Efficacy of Commercially Available Irrigation Solutions on Removal of Staphylococcus Aureus and Biofilm From Porous Titanium Implants: An In Vitro Study.

BACKGROUND: Periprosthetic joint infection remains a major problem. The bactericidal efficacy of commercial irrigation solutions for the treatment of infection is not well established in the presence of porous titanium (Ti) implants. This study compared the in vitro efficacy of five irrigation solutions on infected three-dimensional-printed porous Ti discs. METHODS: Titanium discs (2 × 4 mm, 400, 700, and 1,000 µm) were infected with S. aureus (1 × 106 colony-forming unit/mL) and incubated for 3 hours or 3 days to create acute or chronic infection with biofilm. Discs were irrigated with saline, antibiotic, or antiseptic solutions, then repeatedly sonicated. Sonicates were cultured for bacterial quantification. Statistical analyses were performed using one-way analysis of variance (ANOVA), followed by Tukey-Kramer post hoc testing (P < .05 significance). Biofilms were visualized by scanning electron microscopy. RESULTS: Saline irrigation was ineffective in both groups. In acute infections with 400 µm pores, differences were found with saline versus solution #3 (P = .015) and #4 (P = .015). Solution #4 had the lowest bacterial counts for all pore sizes. For biofilm, irrigation with saline, solutions #1, #2, and #3 inadequately cleared bacteria in all pore sizes. Lower remaining concentrations were observed in #4 with 400µm pores compared to saline (P = .06) and #2 (P = .039). The scanning electron microscopy showed a reduction of biofilm in samples washed with #4. CONCLUSIONS: Irrigation of infected porous Ti discs with saline, solutions #1 and #2 failed to reduce the bacterial load. The 400 µm discs consistently had more bacteria despite irrigation, highlighting the difficulty of removing bacteria from small pores. Solutions #3 and #4 reduced bacteria acutely, but only #4 demonstrated efficacy in clearing biofilm compared to saline. These results should be considered when treating periprosthetic joint infection in the presence of porous components and the potential presence of biofilm.

Effects of Vancomycin/Tobramycin-Doped Ceramic Composite (Polyvinyl Alcohol Composite-Vancomycin/Tobramycin-Polymeric Dicalcium Phosphate Dihydrate) in a Rat Femur Model Implanted With Contaminated Porous Titanium Cylinders.

BACKGROUND: Periprosthetic joint infection (PJI) remains common and problematic. We hypothesized that using a bioceramic that provided rapid release of the antibiotics (vancomycin [VAN] or VAN and tobramycin [VAN and TOB]) from a polyvinyl-alcohol-composite (PVA) combined with a delayed and sustained antibiotic release from polymeric-dicalcium-phosphate-dihydrate (PDCPD) ceramic would inhibit S. aureus-associated implant infections. METHODS: A total of 50 male Sprague Dawley rats were randomly divided into 5 groups-I: negative control; II: bacteria only; III: bacteria + saline wash; IV: bacteria + PVA-VAN-PDCPD, and V: bacteria + PVA-VAN-TOB-PDCPD. A porous titanium (Ti) implant was press-fit into the rat knee. S. aureus-containing broth was added into the joint space creating a PJI. After 1 week, the joints from groups III to V were washed with saline and the fluid collected for bacterial quantification. This was followed by saline irrigation treatment (groups III to V) and application of the antibiotic-loaded PVA-PDCPD bioceramic (groups IV and V). On day 21, joint fluid was collected, and the implants harvested for bacterial quantification. RESULTS: No bacteria were isolated from the negative control (group I). The positive control (group II) was positive on both days 7 and 21. Bacteria were still present on day 21 in the fluid and implant in group III. Groups (IV and V) showed a decrease in the bacterial burden in the fluid and implant on day 21. There were significant differences in bacteria levels in the collected wash fluid and on the implant at day 21 between the saline wash (group III) and treatment groups (IV and V). CONCLUSIONS: In this animal model of acute periprosthetic infection, treatment with PVA-VAN-PDCPD and PVA-VAN/TOB-PDCPD reduced bacterial load in the infected joint and the infected Ti implant. Application of PVA-VAN-PDCPD and/or PVA-VAN/TOB-PDCPD after saline irrigation could be used as an addition to the treatment of PJI.

A Reduction in Opioid Prescription Size After Total Joint Arthroplasty Can be Safely Performed Without an Increase in Complications.

