RESUMO
The aim of this study was to evaluate the effect of ambient temperature on the physical and chemical characteristics of the longissimus dorsi muscle by comparing the quality of meat from pigs reared in a controlled and in an uncontrolled environment, the latter provided with a shallow pool. Twenty castrated male pigs of the Topigs line were randomly allotted to two treatments: a controlled environment, with constant temperature (22 °C) and relative humidity (70%); and an uncontrolled environment in a conventional shed for rearing pigs equipped with a shallow pool, where pigs were subject to climatic variations. Meat from pigs kept in the controlled environment showed a greater capacity to retain intracellular water, higher tenderness, and lower cholesterol levels than meat from pigs reared in the uncontrolled environment, but displayed higher lipid oxidation and a lower concentration of DHA. Treatments had no effect on color, pH, chemical composition, or fatty acid profile (except DHA concentration). Rearing pigs in sheds equipped with a shallow pool minimizes the effects of environmental heat on meat quality, allowing the production of high-quality meat in warm climate regions without expensive investments. Animals reared in an uncontrolled environment equipped with a shallow pool are able to produce meat with characteristics within the quality standards and with similar quality to that of meat from animals raised in controlled environment.
Assuntos
Músculos do Dorso/química , Abrigo para Animais , Carne/análise , Suínos , Animais , Colesterol/análise , Ácidos Graxos/análise , Umidade , Concentração de Íons de Hidrogênio , Masculino , TemperaturaRESUMO
The objective of this study was to evaluate the effect of temperature on the performance and carcass yield of pigs housed in different environments. Twenty castrated male pigs of the Topigs line were assigned to two treatments: T1, controlled environment, and T2, uncontrolled environment containing a shallow pool. A completely randomized design consisting of two treatments and ten repetitions each was used. The data were submitted to analysis of variance, and means were compared by the Tukey test at a level of significance of 5 % using the SAS 9.2 program (SAS Institute, Inc., NC, USA). The results showed that rearing pigs in an uncontrolled environment during the growing and finishing phases reduced daily feed intake (1.722 and 3.164 kg, respectively) and improved feed conversion (2.15 and 2.70 kg, respectively), but did not influence the carcass yield of the animals. In conclusion, rearing pigs under different environmental conditions during the growing and finishing phases influenced animal performance without interfering with carcass yield.
Assuntos
Tamanho Corporal , Abrigo para Animais , Temperatura , Criação de Animais Domésticos/métodos , Animais , Ingestão de Alimentos , Masculino , Suínos , Aumento de PesoRESUMO
The aim of this study was to examine the effects of frozen storage for 12 mo on the concentrations of lipids and cholesterol and fatty acid profile of wooden chicken breast meat. A total of 120 samples of chicken breasts were selected, according to the degree of "wooden breast" myopathy ["severe," "moderate," and "normal" (absence of myopathy)], from male chickens slaughtered at 42 d of age, from Cobb 500 strain. Part of the samples (n = 20/grade of severity) were evaluated on the day of collection and the remainder were packaged, frozen and stored at -18°C for up to 12 mo. At the beginning (collection day) and at the end of the proposed freezing period (12 mo), analyses of lipid, cholesterol, and fatty acid profile were carried out. Percentage of saturated (SFA), monounsaturated (MUFA), and polyunsaturated (PUFA) fatty acids were evaluated. Meats affected by wooden breast myopathy had lower levels of PUFA that exert beneficial effects on health, such as DHA, EPA and ARA, and this profile is impaired by prolonged storage (12 mo), which results in important nutritional losses for the consumer.
