Levels of nitrate, nitrite and nitrosamines in model sausages during heat treatment and in vitro digestion - The impact of adding nitrite and spinach (Spinacia oleracea L.).

Nitrite derivatives react with endogenous precursors forming N-nitrosamines associated with development of colorectal cancer. The present study aims to investigate the formation of N-nitrosamines in sausage during processing and in vitro gastrointestinal digestion after adding sodium nitrite and/or spinach emulsion. The INFOGEST digestion protocol was used to simulate the oral, gastric, and small intestinal phases of digestion, and sodium nitrite was added in the oral phase to mimic the input of nitrite from saliva as it has shown to affect the endogenous formation of N-nitrosamines. The results show that the addition of spinach emulsion, in spite of it being a source of nitrate, did not affect the nitrite content in either batter, sausage, or roasted sausage. The levels of N-nitrosamines increased with the added amount of sodium nitrite, and further formation of some volatile N-nitrosamines was observed during roasting and in vitro digestion. In general, N-nitrosamine levels in the intestinal phase followed the same trend as in the undigested products. The results further indicate that nitrite present in saliva may cause a significant increase in N-nitrosamine levels in the gastrointestinal tract and that bioactive components in spinach may protect against the formation of volatile N-nitrosamines both during roasting and digestion.

Processing factors of pesticide residues in biscuits and their relation to the physicochemical properties of pesticides.

Agricultural commodities are generally consumed as processed food. Therefore, it is indispensable to assess pesticide residues in processed products rather than only in the raw agricultural commodity, in order to approach a more realistic scenario of dietary exposure. Processing factors are important tools for dietary exposure risk assessments. In this study, processing factors for the baking process were derived for 41 pesticides in cereal bran-based biscuits. The raw materials used consisted of wheat, rye, oat, and barley grains with incurred pesticides, which originally was produced for test material for European Union Proficiency Tests. Information on physicochemical properties of pesticides was collected for understanding the fate of pesticides during the baking process. Average processing factors varied between 0.67 and 1.6. Most pesticide residues exhibited a reduction of pesticide residues of less than 24%, which correspond to a processing factor (PF) range between 1 and 0.76, showing resistance to the baking process. However, for polar compounds such as carbendazim and volatile compounds (chlorpyrifos-methyl, malathion, and pirimiphos-methyl) larger reduction rates were observed, up to 33% (PF: 0.67). In general, a prolonged baking time did not significantly affect the PF, because the main degradation process takes place within the first 6 min. However, this was not the case for the highly volatile compounds, highly polar compounds, and compounds of low degradation temperature. These latter were significantly reduced with prolonged baking time, resulting in a reduction rate of up to 95%, which means an almost complete elimination.

Role of Sample Processing Strategies at the European Union National Reference Laboratories (NRLs) Concerning the Analysis of Pesticide Residues.

The guidance document SANTE 11945/2015 recommends that cereal samples be milled to a particle size preferably smaller than 1.0 mm and that extensive heating of the samples should be avoided. The aim of the present study was therefore to investigate the differences in milling procedures, obtained particle size distributions, and the resulting pesticide residue recovery when cereal samples were milled at the European Union National Reference Laboratories (NRLs) with their routine milling procedures. A total of 23 NRLs participated in the study. The oat and rye samples milled by each NRL were sent to the European Union Reference Laboratory on Cereals and Feedingstuff (EURL) for the determination of the particle size distribution and pesticide residue recovery. The results showed that the NRLs used several different brands and types of mills. Large variations in the particle size distributions and pesticide extraction efficiencies were observed even between samples milled by the same type of mill.

Effects of milling on the extraction efficiency of incurred pesticides in cereals.

This study investigated the effects of particle size and milling temperature on the extraction efficiencies of pesticide residues from cereal flour. Samples of cereal grains (barley, oat, rye and wheat) were milled using a centrifugal mill with four different sieves (0.2, 1.0, 3.0 and 5.0 mm) or a knife mill both at room temperature and after freezing of the grain at -80°C overnight. The incurred pesticides in the test materials were extracted by the QuEChERS method and analysed by LC-MS/MS and GC-MS/MS. The particle size distribution for the milled samples was determined using a vibratory sieve shaker. Based on the pesticide levels recovered from each of the different millings and the corresponding particle size distributions, it was confirmed that smaller average particle sizes increase the extraction efficiency up to 31%, with all other factors equal. The cereals milled at room temperature produced lower pesticide extraction efficiencies compared with cereals milled when still frozen, especially for heat-sensitive pesticides. Furthermore, milling frozen grains was easier and resulted in more homogeneous samples with smaller relative particle sizes.

Clean-up of cereal extracts for gas chromatography-tandem quadrupole mass spectrometry pesticide residues analysis using primary secondary amine and C18.

The level of co-extracted matrix in wheat and oat extracts obtained by the QuEChERS method (EN 15662) is high and the occurrence of free fatty acids generates a major matrix peak in TIC chromatograms (rt. 13-22min). Matrix can compromise the analytical performance in pesticide analysis using GC-MS/MS. In order to reduce the amount and the effects of matrix we tested the effect of using six different amounts of primary secondary amine (PSA) (0, 25, 50, 100, 150 and 200mg/ml extract) with and without the addition of six different amounts of C18 (0, 25, 50, 100, 150 and 200mg/ml extract) in the dispersive solid phase extraction (dSPE) procedure. dSPE clean-up using 25mg/ml extract significantly reduced the major matrix peak observed for wheat extracts. Higher amounts of PSA reduced the analytical response for iprodione and malathion. For oat extract 50-150mg PSA/ml extract was needed to obtain equally low intensity of the matrix peak. For oat the analytical responses of the target pesticides generally increased with increasing amount of PSA. C18 had no significant effect on the intensity of the major matrix peaks and even resulted in lower analytical responses for several of the target pesticides. Based on the present study it is concluded that the optimal dSPE clean-up procedure employs 25mg PSA/ml extract for wheat and 150mg PSA/ml extract for oat.

Probabilistic assessment of the cumulative dietary exposure of the population of Denmark to endocrine disrupting pesticides.

The four pesticides epoxiconazole, prochloraz, procymidone and tebuconazole, are commonly used pesticides, all suspected of acting as endocrine disrupters. In the present study, we assessed the acute cumulative dietary exposure to the women of child bearing age and the general population of Denmark to these pesticides from the intake of fruit and vegetables. The assessment was carried out using the probabilistic approach combined with the relative potency factor (RPF) approach. Residue data for prochloraz, procymidone, and tebuconazole were obtained from the Danish monitoring programme 2006-2009, while residue data for epoxiconazole were obtained from the Swedish monitoring programme carried out in the period 2007-2009. Food consumption data were obtained from the Danish nationwide dietary survey conducted in 2000-2002. Relative potency factors for the four pesticides were obtained from rat studies. Prochloraz was used as the index compound. All four pesticides increased nipple retention in male offspring, and epoxiconazole, prochloraz, and tebuconazole also increased the gestation period in pregnant rat dams. For women of childbearing age, the high-end cumulative exposure (99.9th percentile) was calculated to 9% of the Adjusted Reference Value (ARV) for the effect on nipple retention and to 1% of the ARV for the effect on increased gestation period.