Acute Effect of E-Cigarette Inhalation on Mucociliary Clearance in E-Cigarette Users.

Background: Recent studies show e-cigarette (EC) users have increased rates of chronic bronchitic symptoms that may be associated with depressed mucociliary clearance (MCC). Little is known about the acute or chronic effects of EC inhalation on in vivo MCC. Methods: In vivo MCC was measured in young adult vapers (n = 5 males, mean age = 21) after controlled inhalation of a radiolabeled (Tc99m sulfur colloid) aerosol. Whole-lung clearance of radiolabeled deposited particles was measured over a 90-minute period for baseline MCC and associated with controlled periodic vaping over the first 60 minutes of MCC measurements. The vaping challenge was administered from a fourth generation box mod EC containing unflavored e-liquid (65% propylene glycol/35% vegetable glycerin, 3 mg/mL freebase nicotine). The challenge was administered at the start of each 10-minute interval of MCC measurements and consisted of 1 puff every 30 seconds for 5 minutes (i.e., 10 puffs for each 10-minute period for a total of 60 puffs during the initial 60 minutes of MCC measurements). Results: Compared with baseline, peripheral lung average clearance (%) over the 90 minutes of MCC measures was enhanced, associated with EC challenge, 12 (±6) versus 24 (±6), respectively (p < 0.05 by Wilcoxon signed-rank test). Conclusions: Acute enhancement of in vivo MCC during EC challenge is contrary to recent studies showing nicotine-associated slowing of ciliary beat and mucus transport at higher nicotine levels than those used here. However, our findings are consistent with an acute increase in fluid volume and mucin secretion to the bronchial airway surface that is likely short lived. Research reported in this publication was supported by the National Institutes of Health R01HL139369 and registered with ClinicalTrials.gov (NCT03700892).

The effect of discontinuing hypertonic saline or dornase alfa on mucociliary clearance in elexacaftor/tezacaftor/ivacaftor treated people with cystic fibrosis: The SIMPLIFY-MCC Study.

Many people with CF (pwCF) desire a reduction in inhaled treatment burden after initiation of elexacaftor/tezacaftor/ivacaftor. The randomized, open-label SIMPLIFY study showed that discontinuing hypertonic saline (HS) or dornase alfa (DA) was non-inferior to continuation of each treatment with respect to change in lung function over a 6-week period. In this SIMPLIFY substudy, we used gamma scintigraphy to determine whether discontinuation of either HS or DA was associated with deterioration in the rate of in vivo mucociliary clearance (MCC) in participants ≥12 years of age. While no significant differences in MCC endpoints were associated with HS discontinuation, significant improvement in whole and peripheral lung MCC was observed after discontinuing DA. These results suggest that pwCF on ETI with mild lung disease do not experience a subclinical deterioration in MCC that could later impact health outcomes after discontinuing HS, and in fact may benefit from improved MCC after stopping DA treatment.

Effect of elexacaftor/tezacaftor/ivacaftor on mucus and mucociliary clearance in cystic fibrosis.

BACKGROUND: The cystic fibrosis transmembrane conductance regulator (CFTR) modulator elexacaftor/tezacaftor/ivacaftor (E/T/I) is highly effective clinically for those with at least one F508del-CFTR allele. The effects of E/T/I on mucociliary clearance (MCC) and sputum properties are unknown. We, therefore, sought to characterize the effects of E/T/I on in vivo MCC and sputum characteristics hypothesized to impact mucus transport. METHODS: Forty-four participants ≥12 years of age were enrolled into this prospective, observational trial prior to initiation of E/T/I and had baseline measurement of MCC and characterization of induced sputum and exhaled breath condensate (EBC) samples. Study procedures were repeated after 1 month of E/T/I treatment. RESULTS: Average age was 27.7 years with baseline forced expiratory volume in 1 second (FEV1) of 78.2 % predicted. 52 % of subjects had previously been treated with a 2-drug CFTR modulator combination. The average whole lung MCC rate measured over 60 min (WLAveClr60) significantly improved from baseline to post-E/T/I (14.8 vs. 22.8 %; p = 0.0002), as did other MCC indices. Sputum% solids also improved (modeled mean 3.4 vs. 2.2 %; p<0.0001), whereas non-significant reductions in sputum macrorheology (G', G") were observed. No meaningful changes in exhaled breath condensate endpoints (sialic acid:urea ratio, pH) were observed. CONCLUSIONS: E/T/I improved the hydration of respiratory secretions (% solids) and markedly accelerated MCC. These data confirm the link between CFTR function, mucus solid content, and MCC and help to define the utility of MCC and mucus-related bioassays in future efforts to restore CFTR function in all people with CF.

