Effects of feeding whole-cracked rapeseeds, nitrate, and 3-nitrooxypropanol on composition and functional properties of the milk fat fraction from Danish Holstein cows.

The aim of this study was to determine the individual and combined effects of supplementing fat with whole-cracked rapeseed (FAT), nitrate (NITRATE), and 3-nitrooxypropanol (3-NOP) on compositional and functional properties of milk fat. An 8 × 8 incomplete Latin square design was conducted with 48 lactating Danish Holstein cows over 6 periods of 21 d each. Eight diets were 2 × 2 × 2 factorially arranged: FAT (30 or 63 g crude fat/kg DM), NITRATE (0 or 10 g nitrate/kg DM), and 3-NOP (0 or 80 mg 3-NOP/kg DM), and cows were fed ad libitum. Milk samples were analyzed for general composition, fatty acids (FA) and thermal properties of milk fat. Milk fat content was decreased by supplementing fat but increased by 3-NOP. The changes in FA composition were mainly driven by the FAT × 3-NOP interaction. Fat supplementation shifted milk FA composition toward a lower content of SFA and greater contents of MUFA and PUFA, whereas these effects became smaller in combination with 3-NOP. However, 3-NOP had no effects on SFA, MUFA, or PUFA in low-fat diets. Fat supplementation lowered solid-fat content in milk fat because of the decreased SFA content. The onset crystallization temperature of milk fat was decreased by 3-NOP when supplemented in low-fat diets. According to the FAT × 3-NOP interaction, supplementation of fat without 3-NOP shifted the peak temperature of the low-melting fraction of milk fat toward low temperature as a result of a decreased proportion of C16:0 and increased proportions of C18:1 cis-9, C18:1 trans-11, C18:2 cis-9, and CLA cis-9,trans-11. In conclusion, no additive effects were observed among FAT, NITRATE, and 3-NOP on chemical and thermal properties of milk fat, and fat supplementation largely changed milk FA composition, which in turn affected the thermal properties of milk fat.

Effects of feeding whole-cracked rapeseeds, nitrate, and 3-nitrooxypropanol on protein composition, minerals, and vitamin B in milk from Danish Holstein cows.

The present study was conducted to assess the individual or combined effects of feeding dietary fat (whole-cracked rapeseed), nitrate, and 3-nitrooxypropanol (3-NOP) on protein profile, mineral composition, B vitamins, and nitrate residues in milk from dairy cows. A total of 48 Danish Holstein cows used in an 8 × 8 incomplete Latin square design were fed 8 factorially arranged diets: (30 or 63 g crude fat/kg DM) × (0 or 10 g nitrate/kg DM) × (0 or 80 mg 3-NOP/kg DM) over 6 periods of 21 d each. In each period, milk samples were collected from individual cows during the third week by pooling milk obtained from 4 consecutive milkings and analyzed for protein profile, including protein modifications, mineral composition, riboflavin, cobalamin, and presence of nitrate residues. Fat supplementation led to an increase in the phosphorylation degree of αS1-CN by 8.5% due to a decreased relative proportion of αS1-CN 8P and an increased relative proportion of αS1-CN 9P and further to a decrease in the relative proportion of αS2-CN by 2.4%. Additionally, fat supplementation decreased the relative proportions of glycosylated and unglycosylated forms of κ-CN, consequently leading to a 3.6% decrease in total κ-CN. In skim milk, K, Ca, P, and Mg concentrations were altered by individual use of fat, nitrate, and 3-NOP. Feeding nitrate resulted in a 5.4% increase in riboflavin concentration in milk, whereas supplementing 3-NOP increased the cobalamin concentration in milk by 21.1%. The nitrate concentration in milk was increased upon feeding nitrate, but this increased concentration was well below the maximum permissible limit of nitrate in milk (<50 mg/L). Overall, no major changes were observed in milk protein, and mineral compositions by feeding fat, nitrate, and 3-NOP to dairy cows, but the increased riboflavin and cobalamin concentrations by nitrate and 3-NOP, respectively, could be of beneficial nutritional value for milk consumers.

Effects on feed intake, milk production, and methane emission in dairy cows fed silage or fresh grass with concentrate or fresh grass harvested at early or late maturity stage without concentrate.

