Growth conditions inducing G1 cell cycle arrest enhance lipid production in the oleaginous yeast Lipomyces starkeyi.

Lipid droplets are cytoplasmic organelles that store lipids for energy and membrane synthesis. The oleaginous yeast Lipomyces starkeyi is one of the most promising lipid producers and has attracted attention as a biofuel source. It is known that the expansion of lipid droplets is enhanced under nutrient-poor conditions. Therefore, we prepared a novel nitrogen-depleted medium (N medium) in which to culture L. starkeyi cells. Lipid accumulation was rapidly induced, and this was reversed by the addition of ammonium. In this condition, cell proliferation stopped, and cells with giant lipid droplets were arrested in G1 phase. We investigated whether cell cycle arrest at a specific phase is required for lipid accumulation. Lipid accumulation was repressed in hydroxyurea-synchronized S phase cells and was increased in nocodazole-arrested G2/M phase cells. Moreover, the enrichment of G1 phase cells seen upon rapamycin treatment induced massive lipid accumulation. From these results, we conclude that L. starkeyi cells store lipids from G2/M phase and then arrest cell proliferation in the subsequent G1 phase, where lipid accumulation is enhanced. Cell cycle control is an attractive approach for biofuel production.

Nitrogen starvation causes lipid remodeling in Rhodotorula toruloides.

BACKGROUND: The oleaginous yeast Rhodotorula toruloides is a promising chassis organism for the biomanufacturing of value-added bioproducts. It can accumulate lipids at a high fraction of biomass. However, metabolic engineering efforts in this organism have progressed at a slower pace than those in more extensively studied yeasts. Few studies have investigated the lipid accumulation phenotype exhibited by R. toruloides under nitrogen limitation conditions. Consequently, there have been only a few studies exploiting the lipid metabolism for higher product titers. RESULTS: We performed a multi-omic investigation of the lipid accumulation phenotype under nitrogen limitation. Specifically, we performed comparative transcriptomic and lipidomic analysis of the oleaginous yeast under nitrogen-sufficient and nitrogen deficient conditions. Clustering analysis of transcriptomic data was used to identify the growth phase where nitrogen-deficient cultures diverged from the baseline conditions. Independently, lipidomic data was used to identify that lipid fractions shifted from mostly phospholipids to mostly storage lipids under the nitrogen-deficient phenotype. Through an integrative lens of transcriptomic and lipidomic analysis, we discovered that R. toruloides undergoes lipid remodeling during nitrogen limitation, wherein the pool of phospholipids gets remodeled to mostly storage lipids. We identify specific mRNAs and pathways that are strongly correlated with an increase in lipid levels, thus identifying putative targets for engineering greater lipid accumulation in R. toruloides. One surprising pathway identified was related to inositol phosphate metabolism, suggesting further inquiry into its role in lipid accumulation. CONCLUSIONS: Integrative analysis identified the specific biosynthetic pathways that are differentially regulated during lipid remodeling. This insight into the mechanisms of lipid accumulation can lead to the success of future metabolic engineering strategies for overproduction of oleochemicals.

Identification and characterization of the suppressed lipid accumulation-related gene, SLA1, in the oleaginous yeast Lipomyces starkeyi.

The oleaginous yeast Lipomyces starkeyi is an attractive industrial yeast that can accumulate high amounts of intracellular lipids. Identification of genes involved in lipid accumulation contributes not only to elucidating the lipid accumulation mechanism but also to breeding industrially useful high lipid-producing strains. In this study, the suppressed lipid accumulation-related gene (SLA1) was identified as the causative gene of the sr22 mutant with decreased lipid productivity. SLA1 mutation reduced gene expression in lipid biosynthesis and increased gene expression in ß-oxidation. Our results suggest that SLA1 mutation may leads to decreased lipid productivity. SLA1 deletion also exhibited decreased gene expression in ß-oxidation and increased lipid accumulation, suggesting that SLA1 deletion is a useful tool to improve lipid accumulation in L. starkeyi for industrialization.

Expanding the genetic toolbox for Cutaneotrichosporon oleaginosus employing newly identified promoters and a novel antibiotic resistance marker.