BACKGROUND: Excessive opioid prescriptions after total joint arthroplasty (TJA) increase risks for adverse opioid-related events, chronic opioid use, and unlawful opioid diversion. Decreasing postoperative prescriptions may improve quality after TJA. Concerns exist that a decrease in opioids prescribed may increase complications, such as readmissions, emergency department (ED) visits, or worsened patient-reported outcomes (PROs). The purpose of this study was to explore whether a reduction in opioids prescribed after TJA resulted in increased complications. METHODS: Data originated from a statewide database prospectively abstracted, including oral morphine equivalents prescribed at discharge, readmissions, ED visits, and PROs. Data were collected from 84,998 TJA occurring 1 year before and after the creation of an opioid-prescribing protocol that had decreased prescriptions by approximately 50%. Trends were monitored using Shewhart control charts. Regression models were used to determine statistically significant changes over time. RESULTS: All groups showed a reduction in opioids prescribed by almost 50% without an increase in emergency room visits or readmissions and without a detrimental effect on PROs. Compared to baseline data before opioid reduction, opioid-naive total knee arthroplasty had significant improvements in all outcomes (P = .03, P = .02, P < .001, P < .001). Opioid-tolerant total knee arthroplasty and total hip arthroplasty had no worsened outcomes and significant improvement in (Knee Injury and Osteoarthritis Outcome score for Joint Replacement P = .03) and (Hip Disability and Osteoarthritis Outcome Score for Joint Replacement P = .03). Opioid-naive total hip arthroplasty had significant improvements in Hip Disability and Osteoarthritis Outcome Score Joint Replacement (P = .003) and Patient Reported Outcomes Measurement Information System (P = .001). CONCLUSIONS: Postoperative opioid prescription recommendations from a statewide registry decreased prescribing by approximately 50% without decreasing PROs or increasing ED visits or readmissions. A reduction in opioids prescribed after TJA can be accomplished safely and without increased complications.

Do 'Surgeon Champions' and High-Volume Surgeons Have Lower Rates of Periprosthetic Femur Fracture? Perspective From a State-Wide Quality Improvement Registry.

BACKGROUND: Recently, a state-wide registry identified fracture as a major cause of total hip arthroplasty revision. There were 52.8% of revisions occurring within 6 months (fracture leading cause). Registry sites have a 'surgeon champion' who acts as liaison and advocate. This study evaluated the effect of surgeon volume and role of 'surgeon champion' on fracture rates. METHODS: There were 95,948 cases from 2012 to 2019 queried with peri-implant femoral fractures identified (within 6 months). Funnel plots were generated to compare individual surgeon-specific fracture rates. Surgeons who had a fracture rate below the confidence interval were labeled 'green' (lower than mean), within were 'yellow' (no difference), and above were 'red' (significantly higher). RESULTS: For all surgeons, 19.6% were red, 72.1% yellow, and 8.3% green. There were 17.2% 'surgeon champions' and 6.2% 'nonchampions' that were green (P = .01), while 20.7 and 19.3% were red (P = .82). There was a significant association between volume and performance (P < .01). No surgeons in the lower two quartiles (<84; 84 to 180 cases), while 4 and 29% of higher-volume surgeons (181 to 404; >404 cases) were green. There was no statistical difference in red status by volume (P = .53). CONCLUSION: 'Surgeon champions' and high-volume surgeons were more likely to be high performers but not less likely to be low performers. Active involvement in quality improvement and/or high volume was associated with better outcomes but did not impart complication immunity. 'Green' surgeons should mentor colleagues to help reduce fractures by re-evaluating modifiable factors. Analyzing outcomes to promote quality and decrease complications is paramount.

Early Survivorship of Uncemented Total Knee Arthroplasty Varies by Age and Sex Based on Data From the Michigan Arthroplasty Registry Collaborative Quality Initiative.

BACKGROUND: Outcome data for newer uncemented total knee arthroplasty (TKA) designs has been mixed. Registry studies showed worse survivorship, but clinical trials have not demonstrated differences compared to cemented designs. There has been renewed interest in uncemented TKA with modern designs and improved technology. The utilizations of uncemented knees in Michigan, 2-year outcomes, and the effects of age and sex were evaluated. METHODS: A statewide database from 2017 through 2019 was analyzed for incidence, distribution, and early survivorship of cemented versus uncemented TKAs. There was 2-year minimum follow-up. Kaplan-Meier survival analysis was used to generate time to first revision cumulative percent revision curves. The impacts of age and sex were examined. RESULTS: Use of uncemented TKAs increased from 7.0 to 11.3%. Uncemented TKAs were more commonly men, younger, heavier, American Society of Anesthesiologists score > 2, and opioid users (P < .05). At 2 years, overall cumulative percent revision was higher in uncemented (2.44% [2.00, 2.99]) versus cemented (1.76% [1.64, 1.89]), particularly in women uncemented (2.41 [1.87, 3.12]) versus cemented (1.64 [1.50, 1.80]). Revision rates were greater with uncemented women >70 years (1.2% 1 year, 1.02% 2 years) versus < 70 years (0.56%, 0.53%), notably uncemented were inferior in both groups (P < .05). Men, regardless of age, had similar survivorships with both cemented and uncemented designs. CONCLUSION: The use of an uncemented TKA had an increased risk of early revision compared to cemented. This finding, however, was only apparent in women, especially those >70 years old. Surgeons should consider cement fixation in women >70 years.

