and swine wastewater effectively regulates the carbon-to-nitrogen ratio and also improves methane production efficiency. The dense lignocellulosic structure, unsuitable carbon-to-nitrogen ratio, and light texture of rice straw hinder its application in anaerobic digestion. Effective pretreatment technologies can improve degradation efficiency and methane production. Our study is the first to apply domesticated paddy soil microbes to enhance the efficiency of hydrolytic acidification of rice straw and swine wastewater at varying temperatures and times. The results show that the highest total organic carbon (1757.2 mg/L), soluble chemical oxygen demand (5341.7 mg/L), and organic acid concentration (4134.6 mg/L) appeared in the hydrolysate after five days of hydrolytic acidification at 37 °C. Moreover, the use of hydrolysate produced 13% more gas and reduced the anaerobic digestion period by ten days compared to the untreated control. This suggests that using domesticated paddy soil microbes as a pretreatment might be a sustainable and cost-effective strategy for improving the degradation efficacy and methane production from lignocellulosic materials.

Impact of High-Pressure Homogenization on the Cell Integrity of Tetradesmus obliquus and Seed Germination.

Microalgae have almost unlimited applications due to their versatility and robustness to grow in different environmental conditions, their biodiversity and variety of valuable bioactive compounds. Wastewater can be used as a low-cost and readily available medium for microalgae, while the latter removes the pollutants to produce clean water. Nevertheless, since the most valuable metabolites are mainly located inside the microalga cell, their release implies rupturing the cell wall. In this study, Tetradesmus obliquus grown in 5% piggery effluent was disrupted using high-pressure homogenization (HPH). Effects of HPH pressure (100, 300, and 600 bar) and cycles (1, 2 and 3) were tested on the membrane integrity and evaluated using flow cytometry and microscopy. In addition, wheat seed germination trials were carried out using the biomass at different conditions. Increased HPH pressure or number of cycles led to more cell disruption (75% at 600 bar and 3 cycles). However, the highest increase in wheat germination and growth (40-45%) was observed at the lowest pressure (100 bar), where only 46% of the microalga cells were permeabilised, but not disrupted. Non-treated T. obliquus cultures also revealed an enhancing effect on root and shoot length (up to 40%). The filtrate of the initial culture also promoted shoot development compared to water (21%), reinforcing the full use of all the process fractions. Thus, piggery wastewater can be used to produce microalgae biomass, and mild HPH conditions can promote cell permeabilization to release sufficient amounts of bioactive compounds with the ability to enhance plant germination and growth, converting an economic and environmental concern into environmentally sustainable applications.

Removal of microorganisms and antibiotic resistance genes from swine wastewater: a comparison between polyaluminum chloride (PAC), polyaluminum sulfate (LST), and aluminum hydroxide iron (LT).

The presence of antibiotic-resistant bacteria (ARB) and antibiotic-resistance genes (ARGs) in swine wastewater may present a threat to the environment and public health. Conventional swine wastewater treatment processes generally fail to effectively reduce the content of ARGs. Therefore, it is necessary to develop a highly efficient and low-cost treatment method to solve this environmental problem. In doing so, we evaluated the application of three common coagulants in the treatment of swine wastewater. Using metagenomics, we evaluated the removal efficiency of ARG loads, as well as the effect of coagulation on the structure and diversity of swine wastewater, and on the bacterial community. The results showed that the three coagulants could effectively reduce the physicochemical pollution indexes of swine wastewater (e.g., TP, NTU, COD). After treatment, the loads of a variety of antibiotics in the swine wastewater were significantly reduced, with the exception of NFX and SMD, which were all close to 100%. At the same time, in evaluating the total number of microbial colonies and the total number of fecal Escherichia coli bacteria under the three conditions, Polyaluminum Chloride (PAC) ranked first among the three coagulants with 89.18%, 93.07%, 89.92%, 98.76%, 99.60%, and 98.68%. Metagenomic analysis revealed that the abundance of cfcC, tetX, mphE, msrE, tet36, and other ARGs in the water sample after the LST treatment was significantly lower than that of the original swine wastewater sample. These findings demonstrate the feasibility of using coagulants to treat swine wastewater, which is of great significance for improving water quality and reducing the potential impacts of ARGs.

Removal effects of Myriophyllum aquaticum on combined pollutants of nutrients and heavy metals in simulated swine wastewater in summer.

