Noninvasive detection of passively targeted poly(ethylene glycol) nanocarriers in tumors.

The present studies noninvasively investigate the passive tumor distribution potential of a series of poly(ethylene glycol) (PEG) nanocarriers using a SkinSkan spectrofluorometer and an In Vivo Imaging System (IVIS) 100. Fluorescein conjugated PEG nanocarriers of varying molecular weights (10, 20, 30, 40, and 60 kDa) were prepared and characterized. The nanocarriers were administered intravenously to female balb/c mice bearing subcutaneous 4T1 tumors. Passive distribution was measured in vivo (λ(exc), 480 nm; λ(em), 515-520 nm) from the tumor and a contralateral skin site (i.e., control site). The signal intensity from the tumor was always significantly higher than that from the contralateral site. Trends in results between the two methods were consistent with tumor distribution increasing in a molecular weight-dependent manner (10 < 20 < 30 ≪ 40 ≪ 60 kDa). The 10 kDa nanocarrier was not detected in tumors at 24 h, whereas 40-60 kDa nanocarriers were detected in tumors for up to 96 h. The 30, 40, and 60 kDa nanocarriers showed 2.1, 5.3, and 4.1 times higher passive distribution in tumors at 24 h, respectively, as compared to the 20 kDa nanocarrier. The 60 kDa nanocarrier exhibited 1.5 times higher tumor distribution than 40 kDa nanocarrier at 96 h. Thus, PEG nanocarriers (40 and 60 kDa) with molecular weights close to or above the renal exclusion limit, which for globular proteins is ≥45 kDa, showed significantly higher tumor distribution than those below it. The hydrodynamic radii of PEG polymers, measured using dynamic light scattering (DLS), showed that nanocarriers obtained from polymers with hydrodynamic radii ≥8 nm exhibited higher tumor distribution. Ex vivo mass balance studies revealed that nanocarrier tissue distribution followed the rank order tumor > lung > spleen > liver > kidney > muscle > heart, thus validating the in vivo studies. The results of the current studies suggest that noninvasive dermal imaging of tumors provides a reliable and rapid method for the initial screening of nanocarrier tumor distribution pharmacokinetics.

Influence of molecular size on the retention of polymeric nanocarrier diagnostic agents in breast ducts.

PURPOSE: To investigate the influence of nanocarrier molecular size and shape on breast duct retention in normal rats using a non-invasive optical imaging method. METHODS: Fluorescein-labeled PEG nanocarriers of different molecular weights and shapes (linear, two-arm, four-arm, and eight-arm) were intraductally administered (50 nmol) to female Sprague-Dawley rats. Whole body images were obtained non-invasively. Fluorescence intensities (i.e., amount remaining in duct) were plotted against time to estimate the nanocarrier ductal retention half-lives (t(1/2)). Plasma samples were taken and the pharmacokinetics (Tmax, Cmax) of absorbed nanocarriers was also assessed. RESULTS: The t(1/2) of linear 12, 20, 30, 40, and two-arm 60 kDa nanocarriers were 6.7 ± 0.9, 16.1 ± 4.1, 16.6 ± 3.4, 21.5 ± 2.7, and 19.5 ± 6.1 h, whereas the four-arm 20, 40, and eight-arm 20 kDa had t(1/2) of 9.0 ± 0.5, 11.5 ± 1.9, and 12.6 ± 3.0 h. The t(1/2) of unconjugated fluorescein was significantly lower (14.5 ± 1.4 min). The Tmax for 12, 40, 60 kDa nanocarriers were 1, 24, and 32 h, respectively, and only 30 min for fluorescein. CONCLUSIONS: Since normal breast ducts are highly permeable, the use of nanocarriers may be helpful in prolonging ductal retention of diagnostic and/or therapeutic agents.

Breast intraductal nanoformulations for treating ductal carcinoma in situ I: Exploring metal-ion complexation to slow ciclopirox release, enhance mammary persistence and efficacy.