Mark Coventry Award: Efficacy of Saline Wash Plus Antibiotics Doped Polyvinyl Alcohol (PVA) Composite (PVA-VAN/TOB-P) in a Mouse Pouch Infection Model.

BACKGROUND: The efficacy of saline irrigation for treatment of periprosthetic infection (PJI) is limited by the presence of contaminated medical devices. This study evaluated treatment efficacy of locally placed polyvinyl alcohol (PVA)/bioceramic composite doped with vancomycin (PVA-VAN-P) or vancomycin and tobramycin (PVA-VAN/TOB-P) after saline irrigation in a mouse pouch infection model. METHODS: Sutures were implanted into air pouches of BALB/cJ mice, then inoculated with Staphylococcus aureus. Mice were randomized into 6 groups (n = 6 each): (1) no bacteria; (2) bacteria without saline wash; (3) saline wash only; (4) saline wash + PVA-P; (5) saline wash + PVA-VAN-P, and (6) saline wash + PVA-VAN/TOB-P. After 7 days, pouches were washed with saline alone or with additional injection of 0.2 mL of the composites. Sacrifice occurred 14 days after the washout. Histology was performed on the pouch tissues and bacteria cultures on the washout fluid. RESULTS: Bacterial culture (optical density) showed that infection persisted after saline irrigation (0.10 ± 0.14) but was effectively eradicated by the addition of PVA-VAN-P (0.05 ± 0.09) and PVA-VAN/TOB-P (0.002 ± 0.003, P < .05). These effects were confirmed by histology. Importantly, no residues of the PVA-P were detected in either the pouch washouts or pouch tissues. CONCLUSION: PJI is common and problematic, and few innovations have changed clinical practice and/or outcome. Our data confirmed that the effect of saline irrigation was very limited in the presence of contaminated sutures. PVA-VAN/TOB-P was biodegradable, biocompatible, and effective in eradicating bacterial retention after saline irrigation. Application of PVA-VAN/TOB-P after saline irrigation could be an option for treatment of PJI and should be evaluated in future PJI animal models.

John N. Insall Award: MARCQI's Pain-Control Optimization Pathway (POP): Impact of Registry Data and Education on Opioid Utilization.

BACKGROUND: In 2019, the Michigan Arthroplasty Registry Collaborative Quality Initiative (MARCQI) recommended an evidence-based opioid pain pathway to participating physicians and hospitals for patients undergoing total joint arthroplasty (TJA). The purpose of this study was to determine if the education could influence and have lasting effects on the prescribing patterns for TJA patients. METHODS: Using the MARCQI database, the number of oral morphine equivalents (OMEs) prescribed at discharge were collected from January 2018 through December 2019 for all primary arthroplasty procedures. Periods compared included before and after July 2018 Michigan opioid laws as well as before and after the March 2019 MARCQI recommendations. The data compared total hip arthroplasty (THA) and total knee arthroplasty (TKA) patients, opioid-naive vs opioid-tolerant patients, individual surgeons, and MARCQI sites. RESULTS: The data included 84,998 TJAs: 22,774 opioid-naive THAs, 9124 opioid-tolerant THAs, 40,882 opioid-naive TKAs, and 12,218 opioid-tolerant TKAs. In all the groups and at all time periods there were a significant decrease in prescriptions (P < .001). Individual surgeons and participating sites also demonstrated decreased OMEs on discharge after the recommendations. Between the first and last months of collection, this represented an overall decrease of opioid OMEs for THA by 47.1% for opioid-naive patients and 53.4% for opioid-tolerant patients. For TKA patients, the OME decrease was 48.3% for opioid-naive patients, and 48.4% for opioid-tolerant patients. CONCLUSION: The MARCQI pain control optimization pathway (POP) program has been successful in drastically reducing opioid prescribing with lasting effects, which has substantially limited the overall opioid prescription burden for patients undergoing arthroplasty.