The objective of the study was to quantify the effects on dry matter intake (DMI), nutrient digestibility, gas exchange, milk production, and milk quality in dairy cows fed fresh grass harvested at different maturity stages. Sixteen Danish Holstein cows in mid-lactation were divided into 4 blocks and used in 4 incomplete 4 × 2 Latin squares with 2 periods of 21 d. The cows received 1 of 4 treatments in each period, resulting in 8 cows per treatment, as follows: grass-clover silage supplemented with 6 kg/d concentrate pellets (SILc), fresh grass harvested at late maturity stage supplemented with 6 kg/d concentrate pellets (LATc), fresh grass harvested at late maturity stage (LAT), and fresh grass harvested at early maturity stage (ERL). The cows were housed in tiestalls and milked twice daily. The cows had ad libitum access to the forage, and concentrate pellets were divided into equal amounts and fed separately in the morning and afternoon. Fecal samples were collected to determine apparent total-tract digestibility, and samples of rumen fluid were collected for determination of short chain fatty acid composition. Halters were used for measuring eating and rumination time. Gas exchange was measured in open-circuit respiration chambers. Total DMI was higher in LATc and ERL (16.9 ± 0.45 and 15.5 ± 0.39 kg/d, respectively) compared with LAT (14.1 ± 0.42 kg/d). Relative to SILc, cows fed fresh grass experienced a convex pattern in DMI during the experiment. The changes in DMI were related to changes in leaf to stem ratio, fiber concentration, and organic matter digestibility determined in vitro in samples of the fresh grass harvested throughout the experiment. The apparent total-tract digestibility of organic matter was higher in SILc and LAT compared with LATc. Methane yield was lower for LATc compared with LAT (19.5 ± 0.61 vs. 22.6 ± 0.55 g of CH4/kg of DMI), and was not different between LAT and ERL. Compared with LAT, milk yield was higher for ERL (21.1 ± 1.14 vs. 23.4 ± 1.11 kg/d) and energy-corrected milk (ECM) yield was higher for LATc (21.5 ± 0.99 vs. 25.3 ± 1.03 kg/d). We detected no differences in milk or ECM yield between SILc and LATc. Milk protein yield was higher and milk fat concentration was lower in LATc compared with LAT. The fatty acid percentages of ∑C4-C14:1 and ∑C16 in milk were higher for SILc compared with LATc, signifying pronounced de novo synthesis. The n-6:n-3 ratio in milk fatty acids was lower for SILc and LAT compared with LATc, indicating improved nutritional quality for SILc and LAT. However, retinol concentration in milk was lower in SILc compared with all other treatments. The study implies that feeding silage instead of fresh grass has no effect on DMI, ECM yield, or CH4 yield, and that concentrate supplementation can increase milk production, affects milk quality, and reduces the effect on climate, whereas feeding less mature grass increases DMI and milk yield, but has no effect on CH4 yield.

Fava beans can substitute soybean meal and rapeseed meal as protein source in diets for lactating dairy cows.

The effect of replacing mixtures of wheat and soybean meal and wheat and rapeseed meal by toasted fava beans, and the effect of toasting fava beans on feed intake, milk yield, and composition of milk and feces were investigated using 40 Holstein cows in each of two 4 × 4 Latin square design trials conducted simultaneously. In trial 1, the 4 treatment concentrates were untreated fava beans, toasted fava beans, 42% soybean meal + 58% rolled wheat, and a 21, 29, and 50% mix of soybean meal, rolled wheat, and toasted fava beans, respectively [on dry matter (DM) basis]. In trial 2, the 4 experimental treatments were untreated fava beans, toasted fava beans, 64% rapeseed meal + 36% rolled wheat, and a 32, 18, and 50% mix of rapeseed meal, rolled wheat, and toasted fava beans, respectively (on DM basis). In each trial, 16 primiparous and 24 multiparous cows were fed the treatment concentrates as part of a partial mixed ration, of which the forage consisted of 50% corn silage and 50% grass-clover silage. Substitution of soybean meal and wheat or rapeseed meal and wheat with toasted fava beans did not affect total DM intake, and no linear effects were observed on milk yield or energy-corrected milk (ECM) yield. However, in trial 2, a quadratic effect was observed on milk yield when substituting rapeseed meal and wheat with toasted fava beans. In both trials, substitution of soybean meal and wheat or rapeseed meal and wheat with toasted fava beans increased milk lactose concentration and decreased milk protein yield and concentration of protein in milk. In both trials, fecal concentration of starch increased linearly when substituting soybean meal and wheat or rapeseed meal and wheat with toasted fava beans. In trial 2, fecal concentration of P decreased when substituting rapeseed meal and wheat with toasted fava beans. In situ investigations showed increased rumen undegradable protein concentration and thereby increased estimated metabolizable protein supply when toasting fava beans. However, in both trials, milk protein yield and concentration decreased when cows were fed toasted compared with untreated fava beans. Furthermore, when cows were fed toasted compared with untreated fava beans in trial 1, milk yield, ECM yield, and nitrogen efficiency decreased. We conclude that toasted fava beans could substitute soybean meal and wheat or rapeseed meal and wheat with regard to ECM yield. However, milk protein yield decreased when substituting soybean meal and wheat or rapeseed meal and wheat with toasted fava beans. Compared with untreated fava beans, toasting had no positive effect on milk production and nitrogen efficiency.