Swine wastewater (SW) treatment by Myriophyllum aquaticum is an important biotechnology for its resource utilization. However, some knowledge gaps remain in compound-pollutant removal in SW, especially in practical applications. To clarify the responses of M. aquaticum to the compound pollutants as well as the related operational parameters in SW treatment, three initial doses (0.5, 1.0, and 1.5 kg per pond in 150 L simulated SW) of M. aquaticum and a control (no plant; CK) were allocated to 12 ponds under a plastic roof in Nanjing city of Eastern China during 75 days in the summer of 2019. Results showed that M. aquaticum could be used as a pioneer plant to efficiently remove compounded pollutants of nitrogen (N), phosphorus (P), and especially for heavy metals in simulated SW. Compared with CK, M. aquaticum assisted in improving the total N, NH4+-N, NO3--N, NO2--N, and dissolved organic N by 30.1%, 100%, 100%, 97.6%, 20.2%, 39.8% whereas Cu, Zn, and Cd by 50.4%, 36.4% and 47.9% on average during the 75-day experiment in summer, respectively. Moreover, concentrations of Cu and Cd at day 75 were in the ranges of 1.92-2.82 and 0.64-1.47 g kg-1 DW, respectively, exceeding the corresponding limits of the heavy-metal hyperaccumulator. For the operational parameters, the optimized initial dose was 1.0 kg per pond with M. aquaticum harvested after 45 summer days, respectively. Given that M. aquaticum has been widely used as animal feed in recent years and limit values for Cu and Zn in animal feed are not set in China, the toxicities of Cu and Zn should be assessed and the guideline of their limit values needs to be established for safe feed production. Interestingly, NH4+-N could dominate the removal of heavy metals especially Cd in the simulated SW, however, related mechanisms are needed for further study.

Removal of antibiotic resistance genes from swine wastewater by membrane filtration treatment.

Antibiotic resistance genes (ARGs) have attracted extensive attention as an emerging environmental contaminant potentially threatening humans. One of the main emission sources of ARGs is swine wastewater. In this study, integrated membrane filtration including ultrafiltration and two-stage reverse osmosis was conducted for swine wastewater treatment. The abundances of 16 target ARGs, which accounted for 72.64% of the total ARGs in swine wastewater according to metagenomic sequencing, were quantified by quantitative real-time PCR (qPCR) during each stage of the membrane filtration process. The results showed that integrated membrane filtration could reduce more than 99.0% of conventional pollutants and 99.79% of ARGs (from 3.02 × 108 copy numbers/mL to 6.45 × 105 copy numbers/mL). Principal component analysis (PCA) indicated that the removal efficiency of ARGs subtype by membrane filtration did not depend on ARGs type. However, strong correlations were found between ARGs and the wastewater quality indicators TP, SS and EC according to Cooccurrence patterns, indicating that ARG removal was closely associated with insoluble solid particles and soluble ions in swine wastewater. These results showed that membrane filtration could not only remove conventional pollutants such as nitrogen and phosphorus but also reduce the emerging pollutant of ARGs and decrease the risk of ARGs flowing into natural water.

Heterotrophic nitrification and related functional gene expression characteristics of Alcaligenes faecalis SDU20 with the potential use in swine wastewater treatment.

A new heterotrophic nitrifying bacterium was isolated from the compost of swine manure and rice husk and identified as Alcaligenes faecalis SDU20. Strain SDU20 had heterotrophic nitrification potential and could remove 99.7% of the initial NH4+-N. Nitrogen balance analysis revealed that 15.9 and 12.3% of the NH4+-N were converted into biological nitrogen and nitrate nitrogen, respectively. The remaining 71.44% could be converted into N2 or N2O. Single-factor experiments showed that the optimal conditions for ammonium removal were the carbon source of sodium succinate, C/N ratio 10, initial pH 8.0, and temperature 30 °C. Nitrification genes were determined to be upregulated when sodium succinate was used as the carbon source analyzed by quantitative real-time polymerase chain reaction (qRT-PCR). Strain SDU20 could tolerate 4% salinity and show resistance to some heavy metal ions. Strain SDU20 removed 72.6% high concentrated NH4+-N of 2000 mg/L within 216 h. In a batch experiment, the highest NH4+-N removal efficiency of 98.7% and COD removal efficiency of 93.7% were obtained in the treatment of unsterilized swine wastewater. Strain SDU20 is promising in high-ammonium wastewater treatment.

Performances of simultaneous enhanced removal of nitrogen and phosphorus via biological aerated filter with biochar as fillers under low dissolved oxygen for digested swine wastewater treatment.

This study aims to explore the feasibility of biochar as a carrier to improve the simultaneous removal of nitrogen and phosphorus in biological aerated filters (BAFs) for treating low C/N digested swine wastewater (DSW). Two similar BAFs (BAF-A with hydrophobic polypropylene resin as fillers and BAF-B with bamboo biochar as carrier) were developed for DSW treatment. Results showed that the NH4+-N, TN, and TP removal performances in BAF-B were higher than those in BAF-A. Carrier type had an obvious influence on the structures and diversity of the microbial population. The biochar carrier in BAF-B was conducive to the enrichment of the functional microorganisms and the increase of microbial diversity under high NH4+-N conditions. Microbial analysis showed that the genera Rhodanobacter (10.64%), JGI_0001001-h003 (14.24%), RBG-13-54-9 (8.87%), Chujaibacter (11.27%), and Ottowia were the predominant populations involved in nitrogen and phosphorus removal in the later stage of phase III in BAF-B. BAF with biochar as carrier was highly promising for TN and TP removal in low C/N and high NH4+-N DSW treatment.