Causes of Early Hip Revision Vary by Age and Gender: Analysis of Data From a Statewide Quality Registry.

BACKGROUND: While total hip arthroplasty (THA) is extremely successful, early failures do occur. The purpose of this study was to determine the cause of revision in specific patient demographic groups at 3 time points to potentially help decrease the revision risk. METHODS: Data for cases performed between 2012 and 2018 from a statewide, quality improvement arthroplasty registry were used. The database included 79,205 THA cases and 1,433 revisions with identified etiology (1,584 in total). All revisions performed at <5 years from the primary THA were reviewed. Six groups, men/women, <65, 65-75, and >75 years, were compared at revision time points <6 months, <1 year, and <5 years. RESULTS: There were obvious and significant differences between subgroups based on demographics and time points (P < .0001). Seven hundred and fifty-six (53%) of all revisions occurred within 6 months. The most common etiologies within 6 months (756 revisions) were fracture (316, 41.8%), dislocation/instability (194, 25.7%), and infection (98, 12.9%). At this early time point, the most common revision cause was fracture for all age/gender-stratified groups, ranging from 27.6% in young men to 60% in older women. Joint instability became the leading cause for revision after 1 year in all groups. CONCLUSION: This quality improvement project demonstrated clinically meaningful differences in the reason for THA revision between gender, age, and time from surgery. Strategies based on these data should be employed by surgeons to minimize the factors that lead to revision.

Long-Term Sustainability of a Quality Initiative Program on Transfusion Rates in Total Joint Arthroplasty: A Follow-Up Study.

BACKGROUND: There are significant variations in transfusion rates among institutions performing total joint arthroplasty. We previously demonstrated that implementation of an educational program to increase awareness of the American Association of Blood Banks' transfusion guidelines led to an immediate decrease in transfusion rates at our facilities. It remained unclear how this initiative would endure over time. We report the long-term success and sustainability of this quality program. METHODS: We reviewed the Michigan Arthroplasty Collaborative Quality Initiative data from 2012 through 2017 of all patients undergoing primary hip and knee arthroplasty at our institutions for preoperative and postoperative hemoglobin level, transfusion status, and number of units transfused and transfusions outside of protocol to identify changes surrounding our blood transfusion educational initiative. We calculated the transfusions prevented and cost implications over the course of the study. RESULTS: We identified 6645 primary hip and knee arthroplasty patients. There was a significant decrease in transfusion rate and overall transfusions in each group when compared to pre-education values. Subgroup analysis of TKA and THA independently showed significant decreases in both transfusion rate and overall transfusions. Over the final 3 years of the study, only 2 patients were transfused outside of the American Association of Blood Banks protocol. We estimate prevention of 519 transfusions over the study period. CONCLUSION: Application of this quality initiative was an effective means of identifying opportunities for quality improvement. The program was easily initiated, had significant early impact, and has been shown to be sustainable.

Does Suture Type Influence Bacterial Retention and Biofilm Formation After Irrigation in a Mouse Model?