Effect of dried oregano (Origanum vulgare L.) plant material in feed on methane production, rumen fermentation, nutrient digestibility, and milk fatty acid composition in dairy cows.

Essential oils (EO) from oregano may have antimicrobial properties, potentially representing a methane mitigation strategy suitable for organic production. This study aimed to (1) examine the potential of oregano in lowering enteric methane production of dairy cows fed differing levels of dried oregano (Origanum vulgare ssp. hirtum) plant material containing high levels of EO; (2) determine whether differing levels of dried oregano plant material of another subspecies (Origanum vulgare ssp. vulgare) with naturally low levels of EO in feed affected enteric methane production; and (3) evaluate the effect of various levels of the 2 oregano subspecies (containing high or low levels of EO) in feed on rumen fermentation, nutrient digestibility, and milk fatty acids. Each experiment had a 4 × 4 Latin square design using 4 lactating Danish Holstein dairy cows that had rumen, duodenal, and ileal cannulas and were fed 4 different levels of oregano. Experiment 1 used low EO oregano [0.12% EO of oregano dry matter (DM)] and evaluated a control (C) diet with no oregano and 3 oregano diets with 18 (low; L), 36 (medium; M), and 53 g of oregano DM/kg of dietary DM (high; H). Experiment 2 used high EO oregano (4.21% EO of oregano DM) with 0, 7, 14, and 21 g of oregano DM/kg of dietary DM for C, L, M, and H, respectively. Oregano was added to the diets by substituting grass/clover silage on a DM basis. Low or high EO oregano in feed did not affect dry matter intake (DMI) or methane production (grams per day, grams per kilogram of DMI, grams per kilogram of energy-corrected milk, and percentage of gross energy intake). Rumen fermentation was slightly affected by diet in experiment 1, but was not affected by diet in experiment 2. In both experiments, the apparent total-tract digestibility of DM, organic matter, and neutral detergent fiber decreased linearly and cubically (a cubic response was not observed for neutral detergent fiber) with increasing dietary oregano content, while milk fatty acids were slightly affected. In conclusion, dried oregano plant material with either high or low levels of EO did not lower the methane production of dairy cows over 4 consecutive days, and no substantial effects were observed on rumen fermentation or nutrient digestibility. This conclusion regarding methane production is in contrast with literature and requires further study.

Milking time and risk of over-milking can be decreased with early teat cup removal based on udder quarter milk flow without loss in milk yield.

Increasing the milk flow rate at which milking is terminated can shorten milking time and increase milking efficiency. The effects on milk yield and composition have not been fully investigated when the take-off is set at the udder quarter level and independent of feeding during milking. The objective of this study was to investigate the effect of 3 take-off levels at the udder quarter level (0.06, 0.3, and 0.48 kg/min) applied with or without feeding during milking on milking time, milk yield, the degree of udder emptying, milk composition, and free fatty acids. In this study, 30 cows were allocated into 6 groups, balanced by lactation number, lactation stage, and milk yield, and subjected to a 3 × 2 factorial arrangement of treatments using a Latin square design. Treatments were applied for 1 wk each. This study demonstrated milking time could be reduced by applying up to a take-off level of 0.48 kg/min on udder quarter level without losing milk yield or compromising milk composition or udder health.

Seasonal variation in the composition and melting behavior of milk fat.