Assuntos
Ácidos Graxos , Doenças Musculares , Animais , Masculino , Ácidos Graxos/análise , Galinhas , Congelamento , Ácidos Graxos Insaturados , Colesterol/análise , Carne/análise , Doenças Musculares/etiologia , Doenças Musculares/veterináriaRESUMO
The objective of the present study was to characterize possible variations in the quality of wooden chicken breast meat during freezing for 12 mo, in order to prove whether the shelf life recommended by the industry allows the storage of that type of meat without compromising its consumption. Three hundred samples of male Cobb 500 broilers slaughtered at 42 d of age were used. Part of the samples (n = 20 normal-control group; n = 20 moderate degree; n = 20 severe degree) were analyzed on the day of collection (beginning), previously kept under refrigeration (4°C). The other samples were stored (-18°C) for up to 12 mo. At the end of each proposed freezing period (3, 6, 9, and 12 mo), physical and chemical analyses were performed (per period: n = 20 normal-control group; n = 20 moderate degree; n = 20 severe degree). Color (L*, a*, and b*), pH, water-holding capacity, cooking losses, tenderness, lipid oxidation, chemical composition, cholesterol concentration, mineral profile, and collagen concentration were evaluated. The physicochemical quality of wooden chicken breast meat is significantly altered during frozen storage for 12 mo, being of inferior quality when compared to normal chicken breast meat, which can negatively affect consumer acceptance. However, it should be noted that even after 12 mo of freezing, the meats did not show oxidative rancidity.
Assuntos
Galinhas , Doenças Musculares , Masculino , Animais , Congelamento , Carne/análise , Culinária , Doenças Musculares/etiologia , Doenças Musculares/veterinária , Músculos Peitorais/químicaRESUMO
The purpose of the present study was to characterize the chemical composition, lipid oxidation, and physical characteristics of fresh sausages produced with meat from the pectoralis major muscle affected by deep pectoral myopathy. For the characterization of myopathy, samples were collected from broiler chickens slaughtered between 42- and 46-days old in a slaughterhouse in the state of São Paulo. The experiment consisted of samples from pectoralis major muscle of birds affected or not by DPM (normal-absence of myopathy and DPM category 3-progressive degeneration of the pectoralis minor with a greenish appearance). After classification of the samples, a part of raw products with the pectoralis minor removed, was submitted to microbiological and physical analyses for the characterization of DPM. Afterward, only the pectoralis major muscle was used to manufacture fresh sausages and 2 groups were established. The evaluated parameters were: color, pH, water-holding capacity (WHC), cooking loss (CL), shear force (SF), water activity (Aw), and chemical composition. Meat pH was higher (P < 0.05) in meats with DPM, however, WHC values were lower (71.92%), which made CL value increase (25.31%). In addition, the coloring increased and the technological characteristics of raw breasts were less favorable with the presence of DPM. All fresh sausages' color (except a* higher control group), pH, and Aw values were higher in DPM group. No effect on SF values was observed between fresh sausages. In chemical composition, only protein content increased in fresh sausages with DPM. Microbiological analyses did not indicate bacterial contamination of raw samples and fresh sausages. Data obtained in the present study suggest fresh sausages produced with breasts affected by DPM are a viable alternative and may confer more favorable qualitative characteristics to sausages than the raw marketed meat.
Assuntos
Galinhas , Doenças Musculares , Animais , Galinhas/fisiologia , Brasil , Carne/análise , Doenças Musculares/etiologia , Doenças Musculares/veterinária , Músculos Peitorais/fisiologia , Água/análiseRESUMO
This study aimed to evaluate the effects of aging on the quality of breast meat from broilers affected of wooden breast. Samples that were classified as normal (control), moderate (hardness verified only in one region of breast fillet), and severe (hardness verified in all the extension of breast fillet) were evaluated fresh and after three and seven days of aging. Normal samples and samples with a moderate degree of myopathy showed greater water-holding capacity, which may benefit the processing industry of poultry meat. During the aging process, increase was observed in total collagen concentration (from 0.41% in normal samples to 0.56% in samples with severe degree). Samples of chicken breast affected by moderate degree showed higher myofibril fragmentation index (MFI = 115) than normal chicken samples (95.65). Although chicken samples affected with severe degree of wooden breast myopathy are more tender than normal chicken breasts, they produce more exudate, which can be detrimental to the processing of poultry meat. The aging process may improve the reduction of cooking weight loss and protein loss in exudation of broilers' breasts affected by wooden breast myopathy.