BACKGROUND: Irrigation and débridement are frequently utilized in the management of surgical infections, but even with aggressive débridement, it is difficult to remove all the suture material from the tissues and retained suture material may harbor bacteria and/or biofilm. The degree to which barbed or braided sutures may differentially influence the risk of infection has not been defined in a well-controlled animal model. QUESTIONS/PURPOSES: We compared braided and barbed monofilament sutures after irrigation of an infected mouse air pouch model to determine whether the suture type influenced the effectiveness of the irrigation. After irrigation of infected pouches, sutures were compared for (1) bacterial adherence and bacterial retention; (2) qualitative and quantitative pouch thickness and cellular density; and (3) quantitative biofilm formation. METHODS: Soft tissue air pouches were created on the backs of 60 female, mature 10-week-old BALB/cJ mice by sequentially introducing air into the subcutaneous tissue and allowing the pouch to mature. The pouches were inoculated with Staphylococcus aureus and braided or barbed monofilament sutures were implanted. Pouch irrigation was performed Day 7 after suture implantation. Suture segments were collected before and after irrigation. After euthanasia on Day 14, pouch tissues with residual suture segments were collected for analysis: microbiologic analysis done using optical density as a measure of the concentration of bacteria in the culture (the larger concentration indicates higher number of bacteria) and histologic evaluation of the pouch tissues were semiquantitative, whereas environmental scanning electron microscopy (ESEM) and confocal analyses of the biofilm and bacteria on the sutures were qualitative. RESULTS: Histologic evaluation of pouch tissue showed all groups had inflammatory responses. Quantitatively microbiology showed no difference in bacterial number calculated from the optical density (OD) values between the two suture materials at any time point in the irrigation group. In the no-irrigation group, for the Day 7 time point, mean (± SD) OD was greater in the barbed than the OD in the braided sutures (0.52 ± 0.12 versus 0.37 ± 0.16, mean difference 0.43 [95% confidence interval, 0.08-0.13]; p = 0.007). Qualitatively, ESEM showed more bacterial retention by braided sutures before and after irrigation. Confocal imaging of the sutures demonstrated penetration of biofilm into the interstices of braided sutures and less adhesion in barbed monofilament sutures. The quantification of the biomass showed no differences between groups at all time points (before-irrigation biomass was 11.2 ± 9.3 for braided versus 5.2 ± 4.7 for barbed sutures, p = 0.196; and after-irrigation biomass was 7.2 ± 7.5 for braided versus 3.3 ± 4.3 for barbed suture, p = 0.259). CONCLUSIONS: All sutures can retain bacteria and biofilm, but it is rarely possible to remove all suture material at the time of irrigation to treat infection. After an irrigation procedure, qualitatively braided sutures appeared to harbor more bacteria and to retain more biofilm than barbed monofilaments. CLINICAL RELEVANCE: When saline irrigation was used to simulate infection treatment in an infected mouse air pouch model, bacteria/biofilm was not completely eliminated from either braided or barbed monofilament sutures. The irrigation appeared to clear more bacteria and biofilm from the monofilament despite having barbs. Unfortunately, current technologies do not allow direct quantitative comparisons of biofilm retention. Clinicians should be aware that in the face of infection, any retained sutures may harbor bacteria despite irrigation.

Decreased Bacterial Adherence, Biofilm Formation, and Tissue Reactivity of Barbed Monofilament Suture in an In Vivo Contaminated Wound Model.

BACKGROUND: Monofilament and barbed monofilament sutures have been shown in in vitro models to have less bacterial adherence than braided suture. This study evaluates bacterial adherence to suture materials and tissue reactivity with an in vivo contaminated wound mouse model. METHODS: Staphylococcus aureus was used to create an in vivo contaminated wound model at 2 amounts (106 colony-forming units [CFU] and 108 CFU) using a mouse air pouch. Three types of commonly used absorbable suture were evaluated: braided, monofilament, and barbed monofilament. Bacterial suture adherence was evaluated with suture culture, a photon-capturing camera system, and scanning electron microscopy. Tissue reactivity was assessed through histology and protein expression. RESULTS: The braided suture group with the high amount of S aureus exhibited frank purulence and air pouch hypertrophy in all 8 mice. A significant difference was found between suture groups inoculated with 108 CFU (P < .05) as measured by bacterial culture concentration using the optical density method. The braided suture hosted more bacteria than either monofilament (P < .005) or barbed monofilament suture (P < .005). No difference was appreciated between the monofilament and barbed monofilament groups. Kruskal-Wallis test demonstrated a significant difference between groups in regard to levels of tumor necrosis factor-α (P < .05) and interleukin-1 (P < .05). CONCLUSION: Our in vivo contaminated wound model demonstrated that barbed monofilament suture performed similarly to monofilament suture and better than braided suture in terms of bacterial adherence, biofilm formation, and tissue reactivity.

How Do Preoperative Medications Influence Outcomes After Total Joint Arthroplasty?

BACKGROUND: Recent health care policy changes require hospitals and physicians to demonstrate improved quality. In 2012, a prospective database was formed with the Blue Cross and Blue Shield of Michigan to improve quality of care. The purpose of this study was to analyze patient preoperative medication as predictors of outcomes after total joint arthroplasty. METHODS: Data were collected on patient's preoperative medications from 2012 to 2015 using a total joint arthroplasty database. Medications were categorized as antiplatelet, antimicrobial, anticoagulant, narcotic, steroid, insulin, or oral diabetes medication. Outcomes included hospital length of stay (LOS), discharge disposition/destination, and 90-day readmission. Univariate and multivariate regression analyses were performed. RESULTS: A total of 3959 patients were studied. Eighty percent (3163 patients) were discharged home. The remainder (795) went to an extended-care facility (ECF). Patients discharged to an ECF were taking more medications (1.13 vs 0.80 in total knee arthroplasty; 1.18 vs 0.83 in total hip arthroplasty; P <.001). Patients who were readmitted took more medications (1.0 vs 0.85; P <.01). There were more discharges to an ECF in narcotic, steroid, and diabetes medication users. Patients taking anticoagulants, narcotics, insulin, and antiplatelets had greater readmission rates. There was a significant correlation between the number of medications and an increased LOS. CONCLUSION: Patients taking more medications were more frequently discharged to an ECF and had increased LOS and readmission rates. Narcotics and diabetic medications had the greatest influence. Category and quantity of preoperative medications can be used as predictors of outcomes after arthroplasty surgery.