BACKGROUND: Cutaneotrichosporon oleaginosus is an oleaginous yeast that can produce up to 80% lipid per dry weight. Its high capacity for the biosynthesis of single cell oil makes it highly interesting for the production of engineered lipids or oleochemicals for industrial applications. However, the genetic toolbox for metabolic engineering of this non-conventional yeast has not yet been systematically expanded. Only three long endogenous promoter sequences have been used for heterologous gene expression, further three dominant and one auxotrophic marker have been established. RESULTS: In this study, the structure of putative endogenous promoter sequences was analyzed based on more than 280 highly expressed genes. The identified motifs of regulatory elements and translational initiation sites were used to annotate the four endogenous putative promoter sequences D9FADp, UBIp, PPIp, and 60Sp. The promoter sequences were tested in a construct regulating the known dominant marker hygromycin B phosphotransferase. The four newly described promoters and the previously established GAPDHp successfully initiated expression of the resistance gene and PPIp was selected for further marker development. The geneticin G418 resistance (aminoglycoside 3'-phosphotransferase, APH) and the nourseothricin resistance gene N-acetyl transferase (NAT) were tested for applicability in C. oleaginosus. Both markers showed high transformation efficiency, positive rate, and were compatible for combined use in a successive and simultaneous manner. CONCLUSIONS: The implementation of four endogenous promoters and one novel dominant resistance markers for C. oleaginosus opens up new opportunities for genetic engineering and strain development. In combination with recently developed methods for targeted genomic integration, the established toolbox allows a wide spectrum of new strategies for genetic and metabolic engineering of the industrially highly relevant yeast.

Hannaella oleicumulans sp. nov. and Hannaella higashiohmiensis sp. nov., two novel oleaginous basidiomycetous yeast species.

Three strains of novel oleaginous yeast species were isolated from soil samples collected in Shiga Prefecture, Japan. The sequences of the internal transcribed spacer (ITS) region and the D1/D2 region of the large subunit (LSU) of the rRNA genes indicated that these novel yeast species are members of the genus Hannaella. The results of molecular phylogenetic analysis indicated that strains 38-3 and 8s1 were closely related to Hannaella oryzae. They differed by 10 nucleotide substitutions and one gap (1.77 %) in the D1/D2 region of the LSU of the rRNA genes and by 17-18 nucleotide substitutions and 10-11 gaps (5.45-5.85 %) in the ITS region. Strain 51-4 differed from the type strain of the most closely related species, Hannaella pagnoccae, by 26 nucleotide substitutions (4.46 %) in the D1/D2 region of the LSU of the rRNA genes and by 20 nucleotide substitutions and six gaps (5.42 %) in the ITS region. The names proposed for these previously undescribed species are Hannaella oleicumulans sp. nov. and Hannaella higashiohmiensis sp. nov.

Challenges and prospects of yeast-based microbial oil production within a biorefinery concept.

Biodiesel, unlike to its fossil-based homologue (diesel), is renewable. Its use contributes to greater sustainability in the energy sector, mainly by reducing greenhouse gas emissions. Current biodiesel production relies on plant- and animal-related feedstocks, resulting in high final costs to the prices of those raw materials. In addition, the production of those materials competes for arable land and has provoked a heated debate involving their use food vs. fuel. As an alternative, single-cell oils (SCOs) obtained from oleaginous microorganisms are attractive sources as a biofuel precursor due to their high lipid content, and composition similar to vegetable oils and animal fats. To make SCOs competitive from an economic point of view, the use of readily available low-cost substrates becomes essential. This work reviews the most recent advances in microbial oil production from non-synthetic sugar-rich media, particularly sugars from lignocellulosic wastes, highlighting the main challenges and prospects for deploying this technology fully in the framework of a Biorefinery concept.

Mastering targeted genome engineering of GC-rich oleaginous yeast for tailored plant oil alternatives for the food and chemical sector.

