Biological treatment removal of rare earth elements and yttrium (REY) and metals from actual acid mine drainage.

Actual acid mine drainage (AMD) containing a high concentration of sulfate (∼1,000 mg·L-1), dissolved metals, uranium, rare earth elements and yttrium (REY) was treated using a down-flow fixed-structured bed biological reactor (DFSBR). The reactor was operated in a continuous flow mode for 175 days and the temperature was maintained at 30 °C. The synthetic AMD was gradually replaced by the actual AMD in 20, 50 and 75% of the total medium volume. Sugarcane vinasse was used as the electron donor and the influent pH of the reactor was decreased from 6.9 to 4.6 until the system collapsed. REY elements and transition metals were removed from the actual AMD and precipitated in the down-flow fixed-structured bed reactor. Sulfate reduction achieved 67 ± 22% in Phase II and chemical oxygen demand (COD) removal was above 56% in Phases I and II. Removal of La, Ce, Pr, Nd, Sm and Y was higher than 70% in both Phases II and III while Fe, Al, Si and Mn were removed with efficiencies of 79, 67, 48 and 25%, respectively. The results highlighted the potential use of DFSBR in the treatment of AMD, providing possibilities for simultaneous sulfate reduction and metal and REY recovery in a single unit.

Energy and protein requirements for growth of Holstein × Gyr heifers.

There is little information regarding the nutritional requirements for dairy heifers, leading the majority of nutrient requirement systems to consider dairy heifers to be similar to beef heifers. Therefore, we evaluated the muscle protein metabolism and physical and chemical body composition of growing Holstein × Gyr heifers and estimated the energy and protein requirements. We performed a comparative slaughter experiment with 20 Holstein × Gyr heifers at an initial body weight of 218 ± 36.5 kg and an average age of 12 ± 1.0 months. Four heifers were designated as the reference group, and the 16 remaining heifers were fed ad libitum. The 16 heifers were distributed using a completely randomized design in a 2 × 2 factorial arrangement with two roughages (corn silage or sugarcane) and two concentrate levels (30 or 50%) for 112 days. Greater (p < 0.05) values for fractional rates of muscle protein synthesis, degradation and accretion were observed for heifers that were fed 50% concentrate. The following equations were obtained to estimate the net energy for gain (NEg ) and net protein for gain (NPg ): NEg (Mcal/day) = 0.0685 × EBW0.75  × EBWG1.095 and NPg (g/day) = 203.8 × EBWG - 14.80 × RE, respectively, in which EBW is the empty body weight, EBWG is the empty body weight gain and RE is the retained energy. We concluded that increased rates of protein turnover are achieved when a greater quality diet is provided. In the future, these results can be used to calculate the nutritional requirements for growth of Holstein × Gyr heifers after equation validation rather than using the recommendations provided by other systems, which use values developed from beef heifers, to determine the nutritional requirements of dairy cattle.

Sulfidogenesis interference on methane production from carbohydrate-rich wastewater.

Two anaerobic fixed-structured bed reactors were fed with synthetic wastewater simulating the soluble fraction of sugarcane vinasse to evaluate the interference of sulfidogenesis on methanogenesis. The reactors running in parallel were subjected to the same operating conditions. The influent organic matter concentration (in term of chemical oxygen demand (COD)) remained close to 4,000 mgCOD L(-1) and the hydraulic retention time was 24 hours. One reactor, the methanogenic (control reactor), received sulfate only to provide the sulfur required as a nutrient to the methanogenic biomass. The other one, the sulfidogenic/methanogenic reactor (SMR), received sulfate concentration corresponding to COD/sulfate ratios of 4, 5 and 3. In the last phase, the COD removal efficiencies were higher than 96% in both reactors and the SMR achieved 97% of sulfate removal efficiency (COD/sulfate ratio of 3 and influent sulfate concentration close to 1,300 mgSO4(2-) L(-1)). Both reactors also had similar methane yields in this phase, close to 350 mLCH4 gCODremoved(-1) at standard temperature and pressure. These results indicated no significant inhibition of methanogenic activity under the sulfidogenic conditions assessed.

Estimating mineral requirements of Nellore beef bulls fed with or without inorganic mineral supplementation and the influence on mineral balance.

The objectives of this study were to quantify the mineral balance of Nellore cattle fed with and without Ca, P, and micromineral (MM) supplementation and to estimate the net and dietary mineral requirement for cattle. Nellore cattle ( = 51; 270.4 ± 36.6 kg initial BW and 8 mo age) were assigned to 1 of 3 groups: reference ( = 5), maintenance ( = 4), and performance ( = 42). The reference group was slaughtered prior to the experiment to estimate initial body composition. The maintenance group was used to collect values of animals at low gain and reduced mineral intake. The performance group was assigned to 1 of 6 treatments: sugarcane as the roughage source with a concentrate supplement composed of soybean meal and soybean hulls with and without Ca, P, and MM supplementation; sugarcane as the roughage source with a concentrate supplement composed of soybean meal and ground corn with and without Ca, P, and MM supplementation; and corn silage as the roughage source with a concentrate supplement composed of soybean meal and ground corn with and without Ca, P, and MM supplementation. Orthogonal contrasts were adopted to compare mineral intake, fecal and urinary excretion, and apparent retention among treatments. Maintenance requirements and true retention coefficients were generated with the aid of linear regression between mineral intake and mineral retention. Mineral composition of the body and gain requirements was assessed using nonlinear regression between body mineral content and mineral intake. Mineral intake and fecal and urinary excretion were measured. Intakes of Ca, P, S, Cu, Zn, Mn, Co, and Fe were reduced in the absence of Ca, P, and MM supplementation ( < 0.05). Fecal excretion of Ca, Cu, Zn, Mn, and Co was also reduced in treatments without supplementation ( < 0.01). Overall, excretion and apparent absorption and retention coefficients were reduced when minerals were not supplied ( < 0.05). The use of the true retention coefficient instead of the true absorption coefficient provided a better estimate of mineral requirements. Dietary mineral requirements were lower for P, Cu, and Zn and greater for Fe compared with previously published recommendations. This study provides useful information about mineral requirements and mineral supplementation to obtain adequate dietary mineral supply of Nellore cattle in tropical conditions.