Socioeconomic Risk Adjustment Models for Reimbursement Are Necessary in Primary Total Joint Arthroplasty.

BACKGROUND: Alternative payment models, such as bundled payments, aim to control rising costs for total knee arthroplasty (TKA) and total hip arthroplasty (THA). Without risk adjustment for patients who may utilize more resources, concerns exist about patient selection and access to care. The purpose of this study was to determine whether lower socioeconomic status (SES) was associated with increased resource utilization following TKA and THA. METHODS: Using the Michigan Arthroplasty Registry Collaborative Quality Initiative database, we reviewed a consecutive series of 4168 primary TKA and THA patients over a 3-year period. We defined lowest SES based upon the median household income of the patient's ZIP code. Demographics, medical comorbidities, length of stay, discharge destination, and readmission rates were compared between patients of lowest SES and higher SES. RESULTS: Patients in the lowest SES group had a longer hospital length of stay (2.79 vs 2.22 days, P < .001), were more likely to be discharged to a rehabilitation facility (27% vs 18%, P < .001), and be readmitted to the hospital within 90 days (11% vs 8%, P = .002) than the higher SES group. Multivariate analysis revealed that lowest SES was an independent risk factor for all 3 outcome variables (all P < .001). CONCLUSION: Patients in the lowest SES group utilize more resources in the 90-day postoperative period. Therefore, risk adjustment models, including SES, may be necessary to fairly compensate hospitals and surgeons and to avoid potential problems with access to joint arthroplasty care.

The Effect of Comorbidities on Discharge Disposition and Readmission for Total Joint Arthroplasty Patients.

BACKGROUND: As the annual demand and number of total joint arthroplasty cases increase, so do concerns of outcomes of patient with specific comorbidities relative to outcomes and costs of care. METHODS: The study cohort included 2009 primary total knee arthroplasty (TKA) patients and 905 total hip arthroplasty patients. Discharge disposition was classified as discharge to any facility or home. The comorbidities of the patients who were readmitted and those without a 90-day event were also evaluated. RESULTS: In the TKA population, age, female gender, nonsmoking status, venous thromboembolism (VTE) history, and diabetes were significantly associated with discharge to extended care facility (ECF) on univariate analysis, unlike body mass index. With multivariate analyses, female gender, age, VTE history, and diabetes were associated with ECF placement, but smoking was not. In the total hip arthroplasty population, age, female gender, and nonsmoking status were significantly associated with discharge to ECF on univariate analysis, whereas body mass index, diabetes, and VTE history were not. On multivariate analyses, female gender and age were associated with ECF, but smoking was not. The only significant finding for the readmission data was an increased rate of readmission for TKA patients of older age. CONCLUSION: The potential of projecting patient discharge and readmission allows physicians to counsel patients and improve patient expectations.

The Evaluation of Comorbidities Relative to Length of Stay for Total Joint Arthroplasty Patients.

BACKGROUND: The ability to identify those at risk for longer inpatient stay helps providers with postoperative planning and patient expectations. Decreasing length of stay (LOS) in the future will be determined by appropriate patient selection, risk stratification, and preoperative patient optimization. The purpose of this study was to identify factors that place patients at risk for extended postoperative LOSs. METHODS: The study cohort included 2009 primary total knee arthroplasty (TKA) patients and 905 total hip arthroplasty (THA) patients. Patient comorbidities were prospectively identified and the LOS for each patient was tracked after a primary arthroplasty. Statistical analysis was performed to correlate which comorbidities were associated with longer inpatient stays. RESULTS: In the TKA population, gender, smoking status, venous thromboembolism history, body mass index, and diabetes status were not found to be a significant predictor for the LOS. Age was found to be a factor in univariate regression testing (P < .001). In the THA population, univariate testing showed female gender (P < .001), smoking status (P = .002), and age (P < .001) to be factors, but like the TKA population, venous thromboembolism history or diabetes status was not significant. In THA multivariate analysis, age (P < .001) and female gender (P = .018) continued to be factors, but smoking was determined to be a confounding variable. CONCLUSION: Age and gender were associated with a longer LOS after THA, whereas only age was a significant factor after TKA. Development of age-adjusted LOS models may help aid patient expectations and risk management.