BACKGROUND: Sustainable production of triglycerides for various applications is a major focus of microbial factories. Oleaginous yeast species have been targeted for commercial production of microbial oils. Among all the oleaginous yeasts examined in a previous comparative study, Cutaneotrichosporon oleaginosus showed the highest lipid productivity. Moreover, a new lipid production process for C. oleaginosus with minimal waste generation and energy consumption resulted in the highest lipid productivity in the history of oleaginous yeasts. However, productivity and product diversity are restricted because of the genetic intractability of this yeast. To date, successful targeted genetic engineering of C. oleaginosus has not yet been reported. RESULTS: The targeted gene editing was successfully carried out in C. oleaginosus using CRISPR/Cas system. A tailored enzyme system isolated to degrade the C. oleaginosus cell wall enabled the isolation of viable spheroplasts that are amenable to in-cell delivery of nucleic acids and proteins. The employment of both Cas9 protein and Cas mRNA was effective in obtaining strains with URA5 knockout that did not exhibit growth in the absence of uracil. Subsequently, we successfully created several strains with enhanced lipid yield (54% increase compared to that in wild type) or modified fatty acid profiles comparable with those of cocoa butter or sunflower oil compositions. CONCLUSION: This study establishes the first targeted engineering technique for C. oleaginosus using the CRISPR/Cas system. The current study creates the foundation for flexible and targeted strain optimizations towards building a robust platform for sustainable microbial lipid production. Moreover, the genetic transformation of eukaryotic microbial cells using Cas9 mRNA was successfully achieved.

LsSpt23p is a regulator of triacylglycerol synthesis in the oleaginous yeast Lipomyces starkeyi.

The oleaginous yeast Lipomyces starkeyi has considerable potential in industrial application, since it can accumulate a large amount of triacylglycerol (TAG), which is produced from sugars under nitrogen limitation condition. However, the regulation of lipogenesis in L. starkeyi has not been investigated in depth. In this study, we compared the genome sequences of wild-type and mutants with increased TAG productivity, and identified a regulatory protein, LsSpt23p, which contributes to the regulation of TAG synthesis in L. starkeyi. L. starkeyi mutants overexpressing LsSPT23 had increased TAG productivity compared with the wild-type strain. Quantitative real-time PCR analysis showed that LsSpt23p upregulated the expression of GPD1, which encodes glycerol 3-phosphate dehydrogenase; the Kennedy pathway genes SCT1, SLC1, PAH1, DGA1, and DGA2; the citrate-mediated acyl-CoA synthesis pathway-related genes ACL1, ACL2, ACC1, FAS1, and FAS2; and OLE1, which encodes ∆9 fatty acid desaturase. Chromatin immunoprecipitation-quantitative PCR assays indicated that LsSpt23p acts as a direct regulator of SLC1 and PAH1, all the citrate-mediated acyl-CoA synthesis pathway-related genes, and OLE1. These results indicate that LsSpt23p regulates TAG synthesis. Phosphatidic acid is a common substrate of phosphatidic acid phosphohydrolase, which is used for TAG synthesis, and phosphatidate cytidylyltransferase 1 for phospholipid synthesis in the Kennedy pathway. LsSpt23p directly regulated PAH1 but did not affect the expression of CDS1, suggesting that the preferred route of carbon is the Pah1p-mediated TAG synthesis pathway under nitrogen limitation condition. The present study contributes to understanding the regulation of TAG synthesis, and will be valuable in future improvement of TAG productivity in oleaginous yeasts. KEY POINTS: LsSpt23p was identified as a positive regulator of TAG biosynthesis LsSPT23 overexpression enhanced TAG biosynthesis gene expression and TAG production LsSPT23M1108T overexpression mutant showed fivefold higher TAG production than control.

The monitoring of oil production process by deep learning based on morphology in oleaginous yeasts.

