Design and assessment of an active anti-epidermal growth factor receptor (EGFR) single chain variable fragment (ScFv) with improved solubility.

ScFv is emerging as a therapeutic alternative to the full-length monoclonal antibodies due to its small size and low production cost, but its low solubility remains a limiting factor toward wider use. Here, we increased the solubility of an Anti-epidermal growth factor receptor ScFv (Anti-EGFR ScFv) by attaching, a short 12-residue solubility enhancing peptide (SEP) tag at its C terminus. We first estimated the solubility increase by running 500-ns Brownian dynamics (BD) simulations. We then experimentally evaluated the predictions by producing recombinant Anti-EGFR ScFv with and without a SEP tag (called C9R) in E. coli. At 20 °C, ∼85% of Anti-EGFR ScFv-C9R expressed in the soluble fraction, whereas all of the Anti-EGFR ScFv remained in the insoluble fraction. The total yield of Anti-EGFR ScFv-C9R was 17.15 mg which was ∼3 times higher than that of Anti-EGFR ScFv refolded from the insoluble fraction. Static and dynamic light scattering demonstrated the higher solubility of the purified Anti-EGFR ScFv-C9R, and Circular Dichroism (CD) indicated its high thermal stability, whereas the untagged protein aggregated at 37 °C and pH 6. Finally, the binding activity of Anti-EGFR ScFv-C9R to EGFR was confirmed by surface plasmon resonance (SPR). Altogether, these results illustrate the improved biophysical and biochemical characteristics of Anti-EGFR ScFv-C9R and emphasize the potentials of SEP-tags for enhancing the solubility of aggregation-prone antibody fragments.

Biophysical analysis of Gaussia luciferase bioluminescence mechanisms using a non-oxidizable coelenterazine.

Gaussia luciferase (GLuc 18.2kDa; 168 residues) is a marine copepod luciferase that emits a bright blue light when oxidizing coelenterazine (CTZ). It is a helical protein where two homologous sequential repeats form two anti-parallel bundles, each made of four helices. We previously identified a hydrophobic cavity as a prime candidate for the catalytic site, but GLuc's fast bioluminescence reaction hampered a detailed analysis. Here, we used azacoelenterazine (Aza-CTZ), a non-oxidizable coelenterazine (CTZ) analog, as a probe to investigate its binding mode to GLuc. While analysing GLuc's activity, we unexpectedly found that salt and monovalent anions are absolutely required for Gluc's bioluminescence, which retrospectively appears reasonable for a sea-dwelling organism. The NMR-based investigation, using chemical shift perturbations monitored by 15N-1H HSQC, suggested that Aza-CTZ (and thus unoxidized CTZ) binds to residues in or near the hydrophobic cavity. These NMR data are in line with a recent structural prediction of GLuc, hypothesizing that large structural changes occur in regions remote from the hydrophobic cavity upon the addition of CTZ. Interestingly, these results point toward a unique mode of catalysis to achieve CTZ oxidative decarboxylation.

Anti-EGFR VHH Antibody under Thermal Stress Is Better Solubilized with a Lysine than with an Arginine SEP Tag.

In this study, we assessed the potential of arginine and lysine solubility-enhancing peptide (SEP) tags to control the solubility of a model protein, anti-EGFR VHH-7D12, in a thermally denatured state at a high temperature. We produced VHH-7D12 antibodies attached with a C-terminal SEP tag made of either five or nine arginines or lysines (7D12-C5R, 7D12-C9R, 7D12-C5K and 7D12-C9K, respectively). The 5-arginine and 5-lysine SEP tags increased the E. coli expression of VHH-7D12 by over 80%. Biophysical and biochemical analysis confirmed the native-like secondary and tertiary structural properties and the monomeric nature of all VHH-7D12 variants. Moreover, all VHH-7D12 variants retained a full binding activity to the EGFR extracellular domain. Finally, thermal stress with 45-minute incubation at 60 and 75 °C, where VHH-7D12 variants are unfolded, showed that the untagged VHH-7D12 formed aggregates in all of the four buffers, and the supernatant protein concentration was reduced by up to 35%. 7D12-C5R and 7D12-C9R did not aggregate in Na-acetate (pH 4.7) and Tris-HCl (pH 8.5) but formed aggregates in phosphate buffer (PB, pH 7.4) and phosphate buffer saline (PBS, pH 7.4). The lysine tags (either C5K or C9K) had the strongest solubilization effect, and both 7D12-C5K and 7D12-C9K remained in the supernatant. Altogether, our results indicate that, under a thermal stress condition, the lysine SEP tags solubilization effect is more potent than that of an arginine SEP tags, and the SEP tags did not affect the structural and functional properties of the protein.