A novel method for the quantitative assessment of the fitted containment efficiency of face coverings.

BACKGROUND: Face masks reduce disease transmission by protecting the wearer from inhaled pathogens and reducing the emission of infectious aerosols. Although methods quantifying efficiency for wearer protection are established, current methods for assessing face mask containment efficiency rely on measurement of a low concentration of aerosols emitted from an infected or noninfected individual. METHODS: A small port enabled the introduction of 0.05 µm sodium chloride particles at a constant rate behind the mask worn by a study participant. A condensation particle counter monitored ambient particle numbers 60 cm in front of the participant over 3-minute periods of rest, speaking, and coughing. The containment efficiency (%) for each mask and procedure was calculated as follows: 100 × (1 - average ambient concentration with face covering worn/average ambient concentration with a sham face covering in place). The protection efficiency (%) was also measured using previously published methods. The probability of transmission (%) from infected to uninfected (a function of both the containment efficiency and the protection efficiency) was calculated as follows: {1 - (containment efficiency/100)}×{1 - (protection efficiency/100)}×100. RESULTS: The average containment efficiencies for each mask over all procedures and repeated measures were 94.6%, 60.9%, 38.8%, and 43.2%, respectively, for the N95 mask, the KN95 mask, the procedure face mask, and the gaiter. The corresponding protection efficiencies for each mask were 99.0%, 63.7%, 45.3%, and 24.2%, respectively. For example, the transmission probability for 1 infected and 1 uninfected individual in close proximity was ∼14.2% for KN95 masks, compared to 36%-39% when only 1 individual wore a KN95 mask. CONCLUSION: Overall, we detected a good correlation between the protection and containment that a face covering afforded to a wearer.

Design of In Vivo Deposition and Clearance Experiments.

Experiments designed to image in vivo deposition of radiolabel-drug mixtures are useful for estimating inhaled drug delivery and for assessing bioequivalence of delivery devices. Validation of the radiolabel-drug mixture is vital to ensure that subsequent imaging is reflective of drug deposition. Application of gamma attenuation corrections allows both total and regional lung deposition of drug to be estimated by two-dimensional (2D) imaging. Imaging methods are also useful for measuring in vivo mucociliary clearance (MC) function. Such measures allow assessment of the efficacy of drugs designed to improve clearance of airway secretions in airway disease. MC rates can be measured by controlled inhalation and gamma camera monitoring of radiolabeled aerosols containing non-permeating tracers. While in vivo MC rates reflect the function of the mucociliary apparatus, they are also dependent on regional deposition patterns of the inhaled aerosol.

Respiratory Tract Deposition of E-Cigarette Particles.

