Methane production, nutrient digestion, ruminal fermentation, N balance, and milk production of cows fed timothy silage- or alfalfa silage-based diets.

The objective of this study was to investigate the effects of changing forage source in dairy cow diets from timothy silage (TS) to alfalfa silage (AS) on enteric CH4 emissions, ruminal fermentation characteristics, digestion, milk production, and N balance. Nine ruminally cannulated lactating cows were used in a replicated 3 × 3 Latin square design (32-d period) and fed (ad libitum) a total mixed ration (TMR; forage:concentrate ratio of 60:40, dry matter basis), with the forage portion consisting of either TS (0% AS; 0% AS and 54.4% TS in the TMR), a 50:50 mixture of both silages (50% AS; 27.2% AS and 27.2% TS in the TMR), or AS (100% AS; 54.4% AS and 0% TS in the TMR). Compared with TS, AS contained less (36.9 vs. 52.1%) neutral detergent fiber but more (20.5 vs. 13.6%) crude protein (CP). In sacco 24-h ruminal degradability of organic matter (OM) was higher for AS than for TS (73.5 vs. 66.9%). Replacement of TS with AS in the diet entailed increasing proportions of corn grain and bypass protein supplement at the expense of soybean meal. As the dietary proportion of AS increased, CP and starch concentrations increased, whereas fiber content declined in the TMR. Dry matter intake increased linearly with increasing AS proportions in the diet. Apparent total-tract digestibility of OM and gross energy remained unaffected, whereas CP digestibility increased linearly and that of fiber decreased linearly with increasing inclusion of AS in the diet. The acetate-to-propionate ratio was not affected, whereas ruminal concentration of ammonia (NH3) and molar proportion of branched-chain VFA increased as the proportion of AS in the diet increased. Daily CH4 emissions tended to increase (476, 483, and 491 g/d for cows fed 0% AS, 50% AS, and 100% AS, respectively) linearly as cows were fed increasing proportions of AS. Methane production adjusted for dry matter intake (average=19.8 g/kg) or gross energy intake (average=5.83%) was not affected by increasing AS inclusion in the diet. When expressed on a fat-corrected milk or energy-corrected milk yield basis, CH4 production increased linearly with increasing AS dietary proportion. Urinary N excretion (g/d) increased linearly when cows were fed increasing amounts of AS in the diet, suggesting a potential for higher nitrous oxide (N2O) and NH3 emissions. Efficiency of dietary N use for milk protein secretion (g of milk N/g of N intake) declined with the inclusion of AS in the diet. Despite marked differences in chemical composition and ruminal degradability, under the conditions of this study, replacing TS with AS in dairy cow diets was not effective in reducing CH4 energy losses.

Methane production, digestion, ruminal fermentation, nitrogen balance, and milk production of cows fed corn silage- or barley silage-based diets.

This study evaluated the effects of replacing barley silage (BS) with corn silage (CS) in dairy cow diets on enteric CH4 emissions, ruminal fermentation characteristics, digestion, milk production, and N balance. Nine ruminally cannulated lactating cows were used in a replicated 3 × 3 Latin square design (32-d period) and fed (ad libitum) a total mixed ration (TMR; forage:concentrate ratio 60:40; dry matter basis) with the forage portion consisting of either barley silage (0% CS; 0% CS and 54.4% BS in the TMR), a 50:50 mixture of both silages (27% CS; 27.2% CS and 27.2% BS in the TMR), or corn silage (54% CS; 0% BS and 54.4% CS in the TMR). Increasing the CS proportion (i.e., at the expense of BS) also involved increasing the proportion of corn grain (at the expense of barley grain). Intake and digestibility of dry matter and milk production increased linearly as the proportion of CS increased in the diet. Increasing dietary CS proportion decreased linearly the acetate molar proportion and increased linearly that of propionate. Daily CH4 emissions tended to respond quadratically to increasing proportions of CS in the diet (487, 540, and 523 g/d for 0, 27, and 54% CS, respectively). Methane production adjusted for dry matter or gross energy intake declined as the amount of CS increased in the diet; this effect was more pronounced when cows were fed the 54% CS diet than the 27% CS diet. Increasing the CS proportion in the diet improved N utilization, as reflected by decreases in ruminal ammonia concentration and urinary N excretion and higher use of dietary N for milk protein secretion. Total replacement of BS with CS in dairy cow diets offers a strategy to decrease CH4 energy losses and control N losses without negatively affecting milk performance.

Replacing alfalfa silage with corn silage in dairy cow diets: Effects on enteric methane production, ruminal fermentation, digestion, N balance, and milk production.