Dairy bulk tank milk was sampled during 1yr from 2 conventional (C1 and C2) and 1 organic dairy (O1) for studying the seasonal variation as well as the variation between dairies in the composition and properties of milk fat. The composition of fatty acids (FA) as well as triglycerides (TAG) in milk fat was analyzed, and the melting properties of milk fat were analyzed by use of differential scanning calorimetry. The main differences in fat content and composition of FA in milk fat between dairies included a higher fat content, greater proportion of C18:0, and smaller proportion of C16:0 in milk from dairy C2, which could be associated with a higher frequency of Jersey herds supplying milk to this dairy. The organic milk was characterized by a higher proportion of C18:3n-3, C18:2 cis-9,trans-11, C6 to C14, a lower proportion of C18:1 cis-9, and a higher melting point of the low-melting fraction. The TAG composition showed a greater proportion of C24 to C38 TAG in milk fat from dairy O1 and a greater proportion of C52 to C54 TAG in milk fat from dairy C2, which was in accordance with the differences in FA composition. Melting point of the low-melting fraction was higher for milk fat from dairy O1 compared with dairies C1 and C2, whereas no differences between dairies were observed with respect to melting points of the medium- and high-melting fractions. The seasonal variation in FA composition was most pronounced for dairy O1 although similar patterns were observed for all dairies. During the summer, the content of C18:0 and C18:1 cis-9 in milk fat was greater, whereas the content of C14:0 and C16:0 was lower. In addition, the content of C18:2 cis-9,trans-11 and C18:1 trans-11 increased in late summer for dairy O1. The differential scanning calorimetry thermograms of individual milk fat samples could be divided into 3 groups by principal component analysis. For dairy O1, summer samples belonged to group 1, spring and autumn samples to group 2, and winter samples to group 3. For dairy C1 winter samples (group 2), were separated from other samples (group 1), and for dairy C2 all samples were in group 1. Individual melting points were related to FA composition, and the melting point of the low-melting fraction was positively correlated to the content of C14:0 and C16:0 in milk fat and negatively correlated to the content of C18:1 cis-9 and C18:0.

Cooling causes changes in the distribution of lipoprotein lipase and milk fat globule membrane proteins between the skim milk and cream phase.

Lipoprotein lipase (LPL) activity and free fatty acid levels were studied in freshly milked, uncooled milk from individual Danish Holstein or Jersey cows, or after storage for up to 24h at either a cooling temperature (4°C) or at the milking temperature (31°C). Upon cooling for up to 24h, LPL activity increased in the cream phase, whereas the activity in the skim milk was steady, as observed for Jersey cows, or increased, as seen for the Holsteins. Storage at 31°C decreased the LPL activity in both the cream phase and the skim milk phase. The increase in free fatty acid levels was found to depend on LPL activity, incubation temperature, substrate availability, and incubation time. Furthermore, the migration of milk proteins between the skim milk phase and the cream phase upon cooling of milk from Jersey cows or from Danish Holstein cows was studied using proteomic methods involving 2-dimensional gel electrophoresis and mass spectrometry. Proteins associated with the milk fat globules were isolated from all milk fractions and analyzed. Major changes in the distributions of proteins between the skim milk phase and the cream phase were observed after cooling at 4°C for 4h, where a total of 29 proteins between the 2 breeds was found to change their association with the milk fat globule membrane (MFGM) significantly. Among these, the MFGM proteins adipophilin, fatty acid-binding protein, and lactadherin, as well as the non-MFGM proteins ß-casein, lactoferrin, and heat shock protein-71, were identified. Adipophilin, lactadherin, and lactoferrin were quantitatively more associated with the MFGM upon cold storage at 4°C, whereas ß-casein, fatty acid-binding protein, and heat shock protein-71 were found to be less associated with the MFGM upon cold storage.

Transfer of dietary zinc and fat to milk--evaluation of milk fat quality, milk fat precursors, and mastitis indicators.

The present study demonstrated that the zinc concentration in bovine milk and blood plasma is significantly affected by the intake of saturated fat supplements. Sixteen Holstein cows were used in a 4 x 4 Latin square design with 4 periods of 12 d, and 4 dietary treatments were conducted. A total mixed ration based on corn silage, grass-clover silages, and pelleted sugar beet pulp was used on all treatments. A high de novo milk fat diet was formulated by adding rapeseed meal and molasses in the total mixed ration [39 mg of Zn/kg of dry matter (DM)], and a low de novo diet by adding saturated fat, fat-rich rapeseed cake, and corn (34 mg of Zn/kg of DM). Dietary Zn levels were increased by addition of ZnO to 83 and 80 mg of Zn/kg of DM. Treatments did not affect daily DM intake, or yield of energy-corrected milk, milk fat, or milk protein. The high de novo diet significantly increased milk fat percentage and milk content of fatty acids with chain length from C6 to C16, and decreased content of C18 and C18:1. Treatments did not influence milk free fatty acids at 4 degrees C at 0 or 28 h after milking. The average diameter of milk fat globules was significantly greater in milk from cows offered low de novo diets. Furthermore, the low de novo diet significantly increased the concentration of nonesterified fatty acids and d-beta-hydroxybutyrate in blood plasma, the latter was also increased in milk. Treatments did not affect the enzyme activity of lactate dehydrogenase and N-acetyl-beta-d-glucosaminidase in milk or the activity of isocitrate dehydrogenase and malate dehydrogenase in blood plasma. The low de novo diet significantly increased plasma Zn and milk Zn content, whereas dietary Zn level did not in itself influence these parameters. This indicates that the transfer of fat from diet to milk might facilitate transfer of Zn from diet to milk.