BACKGROUND: Monitoring jar fermenter-cultured microorganisms in real time is important for controlling productivity of bioproducts in large-scale cultivation settings. Morphological data is used to understand the growth and fermentation states of these microorganisms during monitoring. Oleaginous yeasts are used for their high productivity of single-cell oils but the relationship between lipid productivity and morphology has not been elucidated in these organisms. RESULTS: In this study, we investigated the relationship between the morphology of oleaginous yeasts (Lipomyces starkeyi and Rhodosporidium toruloides were used) and their cultivation state in a large-scale cultivation setting using a real-time monitoring system. We combined this with deep learning by feeding a large amount of high-definition cell images obtained from the monitoring system to a deep learning algorithm. Our results showed that the cell images could be grouped into 7 distinct groups and that a strong correlation existed between each group and its biochemical activity (growth and oil-productivity). CONCLUSIONS: This is the first report describing the morphological variations of oleaginous yeasts in a large-scale cultivation, and describes a promising new avenue for improving productivity of microorganisms in large-scale cultivation through the use of a real-time monitoring system combined with deep learning. KEY POINTS: • A real-time monitoring system followed the morphological change of oleaginous yeasts. • Deep learning grouped them into 7 distinct groups based on their morphology. • A correlation between the cultivation state and the shape of the yeast was observed.

Effect of carbon and nitrogen concentrations on lipid accumulation and regulation of acetyl-CoA carboxylase in Papiliotrema laurentii.

Biodiesel is an interesting alternative to petroleum diesel as it is renewable, biodegradable, and has a low pollutant content. Yeast oils can be used for biodiesel production instead of edible oils, mitigating the use of arable land and water for biodiesel production. Maximum lipid accumulation is reached at 48 h of cultivation by the oleaginous yeast Papiliotrema laurentii UFV-1. Nevertheless, the effects of carbon and nitrogen concentrations on lipid accumulation, as well as the regulation of lipid metabolism in this yeast are still not well-characterised. Therefore, this work evaluated the effects of carbon and nitrogen concentrations on the lipid accumulation in P. laurentti, the expression of the ACC gene, and the activity of the enzyme acetyl-CoA carboxylase (ACCase) in different carbon:nitrogen ratios (C:N) and glucose concentrations. The variation of ammonium sulfate concentration did not affect the growth and lipid accumulation in P. laurentii UFV-1. On the other hand, glucose concentration remarkably influenced biomass and lipid production by this yeast. Therefore, the carbon concentration is more important than the nitrogen concentration for lipid production by P. laurentii UFV-1. Importantly, the levels of both ACC gene expression and ACCase activity were maximum during the late-exponential growth phase and decreased after reaching the highest lipid contents, which was easier evidenced during the accumulation and maximum lipid levels. As such, the reduction of ACCase enzyme activity seems to be related to the decrease in the expression level of the ACC gene.

Determining mating type and ploidy in Rhodotorula toruloides and its effect on growth on sugars from lignocellulosic biomass.

Rhodotorula toruloides is being developed for the use in industrial biotechnology processes because of its favorable physiology. This includes its ability to produce and store large amounts of lipids in the form of intracellular lipid bodies. Nineteen strains were characterized for mating type, ploidy, robustness for growth, and accumulation of lipids on inhibitory switchgrass hydrolysate (SGH). Mating type was determined using a novel polymerase chain reaction (PCR)-based assay, which was validated using the classical microscopic test. Three of the strains were heterozygous for mating type (A1/A2). Ploidy analysis revealed a complex pattern. Two strains were triploid, eight haploid, and eight either diploid or aneuploid. Two of the A1/A2 strains were compared to their parents for growth on 75%v/v concentrated SGH. The A1/A2 strains were much more robust than the parental strains, which either did not grow or had extended lag times. The entire set was evaluated in 60%v/v SGH batch cultures for growth kinetics and biomass and lipid production. Lipid titers were 2.33-9.40 g/L with a median of 6.12 g/L, excluding the two strains that did not grow. Lipid yields were 0.032-0.131 (g/g) and lipid contents were 13.5-53.7% (g/g). Four strains had significantly higher lipid yields and contents. One of these strains, which had among the highest lipid yield in this study (0.131 ± 0.007 g/g), has not been previously described in the literature. SUMMARY: The yeast Rhodotorula toruloides was used to produce oil using sugars extracted from a bioenergy grass.

Simultaneous Lipid and Carotenoid Production via Rhodotorula paludigena CM33 Using Crude Glycerol as the Main Substrate: Pilot-Scale Experiments.

