Antioxidant effect of acerola fruit powder, rosemary and licorice extract in caiman meat nuggets containing mechanically separated caiman meat.

The aim of this work was to evaluate the antioxidant effect of acerola fruit powder, rosemary and licorice extract in caiman meat nuggets containing high amounts of mechanically separated caiman meat (MSCM) during 120 days of frozen storage. Five treatments were prepared: a control without antioxidant (CON), sodium erythorbate at 500 mg/kg (ERY), acerola fruit powder at 500 mg/kg (AFP), with licorice extract at 500 mg/kg (LIE) and rosemary extract at 500 mg/kg (ROE). The addition of natural antioxidants increased color, cohesiveness, and decreased TBARS values. The redness values were higher for LIE and these values were different to the CON. Nuggets with licorice extract had significantly lower TBARS values at the end of the storage period compared to the control. All the treatments were similar in sensory analysis, with good acceptability. These results indicate licorice extract used in caiman meat nuggets containing a high amount of MSCM caiman has the potential to improve quality during frozen storage.

Impact of ultrasound and potassium chloride on the physicochemical and sensory properties in low sodium restructured cooked ham.

The objectives of this study were to evaluate the effects of power ultrasound (nominal intensity 600 W·cm-2 for 10 min) and the addition of potassium chloride (KCl) on the physicochemical properties and sensorial acceptance of low sodium restructured cooked ham. Four treatments of low sodium restructured cooked ham (mean of 324.52 mg Na/100 g) were prepared: CT - Control Treatment; UsT - Ultrasound Treatment; KT - addition of 0.5% KCl; UsKT - Ultrasound Treatment and addition of 0.5% KCl. Ultrasound application reduced the total fluid released and improved the sensory acceptance for salty taste and flavor compared to CT. The addition of KCl showed the lowest values for total fluid release, the highest scores for all parameters of sensory acceptance, improved hardness and chewiness, which results were not statistically different from the results obtained by combining ultrasound and KCl. Therefore, the use of KCl was considered a technological and sensorial viable alternative to produce low sodium restructured cooked ham. CHEMICAL COMPOUNDS USED IN THIS RESEARCH: Methanol (PubChem CID: 887); Chloroform (PubChem CID: 6212); Sodium Carbonate (PubChem CID: 10340); Sodium hydroxide (PubChem CID: 14798); Boric acid (PubChem CID: 7628).

Water adsorption isotherms and isosteric sorption heat of spray-dried and freeze-dried dehydrated passion fruit pulp with additives and skimmed milk / Isotermas de adsorção e calor isostérico de sorção de polpa de maracujá desidratada por spray dryer e liofilizador com aditivos e leite desnatado

Moisture equilibrium data of passion fruit pulp powders with maltodextrin and gum arabic were obtained by two different drying methods (spray drying and freeze drying) and determined at 20, 30, 40 and 50º C. Skimmed milk was used to substitute part of these additives in the samples. One formulation using passion fruit pulp/maltodextrin/skimmed milk (PMS) was prepared, and another using passion fruit pulp/gum arabic/skimmed milk (PGS). The behavior of curves was type III, according to Brunauer's classification. GAB models were fitted to experimental equilibrium data. The parameters obtained from GAB models was affected by the presence of additives. The behavior of the sorption isotherms for different temperatures are similar, noting only a small effect of temperature. There were little differences between both drying methods and additives used in relation to equilibrium moisture content. The parameters obtained with the addition of the skimmed milk were considered satisfactory (Xm values ranged from 0,04084 to 0,06488 in dry basis), demonstrating that it is an effective and cheap alternative for regular additives. A progressive increase in the heat of sorption in relation to decreasing moisture content was observed and the heat of sorption values of different samples are all similar, comparing the relative equilibrium moisture content.

Dados de umidade de equilíbrio da polpa de maracujá em pó com maltodextrina e goma arábica obtidas por dois diferentes processos de secagem (spray dryer e liofilizador) foram determinados a 20, 30, 40 e 50° C. Leite desnatado foi utilizado nas amostras em substituição a uma parte desses dois aditivos. Prepararou-se uma formulação, usando polpa de maracujá/maltodextrina/leite desnatado (PMS) e outra com polpa de maracujá/goma arábica/leite desnatado (PGS). Os comportamentos das isotermas obedeceram ao tipo III, de acordo com a classificação de Brunauer e utilizou-se o modelo de GAB para ajuste dos dados de equilíbrio. Os parâmetros obtidos pelo modelo de GAB foram afetados pela presença dos aditivos. O comportamento das isotermas de sorção para as diferentes temperaturas foram similares, notando-se uma pequena diferença em relação ao efeito da temperatura. Observaram-se também pequenas diferenças entre os dois métodos de secagem utilizados e os aditivos usados em relação ao teor de umidade de equilíbrio. Os parâmetros obtidos pela adição do leite desnatado foram considerados satisfatórios (Xm variando de 0,04084 a 0,06488 em base seca) mostrando que o leite desnatado pode ser uma alternativa boa e com menor custo na substituição dos aditivos comumente utilizados nesse tipo de processo. Observou-se uma aumento do calor isostérico de sorção em relação a diminuição do teor de umidade e os valores das diferentes amostras utilizadas foram similares, comparando-se o teor de umidade de equilíbrio.