Total and regional deposition of inhaled electronic cigarette (E-cig) particles in the respiratory tract (RT) depends on both physical properties of the inhaled particles and biological factors of users, for example, breathing pattern or puff profile, airway anatomy, and regional ventilation. Accurate particle sizing of E-cig aerosols is essential for predicting particle deposition in the RT. Studies using a variety of sizing methods have shown mass median aerodynamic diameters ranging from 0.2 to 1.2 um and secondary count diameters in the ultrafine range (<0.1 µm). Incorporating these particle sizes into a multiple-path particle dosimetry (MPPD) model shows 10% to 45% total lung deposition by mass and 30% to 80% for ultrafine particles depending on the breathing patterns. These predictions are consistent with experimental measures of deposition fraction of submicron and ultrafine particles. While box-mod-type E-cig devices allow for full "direct-lung" inhalations of aerosol, the more recent pod-based, and disposable E-cigs (e.g., JUUL, Puff Bar, Stig) deliver the aerosol as a "mouth-to-lung" puff, or bolus, that is inhaled early in the breath followed to various degrees by further inhalation of ambient air. Measurement of realistic ventilation patterns associated with these various devices may further improve deposition predictions. Finally, while in vivo measures of RT deposition present a challenge, a recent methodology to radiolabel E-cig particles may allow for such measurements by gamma scintigraphy. Supported by NIH/NHLBI R01HL139369. © 2022 American Physiological Society. Compr Physiol 12: 1-10, year.

Effect of lumacaftor-ivacaftor on mucociliary clearance and clinical outcomes in cystic fibrosis: Results from the PROSPECT MCC sub-study.

CFTR function is required for normal mucociliary clearance (MCC) and cough-assisted clearance (CC). Lumacaftor-ivacaftor is approved for use in people with cystic fibrosis (CF) carrying two copies of F508del-CFTR. In this observational study performed at four study sites, we characterized the effect of lumacaftor-ivacaftor on mucociliary and cough clearance and related this to other clinical and research endpoints after one month of treatment. Twenty-five adolescents and adults were enrolled. No effect on whole lung MCC was observed, but CC was significantly increased. Sweat chloride improved by 18 mEq/L in this group, indicating a modest restoration of CFTR activity, but no demonstrable change in FEV1 or lung clearance index was observed. We speculate that the modest effect of lumacaftor-ivacaftor on CFTR function was insufficient to yield an improvement in MCC.

Effect of Respiratory Tract Disease on Particle Deposition.

This chapter describes the effects that respiratory disease has on particle deposition in the lungs. The geometry of airways, breathing patterns, and regional ventilation are all affected by various lung diseases, including COPD, asthma, and cystic fibrosis, and in turn modify total and regional deposition from normal. Total particle deposition in the lung is increased by airways obstruction and increased ventilation at rest compared to healthy individuals. Regional particle deposition is 1) shifted from distal to more proximal bronchial airways by airway obstruction, and 2) becomes more heterogeneous due to uneven lung ventilation. The net effect of the changes in total and regional particle deposition from normal is to greatly enhance bronchial airway surface doses for particle deposition while leaving unventilated lung regions inaccessible to the particles. As a result, both therapeutic aerosol delivery and the adverse effects of pollutant particles may be altered with progression of lung disease.

Acute and durable effect of inhaled hypertonic saline on mucociliary clearance in adult asthma.

BACKGROUND: Impaired mucus clearance and airway mucus plugging have been shown to occur in moderate-severe asthma, especially during acute exacerbations. In cystic fibrosis, where airway mucus is dehydrated, it has been shown that inhaled hypertonic saline (HS) produces both acute and sustained enhancement of mucociliary clearance (MCC). The current study was designed to assess the acute and sustained effect of inhaled 7% HS on MCC in adult asthma. METHODS: Well-controlled, moderate-severe female asthmatic patients (n=8) were screened with a single test dose of albuterol (four puffs by metered-dose inhaler) followed by HS (7% sodium chloride, 4 mL using PARI LC Star nebuliser). Spirometry was measured pre-treatment and 5 and 30 min post-treatment for safety. MCC was measured using γ-scintigraphy on three separate visits: at baseline, during inhalation and 4 h after a single dose of HS. RESULTS: MCC was acutely enhanced during HS treatment; mean±sd clearance over 60 min of dynamic imaging (Ave60Clr) was 8.9±7.9% (baseline) versus 23.4±7.6% (acute HS) (p<0.005). However, this enhancement was not maintained over a 4-h period where post-HS treatment Ave60Clr was 9.3±8.2%. In this small cohort we found no decrements in lung function up to 30 min post-treatment (forced expiratory volume in 1 s 97.4±10.0% predicted pre-treatment and 98.9±10.7% predicted 30 min post-treatment). CONCLUSION: While MCC was rapidly enhanced during 7% HS treatment there was no effect on MCC at 4 h post-treatment. While these findings may not support aerosolised HS use for maintenance therapy, they do suggest a benefit of treating acute exacerbations in patients with moderate-severe asthma.