Effect of microaerophilic treatment on swine wastewater (SWW) treatment: Engineering and microbiological aspects.

The microaerobic process on swine wastewater (SWW) treatment was investigated, evaluating its effect on organic matter hydrolysis and removal, biogas production, operational stability, and microbial community structure. UASB reactors operating under higher organic loading rates (OLRs) and lower hydraulic retention times (HRTs) than those found in the SWW treatment literature were also assessed. The microaerophilic reactor R2 presented a higher total and particulate organic matter removals and operational stability than the anaerobic reactor R1, reaching CODP removals of 79.4 ± 4.6%. In the specific methanogenic activity (SMA) tests, the microaerobic sludge (R2) showed hydrolytic and acetogenic/methanogenic activity superior to inoculum and anaerobic sludge (R1). The microbiological evaluation of R2 revealed the high presence of hydrolytic microorganisms, therefore justifying the higher hydrolytic activity found in the SMA tests and higher particulate organic matter removal found in the microaerobic reactor.

Removal effects of different emergent-aquatic-plant groups on Cu, Zn, and Cd compound pollution from simulated swine wastewater.

Aquatic plants play effective in removing heavy metal (HM) as a prominent factor of bioremediations, however, there are still knowledge gaps in species selection and configuration for high removal efficiency (RE) of compound HM and ornamental value. In this study, seven emergent-aquatic-plant species were configured into seven groups and planted in a simulated swine wastewater (SW) with Cu, Zn, and Cd for 75 days in summer. REs of Cu, Zn, and Cd were 45.06-86.93%, 42.40-87.22%, and 73.85-85.52% at day 75, respectively. Higher REs were observed from day 30-45 for Cu and Zn, whereas days 15-30 for Cd. The synergistic removal of Zn and Cu or Zn and Cd was almost observed (p < 0.05). The configuration of G5 (S. tabernaemontani, I. sibirica, and P. cordata) was generally efficient roles in the removal at day 45, with REs of 85.14%, 87.06%, and 83.56% for Cu, Zn, and Cd, respectively. The dry weight of roots, water NH4+-N, temperature, pH, and dissolved oxygen acted on heavy-metal removal. During days 45-75, concentrations of Cu, Zn, and Cd in G5 were 0.52-0.66, 0.54-0.65, and 0.23-0.33 mg L-1. The former two were below the limits of Grade Ⅱ (1.0 mg L-1) and the latter was above the limits of Grade Ⅴ (0.1 mg L-1; GB3838-2002). Thus, G5 could be optimal for Cu and Zn removal from simulated SW, however, efficient Cd removal is required to ensure efficient SW recycling.

Development of reactive iron-coated natural filter media for treating antibiotic residual in swine wastewater: Mechanisms, intermediates and toxicity.

Degradation mechanisms, surface phenomena, and the influence of co-existing organic matter on heterogeneous Fenton-like reactions were investigated using low-cost natural materials, to remove three veterinary antibiotics. Zeolite rock, laterite rock, and pumice rock were modified by adding ferric chloride. Fenton-like reactions yielded more than 50 % of antibiotic removal at a neutral pH. The modified zeolite exhibited the highest antibiotic removal efficiency. The heterogeneous Fenton-like reaction could be indicated by the simultaneous detection of Fe(II) and Fe(III) on the surface of the modified zeolite. Leaching iron was also observed to reduce the antibiotics with homogeneous Fenton-like reaction. The co-existing organic matter expressed by the COD below 400 mg/L did not have a considerable adverse impact on antibiotic removal. An H2O2 concentration as low as 20 µM was sufficient to react with the modified zeolite and degraded more than 70 % of the antibiotics at a neutral pH. The modified zeolite could be reused at least three times, with a removal efficiency of at least 80 %. The antibiotic degradation efficiencies in real treated swine wastewater were above 75 %. Moreover, the degradation intermediates and bacterial inhibition after treatment were investigated.

Optimization of Fenton process for removing TOC and color from swine wastewater using response surface method (RSM).

The Fenton oxidation process was applied to biologically treated swine wastewater (BSWW) for the removal of TOC and color constituents after coagulation with FeCl3. Optimizing of operational variables such as FeSO4 and H2O2 doses was achieved by the response surface method (RSM). Statistical analysis led to the conclusion that FeSO4 is the more important than H2O2 in the removal of TOC. However, H2O2 plays a more significant role than FeSO4 in color removal. The optimal conditions for effective removal of TOC and color from swine wastewater were derived by using process optimization. The experimental results show that overall removal of TOC and color is 76.7% and 98%, respectively, when optimal conditions of 800 mg/L (FeSO4) and 5207 mg/L (H2O2) at 120 min were used. Furthermore, the optimization model produces a desirability value of 0.980 that verifies the optimal conditions. Finally, it is observed that removal of undesirable compounds follows a pseudo-first order and pseudo-second order kinetics model with high R2 values of 0.99 for both TOC and color removal, respectively. Statistical analysis and process optimization show that the employed model may determine conditions conducive to the effective removal of TOC and color from swine wastewater.