Rhodotorula paludigena CM33 is an oleaginous yeast that has been demonstrated to accumulate substantial quantities of intracellular lipids and carotenoids. In this study, crude glycerol, a by-product of biodiesel production, was used as a carbon source to enhance the accumulation of lipids and carotenoids in the cells. The culture conditions were first optimized using response surface methodology, which revealed that the carotenoid concentration and lipid content improved when the concentration of crude glycerol was 40 g/L. Different fermentation conditions were also investigated: batch, repeated-batch, and fed-batch conditions in a 500 L fermenter. For fed-batch fermentation, the maximum concentrations of biomass, lipids, and carotenoids obtained were 46.32 g/L, 37.65%, and 713.80 mg/L, respectively. A chemical-free carotenoid extraction method was also optimized using high-pressure homogenization and a microfluidizer device. The carotenoids were found to be mostly beta-carotene, which was confirmed by HPLC (high pressure liquid chromatography), LC-MS (liquid chromatography-mass spectrometry), and NMR (nuclear magnetic resonance). The results of this study indicate that crude glycerol can be used as a substrate to produce carotenoids, resulting in enhanced value of this biodiesel by-product.

Sequential bioconversion of C1-gases (CO, CO2, syngas) into lipids, through the carboxylic acid platform, with Clostridium aceticum and Rhodosporidium toruloides.

Syngas (CO, CO2, H2) was effectively bioconverted into lipids in a two-stage process. In the first stage, C1-gases were bioconverted into acetic acid by the acetogenic species Clostridium aceticum through the Wood-Ljungdahl metabolic pathway in a stirred tank bioreactor, reaching a maximum acetic acid concentration of 11.5 g/L, with a production rate of 0.05 g/L·h. Throughout this experiment, samples were extracted at different periods, i.e., different concentrations, to be used in the second stage, aiming at the production of lipids from acetic acid. The yeast Rhodosporidium toruloides, inoculated in the acetogenic medium, was able to efficiently accumulate lipids from acetic acid generated in the first stage. The best results, in terms of lipid content, dry biomass, biomass yield (Y(X/S)) and lipid yield (Y(L/S)) were 39.5% g/g dry cell weight, 3 g/L, 0.35 and 0.107, respectively. In terms of abundance, the lipid profile followed the order: C18:1 > C16:0 > C18:2 > C18:0 > Others. Experiments were also performed to determine the toxicity exerted by high concentrations of acetic acid on R. toruloides, resulting in inhibition at initial acid concentrations around 18 g/L leading to a higher lag phase and being lethal to the yeast at initial acetic acid concentrations around 22 g/L and above. This research paves the way for a novel method of growing oleaginous yeasts to produce sustainable biofuels from syngas or C1-pollutant gases.

Biodiesel production and properties estimation from food waste and domestic wastewater by Rhodosporidium toruloides.

Producing biodiesel from food waste (FW) would benefit both environment and economy. Current study investigated biodiesel production from food waste and domestic wastewater by utilizing the oleaginous yeast Rhodosporidium toruloides under non-sterile condition. The potential of biolipid production from the mixture of effluents of existing local FW treatment facilities and domestic wastewater was firstly evaluated. Then, to increase the nutrient recovery efficiency, FW hydrolysis process by crude enzymes produced from solid FWs by Aspergillus oryzae was introduced and the conditions were further optimized. The optimized hydrolysis process resulted in reducing sugar (RS) yield of 251.81 ± 8.09 mg gdryFW-1 and free amino nitrogen (FAN) yield of 7.70 ± 0.74 mg gdryFW-1 while waste oil with the RS yield of 93.54 ± 0.01 mg gdryFW-1 was easily separated without solvent usage. Compared to the hydrolysate only used, when mixed with domestic wastewater, the results showed obvious enhancement on biomass yield, biolipid yield, and wastewater treatment efficiency. The maximum biolipid yield was 29.80 ± 0.50 mg gdryFW-1 and the estimated quality of biodiesel produced from the biolipid met both EN 14214 and ASTM D6751 standards.

Increasing lipid production from Zygosaccharomyces siamensis AP1 in molasses substrate using sequencing batch method.

