RESUMO
Donkey milk is characterized by low contents of total solids, fat, and caseins, especially κ-casein, which results in formation of a very weak gel upon renneting. The objective of this study was to evaluate the effect of fortification of donkey milk with microbial transglutaminase (MTGase) for cheesemaking in relation to different enzyme addition protocols (patterns, PAT). Four independent trials were performed using MTGase (5.0 U/g of milk protein) according to the following experimental patterns: control (no MTGase addition); MTGase addition (40°C) 15 min before starter inoculation (PAT1); addition of MTGase to milk simultaneously with starter culture (40°C) (PAT2); and MTGase addition simultaneously with rennet (42°C) in acidified milk (pH 6.3) (PAT3). Evolution of pH during acidification, cheesemaking parameters, and proximal composition and color of cheese at 24 h were recorded. The protein fractions of cheese and whey were investigated by urea-PAGE and sodium dodecyl sulfate-PAGE. Addition of MTGase had no significant effect on moisture, protein, fat, or cheese yield. The addition of MTGase with rennet (PAT3) improved curd firmness compared with the control. Among the different patterns of MTGase addition, PAT3 reduced gel formation time, time between rennet addition and cheese molding, and weight loss of cheese at 24 h. The PAT3 treatment also resulted in the lowest lightness and highest yellowness color values of the cheese. Sodium dodecyl sulfate-PAGE of cheeses revealed that MTGase modified the protein pattern in the high-molecular-weight zone (range 37-75 kDa) compared with the control. Of the MTGase protocols, PAT3 showed better casein retention in cheese, as confirmed by the lanes of α- and ß-caseins in the electropherogram of the whey, which was subtler for this protocol. In conclusion, MTGase may be used in cheese production from donkey milk to improve curd firmness; MTGase should be added simultaneously with the rennet.
Assuntos
Queijo , Leite , Transglutaminases/metabolismo , Animais , Quimosina/química , Equidae , Manipulação de Alimentos , Leite/química , Leite/metabolismo , Proteínas do Leite/metabolismo , Proteínas do Soro do Leite/metabolismoRESUMO
Lactose intolerance is the decreased ability to digest lactose, and the population involved is rapidly increasing all over the world. Different procedures have been reported in the literature to quantify lactose in dairy products, but the official method of analysis is based on enzymatic assay. In this paper, the effectiveness of two enzymatic kits in detecting residual lactose in lactose-free milk was investigated, and a comparison with two alternative chromatographic methods was done. The investigation used several samples of UHT milk containing different levels of lactose, and the results highlighted the inadequacy of the enzymatic assays and of the HPLC-RI method to analyse lactose-free milk. An LC-MS/MS method using the formate adduct was developed, and it allowed quantitation of lactose and lactulose in all samples at a high level of precision and repeatability.
Assuntos
Leite/química , Animais , Cromatografia Líquida de Alta Pressão , Ensaios Enzimáticos , Lactose , Espectrometria de Massas em TandemRESUMO
Canestrato di Moliterno is an Italian Protected Geographical Indication hard cheese, made in winter and spring from a mixture of ewe and goat milks, that has been poorly investigated. The present study was aimed at characterizing the cheese made in the warm season. Two series of samples, ripened in traditional rooms called fondaco as indicated in the official protocol of production, were taken from the main certified producers. The cheeses were analyzed for gross composition; proteolysis and lipolysis; volatile fraction; and organoleptic features. Gross composition was not completely homogeneous among the samples, but primary proteolysis and lipolysis were quite uniform. We observed variations in secondary proteolysis, likely caused by fluctuations in environmental conditions in the fondaco. The sensory profiles of the samples were homogeneous: the cheese was soluble, greasy, and adhesive, with a sheepfold and buttery odor. The main taste attributes were fermented, pungent, and bitter. Overall, the results of this study provide an initial contribution to the characterization of Canestrato di Moliterno, and could be used to improve marketing strategies.
