Inter- and intralaboratory variation of in vitro diffusion cell measurements: an international multicenter study using quasi-standardized methods and materials.

In vitro measurements of skin absorption are an increasingly important aspect of regulatory studies, product support claims, and formulation screening. However, such measurements are significantly affected by skin variability. The purpose of this study was to determine inter- and intralaboratory variation in diffusion cell measurements caused by factors other than skin. This was attained through the use of an artificial (silicone rubber) rate-limiting membrane and the provision of materials including a standard penetrant, methyl paraben (MP), and a minimally prescriptive protocol to each of the 18 participating laboratories. "Standardized" calculations of MP flux were determined from the data submitted by each laboratory by applying a predefined mathematical model. This was deemed necessary to eliminate any interlaboratory variation caused by different methods of flux calculations. Average fluxes of MP calculated and reported by each laboratory (60 +/- 27 microg cm(-2) h(-1), n = 25, range 27-101) were in agreement with the standardized calculations of MP flux (60 +/- 21 microg cm(-2) h(-1), range 19-120). The coefficient of variation between laboratories was approximately 35% and was manifest as a fourfold difference between the lowest and highest average flux values and a sixfold difference between the lowest and highest individual flux values. Intralaboratory variation was lower, averaging 10% for five individuals using the same equipment within a single laboratory. Further studies should be performed to clarify the exact components responsible for nonskin-related variability in diffusion cell measurements. It is clear that further developments of in vitro methodologies for measuring skin absorption are required.

In vivo skin absorption and distribution of the nerve agent VX (O-ethyl-S-[2(diisopropylamino)ethyl] methylphosphonothioate) in the domestic white pig.

The purpose of this study was to characterize the skin absorption and distribution of VX (O-ethyl-S-[2 (diisopropylamino)ethyl] methylphosphonothioate) in the domestic pig in order to evaluate the animal as a potential model for assessing pretreatments against toxic anti-cholinesterase compounds. A liquid droplet (equivalent to a 2 x LD50 dose) of radiolabelled VX was applied to the inner ear-skin of each anaesthetized animal. Blood and tissue samples (liver, lung, kidney, heart and skin exposure sites) were obtained post-mortem. The amount of radioactivity in each sample was measured by liquid scintillation counting, from which the skin absorption rate and dose distribution of VX were calculated. A substantial proportion (22 +/- 3%) of the applied dose remained within the skin at the site of application. It is conceivable that strategies to minimize or remove this reservoir may be of benefit in the early treatment of VX-exposed casualties. Image analysis of autoradiographs of exposed skin sites indicated that each milligram of radioactive VX covered an area of 1.2 +/- 0.5 cm2. The average skin absorption rate of 14C-VX was 661 +/- 126 microg/cm2 per hour. Comparison of these data with previous studies suggests that human skin is less permeable to VX than pig skin, but VX spreads over a greater surface area when applied to human skin. Thus, paradoxically, while pig-ear skin is more permeable than human skin, the difference in skin surface spreading may lead to the absorption of an equivalent systemic dose.

Clinical manifestations of VX poisoning following percutaneous exposure in the domestic white pig.

Nerve agents are a class of organophosphorus chemicals that inhibit certain cholinesterase enzymes (ChE). If untreated, percutaneous exposure to nerve agents, such as VX (O-ethyl-S-[2(diisopropylamino)ethyl] methylphosphonothioate) can cause paralysis, apnoea and death. Much of the information concerning the percutaneous absorption and subsequent toxicity of nerve agents has been obtained using various rodent models. However, the most relevant 'skin model' is arguably the pig. Therefore, the purpose of this study was to examine the clinical manifestations of VX intoxication in the domestic white pig following a 2 LD50 (120 microg/kg) percutaneous challenge. There was a consistent onset of signs (where present) in each animal: mastication was followed by miosis, salivation, fasciculations and apnoea. Whilst ChE activity did not correlate with the onset of signs, there was a qualitative relationship in that mastication preceded substantial ChE inhibition, miosis lagged behind the linear decrease in acetylcholinesterase (AChE) activity and fasciculations and apnoea occurred after maximum ChE inhibition had been attained (5-10% of normal). These observations may be of use for the triage of patients exposed to VX. In comparison with similar studies with GD, VX did not affect glucose utilization. However, VX was similar to GD in that it caused a mild hyperkalaemia and hyperphosphataemia, although the significance of this observation was not clear. There was substantial lateral diffusion of the initial droplet of VX over the application site, indicating that, when decontaminating exposed skin, attention should also be directed to areas peripheral to the original site of exposure.

The effects of sulfur mustard exposure and freezing on transdermal penetration of tritiated water through ex vivo pig skin.

The percutaneous absorption of tritiated water ((3)H(2)O) through sulfur mustard (SM) exposed abdominal pig skin was measured using in vitro Franz-type static diffusion cells. The barrier function to water permeation following exposure to liquid SM for 8 min and excision 3h later did not change significantly. A small, but statistically significant difference (P<0.05) in steady state penetration (Jss), permeability coefficient (Kp) and lag time (t(L)) of (3)H(2)O was observed between fresh skin and skin stored frozen (-20 °C) for up to two weeks. Steady-state penetration and Kp values were significantly higher (P < 0.05) in skin stored frozen compared with fresh skin. Fresh naïve skin had an average Kp of 1.65 × 10(-3) cm h(-1), whereas frozen naïve skin was 2.04 × 10(-3) cm h(-1). Fresh SM exposed skin had a mean Kp of 1.72 × 10(-3) cm h(-1), whereas frozen SM exposed skin was 2.31 × 10(-3) cm h(-1). Lag times were also shorter (P<0.05) in skin that had been stored frozen. Frozen, SM-exposed porcine abdominal skin may be used for in vitro penetration studies, but effects of treatment and storage on the barrier layer should be taken into account.