Yeasts are considered potential lipid producers to substitute oil-producing plants. Previous study succeeded in isolating Zygosaccharomyces siamensis AP1 from Indonesia which was able to accumulate 19% lipid. The strain, however, was not optimized for high cell density growth which is required for industry-level. In this study, efforts were made to increase cell density and lipid production of Z. siamensis AP1 using molasses as carbon source and implementing sequencing batch method. The yeast was grown in various combinations of carbon and nitrogen sources. The C:N ratio of the best substrate combination is then optimized. Afterwards, batch and sequencing batch methods were applied in fermentation with various concentrations (20-480 g/L) of molasses. The results show that lipid produced using molasses was slightly higher compared to using glucose, 0.21 g/L and 0.19 g/L respectively, with the same nitrogen source. Combination of molasses and ammonium sulfate with C:N ratio 70:1 gave the highest lipid (0.28 g/L). Sequencing batch able to increase cell density 2.4-fold compared to batch method. This study was the first to report that sequencing batch application with molasses as carbon source can increase lipid production from Z. siamensis. Further study to optimize medium composition for sequencing batch is suggested.

Mitochondrial dynamics and degradation in the oleaginous yeast Lipomyces starkeyi.

Emerging evidence implicates the vital role of mitochondria in lipid consumption and storage, highlighting the intimate link between energy production and saving. Although formation of giant lipid droplets, which is the key hallmark of the oleaginous yeast Lipomyces starkeyi, appears to be regulated in response to changes in mitochondrial shape and metabolism, technical limitations of genetic manipulation have become an obstacle to uncover the mitochondrial behavior in this nonconventional yeast. Here, we established an L. starkeyi strain stably expressing a fluorescent marker for monitoring mitochondrial morphology and degradation and found that mitochondria are mostly fragmented in L. starkeyi cells under fermentable, nonfermentable, and nitrogen depletion conditions. Notably, a fraction of mitochondria-specific fluorescent signals was localized to the vacuole, a lytic organelle in yeast, indicating degradation of mitochondria in those cells. This possible catabolic event was more predominant in cells under nutrient-poor conditions than that in cells under nutrient-rich conditions, concomitantly with lipid droplet formation. Collectively, our studies provide a new tool to investigate mitochondrial dynamics in L. starkeyi and decipher the potential role of mitochondrial degradation in lipid metabolism.

Screening of xylose utilizing and high lipid producing yeast strains as a potential candidate for industrial application.

BACKGROUND: Sustainable production of oil for food, feed, fuels and other lipid-based chemicals is essential to meet the demand of the increasing human population. Consequently, novel and sustainable resources such as lignocellulosic hydrolysates and processes involving these must be explored. In this paper we screened for naturally-occurring xylose utilizing oleaginous yeasts as cell factories for lipid production, since pentose sugar catabolism plays a major role in efficient utilization of lignocellulosic feedstocks. Glycerol utilization, which is also beneficial in yeast-based oil production as glycerol is a common by-product of biodiesel production, was investigated as well. Natural yeast isolates were studied for lipid accumulation on a variety of substrates, and the highest lipid accumulating strains were further investigated in shake flask cultivations and fermenter studies on xylose and hydrolysate. RESULTS: By collecting leaves from exotic plants in greenhouses and selective cultivation on xylose, a high frequency of oleaginous yeasts was obtained (> 40%). Different cultivation conditions lead to differences in fatty acid contents and compositions, resulting in a set of strains that can be used to select candidate production strains for different purposes. In this study, the most prominent strains were identified as Pseudozyma hubeiensis BOT-O and Rhodosporidium toruloides BOT-A2. The fatty acid levels per cell dry weight after cultivation in a nitrogen limited medium with either glucose, xylose or glycerol as carbon source, respectively, were 46.8, 43.2 and 38.9% for P. hubeiensis BOT-O, and 40.4, 27.3 and 42.1% for BOT-A2. Furthermore, BOT-A2 accumulated 45.1% fatty acids per cell dry weight in a natural plant hydrolysate, and P. hubeiensis BOT-O showed simultaneous glucose and xylose consumption with similar growth rates on both carbon sources. The fatty acid analysis demonstrated both long chain and poly-unsaturated fatty acids, depending on strain and medium. CONCLUSIONS: We found various natural yeast isolates with high lipid production capabilities and the ability to grow not only on glucose, but also xylose, glycerol and natural plant hydrolysate. R. toruloides BOT-A2 and P. hubeiensis BOT-O specifically showed great potential as production strains with high levels of storage lipids and comparable growth to that on glucose on various other substrates, especially compared to currently used lipid production strains. In BOT-O, glucose repression was not detected, making it particularly desirable for utilization of plant waste hydrolysates. Furthermore, the isolated strains were shown to produce oils with fatty acid profiles similar to that of various plant oils, making them interesting for future applications in fuel, food or feed production.