Quality Initiative Programs Can Decrease Total Joint Arthroplasty Transfusion Rates-A Multicenter Study Using the MARCQI Total Joint Registry Database.

BACKGROUND: The Michigan Arthroplasty Registry Collaborative Quality Initiative (MARCQI) noted wide variability between member hospitals in blood transfusion rates after primary total hip and knee arthroplasty (THA and TKA). Blood transfusion has substantial risks and accepted recommendations exist to guide transfusion practices. MARCQI began an initiative to decrease unnecessary transfusions by identifying/reporting outliers, discussing conservative transfusion practices, and recommending transfusion guidelines. There was a later recommendation to consider intraoperative use of tranexamic acid. METHODS: All MARCQI-registered unilateral TKA and THA cases from the 28 member hospitals (pre-November 2013) were included. For 3 time periods (before November 13, 2013; November 13, 2013, to November 12, 2014; and after November 12, 2014), we calculated average risk and range of transfusion, transfusion with nadir hemoglobin >8 g/dL, mean length of stay, and 90-day risk of discharge to nursing home, readmission, deep infection, and emergency department visits. RESULTS: For THA, risk and range of transfusion decreased over the 3 time periods: 12.6% (2.5%-36.2%), 7.6% (2.2%-23.8%), and 4.5% (0.7%-14.4%); for TKA, 6.3% (1.3%-15.6%), 3.1% (0%-12.5%), and 1.3% (0%-7.4%). Decreases were also noted for transfusion with a nadir hemoglobin >8 g/dL with a near elimination of "unnecessary" transfusions. There was no evidence of increase in length of stay, discharge to nursing home, readmission, deep infection, or emergency department visits. CONCLUSION: A simple intervention can decrease unnecessary blood transfusions during and after elective primary unilateral THA or TKA. A collaborative registry can be used effectively to improve the quality of patient care and set a new benchmark for transfusion.

Can an Arthroplasty Registry Help Decrease Transfusions in Primary Total Joint Replacement? A Quality Initiative.

BACKGROUND: Standardized care plans are effective at controlling cost and quality. Registries provide insights into quality and outcomes for use of implants, but most registries do not combine implant and care quality data. In 2012, several Michigan area hospitals and a major insurance provider formed a voluntary statewide total joint database/registry, the Michigan Arthroplasty Registry Collaborative Quality Initiative (MARCQI), to collect procedural, hospital, discharge, and readmission data. Noting substantial variation in transfusion practices after total joint arthroplasty (TJA) in our institutions, we used these prospectively collected data to examine whether awareness and education of the American Association of Blood Banks' (AABB) transfusion guidelines would result in decreased transfusions. QUESTIONS/PURPOSES: (1) Can an established arthroplasty registry help implement a quality initiative (QI) designed to decrease the proportion of transfused postoperative patients undergoing TJA? (2) Do data-driven transfusion protocols decrease length of stay without increasing ischemic complications (myocardial infarctions and cerebrovascular accidents)? (3) Are decreased transfusion proportions associated with decreased readmissions, nonischemic morbidity (including deep vein thrombosis and deep prosthetic infection), and mortality in postoperative patients who had undergone TJA? METHODS: After reviewing data from the recently established MARCQI registry, the orthopaedic department noticed many discrepancies and practice variances regarding blood transfusions among their providers. In October 2013, a QI was implemented to raise awareness of the discrepancies and education about the AABB guidelines was presented at the monthly orthopaedic service line meeting. A total of 1872 TJA cases were reviewed; 50 were excluded for incomplete data and two for intraoperative transfusions for the period before education (May 2012 to June 2013, n = 1240) and after education (November 2013 to April 2014, n = 580). Data collected included gender, age, length of stay, body mass index, preoperative hemoglobin level, lowest postoperative hemoglobin level during admission, transfusion status, number of units transfused, ischemic and nonischemic morbidity, hospital readmissions within 90 days, and mortality. Pre- and post-QI transfusion proportions were calculated. Chi-square test, Student's t-test, and a multivariate analysis were performed to compare differences in transfusion proportions for patients with a postoperative hemoglobin ≥ 8 g/dL. RESULTS: Overall, the percentage of patients transfused with a postoperative hemoglobin ≥ 8 g/dL decreased 80% (6.5% [71 of 1092] versus 1.3% [seven of 538]; odds ratio, 5.3; 95% confidence interval, 2.4-11.6; p < 0.001) after the educational intervention. Before education, 16% (195 of 1240) of all patients undergoing TJA were transfused, whereas 6.5% (71 of 1092) were outside recommended AABB guidelines (hemoglobin ≥ 8 g/dL). In the 6 months after QI initiation, overall transfusions decreased to 6% (35 of 580) with 1.3% (seven of 538) having a hemoglobin ≥ 8 g/dL. The mean length of stay for nontransfused patients was shorter (2.4 days ± 0.9 versus 3.3 days ± 1.1, p < 0.001) and ischemic complications did not differ between groups (0.32% [four of 1240] versus 0.34% [two of 580], p = 0.61). Before and after education, neither the number of readmissions (5.4% [67 of 1240] versus 4.7% [27 of 580], p = 0.50) nor morbidity (3.6% [45 of 1240] versus 2.4% [14 of 580], p = 0.17) differed between time periods. There were no deaths. CONCLUSIONS: Simple education and awareness of quality practices drive safety and compliance. The impact can be immediate and lasting. Arthroplasty registries that combine procedural and care quality data are vital and may be used for important data-driven QIs. LEVEL OF EVIDENCE: Level III, therapeutic study.

