Effects of the support material addition on the hydrodynamic behavior of an anaerobic expanded granular sludge bed reactor.

As a support material, zeolite can be used to promote the granulation process due to its high settable property and the ability to retain biomass on its surface. The present paper reports on the influence of zeolite addition on the hydrodynamic behavior of an expanded granular sludge bed reactor (EGSB). Different models were applied to fit the flow pattern and to compare EGSB hydrodynamic performance with and without the addition of zeolite. The experimental data fit the tanks in a series model for zeolite bed height of 5cm and upflow velocity of 6m/hr. Higher axial dispersion degree (D/uL) was obtained at lower heights of zeolite. The real hydraulic retention time (HRTr) was increased with both increased zeolite bed height and increased upflow velocity. The short-circuit results for 5cm of zeolite bed and 6, 8 and 10m/hr upflow velocity were 0.3, 0.24 and 0.19 respectively, demonstrating the feasibility of using zeolite for a proper hydrodynamic environment to operate the EGSB reactor. The presence of zeolite resulted in the higher percentage values of dead zones, ranging from 12% to 24%. Zeolite addition exerted a positive effect on the hydrodynamics pattern for this technology being advantageous for the anaerobic process because of its possible contribution to better biofilm agglomeration, granule formation and substrate-microorganism contact.

Bioavailability and dosing strategies of mineral in anaerobic mono-digestion of maize straw.

The influence of the bonding form distribution of Fe, Ni, Co and Mn and their potential bioavailability during the anaerobic degradation of maize straw was investigated. Two reactors were operated over 117 days at 37°C and different dosage strategies of mineral were studied in reactor (R2). Control reactor (R1) was metal-limited over time. mineral supplementation (1 g L-1) once a week reported the highest methane yield (257 mL g-1 VS) with 30% of increment. Ni and Co predominated in their oxidizable bonding forms and Fe mainly existed as residual and oxidizable fractions. The potential bioavailability (Mn ˃˃ Co ≈ Ni ˃ Fe) of R2 was higher comparing to R1. Metal deprivation in R1 led to depletion of both sequential extraction fractions and total metal concentrations until the end of the process. This study confirmed that the dosage strategy of mineral has a stimulatory effect on methane production from crop maize waste.