Assuntos
Queijo/análise , Cabras , Estações do Ano , Sensação , Ovinos , Animais , Feminino , Manipulação de Alimentos/métodos , Itália , Lipólise , Leite/química , Proteólise , PaladarRESUMO
Innovation in the small ruminant dairy sector faces structural challenges because dairies are often involved in breeding and produce cheeses that appeal essentially to local markets using traditional technologies and facilities. An investigation was carried out to produce Fior di latte, a traditional, soft pasta filata cheese, from sheep and goat milks at the farm level. Fior di latte is an Italian high-moisture, round mozzarella currently produced from cow and water buffalo milks; it is very popular in Europe. Cheesemaking trials were performed and the most appropriate technology proved to be a combination of direct acidification and lactic fermentation, with some modifications to the milk coagulation phase. The gross composition of the experimental cheeses was similar to that of bovine Fior di latte, and the overall hygienic quality was satisfactory even though the milk had not been pasteurized. The new cheeses were similar in appearance to the bovine type, but some specific features were detected. Besides the typical "goaty" and "sheepy" flavors, some novel and distinctive descriptors of odor, flavor, and texture were noted. Our experiment showed that good quality Fior di latte cheese that complies with microbiological requirements of the European legislation can be obtained from sheep and goat milks by appropriately modifying the cheesemaking technology.
Assuntos
Queijo/análise , Manipulação de Alimentos/métodos , Leite/química , Animais , Búfalos , Bovinos , Queijo/microbiologia , Queijo/normas , Gorduras na Dieta/análise , Feminino , Fermentação , Manipulação de Alimentos/normas , Microbiologia de Alimentos , Qualidade dos Alimentos , Cabras , Masculino , Leite/microbiologia , Proteínas do Leite/análise , Odorantes , Carneiro Doméstico , PaladarRESUMO
The effects of breed and aging time (1, 7, 14, 21 days) were evaluated on meat tenderness and on proteolysis in 24 young bulls from Romagnola×Podolian crossbreed, Podolian and Friesian breed. Shear force decreased with aging in all breeds and showed the highest values at 1 and 7 days in Podolian meat. Myofibrillar fragmentation index significantly increased in Podolian meat throughout aging whereas in Friesian and in Crossbreed meat it increased only in the first week. Proteolysis was investigated by SDS-PAGE and 2-dimensional electrophoresis showing a different quantity and expression profile of myofibrillar proteins among breeds. In all breeds a decrease of troponin-T and an increase of troponin-T derived polypeptides during aging were observed. The highest decrease of troponin-T together with the presence of fragments of MHC in Podolian meat during aging was an outcome of a more extensive proteolysis in this breed. Data suggest that tenderness and proteolytic changes during aging are related to animal's breed.
Assuntos
Envelhecimento/fisiologia , Hibridização Genética , Carne/análise , Miofibrilas/química , Proteólise , Animais , Bovinos , Eletroforese em Gel de Poliacrilamida , Masculino , Músculo Esquelético/química , Mudanças Depois da Morte , Troponina T/química , Eletroforese em Gel Diferencial BidimensionalRESUMO
The safeguard of river buffalo Mozzarella cheese, a Protected Designation of Origin dairy product, has prompted an analytical study to trace the milk and curd used as raw material in cheesemaking. This is to prevent the illegal use of milk or curd from different geographical areas outside of those indicated in the official production protocol. For this purpose, we studied primary proteolysis occurring in fresh and frozen milk and curd to identify a molecular marker that could indicate the raw material used. Whole casein from frozen river buffalo milk was separated using cation-exchange chromatography and sodium dodecyl sulfate-PAGE, and a protein component with an estimated molecular weight of 15.3 kDa was detected. This protein component was revealed in fresh river buffalo milk as a faint electrophoresis band, which drastically increased in intensity in refrigerated and frozen milk as well as in curd and was found to be associated with beta-CN through hydrophobic interaction. By using matrix-assisted laser desorption/ionization-time of flight peptide mass mapping, this component was identified as the C-terminal fragment f(69-209) of beta-CN (expected molecular weight of 15,748.8 Da). beta-Casein f(69-209), originating from the early hydrolysis of Lys(68)-Ser(69) by plasmin, has no counterpart in bovine milk. The increased rate of hydrolysis by plasmin toward the cleavage site Lys(68)-Ser(69) has to be ascribed to the elevated proline content of the peptide 61-73. The favored production of beta-CN f(69-209) has also drawn attention to the complementary proteose peptone beta-CN f(1-68) that is presumed to play a physiological role in inducing milk secretion similar to that of beta-CN f(1-29). The higher in vivo and in vitro production rate, compared with gamma(1)-CN formation, indicates that beta-CN f(69-209) and its complementary fragment are candidate molecular markers to evaluate milk and curd freshness. We suggested [corrected] indirect ELISA analysis based on the determination of remaining nonhydrolyzed beta-CN to perform a quantitative evaluation of proteolysis.