Supercritical carbon dioxide extraction of volatiles from spices. Comparison with simultaneous distillation-extraction.

Supercritical fluid extraction (SFE) and simultaneous distillation-extraction (SDE) were used to extract the essential oils from three different spices (oregano, basil, and mint), and a comparative study of extracts obtained using SFE and SDE is presented. Temperature and pressure for the SFE extraction were optimized prior to the experimental extractions. The extracts obtained using the two methods were very similar in composition, but SFE yielded better relative standard deviations and avoided the thermal degradation or solvent contamination of samples.

Effect of drying method on the volatiles in bay leaf (Laurus nobilis L.).

The effect of different drying treatments on the volatiles in bay leaf (Laurus nobilis L.) was studied. Simultaneous distillation extraction (SDE) and solid-phase microextraction (SPME) were compared by gas chromatography-mass spectrometry (GC-MS) of the volatile components in bay leaves. SDE yielded better quantitative analysis results. Four drying treatments were employed: air-drying at ambient temperature, oven-drying at 45 degrees C, freezing, and freeze-drying. Oven drying at 45 degrees C and air-drying at ambient temperature produced quite similar results and caused hardly any loss in volatiles as compared to the fresh herb, whereas freezing and freeze-drying brought about substantial losses in bay leaf aroma and led to increases in the concentration levels of certain components, e.g., eugenol, elemicin, spathulenol, and beta-eudesmol.

Influence of drying on the flavor quality of spearmint (Mentha spicata L.).

Spearmint (Mentha spicata L.) was dried using three different drying methods: oven-drying at 45 degrees C, air-drying at ambient temperature, and freeze-drying. The effect of the drying method on the volatile compounds and on the structural integrity and sensory characteristics of the spice was evaluated. The volatile components from fresh and dried spearmint samples were isolated by simultaneous distillation-extraction (SDE) and analyzed by gas chromatography-mass spectrometry (GC-MS). A total of 28 compounds were identified, carvone, limonene, and 1,8-cineole, in that order, being the main components in all of the samples. Oven-drying at 45 degrees C and air-drying at ambient temperature were the methods that produced the best results. An increase in monoterpenes was observed in all of the dried samples, except in the freeze-dried samples that underwent freezing at -198 degrees C. Freeze-drying resulted in substantial losses in oxygenated terpenes and sesquiterpenes. The effect of each drying method on leaf structure was observed by scanning electron microscopy. From a sensory standpoint, drying the spearmint brought about a decrease in herbaceous and floral notes together with an increase in minty odor.