RESUMO
One of the current myopathies affecting the chicken meat industry is deep pectoral myopathy (DPM), also known as green muscle disease or Oregon disease, the condition is considered a major problem in poultry processing lines. Thus, the present study proposes to examine the meat quality of the Pectoralis major muscle (breast fillet) from carcasses of broilers affected by DPM in Pectoralis minor muscle (tender) and from a control group. Breast fillets samples were harvested from Ross AP95 broilers that were slaughtered at 42 days of age and were selected to the occurrence of the myopathy (score 2 and score 3) and from a control group without (score 0) the presence of myopathy. Chemical composition, cholesterol, fatty acid profile, pH, color, water-holding capacity, cooking loss, shear force, sarcomere length, and collagen were analyzed in the breast fillet. And with the results it was observed the samples classified as DPM score 2 had a higher moisture and a lower protein percentage. The higher values lipid was found in the samples from broilers affected by DPM. There was no difference (P > 0.05) fatty acid profile only to C10:0, C15:0, C17:0, C20:0, and C18:2c9,t11. Differences were detected (P < 0.05) for the pH, WHC, SF, and sarcomere length of the samples from broilers affected by DPM. The higher pH observed in the samples from birds classified as DPM score 2 and the higher WHC values were observed in the samples affected by DPM (score 2 and 3). The SF (P < 0.05) among samples, with the most tender samples (lower SF values) being those unaffected by the condition DPM (score 0). The dorsal side surface, where the Pectoralis major muscle is in contact with the Pectoralis minor muscle, higher L* values were found in the meat affected by the myopathy. Although deep pectoral myopathy affects the Pectoralis minor muscle of broilers, it can also alter the qualitative characteristics and chemical composition of the breast fillets (Pectoralis major muscle).
Assuntos
Galinhas , Doenças Musculares , Animais , Culinária , Carne/análise , Doenças Musculares/etiologia , Doenças Musculares/veterinária , Músculos PeitoraisRESUMO
The aim of this study was to characterize the breast meat of turkeys affected by different degrees of severity (normal [NORM], moderate [MOD], and severe [SEV]) of the white striping (WS) myopathy, as well as to evaluate the influence of this myopathy on meat quality. Twenty-nine samples of the pectoralis major muscles of each treatment were obtained from Nicholas breed male and female turkeys, reared and slaughtered in the center-west region of Brazil. The whole breasts of the turkeys were used for macroscopic classification, weight evaluation, and morphometric measurements. Then, the pectoralis major muscle was separated for histological evaluation and qualitative physicochemical analyses, namely ventral and dorsal color (L∗, a∗, and b∗), pH value, water holding capacity (WHC), cooking loss (CL), shear force (SF) (Meullenet-Owens Razor Shear [MORS] and Warner-Bratzler), sarcomere length, total, soluble, and insoluble collagen contents, proximate composition (protein, lipids, moisture, and ash), cholesterol content, and fatty acid profile. The results showed that muscles affected by myopathy, both MOD and SEV, exhibited larger weights (around 2.8 kg) compared to NORM muscles (1.3 kg) and a significant increase (P < 0.05) in the diameter of the fibers. The increase in the degree of severity of the myopathy increased (P < 0.05) the value of L∗ of the dorsal part and ventral part of the muscle. No differences (P > 0.05) were observed in the pH, CL, and WHC values of the muscles, whereas the MORS and Warner-Bratzler SF of the SEV fillets resulted in significantly lower shear values (P < 0.05) compared to the NORM fillets. In addition, the MOD and SEV fillets presented lower values of protein (P < 0.05) than NORM fillets. No significant differences (P > 0.05) were observed for moisture and lipid and cholesterol contents. Meat with MOD and SEV severity of WS myopathy had higher (P < 0.05) concentrations of total and insoluble collagen. Thus, the presence of WS myopathy in MOD and SEV degrees affected a large part of the histological and quality characteristics evaluated.
