Sterility and performance of open and closed extracorporeal circuits after long-term dry-wet setups.

BACKGROUND: The timeframe for safely using previously setup dry, crystalloid, and blood-primed extracorporeal circuits has long been debated. This study was undertaken to determine a safe deviation from standardized recommendations. METHODS: Open (cardiopulmonary bypass) circuits and closed extracorporeal membrane oxygenation circuits were setup dry for up to 60 days and wet primed for up to 6 weeks with one control inoculated with Escherichia coli. Open circuits were cultured daily, closed circuits weekly. Circuits were primed with blood, albumin, heparin, NaHCO3, and CaCl2. Baseline pCO2, pO2, hemoglobin, lactate dehydrogenase, and plasma free hemoglobin were measured. Circuits were recirculated at a blood flow of 6 Liters/minute with a sweep gas of 1 Liter/minute at 100% FiO2 for 1 minute. Post oxygenator blood gases were collected at 8-, 16-, and 24-hour intervals. RESULTS: There was no observed compromise to the sterility of the circuits and no clinically significant gas exchange abnormalities observed over the duration of the study period. Statistical significance (p < 0.01) was seen in free hemoglobin and lactate dehydrogenase levels, most significant in between the 16- and 24-hour time point in the closed systems intentionally inoculated with E. coli. CONCLUSION: Open and closed circuits can be safely setup dry for up to 60 days. Open, wet-primed circuits can be used safely up to 5 days. Closed, wet-primed circuits can be used safely up to 6 weeks. Blood-primed circuits can be safely run up to 16 hours prior to patient use but should be validated in a randomized clinical study.

Use of platelet gel and its effects on infection in cardiac surgery.

The use of plasmapheresis in cardiac surgery has failed to show an unequivocal benefit. However, the further processing of plasmapheresed blood to obtain a platelet-rich concentrate, termed platelet gel, may reduce patient susceptibility to infection through poorly understood mechanisms related to a combination of platelets, white blood cell content, and expedited wound healing. The purpose of the study was to retrospectively evaluate the incidence wound infections in patients undergoing cardiac surgery. Platelet gel (PG) patients (n = 382) received topical administration of a mixture of platelet concentrated plasma, 10% calcium chloride (5 mL), and bovine thrombin (5000 units). A control group (NoPG, n = 948) operated on concurrently with the treatment group did not receive PG, but otherwise received similar wound care. A historical control (HC, n = 929) included patients operated on before the availability of PG. After Institutional Review Board approval, 20 factors reported in the literature to predispose individuals for increased infection were recorded along with infections classified either as superficial or deep sternal according to the Society of Thoracic Surgeon criteria. All data were obtained from our institutional contribution to the Society of Thoracic Surgeon database. All adult (>19 years of age) patients undergoing cardiac surgery at our institution between October 2002 and June 2005 were included in this study (n = 2259). The incidence of superficial infection was significantly lower in the PG group (0.3%) compared both with the NoPG (1.8%) and HC (1.5%) groups (p < .05). There was a similar relationship found when comparing deep sternal wound infections (PG, 0.0% vs. NoPG, 1.5%; p < .029 and PG vs. HC, 1.7%;p < .01). In conclusion, the application of PG in patients undergoing cardiac surgery seems to confer a level of protection against infection, although the mechanisms of action remain to be elucidated.

Improved outcomes during cardiac surgery: a multifactorial enhancement of cardiopulmonary bypass techniques.