A simple HEPA filtering facepiece.

Shortages of efficient filtering facepiece respirators leave the public vulnerable to transmission of infectious diseases in small particle aerosols. This study demonstrates that a high-filtration-efficiency facepiece capable of filtering out >95% of 0.05µm particles while being worn can be simply produced with available materials.

Assessing the effect of beard hair lengths on face masks used as personal protective equipment during the COVID-19 pandemic.

BACKGROUND: Globally, a large percentage of men keep a beard at least occasionally. Workplace regulations prohibit beards with N95 respirators, but there is little information on the effect of beards with face masks worn by the public for protection against SARS-CoV-2. METHODS AND FINDINGS: We examined the fitted filtration efficiency (FFE) of five commonly worn protective face masks as a function of beard length following the US Occupational Safety and Health Administration Quantitative Fit Test: N95 (respirator), KF94 and KN95, surgical/procedure, and cloth masks. A comparison using N95 respirators was carried out in shaven and bearded men. A detailed examination was conducted for beard lengths between 0 and 10 mm (0.5 mm increments). The effect of an exercise band covering the beard on FFE was also tested. Although N95 respirators showed considerable variability among bearded men, they had the highest FFE for beard lengths up to 10 mm. KF94 and KN95 masks lost up to 40% of their FFE. Procedure and cotton masks had poor performance even on bare skin (10-30% FFE) that did not change appreciably with beard length. Marked performance improvements were observed with an exercise band worn over the beard. CONCLUSIONS: Though variable, N95 respirators offer the best respiratory protection for bearded men. While KF94 and KN95 FFE is compromised considerably by increasing beard length, they proved better options than procedure and cotton face masks. A simple exercise band improves FFE for face masks commonly used by bearded men during the COVID-19 pandemic.

Evaluation of Cloth Masks and Modified Procedure Masks as Personal Protective Equipment for the Public During the COVID-19 Pandemic.