Assuntos
Doenças Musculares , Perus , Animais , Brasil , Galinhas , Feminino , Masculino , Carne/análise , Doenças Musculares/etiologia , Doenças Musculares/veterinária , Músculos PeitoraisRESUMO
The aim of this study was to examine the effects of storage on the quality of sausages made with breast from chickens affected by wooden breast myopathy (WBM). Breast samples from male broilers slaughtered at 48 days old were used. Normal (absence of myopathy), moderate degree (hardness only in one region of the breast) and severe degree samples (hardness over the entire length of the breast) were processed into sausages and evaluated prior to storage and after being vacuum-packed and stored for 7, 14, 21 and 28 days at 4 °C. There was a decrease (p < 0.001) in pH and an increase (p < 0.001) in cooking weight loss in samples of sausages, regardless of the myopathy, after 28 days of storage. Sausages produced with chicken breast samples affected by wooden breast myopathy presented higher (p < 0.0001) moisture concentration (72% for the severe degree) and higher (p = 0.0224) protein concentration (17.27% and 17.36%, respectively, for the moderate and severe degrees) than sausages made of normal samples (70.72% and 14.32%, respectively). The results indicate that sausages produced with meat from birds moderately and severely affected by the myopathy show higher oxidative stability. Fresh sausages produced with breast meat from birds affected by wooden breast syndrome may be stored (4 °C) for up to 28 days without exhibiting the characteristic rancid taste and smell. In sensory analysis, no differences were observed between the formulations, which suggests that the consumers approved the samples regardless of the disease severity in the meat used for the making of the sausages. The current results show that chicken meat affected by wooden breast myopathy can be used for producing fresh sausages in the industry.
RESUMO
This study aimed to characterize the effects of wooden breast myopathy (WBM) on quality of broiler chicken breast meat. Normal samples (absence of myopathy), moderate-degree samples (hardness only in one area of the breast fillet) and severe-degree samples (hardness throughout the breast fillet) were classified. In macroscopic analysis, the pectoral muscle affected by the WBM showed, in general, pale color with stiff, irregular and reddish regions (suffusions and petechiae), with the presence of white striations. In microscopic analysis, the myopathy was characterized by loss of the polygonal aspect of the muscle fibers. Samples with moderate degree of the myopathy showed greater (p = 0.0266) water retention capacity. There was an increase (p = 0.004) in total collagen concentration in samples from the severe-degree group 0.29% in normal samples to 0.43 and 0.48% in samples from moderate- and severe-degree groups, respectively. Samples of chicken breast affected by the severe-degree WBM showed lower (p < 0.0001) myofibrillar fragmentation index (64.51) and lower (p = 0.0002) fat concentration (2.17%) than normal chicken samples (80.45 and 3.79%, respectively). Samples affected by WBM are larger and heavier and present poorer physical quality when compared to normal chicken meat. Histologically it is possible to observe loss of the polygonal aspect of muscle fibers.
RESUMO
Considering the increased incidence of wooden breast myopathy in broilers, the intake involves no threat to human health, indefinite etiology consumer rejection by appearance in such breasts, and the lack of studies on the industrial use of wooden breast. The objective of this study was evaluating the quality of hamburgers made with chicken meat affected by wooden breast. Breast samples from broilers slaughtered at 48-days-old were used. Normal (absence of myopathy), moderate degree (hardness only in one region of the breast) and severe degree (hardness over the entire length of the breast) samples were processed for the manufacture of hamburgers whose quality analyses (color, pH, cooking weight loss, shrinkage percentage, tenderness, storage weight loss, water activity, lipid oxidation, chemical composition and consumer test) were performed on non-stored samples (Day 0), and after storing at 30, 60, 90 and 120 days at -20 °C. There was a reduction (p < 0.05) in tenderness in samples of moderate-grade hamburgers (from 161.45 N to 289.40 N) after 120 days of storage. Hamburgers produced with chicken breast samples affected by wooden breast myopathy presented higher (p < 0.0001) fat concentration (5.32 g/100 g and 5.26 g/100 g, respectively, for the moderate and severe degree) than hamburgers made of normal samples (4.45 g/100 g). Lipid oxidation values increased, which exceeded the limit of rancidity detection, independent of myopathy. The consumers equally appreciated the aroma, flavor, and texture, and rated their overall acceptance as similar regardless of the quality of chicken meat. Chicken breast hamburgers with wooden breast myopathy is a viable alternative for the poultry industry.