Influence of air intake on the concentration of free fatty acids and vacuum fluctuations during automatic milking.

The main objective of the study was to determine whether the amount of air intake during quarter milking influences the concentration of free fatty acids (FFA) and vacuum fluctuations at the teat end when milking automatically. Air intake in the teat cup was restricted from the normal inlet of 4.5 to 7 L/min to 1.7 and 0 L/min on 2 farms and experiments were carried out as half-udder studies with 40 cows. Blockage of the air inlet reduced FFA from 1.02 to 0.77 mEq/100 g of fat in one herd and from 1.50 to 1.17 mEq/100 g of fat in the other herd. Milk yield per milking was the most significant factor influencing FFA. Air intake accounted for <20% of the variation in FFA concentration. Characteristics of the cow explained the most variation, which could mainly be assigned to the effects of milk yield, fat percentage, fat globule size, and fat globule size distribution. The interval between milkings was not significant when adjusting for milk yields. Blockage of the air inlet caused vacuum fluctuations at the teat end to increase from 15.4 to 21.5 kPa for one model of an automatic milking system (AMS), but from 12.8 to 53.6 kPa for another model. Measurements made with a flow simulator and water revealed that the AMS model and water flow were the most important factors influencing vacuum fluctuations, and that interactions existed between the diameter of the short milk tube and air intake. Free fatty acids in bulk milk from 5,980 herds averaged 0.75 mEq/L of milk for conventional herds and varied from 0.77 to 0.94 mEq/L of milk for the 5 AMS models on the Danish market. Fault detection in 55 herds pointed out that the most frequent faults in conventional herds were air leakages and intake of too much air in the cluster, whereas AMS herds had problems with the cooling and stirring of milk. Correction of the cooling faults caused FFA to decrease by 0.52 mEq/L in the AMS herds. We concluded that air intake during automatic milking is not the most important factor in reducing FFA, whereas milk yield per milking matters the most. More attention should be paid to the cooling and stirring of milk. Reducing the air intake causes vacuum fluctuations during milking to increase significantly.

Impact of milking frequencies on the level of free fatty acids in milk, fat globule size, and fatty acid composition.

The aim of the present study was to study the effect of milking cows 4 times daily on free fatty acids (FFA) in the milk compared with milking twice daily. An experiment was performed during 2 wk in which half udders in 11 cows were milked 2 or 4 times daily. Milk yield was measured, and milk was analyzed for fat content, FFA, fatty acid composition, fat globule size, and activity of gamma-glutamyl transpeptidase. Concentration of FFA was greater (1.49 mEq/100 g of fat) in milk from half udders milked 4 times daily than in milk from the half udders milked twice daily (1.14 mEq/100 g of fat). Further, it was noted that milk from the half udder milked 4 times daily contained milk fat globules with larger average diameters. Increased milking frequency increased milk yield by 9% compared with the udder half milked twice daily, but fat content and fat yield were not affected. The results are of importance for further understanding the mechanisms behind the increased content of FFA that is frequently observed in automatic milking systems.

Identification of important mechanical and acoustic parameters for the sensory quality of cocoa butter alternatives.

In this study, the correlation between sensory attributes and the mechanical and acoustic properties of cocoa butter alternatives was elucidated. Needle penetration, cone penetration and compression tests were used to characterise mechanical properties and acoustic properties were evaluated by simultaneous texture and sound analyses. Results were correlated with a descriptive sensory evaluation. A significant correlation was found between hardness (needle penetration) and sensory hardness evaluated upon biting (r=0.91, p<0.05) and between Hencky strain (compression test) and the sensory toughness (r=0.94, p<0.05). In contrast, no significant correlation was found between brittleness (cone penetration) and the sensory brittleness. The use of different mechanical methods shed light on a complex rheological behaviour of fat which demonstrates the importance of not simply relying on results from penetration tests when evaluating fat texture. For instance, a hard fat was perceived very differently depending on the degree of elasticity. A significant correlation was found between sound pressure level (simultaneous sound and texture analyses) and the sensory evaluation of the sound intensity upon breakage (r=0.96 and 0.97, p<0.05). Both hardness and elasticity were found to be of great importance for the intensity of the sound emission i.e. a hard texture with a low degree of flexibility (less elastic) is more likely to provide a rapid energy release upon breakage and thus a high intensity sound emission.