The objective of this study was to determine the effects of replacing alfalfa silage (AS) with corn silage (CS) in dairy cow total mixed rations (TMR) on enteric CH4 emissions, ruminal fermentation characteristics, apparent total-tract digestibility, N balance, and milk production. Nine ruminally cannulated lactating cows were used in a replicated 3×3 Latin square design (32-d period) and fed (ad libitum) a TMR [forage:concentrate ratio of 60:40; dry matter (DM) basis], with the forage portion consisting of either alfalfa silage (0% CS; 56.4% AS in the TMR), a 50:50 mixture of both silages (50% CS; 28.2% AS and 28.2% CS in the TMR), or corn silage (100% CS; 56.4% CS in the TMR). Increasing the CS proportion (i.e., at the expense of AS) in the diet was achieved by decreasing the corn grain proportion and increasing that of soybean meal. Intake of DM and milk yield increased quadratically, whereas DM digestibility increased linearly as the proportion of CS increased in the diet. Increasing the dietary CS proportion resulted in changes (i.e., lower ruminal pH and acetate:propionate ratio, reduced fiber digestibility, decreased protozoa numbers, and lower milk fat and higher milk protein contents) typical of those observed when cows are fed high-starch diets. A quadratic response in daily CH4 emissions was observed in response to increasing the proportion of CS in the diet (440, 483, and 434 g/d for 0% CS, 50% CS, and 100% CS, respectively). Methane production adjusted for intake of DM, and gross or digestible energy was unaffected in cows fed the 50% CS diet, but decreased in cows fed the 100% CS diet (i.e., quadratic effect). Increasing the CS proportion in the diet at the expense of AS improved N utilization, as reflected by the decreases in ruminal NH3 concentration and manure N excretion, suggesting low potential NH3 and N2O emissions. Results from this study, suggest that total replacement of AS with CS in dairy cow diets offers a means of decreasing CH4 output and N losses. However, the reduction in fiber degradation and the resulting increase in volatile solids content of the manure may lead to increased CH4 emissions from manure storage.

Effects of increasing amounts of corn dried distillers grains with solubles in dairy cow diets on methane production, ruminal fermentation, digestion, N balance, and milk production.

The objective of this study was to examine the effects of including corn dried distillers grains with solubles (DDGS) in the diet at the expense of corn and soybean meal on enteric CH4 emissions, ruminal fermentation characteristics, digestion (in sacco and apparent total-tract digestibility), N balance, and milk production of dairy cows. Twelve lactating Holstein cows were used in a triplicated 4×4 Latin square design (35-d periods) and fed (ad libitum intake) a total mixed ration containing (dry matter basis) 0, 10, 20, or 30% DDGS. Dry matter intake increased linearly, whereas apparent-total tract digestibility of dry matter and gross energy declined linearly as DDGS level in the diet increased. Increasing the proportion of DDGS in the diet decreased the acetate:propionate ratio, but this decrease was the result of reduced acetate concentration rather than increased propionate concentration. Milk yield increased linearly (up to +4kg/d) with increasing levels of DDGS in the diet and a tendency was observed for a quadratic increase in energy-corrected milk as the proportion of DDGS in the diet increased. Methane production decreased linearly with increasing levels of DDGS in the diet (495, 490, 477, and 475 g/d for 0, 10, 20, and 30% DDGS diets, respectively). When adjusted for gross energy intake, CH4 losses also decreased linearly as DDGS proportion increased in the diet by 5, 8, and 14% for 10, 20, and 30% DDGS diets, respectively. Similar decreases (up to 12% at 30% DDGS) were also observed when CH4 production was corrected for digestible energy intake. When expressed relative to energy-corrected milk, CH4 production declined linearly as the amount of DDGS increased in the diet. Total N excretion (urinary and fecal; g/d) increased as the amount of DDGS in the diet increased. Efficiency of N utilization (milk N secretion as a proportion of N intake) declined linearly with increasing inclusion of DDGS in the diet. However, productive N increased linearly with increasing proportions of DDGS in the diet, suggesting better efficiency of N use by the animal. Results from this study show that feeding DDGS to dairy cows can help to mitigate enteric CH4 emissions without negatively affecting intake and milk production.

Evaluation of molecular methods used for establishing the interactions and functions of microorganisms in anaerobic bioreactors.

Molecular techniques have unveiled the complexity of the microbial consortium in anaerobic bioreactors and revealed the presence of several uncultivated species. This paper presents a review of the panoply of classical and recent molecular approaches and multivariate analyses that have been, or might be used to establish the interactions and functions of these anaerobic microorganisms. Most of the molecular approaches used so far are based on the analysis of small subunit ribosomal RNA but recent studies also use quantification of functional gene expressions. There are now several studies that have developed quantitative real-time PCR assays to investigate methanogens. With a view to improving the stability and performance of bioreactors, monitoring with molecular methods is also discussed. Advances in metagenomics and proteomics will lead to the development of promising lab-on chip technologies for cost-effective monitoring.

