Determination of Nutrients in Liquid Manures and Biogas Digestates by Portable Energy-Dispersive X-ray Fluorescence Spectrometry.

Knowing the exact nutrient composition of organic fertilizers is a prerequisite for their appropriate application to improve yield and to avoid environmental pollution by over-fertilization. Traditional standard chemical analysis is cost and time-consuming and thus it is unsuitable for a rapid analysis before manure application. As a possible alternative, a handheld X-ray fluorescence (XRF) spectrometer was tested to enable a fast, simultaneous, and on-site analysis of several elements. A set of 62 liquid pig and cattle manures as well as biogas digestates were collected, intensively homogenized and analysed for the macro plant nutrients phosphorus, potassium, magnesium, calcium, and sulphur as well as the micro nutrients manganese, iron, copper, and zinc using the standard lab procedure. The effect of four different sample preparation steps (original, dried, filtered, and dried filter residues) on XRF measurement accuracy was examined. Therefore, XRF results were correlated with values of the reference analysis. The best R2s for each element ranged from 0.64 to 0.92. Comparing the four preparation steps, XRF results for dried samples showed good correlations (0.64 and 0.86) for all elements. XRF measurements using dried filter residues showed also good correlations with R2s between 0.65 and 0.91 except for P, Mg, and Ca. In contrast, correlation analysis for liquid samples (original and filtered) resulted in lower R2s from 0.02 to 0.68, except for K (0.83 and 0.87, respectively). Based on these results, it can be concluded that handheld XRF is a promising measuring system for element analysis in manures and digestates.

Effects of sample pre-treatments on the analysis of liquid organic manures by visible and near-infrared spectrometry.

Proper application of a fertilizer requires precise knowledge of its nutrient composition. In the case of liquid organic manures (LOM), this information is often lacking due to heterogeneous nature of these fertilizers. Published "book values" of nutrient contents present the average from a wide range of possible nutrient characteristics, but usually differ considerably from the concentration in a particular manure. Thus, chemical analyses are recommended before applying the specific LOM. Unfortunately, this is usually too costly and time-intensive in practical farming. On-farm analysis by optical spectrometry in the visible and near-infrared (Vis-NIR) range is considered as an efficient alternative. However, calibration of Vis-NIR spectrometry for LOM is challenging as shown in many studies. One reason is LOMs' tendency to rapidly segregate into a fuzzy continuum with liquid and solid properties. By separating LOM into well-defined liquid and solid phases and measuring them separately, calibration of Vis-NIR spectrometry might be improved. In this study, the effects of four sample pre-treatment techniques on the prediction accuracy of macronutrients (N, P, K, Mg, Ca, S), micronutrients (B, Mn, Fe, Cu, Zn), dry matter and pH of LOM using visible and near infrared spectrometry were comprehensively investigated. The concentrations were referred either to wet basis or to dry matter basis. For the study, a total of 163 samples, separated in two similar LOM sets (pig, cattle, digestates), were either dried, filtered, or centrifuged and always compared to non-treated samples. The experiments demonstrate that in comparison to raw samples (Ø r2 = 0.85) neither filtering (Ø r2 = 0.76 for filtrates and Ø r2 = 0.71 for filter residues), centrifugation (Ø r2 = 0.59 for supernatants and Ø r2 = 0.79 for pellets), nor drying (Ø r2 = 0.74) revealed to be a helpful preparation step significantly improving prediction results, independent from referring to wet or dry basis concentrations.

Influence of Light Intensity and Spectrum on Duckweed Growth and Proteins in a Small-Scale, Re-Circulating Indoor Vertical Farm.

Duckweeds can be potentially used in human and animal nutrition, biotechnology or wastewater treatment. To cultivate large quantities of a defined product quality, a standardized production process is needed. A small-scale, re-circulating indoor vertical farm (IVF) with artificial lighting and a nutrient control and dosing system was used for this purpose. The influence of different light intensities (50, 100 and 150 µmol m-2 s-1) and spectral distributions (red/blue ratios: 70/30, 50/50 and 30/70%) on relative growth rate (RGR), crude protein content (CPC), relative protein yield (RPY) and chlorophyll a of the duckweed species Lemna minor and Wolffiella hyalina were investigated. Increasing light intensity increased RGR (by 67% and 76%) and RPY (by 50% and 89%) and decreased chlorophyll a (by 27% and 32%) for L. minor and W. hyalina, respectively. The spectral distributions had no significant impact on any investigated parameter. Wolffiella hyalina achieved higher values in all investigated parameters compared to L. minor. This investigation proved the successful cultivation of duckweed in a small-scale, re-circulating IVF with artificial lighting.