INTRODUCTION: Ductal Carcinoma In Situ (DCIS) represents a significant fraction (~20-25%) of all newly diagnosed breast cancer cases and, if left untreated, a significant fraction of patients will progress to invasive disease. Surgery is the only treatment option. Ciclopirox (CPX), an FDA-approved antifungal drug, has exhibited promising antitumor activity by down-regulating the expression of vital antiapoptotic cellular proteins and inhibiting the genetic expression of several oncogenic pathways. In this study, the feasibility of using nanoscale delivery systems to control release and prolong mammary tissue persistence of a lipophilic metal complex of CPX and Zinc (CPXZn) after intraductal administration was investigated. METHODS: CPX and CPX-Zn nanosuspensions (NSs) were prepared using an evaporative nanoprecipitation-ultra-sonication method. Flash nanoprecipitation was used to prepare PLGA nanoparticles (NPs) loaded with CPXZn. Our established orthotopic DCIS rat model was used to evaluate efficacy. Briefly, two days after 13762 Mat B III cell intraductal inoculation, rats were divided into treatment groups and a single intraductal injection of CPX NS, CPX-Zn NS or CPX-Zn NPs was administered. In the first study arm, the efficacy of CPX NS (1, 3, 5 mg/duct) was evaluated. In the second arm, the in vivo efficacy of CPX NS, CPX-Zn NS and CPX-Zn loaded NPs was evaluated and compared at equivalent CPX doses. The mammary persistence of CPX from CPX NS, CPX-Zn NS, and CPX-Zn PLGA NPs was also assessed. RESULTS: CPX-Zn complex was successfully synthesized and characterized by several spectral analyses. CPX release was slowed from the CPX-Zn NS and further slowed by incorporating CPX-Zn into PLGA NPs as compared to the CPX NS with release half times following the order: CPX NS < CPX-Zn NS << CPX-Zn NP. Intraductal CPX NS administration was dose and time dependent in suppressing tumor initiation suggesting prolonged mammary exposure may improve efficacy. In the second arm, mammary tissue persistence of CPX followed the rank order CPX NS < CPX-Zn NS << CPX-Zn NP at 6 h and 48 h post-administration. Prolonged mammary CPX exposure was highly correlated to improved efficacy. Prolonged CPX tissue persistence, attributed to slower release from the zinc complex and the PLGA NPs, resulted in a 5-fold dose reduction compared to the CPX NS. CONCLUSIONS: The current results demonstrate that slowing drug release in the mammary duct after intraductal administration overcomes the rapid ductal clearance of CPX, prolongs mammary tissue persistence, improves efficacy against DCIS lesions in vivo, and requires 5-fold less CPX to achieve equivalent efficacy. The studies also provide a strategic path forward for developing a locally administered drug delivery system for treating DCIS, for which no primary chemotherapy option is available.

Evaluation of intraductal delivery of poly(ethylene glycol)-doxorubicin conjugate nanocarriers for the treatment of ductal carcinoma in situ (DCIS)-like lesions in rats.

Ductal carcinoma in situ is the most commonly diagnosed early stage breast cancer. The efficacy of intraductally delivered poly(ethylene glycol)-doxorubicin (PEG-DOX) nanocarriers, composed of one or more DOX conjugated to various PEG polymers, was investigated in an orthotopic ductal carcinoma in situ-like rat model. In vitro cytotoxicity was evaluated against 13762 Mat B III cells using MTT assay. The orthotopic model was developed by inoculating cancer cells into mammary ducts of female Fischer 344 retired breeder rats. The ductal retention and in vivo antitumour efficacy of two of the six nanocarriers (5 kDa PEG-DOX and 40 kDa PEG-(DOX)4) were investigated based on in vitro results. Mammary retention of DOX and PEG-DOX nanocarriers was quantified using in vivo imaging. Histopathologic effects of DOX and PEG-DOX nanocarriers on mammary ductal structure were also investigated. Cytotoxicities of small linear PEG-DOX nanocarriers (5 and 10 kDa) were not different from DOX whereas larger PEG-DOX nanocarriers showed reduced potency. The order of mammary retention was 40 kDa PEG-(DOX)4 > 5 kDa PEG-DOX >> DOX, in normal and tumour-bearing rats. Intraductally administered PEG-DOX nanocarriers and DOX were effective in reducing tumour incidence and increasing survival rate, with no significant differences found among the three treatment groups. However, nanocarriers administered intravenously at the same doses were not effective, and intraductally administered free DOX caused severe local toxicity. Intraductal administration of PEG-DOX nanocarriers is effective and less toxic than that of free DOX, as well as IV DOX/PEG-DOX. Furthermore, PEG-DOX nanocarriers demonstrate the added benefit of prolonging DOX ductal retention, which would necessitate less frequent dosing.