Psychrophilic anaerobic digestion biotechnology for swine mortality disposal.

The objective of this study was to investigate the feasibility of using psychrophilic anaerobic digestion in sequencing batch reactors (PADSBRs) to co-digest grinded swine carcasses and swine manure slurry at 20 degrees C and 25 degrees C. The PADSBRs were operated on two-week and four-week treatment cycle lengths, which included the fill, react, and draw phases. Two carcass loading rates (CLRs) were tested, that is 20 and 40g of carcass per litre of manure, which were equivalent to 4 and 8 times, respectively, the normal mortality rate on commercial farms. The PADSBR performance was compared to that of PADSBRs operated at 25 degrees C and fed manure only. The addition of swine carcass to PADSBR feed did not affect the stability of the bioreactors at both CLRs. The performance of the PADSBRs co-digesting swine carcasses was not statistically different from the control in terms of biogas production and quality. There was no accumulation of volatile fatty acids in the bioreactors at the end of the treatment cycle. The mixed-liquor pH and alkalinity remained within acceptable ranges for the anaerobic microflora. Also, there was no operational problem caused by the formation of foam and scum in the system.

Use of electrodialysis and reverse osmosis for the recovery and concentration of ammonia from swine manure.

This project aimed at producing a concentrated nitrogen fertilizer from liquid swine manure using electrodialysis (ED) and reverse osmosis (RO), as a mean to help resolve the excess nutrient problem faced by many swine producers, and offer an alternative to chemical nitrogen fertilizer production. Different types of ED membranes were evaluated based on the NH4+ transfer rate, current efficiency and membrane stability. A combination of CMB/AMX membranes was retained due to its high NH4+ transfer rate and chemical stability. The maximum total ammonia concentration (NH3-N) achievable by ED was limited by water transport from the manure to the concentrate compartment, and ammonia volatilization (17%) from the open concentrate compartment. Results suggested that, under the conditions of this experiment, a maximum total NH3-N concentration of about 16g/L could be reached with the ED system. An ED concentrate (8.7g/L of total NH3-N) was also fed to TFC-HF reverse osmosis membranes. A mass balance analysis revealed that the RO permeate, which represented 49.6% of the initial volume, contained 8.6% of the ammonia. However, the RO concentrate contained only 66.6% of the initial total NH3-N, suggesting that 21.2% of the ammonia was volatilized during the concentration test with RO membranes. Ammonia concentration in the RO concentrate reached approximately 13g/L, which is similar to the maximum concentration that could be achieved by ED. These results suggest that the use of ED and RO membranes to recover and concentrate ammonia is potentially interesting but the process must include an approach to minimize ammonia volatilization or trap volatilized ammonia.

The fate of crop nutrients during digestion of swine manure in psychrophilic anaerobic sequencing batch reactors.

The objectives of the study were to measure the levels of manure nutrients retained in psychrophilic anaerobic sequencing batch reactors (PASBRs) digesting swine manure, and to determine the distribution of nutrients in the sludge and supernatant zones of settled bioreactor effluent. Anaerobic digestion reduced the total solids (TS) concentration and the soluble chemical oxygen demand (SCOD) of manure by 71.4% and 79.9%, respectively. The nitrogen, potassium, and sodium fed with the manure to the PASBRs were recovered in the effluent. The bioreactors retained on average 25.5% of the P, 8.7% of the Ca, 41.5% of the Cu, 18.4% of the Zn, and 67.7% of the S fed to the PASBRs. The natural settling of bioreactor effluent allowed further nutrient separation. The supernatant fraction, which represented 71.4% of effluent volume, contained 61.8% of the total N, 67.1% of the NH4-N, and 73.3% of the Na. The settled sludge fraction, which represented 28.6% of the volume, contained 57.6% of the solids, 62.3% of the P, 71.6% of the Ca, 89.6% of the Mg, 76.1% of the Al, 90.0% of the Cu, 74.2% of the Zn, and 52.2% of the S. The N/P ratio was increased from 3.9 in the raw manure to 5.2 in the bioreactor effluent and 9.2 in the supernatant fraction of the settled effluent. The PASBR technology will then substantially decrease the manure management costs of swine operations producing excess phosphorus, by reducing the volume of manure to export outside the farm. The separation of nutrients will also allow land spreading strategies that increase the agronomic value of manure by matching more closely the crop nutrient requirements.

The effect of temperature on slaughterhouse wastewater treatment in anaerobic sequencing batch reactors.