Nutritional Value of Duckweed as Protein Feed for Broiler Chickens-Digestibility of Crude Protein, Amino Acids and Phosphorus.

Duckweed is gaining attention in animal nutrition and is considered as a potential alternative protein source for broiler chickens. In order to evaluate the nutritional value of duckweed, three individual batches were investigated. They consisted of a mixture of Lemna minuta and Lemna minor (A, 17.5% crude protein), Spirodela polyrhiza (B, 24.6% crude protein) and Lemna obscura (C, 37.0% crude protein). Treatment diets contained 50% batch A, 50% batch B, and 25, 50 and 75% of batch C. All diets were fed to broiler chickens (Ross 308) from an age of 21 to 27 days. Diets with a share of 50 and 75% of batch C led to decreased feed intake (109.3 and 74.9 g/day, respectively) compared to the control. Standardized ileal digestibility of crude protein and amino acids differed significantly between duckweed batches, at values for methionine between 49.9 and 90.4%. For all amino acids, batch A consistently had the lowest and batch C the highest digestibility. Batches had different tannin contents of 2943, 2890 and 303 mg/kg for batches A, B and C, respectively. The apparent ileal digestibility of phosphorus differed significantly between all batches (50.8-78.9%). Duckweed can be used as a protein feed for broiler chickens. However, a defined and stable biomass composition optimized for the requirements of broiler chickens is needed.

Impact of cattle slurry application methods on ammonia losses and grassland nitrogen use efficiency.

Optimal manure management is required to ensure efficient nutrient supply to farmland and to avoid adverse environmental impacts. Accordingly, ammonia (NH3) emissions associated with different slurry application techniques were investigated in grassland trials under different soil and weather conditions across Germany. Cattle slurry was applied in two dressings, early in spring and after the first silage cut, with a target amount of 170 kg N ha-1. The application treatments comprised: trailing shoe (TS), acidified slurry applied with trailing shoe (TS + A), open slot injection (SI), and slurry treated with a nitrification inhibitor (NI) applied by slot injection (SI + NI). In addition, slurry application techniques were compared with a non-N-fertilized control and a mineral fertilizer treatment (calcium ammonium nitrate, CAN). NH3 measurements followed each N application event. NH3 losses were equivalent to 1-39% of total ammoniacal nitrogen (TAN) applied. The average NH3 mitigation potential of the different slurry application techniques compared to TS was 45.7 ± 7, 21.2 ± 6.2 and 13.7 ± 8.2% for TS + A, SI and SI + NI, respectively. The use of nitrification inhibitor with slot injected slurry did not increase NH3 losses relative to TS (p > 0.05). Mean apparent N use efficiency was two times higher for CAN (49%) than the slurry treatments (24%) but was comparable between SI + NI and CAN in five out of the eight cases. Our results indicate that mean TAN related NH3 emissions of tested treatments (3.3, 22.6, 12.2, 17.8 and 19.3% for CAN, TS, TS + A, SI and SI + NI, respectively) were generally lower than described in previous studies. Moreover, the results suggested possible increases in NH3 mitigation and N use efficiency when cattle slurry is applied with acidification or injection techniques. We found no evidence that NI addition to slot injected slurry, a treatment discussed as a measure to reduce N2O emission and nitrate leaching, changed NH3 emission.

Influence of the Nitrate-N to Ammonium-N Ratio on Relative Growth Rate and Crude Protein Content in the Duckweeds Lemna minor and Wolffiella hyalina.

In order to produce protein-rich duckweed for human and animal consumption, a stable cultivation process, including an optimal nutrient supply for each species, must be implemented. Modified nutrient media, based on the N-medium for duckweed cultivation, were tested on the relative growth rate (RGR) and crude protein content (CPC) of Lemna minor and Wolffiella hyalina, as well as the decrease of nitrate-N and ammonium-N in the media. Five different nitrate-N to ammonium-N molar ratios were diluted to 10% and 50% of the original N-medium concentration. The media mainly consisted of agricultural fertilizers. A ratio of 75% nitrate-N and 25% ammonium-N, with a dilution of 50%, yielded the best results for both species. Based on the dry weight (DW), L. minor achieved a RGR of 0.23 ± 0.009 d-1 and a CPC of 37.8 ± 0.42%, while W. hyalina's maximum RGR was 0.22 ± 0.017 d-1, with a CPC of 43.9 ± 0.34%. The relative protein yield per week and m2 was highest at this ratio and dilution, as well as the ammonium-N decrease in the corresponding medium. These results could be implemented in duckweed research and applications if a high protein content or protein yield is the aim.