Importance: During the coronavirus disease 2019 (COVID-19) pandemic, the general public has been advised to wear masks or improvised face coverings to limit transmission of severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2). However, there has been considerable confusion and disagreement regarding the degree to which masks protect the wearer from airborne particles. Objectives: To evaluate the fitted filtration efficiency (FFE) of various consumer-grade and improvised face masks, as well as several popular modifications of medical procedure masks that are intended to improve mask fit or comfort. Design, Setting, and Participants: For this study conducted in a research laboratory between June and August 2020, 7 consumer-grade masks and 5 medical procedure mask modifications were fitted on an adult male volunteer, and FFE measurements were collected during a series of repeated movements of the torso, head, and facial muscles as outlined by the US Occupational Safety and Health Administration Quantitative Fit Testing Protocol. The consumer-grade masks tested included (1) a 2-layer nylon mask with ear loops that was tested with an optional aluminum nose bridge and filter insert in place, (2) a cotton bandana folded diagonally once (ie, "bandit" style) or in a (3) multilayer rectangle according to the instructions presented by the US Surgeon General, (4) a single-layer polyester/nylon mask with ties, (5) a polypropylene mask with fixed ear loops, (6) a single-layer polyester gaiter/neck cover balaclava bandana, and (7) a 3-layer cotton mask with ear loops. Medical procedure mask modifications included (1) tying the mask's ear loops and tucking in the side pleats, (2) fastening ear loops behind the head with 3-dimensional-printed ear guards, (3) fastening ear loops behind the head with a claw-type hair clip, (4) enhancing the mask/face seal with rubber bands over the mask, and (5) enhancing the mask/face seal with a band of nylon hosiery over the fitted mask. Main Outcomes and Measures: The primary study outcome was the measured FFE of common consumer-grade and improvised face masks, as well as several popular modifications of medical procedure masks. Results: The mean (SD) FFE of consumer grade masks tested on 1 adult male with no beard ranged from 79.0% (4.3%) to 26.5% (10.5%), with the 2-layer nylon mask having the highest FFE. Unmodified medical procedure masks with ear loops had a mean (SD) FFE of 38.5% (11.2%). All modifications evaluated in this study increased procedure mask FFE (range [SD], 60.3% [11.1%] to 80.2% [3.1%]), with a nylon hosiery sleeve placed over the procedure mask producing the greatest improvement. Conclusions and Relevance: While modifications to improve medical procedure mask fit can enhance the filtering capability and reduce inhalation of airborne particles, this study demonstrates that the FFEs of consumer-grade masks available to the public are, in many cases, nearly equivalent to or better than their non-N95 respirator medical mask counterparts.

Effect of hypertonic saline on mucociliary clearance and clinical outcomes in chronic bronchitis.

BACKGROUND: Mucus dehydration and impaired mucus clearance are common features of cystic fibrosis (CF) and chronic obstructive pulmonary disease (COPD). In CF, inhaled hypertonic saline (HS) improves lung function and produces sustained increases in mucociliary clearance (MCC). We hypothesised that administration of HS (7% NaCl) twice daily for 2 weeks would improve clinical outcomes and produce sustained increases in MCC in COPD subjects with a chronic bronchitis (CB) phenotype. METHODS: Twenty-two CB subjects completed a double-blinded, crossover study comparing inhaled HS to a hypotonic control solution (0.12% saline) administered via nebuliser twice daily for 2 weeks. Treatment order was randomised. During each treatment period, symptoms and spirometry were measured. MCC was measured at baseline, shortly after initial study agent administration, and approximately 12 h after the final dose. RESULTS: HS was safe and well tolerated but overall produced no significant improvements in spirometry or patient-reported outcomes. CB subjects had slower baseline MCC than healthy subjects. The MCC rates over 60 min (Ave60Clr) in CB subjects following 2 weeks of HS were not different from 0.12% saline but were slower than baseline (Ave60Clr was 9.1±6.3% at baseline versus 5.3±6.9% after HS; p<0.05). Subgroup analyses determined that subjects with residual baseline central lung clearance (14 subjects) had improved spirometry and symptoms following treatment with HS, but not 0.12% saline, treatment. CONCLUSIONS: Inhaled HS appeared to be safe in a general CB population. A specific phenotypic subgroup may benefit from HS but requires additional study.

Filtration Efficiency of Hospital Face Mask Alternatives Available for Use During the COVID-19 Pandemic.