High strength slaughterhouse wastewater was treated in four 42 l anaerobic sequencing batch reactors (ASBRs) operated at 30 degrees C, 25 degrees C and 20 degrees C. The wastewater contained between 30% and 53% of its chemical oxygen demand (COD) as suspended solids (SS). The ASBRs could easily support volumetric organic loading rates (OLRs) of 4.93, 2.94 and 2.75 kg/m3/d (biomass OLRs of 0.44, 0.42 and 0.14 g/g volatile SS (VSS)/d) at 30 degrees C, 25 degrees C, and 20 degrees C, respectively. At all operating temperatures, the total COD (TCOD) and soluble COD (SCOD) were reduced by over 92%, while average SS removal varied between 80% and 96%. Over the experimental period, 90.8%, 88.7% and 84.2% of the COD removed was transformed into methane at 30 degrees C, 25 degrees C and 20 degrees C, respectively. The decrease in the conversion of the COD removed into methane as operating temperature was lowered, may be partly explained by a lower degradation of influent SS as temperature was reduced. The reactors showed a high average methanogenic activity of 0.37, 0.34 and 0.12 g CH4-COD/gVSS/d (22.4, 12.7 and 11.8 l/d) at 30 degrees C, 25 degrees C and 20 degrees C, respectively. The average methane content in the biogas increased from 74.7% to 78.2% as temperature was lowered from 30 degrees C to 20 degrees C.

Potential of low-temperature anaerobic digestion to address current environmental concerns on swine production.

Environmental issues associated with swine production are becoming a major concern among the general public and are thus an important challenge for the swine industry. There is now a renewed interest in environmental biotechnologies that can minimize the impact of swine production and add value to livestock by-products. An anaerobic biotechnology called psychrophilic anaerobic digestion (PAD) in sequencing batch reactors (SBR) has been developed at Agriculture and Agri-Food Canada. This very stable biotechnology recovers usable energy, stabilizes and deodorizes manure, and increases the availability of plant nutrients. Experimental results indicated that PAD of swine manure slurry at 15 to 25 degrees C in intermittently fed SBR reduces the pollution potential of manure by removing up to 90% of the soluble chemical oxygen demand. The process performs well under intermittent feeding, once to 3 times a week, and without external mixing. Bioreactor feeding activities can thus be easily integrated into the routine manure removal procedures in the barn, with minimal interference with other farm operations and use of existing manure-handling equipment. Process stability was not affected by the presence of antibiotics in manure. The PAD process was efficient in eliminating populations of zoonotic pathogens and parasites present in raw livestock manure slurries. Psychrophilic anaerobic digestion in SBR could also be used for swine mortality disposal. The addition of swine carcasses, at loading rates representing up to 8 times the normal mortality rates on commercial farms, did not affect the stability of SBR. No operational problems were related to the formation of foam and scum. The biotechnology was successfully operated at semi-industrial and full commercial scales. Biogas production rate exceeded 0.20 L of methane per gram of total chemical oxygen demand fed to the SBR. The biogas was of excellent quality, with a methane concentration ranging from 70 to 80%. The recovery of green energy, the production of a value-added odorless fertilizer, the elimination of manure pathogens, and the proper disposal of swine mortalities will substantially reduce the carbon and environmental footprints on products of swine origin.

Neutral fat hydrolysis and long-chain fatty acid oxidation during anaerobic digestion of slaughterhouse wastewater.

Neutral fat hydrolysis and long-chain fatty acid (LCFA) oxidation rates were determined during the digestion of slaughterhouse wastewater in anaerobic sequencing batch reactors operated at 25 degrees C. The experimental substrate consisted of filtered slaughterhouse wastewater supplemented with pork fat particles at various average initial sizes (D(in)) ranging from 60 to 450 microm. At the D(in) tested, there was no significant particle size effect on the first-order hydrolysis rate. The neutral fat hydrolysis rate averaged 0.63 +/- 0.07 d(-1). LCFA oxidation rate was modelled using a Monod-type equation. The maximum substrate utilization rate (kmax) and the half-saturation concentration (Ks) averaged 164 +/- 37 mg LCFA/L/d and 35 +/- 31 mg LCFA/L, respectively. Pork fat particle degradation was mainly controlled by LCFA oxidation rate and, to a lesser extent, by neutral fat hydrolysis rate. Hydrolysis pretreatment of fat-containing wastewaters and sludges should not substantially accelerate their anaerobic treatment. At a D(in) of 450 microm, fat particles were found to inhibit methane production during the initial 20 h of digestion. Inhibition of methane production in the early phase of digestion was the only significant effect of fat particle size on anaerobic digestion of pork slaughterhouse wastewater. Soluble COD could not be used to determine the rate of lipid hydrolysis due to LCFA adsorption on the biomass.