Patients presenting for cardiac surgery with cardiopulmonary bypass (CPB) are more likely to have pre-existing comorbidities, which has resulted in a steady increase in the risk associated with CPB. The resulting challenge has mandated the optimization of perfusion care. The purpose of this study was to retrospectively evaluate the impact of a number of simultaneous, evidence based perfusion care changes on patient outcome. After Institutional Review Board approval, two groups of patients were compared. The control group (n = 317) included all patients undergoing CPB in a 12-month period preceding a multifaceted change in perfusion techniques. The treatment group (n = 259) included all patients undergoing CPB in the 12-month period after the changes, which included the incorporation of updated continuous blood gas monitoring, biocompatible circuitry, updated centrifugal blood propulsion, continuous autotransfusion technology, new generation myocardial protection instrumentation, plasmapheresis, topical platelet gel application, excluding hetastarch while increasing the use of albumin, viscoelastographic coagulation monitoring, and implementing a quantitative quality improvement program. After univariate analysis, propensity scoring and multiple conditional logistical regression were used to control for demographic, preoperative, operative, and postoperative parameters. Results of the primary endpoints revealed a lower mortality rate in the treatment group (4% vs. 9% [95% confidence interval 1.33, 7.72], p = 0.009), lower transfusion rate (51% vs. 59% [1.00, 2.11], p = 0.048), and lower complication rate (55% vs. 65% [1.06,2.19], p = 0.025) despite having similar predicted mortality (11 [2,22] vs. 11[3,22], p = NS) and other preoperative and operative parameters. The lower mortality rate was concurrent with a trend towards a lower incidence of complications, consistent with the differences in primary outcomes. In conclusion, the patients treated after the implementation of a multifactorial improvement plan using evidence based changes in CPB care had decreased complication and mortality rates.

Use of the Quest Myocardial Protection System (MPS) for modified ultrafiltration during pediatric cardiac surgery.

Modified ultrafiltration generally is considered a standard of care for treating children undergoing cardiopulmonary bypass for congenital heat surgery. Different methods, incorporating a variety of devices and technologies, have been described. The present report describes a technique of modified ultrafiltration using arterial-venous flow with the Quest Myocardial Protection System (MPS).

Utilization of rapid-infuser devices for massive blood loss.

Rapid volume replacement for severe hemorrhage continues to challenge the clinician involved in the care of the patient suffering hemorrhagic shock. We report on the development and utilization of two rapid-infuser systems for volume replacement in critically ill patients presenting in extremis. We have developed rapid-infusion circuits by using commercially available devices available at our institution. The primary pumping mechanism is either a centrifugal pump (Revolution--COBE Cardiovascular, Arvada, CO, USA), or the Myocardial Protection System (MPS Quest Medical, Allen, TX, USA), and offers advantages over commercially available devices. Both circuits consist of a cardiotomy reservoir, a cardioplegia delivery set, assorted tubing and connectors, and a heater-cooler system. Between January and October of 2003, 15 procedures were performed which utilized one of these two devices. There were nine ruptured aneurysms, five traumas and one radical nephrectomy. The rapid infusion time averaged 228.5 +/- 105.7 min where 10.4 +/- 9.4 L of autotransfusion volume was processed, with 3.9 +/- 4.2 L of red cell volume reinfused. The allogeneic blood products that were transfused included packed red blood cells and fresh frozen plasma, as well as 5% albumin. There were no intraoperative deaths and the rapid-infuser was considered lifesaving in all instances. Mechanical rapid infusion systems may be lifesaving when severe hypovolemia or hemorrhagic shock is encountered. While both devices are able to meet the requirements of rapid fluid replacement, the MPS offers the most safety features and has become the standard of care at our institution.

Coagulation management of a patient with factor V Leiden mutation, lupus anticoagulant, and activated protein C resistance: a case report.

Although patients undergoing cardiac surgery often present with diverse comorbidities, those with coagulation derangements are especially challenging. The present report describes the management of a patient who presented with a Factor V Leiden mutation, lupus anticoagulant, and acquired activated protein C resistance. A 42-year-old female presented with acute shortness of breath and chest pain. She was otherwise healthy 1 month prior to admission when she presented with dysfunctional uterine bleeding, resulting in the transfusion of three units of packed red blood cells. Coagulation evaluation revealed that the patient had lupus anticoagulant, factor V Leiden mutation and an activated protein C resistance. The patient presented with an acute myocardial infarction and was found to have 90% stenosis of her left main coronary artery, moderate mitral and tricuspid regurgitation, and a left ventricular ejection fraction of 25%. An emergent off-pump coronary artery bypass procedure with placement of a vein graft to the left anterior descending artery was completed. Intraoperative thrombophilia was encountered as evidenced by both an elevated thromboelastograph coagulation index (+3.6) and an acquired antithrombin-III deficiency. Postoperatively, the patient was placed on low molecular weight heparin, but developed heparin-induced thrombocytopenia and was switched to a direct thrombin inhibitor, argatroban. The following case report describes the coagulation management of this patient from the time of admission to discharge 43 days later, and the unique challenges this combination of hemostatic defects present to the clinicians.