Preoperative and Postoperative Opiate Use by the Arthroplasty Patient.

BACKGROUND: As opioid use increases nationally, the arthroplasty surgeon is likely to see more patients taking opioid analgesics on initial presentation. The purpose of this study was to investigate the use of opiate medication in the preoperative and postoperative patient undergoing primary total joint arthroplasty. METHODS: From October 2010 to November 2011, data on 367 consecutive patients who underwent primary total joint arthroplasty were reviewed. Using the Michigan Automated Prescription System database, data were collected on opiate use from 3 months preop to 12 months postop. Patients were grouped by preoperative opiate use. Patients with ≥2 opiate prescriptions filled per 6-week period before surgery were considered chronic opiate users. RESULTS: Three hundred fifteen patients fit our inclusion/exclusion criteria. There were 158 primary total knee and 157 primary total hip arthroplasty patients. At 1 year after operation, 64% of chronic opiate users were still being prescribed opiates compared with 22% of the control group (P < .001). Thirty-one percent of the chronic opiate users were discharged to an extended care facility compared to 21% of the control group (P = .123). Of all the opiate prescriptions, 77% were written by a practitioner other than the surgeon. CONCLUSIONS: Opiates are frequently prescribed by providers other than the surgeon preoperatively and postoperatively. The use of opiates that were presumably prescribed to treat joint pain was continued for more than 1 year postoperatively in 64% of cases. Patients taking multiple opiates or more potent opiates preoperatively filled more prescriptions postoperatively. Chronic use of opiates negatively influenced the discharge disposition.

MRI Findings Associated with Recalled Modular Femoral Neck Rejuvenate and ABG Implants.

MARS-MRI is suggested for the diagnosis of adverse local tissue reactions (ALTR) in patients with recalled femoral stems with modular necks, but there has been no major study looking at MARS-MRI findings in this population. A retrospective review was performed on 312 patients who received a modular neck hip implant between October 2007 and February 2012. 62% of patients had intra-articular effusions, with 27% containing debris. Extra-capsular effusions were present in 35% of hips. 54% had synovitis and 5.4% had osteolysis. Tendinopathy and tendon disruption was present in the gluteus medius (58%/12%), hamstring (56%/12%), gluteus minimus (38%/7.7%) and iliopsoas (7.1%/4.8%). Abnormal MARS-MRI findings are associated with modular neck femoral components and can suggest underlying ALTR. MARS-MRI abnormalities merit serious consideration in this population.

Revision of Recalled Modular Neck Rejuvenate and ABG Femoral Implants.

Modular neck femoral stems have been associated with adverse local tissue reactions (ALTR), leading to a voluntary recall, but these effects have not been well-characterized. A retrospective review of intraoperative findings and cobalt/chromium levels was performed in 103 hips undergoing revision for ALTR. The average preoperative serum cobalt level was 7.6 µg/L (range 1.1-23 µg/L) and chromium level was 1.8 µg/L (range 0.1-6.8 µg/L). Metallic sludge was noted in 100%, synovitis in 98%, pericapsular rind in 82%, and calcar erosion in 85%. An osteotomy was required for removal in 44%. We concluded that revision of modular neck femoral stems is associated with increased preoperative metal ion levels and stem-neck corrosion. Despite advanced stem explantation techniques, osteotomy was frequently required, leading to increased morbidity.