Importance: Procuring respiratory protection for clinicians and other health care workers has become a major challenge of the coronavirus disease 2019 (COVID-19) pandemic and has resulted in nonstandard practices such as the use of expired respirators and various decontamination processes to prolong the useful life of respirators in health care settings. In addition, imported, non-National Institute for Occupational Safety and Health (NIOSH)-approved respirators have been donated or acquired by hospitals as a potential replacement for limited NIOSH-approved N95 respirators. Objective: To assess fitted filtration efficiencies (FFEs) for face mask alternatives used during the COVID-19 pandemic. Design, Setting, and Participants: For this quality-improvement study conducted between April and June 2020, we used the Occupational Safety and Health Administration's Quantitative Fit Testing Protocol for Filtering Facepiece Respirators in a laboratory atmosphere supplemented with sodium chloride particles to assess the FFEs of a variety of respirators worn by a male volunteer and female volunteer. Main Outcomes and Measures: The FFEs of respirators commonly worn by clinicians and other health care workers and available respirator alternatives during the COVID-19 pandemic. Results: Of the 29 different fitted face mask alternatives tested on 1 man and 1 woman, expired N95 respirators with intact elastic straps and respirators subjected to ethylene oxide and hydrogen peroxide sterilization had unchanged FFE (>95%). The performance of N95 respirators in the wrong size had slightly decreased performance (90%-95% FFE). All of the respirators not listed as approved in this evaluation (n = 6) failed to achieve 95% FFE. Neither of the 2 imported respirators authorized for use by the Centers for Disease Control and Prevention that were not NIOSH-approved tested in this study achieved 95% FFE, and the more effective of the 2 functioned at approximately 80% FFE. Surgical and procedural face masks had filtering performance that was lower relative to that of N95 respirators (98.5% overall FFE), with procedural face masks secured with elastic ear loops showing the lowest efficiency (38.1% overall FFE). Conclusions and Relevance: This quality-improvement study evaluating 29 face mask alternatives for use by clinicians interacting with patients during the COVID-19 pandemic found that expired N95 respirators and sterilized, used N95 respirators can be used when new N95 respirators are not available. Other alternatives may provide less effective filtration.

A four week trial of hypertonic saline in children with mild cystic fibrosis lung disease: Effect on mucociliary clearance and clinical outcomes.

BACKGROUND: Hypertonic saline (HS) is commonly prescribed for children with cystic fibrosis (CF) despite the absence of strong data indicating clinical efficacy in a population with mild lung disease. We hypothesized that HS treatment would result in a sustained improvement in mucociliary clearance (MCC) in children with CF who had minimal lung disease, thus providing evidence for a biologically relevant effect that also may be associated with clinical improvements. METHODS: We performed a randomized, placebo controlled, double blind study of 6% versus 0.12% sodium chloride, delivered three-times daily with an eFlow nebulizer for 4 weeks. MCC was measured using gamma scintigraphy at baseline, 2-hours after the first study treatment, and ~12-hours after the final dose (at day 28). Spirometry, respiratory symptoms (CFQ-R), and safety were also assessed. RESULTS: Study treatments were generally well tolerated and safe. HS (6% sodium chloride) resulted in a significant, sustained improvement from baseline in whole lung clearance after 4 weeks of therapy (p = 0.014), despite absence of a prolonged single-dose effect after the initial dose. This sustained change (12 hrs after prior dose) was significantly greater when compared to placebo (0.12% sodium chloride) treatment (p = 0.016). Improvements in spirometry with HS did not reach statistical significance but correlated with MCC changes. CONCLUSIONS: The observed sustained improvement in MCC with HS suggests that this treatment may yield health benefits, even in relatively mildly affected children with CF. Highlighting this physiologic finding is important due to the lack of meaningful, validated endpoints in this population.

Numerical evaluation of spray position for improved nasal drug delivery.

Topical intra-nasal sprays are amongst the most commonly prescribed therapeutic options for sinonasal diseases in humans. However, inconsistency and ambiguity in instructions show a lack of definitive knowledge on best spray use techniques. In this study, we have identified a new usage strategy for nasal sprays available over-the-counter, that registers an average 8-fold improvement in topical delivery of drugs at diseased sites, when compared to prevalent spray techniques. The protocol involves re-orienting the spray axis to harness inertial motion of particulates and has been developed using computational fluid dynamics simulations of respiratory airflow and droplet transport in medical imaging-based digital models. Simulated dose in representative models is validated through in vitro spray measurements in 3D-printed anatomic replicas using the gamma scintigraphy technique. This work breaks new ground in proposing an alternative user-friendly strategy that can significantly enhance topical delivery inside human nose. While these findings can eventually translate into personalized spray usage instructions and hence merit a change in nasal standard-of-care, this study also demonstrates how relatively simple engineering analysis tools can revolutionize everyday healthcare. Finally, with respiratory mucosa as the initial coronavirus infection site, our findings are relevant to intra-nasal vaccines that are in-development, to mitigate the COVID-19 pandemic.

