Soluble Prokaryotic Expression and Purification of Bioactive Tumor Necrosis Factor-Related Apoptosis-Inducing Ligand.

Tumor necrosis factor-related apoptosis-inducing ligand (TRAIL) is considered as an antitumor agent owing to its ability to induce apoptosis of cancer cells without imparting toxicity toward most normal cells. TRAIL is produced in poor yield because of its insoluble expression in the cytoplasm of E. coli. In this study, we achieved soluble expression of TRAIL by fusing maltose-binding protein (MBP), b'a' domain of protein disulfide isomerase (PDIb'a'), or protein disulfide isomerase at the N-terminus of TRAIL. The TRAIL was purified using subsequent immobilized metal affinity chromatography and amylose-binding chromatography, with the tag removal using tobacco etch virus protease. Approximately 4.5 mg of pure TRAIL was produced from 125 ml flask culture with a purification yield of 71.6%. The endotoxin level of the final product was 0.4 EU/µg, as measured by the Limulus amebocyte lysate endotoxin assay. The purified TRAIL was validated and shown to cause apoptosis of HeLa cells with an EC50 and Hill coefficient of 0.6 ± 0.03 nM and 2.41 ± 0.15, respectively. The high level of apoptosis in HeLa cells following administration of purified TRAIL indicates the significance and novelty of this method for producing high-grade and high-yield TRAIL.

Granulocyte colony-stimulating factor (GCSF) fused with Fc Domain produced from E. coli is less effective than Polyethylene Glycol-conjugated GCSF.

Human granulocyte colony-stimulating factor (GCSF) is a well-known cytokine for neutropenia treatment. However, daily injections are required due to the short circulating half-life of the protein. To overcome this bottleneck, we fused GCSF with the Fc domain of IgG1 at the C terminus (GCSF-Fc) and with the maltose binding protein (MBP) tag at the N-terminus and expressed it as a soluble protein in the cytoplasm of E. coli. We also conjugated PEG aldehyde to GCSF to make PEG-GCSF. The bioactivities of GCSF-Fc and PEG-GCSF were similar to native GCSF using the mouse M-NFS-60 myelogenous leukemia cell line. The EC50 dose-response curves for GCSF, GCSF-Fc and PEG-GCSF were 37 ± 12 pM, 75 ± 13.5 pM and 46 ± 5.5 pM, respectively. When the proteins were injected into neutropenic rats, the group injected with PEG-GCSF showed the highest and fastest recovery of neutrophils, followed by GCSF-Fc and GCSF. ELISA assay revealed the PEG-GCSF had the longest plasma circulation (>72 h), followed by GCSF-Fc (>48 h) and GCSF (~24 h), which is consistent with the in vivo activities of the proteins. In summary, the GCSF-Fc purified from E. coli was not as efficient as PEG-GCSF in treating neutropenic rats.