Ultra-centrifugation force in adaptive evolution changes the cell structure of oleaginous yeast Trichosporon cutaneum into a favorable space for lipid accumulation.

Microbial lipid production from lignocellulose biomass provides an essential option for sustainable and carbon-neutral supply of future aviation fuels, biodiesel, as well as various food and nutrition products. Oleaginous yeast is the major microbial cell factory but its lipid-producing performance is far below the requirements of industrial application. Here we show an ultra-centrifugation fractionation in adaptive evolution (UCF) of Trichosporon cutaneum based on the minor cell density difference. The lightest cells with the maximum intracellular lipid content were isolated by ultra-centrifugation fractionation in the long-term adaptive evolution. Significant changes occurred in the cell morphology with a fragile cell wall wrapping and enlarged intracellular space (two orders of magnitude increase in cell size). Complete and coordinate assimilations of all nonglucose sugars derived from lignocellulose were triggered and fluxed into lipid synthesis. Genome mutations and significant transcriptional regulations of the genes responsible for cell structure were identified and experimentally confirmed. The obtained T. cutaneum MP11 cells achieved a high lipid production of wheat straw, approximately five-fold greater than that of the parental cells. The study provided an effective method for screening the high lipid-containing oleaginous yeast cells as well as the intracellular products accumulating cells in general.

Liquid wastes as a renewable feedstock for yeast biodiesel production: Opportunities and challenges.

Microbial lipids (bacterial, yeast, or algal) production and its utilization as a feedstock for biodiesel production in a sustainable and economical way along with waste degradation is a promising technology. Oleaginous yeasts have demonstrated multiple advantages over algae and bacteria such as high lipid yields, lipid similarity to vegetable oil, and requirement of lesser area for cultivation. Oleaginous yeasts grown on lignocellulosic solid waste as renewable feedstocks have been widely reported and reviewed. Recently, industrial effluents and other liquid wastes have been evaluated as feedstocks for biodiesel production from oleaginous yeasts. The idea of the utilization of wastewater for the growth of oleaginous yeasts for simultaneous wastewater treatment and lipid production is gaining attention among researchers. However, the detailed knowledge on the economic aspects of different process involved during the conversion of oleaginous yeast into lipids hinders its large-scale application. Therefore, this review aims to provide an overview of yeast-derived biodiesel production by utilizing industrial effluents and other liquid wastes as feedstocks. Various technologies for biomass harvesting, lipid extraction and the economic aspects specifically focused on yeast biodiesel production were also analyzed and reported in this review. The utilization of liquid wastes and the incorporation of cost-efficient harvesting and lipid extraction strategy would facilitate large-scale commercialization of biodiesel production from oleaginous yeasts in near future.

Recent advances in genetic technology development of oleaginous yeasts.

As important chemical raw materials and potential nutritional supplements, microbial lipids play an important role in ensuring economic development, food security, and energy security. Compared with non-natural hosts, oleaginous yeasts exhibit obvious advantages in lipid yield and productivity and have great potential to be genetically engineered into an oil cell factory. The main bottleneck in the current oleaginous yeasts engineering is the lack of genetic manipulation tools. Fortunately, the rapid development of synthetic biology has provided numerous new approaches, resources, and ideas for the field. Most importantly, gene editing technology mediated by CRISPR/Cas systems has been successfully applied to some oleaginous yeasts, almost completely rewriting the development pattern of genetic manipulation technology applicable. This paper reviews recent progress in genetic technology with regard to oleaginous yeasts, with a special focus on transformation methods and genome editing tools, discussing the effects of some important genetic parts. KEY POINTS: •Contribution of microbiotechnology in food safety and biofuel by oleaginous yeasts. •Advancement of genetic manipulation and transformation for oleaginous yeasts.