RESUMO
Foram utilizadas amostras de peito de frangos de corte acometidos pela miopatia White Striping (estrias brancas em seus diferentes graus de severidade) para análise de coloração (L*, a* e b*), lipídeos totais e concentração de colágeno. Amostras de filés acometidos pela miopatia foram avaliadas logo após o abate e outras foram armazenadas congeladas (-20°C) durante três meses. Com a severidade da miopatia ocorre o aumento da concentração de gordura e, consequentemente, alteração da coloração da superfície do peito, além da redução do percentual de colágeno. O congelamento da carne de peito por três meses provoca alterações de cor da superfície dos filés. A produção de exsudato, oriunda do descongelamento, resulta no aumento da concentração de componentes como colágeno solúvel e lipídeos.
Assuntos
Animais , Carne/análise , Colágeno/análise , Congelamento/efeitos adversos , Cor , Doenças Musculares/veterinária , Lipídeos/análise , Armazenamento de Alimentos , GalinhasRESUMO
Qualitative characteristics of breast meat of broilers fed diets supplemented with different concentrations (0; 0.3 and 0.5mg kg-1) of selenium in the form of selenomethionine and sodium selenite were analyzed. A total of 1050 one-day-old male Cobb broiler chicks were arranged factorially at random to five treatments (two concentrations x two sources + control diet without addition of selenium) with 7 replications of thirty birds each and received an isonitrogenous and isocaloric diets in all phases according to their ages (1-21, 22-35, and 36-42 days). At 42 days of age, TBARS (thiobarbituric acid reactive substances) after storage at 4ºC for one, seven and 15 days and also after 30 days under freezing temperatures (-15°C), color (CIELab), water holding capacity, cooking loss, shear force, pH and selenium concentration were determined in slaughtered birds breast meat. Results indicated that the use of selenomethionine provides less lightness and lower oxidation in chicken breast meat stored up to 15 days at 4°C. There was a positive effect of dietary different sources and levels of selenium on breast meat quality of broilers. It was observed a linear effect of dietary selenium levels on the amount of selenium deposited in the muscle, and the organic source (selenomethionine) is more effective than inorganic one (sodium selenite) for broiler meat conservation.
Analisaram-se características qualitativas da carne do peito de frangos de corte alimentados com rações suplementadas com diferentes concentrações (0; 0,3 e 0,5mg kg-1) de selênio nas formas de selenometionina e selenito de sódio. Foram utilizados 1050 pintainhos machos de um dia de idade da linhagem Cobb, que foram distribuídos em delineamento inteiramente casualizado em esquema fatorial em 5 tratamentos (duas concentrações x duas fontes + tratamento controle, sem adição de selênio) e sete repetições de trinta aves cada e receberam rações isoproteicas e isoenergéticas em todas as fases de criação (1 a 21, 22 a 35 e 36 a 42 dias). Aos 42 dias de idade, TBARS (substâncias reativas ao ácido tiobarbitúrico) após armazenamento a 4ºC por um, sete e 15 dias e 30 dias sob congelamento (15ºC), coloração (CIELab), capacidade de retenção de água, perdas de peso por cocção, força de cisalhamento, pH e concentração de selênio foram determinadas na carne do peito das aves abatidas. Os resultados indicaram que o uso da selenometionina ocasiona queda da oxidação da carne e luminosidade aos 15 dias de armazenamento a 4ºC. Existiu um efeito positivo da suplementação da ração com as diferentes fontes e concentrações de selênio sobre a qualidade da carne do peito das aves. Houve efeito linear dos níveis dietéticos de selênio na quantidade de selênio depositado no músculo, e a fonte orgânica (selenometionina) foi mais efetiva que a inorgânica (selenito de sódio) na conservação da carne de frango.