The effect of size and polymer architecture of doxorubicin-poly(ethylene) glycol conjugate nanocarriers on breast duct retention, potency and toxicity.

Although systemic administration of chemotherapeutic agents is routinely used for treating invasive breast cancer, the only therapeutic options for ductal carcinoma in situ (DCIS) are surgery and radiation. Treating DCIS by delivering drugs locally to the affected milk duct offers significant advantages over systemic administration, including reduced systemic and breast toxicities, as well as a greatly reduced need for surgery and radiation. In this study, mammary gland retention and toxicity of intraductally administered poly(ethylene) glycol-doxorubicin (PEG-DOX) polymeric conjugate nanocarriers of varying molecular sizes and architectures were investigated. Nanocarriers were formed by conjugating one or more copies of doxorubicin to PEG polymers, of varying molecular weights (5, 10, 20, and 40 kDa) and architectures (linear, four-arm and eight-arm). Cytotoxicity against MCF7 cells, a human breast cancer cell line, was assessed, and IC50 values were calculated. The nanocarriers were intraductally administered into the mammary glands of female retired breeder Sprague-Dawley rats. Whole body images were captured using in vivo optical imaging, and changes in ductal structure as well local inflammation were monitored. Fluorescence intensities were monitored, over time, to evaluate nanocarrier mammary gland retention half-lives (t1/2). The IC50 values of PEG-DOX nanocarriers against MCF7 cells were 40 kDa PEG-(DOX)4 (1.23 µM) < 5 kDa PEG-DOX (1.76 µM) < 40 kDa PEG-(DOX)8 (3.49 µM) < 10 kDa PEG-DOX (3.86 µM) < 20 kDa PEG-DOX (8.96 µM) < 40 kDa PEG-DOX (18.11 µM), whereas the IC50 of free DOX was only 0.14 µM. The t1/2 of linear 5, 20, and 40 kDa nanocarriers were 2.2 ±â€¯0.3, 3.6 ±â€¯0.6, and 13.1 ±â€¯3.4 h, whereas the retention t1/2 of 4- and 8-arm 40 kDa nanocarriers were 14.9 ±â€¯5.6 h and 11.9 ±â€¯2.9 h, respectively. The retention t1/2 of free doxorubicin was 2.0 ±â€¯0.4 h, which was significantly shorter than that of the linear and branched 40 kDa PEG-DOX nanocarriers. Increased molecular weight and decreased branching both demonstrated a strong correlation to enhanced mammary gland retention. Intraductally administered free doxorubicin resulted in ductal damage, severe inflammation and generation of atypical cell neoplasms, whereas PEG-DOX nanocarriers induced only minor and transient inflammation (i.e., damaged epithelial cells and detached cellular debris). The 40 kDa 4-arm PEG-DOX nanocarrier demonstrated the longest ductal retention half-life, the lowest IC50 (i.e., most potent), and minimal ductal damage and inflammation. The current results suggest that PEG-DOX nanocarriers with prolonged ductal retention may present the best option for intraductal treatment of DCIS, due to their low local toxicity and potential for sustained therapeutic effect.