Comparative study of simulated nebulized and spray particle deposition in chronic rhinosinusitis patients.

BACKGROUND: Topical intranasal drugs are widely prescribed for chronic rhinosinusitis (CRS), although delivery can vary with device type and droplet size. The study objective was to compare nebulized and sprayed droplet deposition in the paranasal sinuses and ostiomeatal complex (OMC) across multiple droplet sizes in CRS patients using computational fluid dynamics (CFD). METHODS: Three-dimensional models of sinonasal cavities were constructed from computed tomography (CT) scans of 3 subjects with CRS refractory to medical therapy using imaging software. Assuming steady-state inspiratory airflow at resting rate, CFD was used to simulate 1-µm to 120-µm sprayed droplet deposition in the left and right sinuses and OMC with spray nozzle positioning as in current nasal spray use instructions. Zero-velocity nebulization simulations were performed for 1-µm to 30-µm droplet sizes, maximal sinus and OMC deposition fractions (MSDF) were obtained, and sizes that achieved at least 50% of MSDF were identified. Nebulized MSDF was compared to sprayed droplet deposition. We also validated CFD framework through in vitro experiments. RESULTS: Among nebulized droplet sizes, 11-µm to 14-µm droplets achieved at least 50% of MSDF in all 6 sinonasal cavities. Four of 6 sinonasal cavities had greater sinus and OMC deposition with nebulized droplets than with sprayed droplets at optimal sizes. CONCLUSION: Nebulized droplets may target the sinuses and OMC more effectively than sprayed particles at sizes achieving best deposition. Further studies are needed to confirm our preliminary findings. Several commercial nasal nebulizers have average particle sizes outside the optimal nebulized droplet size range found here, suggesting potential for product enhancement.

Radiolabeling an Electronic Cigarette Aerosol Using Technetium Carbon Ultrafine Particles.

BACKGROUND: Electronic cigarettes (ECIGs) are widely used, but their health effects are not well known. ECIG exposure is difficult to quantify, and a direct measurement of deposition would be beneficial to in vivo and in vitro toxicity studies. The aim of this study was to demonstrate effective radiolabeling of an ECIG. METHODS: A technetium-99m-labeled carbon ultrafine (TCU) aerosol was generated and introduced to a fourth-generation ECIG before nucleation and aerosol formation. The aerosolized e-liquid was a commercially available strawberry flavor containing 1.2% nicotine in a 55% propylene glycol and 45% vegetable glycerine base. An ECIG power setting of 100 W was selected. Mass and radioactivity were measured on each stage within a Sierra Cascade Impactor at 14 L/min to verify the labeling technique using the calculated aerodynamic diameters. A strong positive correlation (R2 > 0.95) between the percent activity and percent mass deposition on each stage provides a reliable validation of colocation. RESULTS: Unlabeled ECIG aerosol from the chosen e-liquid produced a mass median aerodynamic diameter (MMAD) of 0.85 µm. An ECIG labeled with TCU produced an aerosol with an activity median aerodynamic diameter of 0.84 µm and an MMAD of 0.84 µm. The relative mass versus radioactivity on each plate was highly correlated (average R2 = 0.973, p < 0.001). CONCLUSION: A TCU radiolabel was generated and shown to associate with the mass of an aerosol produced by a typical commercially available ECIG. Thus, the radioactivity of the deposited aerosol may be used to determine ECIG aerosol deposition for the future in vivo and in vitro dosimetry studies of the third- and fourth-generation ECIGs.