Environmental sustainability assessment of biodiesel production from Jatropha curcas L. seeds oil in Pakistan.

According to IPCC Annual Report (AR-5), environmental impact assessment of any product prototype is recommended before its large-scale commercialization; however, no environmental profile analysis of any biodiesel prototype has been conducted in Pakistan. Therefore, objective of this study was to conduct a comprehensive life cycle assessment (LCA), water footprint and cumulative energy demand (CED) of biodiesel production from Jatropha curcas L. (JC) seeds oil in Pakistan. A cradle-to-gate LCA approach was applied for 400 liter (L) JC biodiesel produced in Pakistan. JC biodiesel production chain was divided into three stages i.e., 1). cultivation of JC crop 2). crude oil extraction from JC seeds and 3). crude oil conversion to biodiesel. Primary data for all the stages were acquired through questionnaire surveys, field visits and measurements in the field. Potential environmental impacts were calculated in SimaPro v.9.2 software using Eco-indicator 99 methodology. Results showed that crude oil extraction stage accounted for highest emissions (77%) to the overall environmental impact categories evaluated, followed by oil conversion stage (21%) and JC cultivation stage (02%), respectively. The three stages of JC biodiesel production chain are major contributor to ecotoxicity with a contribution of 57% to this impact category. Higher contribution to ecotoxicity was due to agrochemicals used in the JC cultivation. Similarly, fossil fuels impact category was responsible for 38% of overall environmental impacts. In addition, water footprint of JC biodiesel production chain was 2632.54 m3/reference unit. Cumulative energy required for 400L JC biodiesel production chain was 46745.70 MJ in Pakistan. Fossil diesel consumption, synthetic fertilizers use and purchased electricity were major hotspot sources to environmental burdens caused by JC biodiesel production in Pakistan. By performing sensitivity analysis at 20% reduction of the baseline values of fossil diesel used, synthetic fertilizers and purchased electricity, a marked decrease in environmental footprint was observed. It is highly recommended that use of renewable energy instead of fossil energy would provide environmental benefits such as lower greenhouse gases and other toxic emissions as compared to conventional petroleum fuels. It is also recommended that JC as a biofuel plant, has been reported to have many desired characteristics such as quick growth, easy cultivation, drought resistance, pest and insect resistance, and mainly great oil content in JC seeds (27-40%). Therefore, JC plant is highly recommended to Billion Tree Afforestation Project (BTAP) for plantation on wasteland because it has multipurpose benefits.

In vivo assessment of reversing aminoglycoside antibiotics nephrotoxicity using Jatropha mollissima crude extract.

Aminoglycoside antibiotics are widely employed clinically due to their powerful bactericidal activities, less bacterial resistance compared to beta lactam group and low cost. However, their use has been limited in recent years due to their potential induction of nephrotoxicity. Here we investigate the possibility of reversing nephrotoxicity caused by gentamicin in rat models by using ethanolic crude extract of the medicinal plant Jatropha Mollissima. Nephrotoxic male Wistar rats was obtained by gentamicin antibiotic, which then treated with two doses of J. mollissima crude extract for 3 weeks with monitoring their parameter in weekly base. Our results indicate that J. mollissima crude extract at both doses has strong protection ability against gentamicin nephrotoxicity, most of tested parameters backed to normal values after few days from the administration of the crude extract, which could be due to the antagonized the biochemical action of gentamicin on the proximal tubules of the kidney. The results of histopathologic analysis showed observable improvement in J. mollissima treated groups compared with untreated groups. Our findings suggests the J. mollissima has exceptional nephron protection potentials able to reverse the nephrotoxicity caused by gentamicin antibiotic.

Facile and Low-cost Synthesis of Mesoporous Ti-Mo Bi-metal Oxide Catalysts for Biodiesel Production from Esterification of Free Fatty Acids in Jatropha curcas Crude Oil.

Mesoporous Ti-Mo bi-metal oxides with various titanium-molybdenum ratios were successfully fabricated via a facile approach by using stearic acid as a low-cost template agent. thermal gravity (TG) /differential scanning calorimetry (DSC) analysis, X-ray diffraction (XRD), Fourier transform infrared (FTIR) spectroscopy, nitrogen adsorption-desorption isotherm, NH3 temperature-programmed desorption (NH3-TPD), scanning electron microscopy (SEM) and transmission electron microscopy (TEM) measurements indicated these materials possessing mesoporous structure, sufficient pore size and high acid intensity. The catalytic performance of prepared catalysts was evaluated by esterification of free fatty acids in Jatropha curcas crude oil (JCCO) with methanol. The effects of various parameters on FFA conversion were investigated. The esterification conversion of 87.8% was achieved under the condition of 180°C, 2 h, methanol to JCCO molar ratio of 20:1 and 3.0 wt.% catalyst (relative to the weight of JCCO). The mesoporous catalysts were found to exhibit high activities toward the simultaneous esterification and transesterification of JCCO. Furthermore, the catalyst could be recovered with a good reusability.

Assessment of Antioxidant and Cytoprotective Potential of Jatropha (Jatropha curcas) Grown in Southern Italy.

Jatropha (Jatropha curcas L.) is a plant native of Central and South America, but widely distributed in the wild or semi-cultivated areas in Africa, India, and South East Asia. Although studies are available in literature on the polyphenolic content and bioactivity of Jatropha curcas L., no information is currently available on plants grown in pedoclimatic and soil conditions different from the autochthon regions. The aim of the present work was to characterize the antioxidant system developed by the plant under a new growing condition and to evaluate the polyphenol amount in a methanolic extract of leaves. Along with these analyses we have also tested the antioxidant and cytoprotective activities on lymphocytes. RP-HPLC-DAD analysis of flavonoids revealed a chromatographic profile dominated by the presence of flavone C-glucosydes. Vitexin is the most abundant identified compound followed by vicenin-2, stellarin-2, rhoifolin, and traces of isovitexin and isorhoifolin. Methanolic extract had high scavenging activity in all antioxidant assays tested and cytoprotective activity on lymphocytes exposed to tertz-buthylhydroperoxide. The results highlighted a well-defined mechanism of adaptation of the plant and a significant content of secondary metabolites with antioxidant properties, which are of interest for their potential uses, especially as a rich source of biologically active products.

Inhibition of local effects induced by Bothrops erythromelas snake venom: Assessment of the effectiveness of Brazilian polyvalent bothropic antivenom and aqueous leaf extract of Jatropha gossypiifolia.

Bothrops erythromelas is a snake of medical importance responsible for most of the venomous incidents in Northeastern Brazil. However, this species is not included in the pool of venoms that are used in the Brazilian polyvalent bothropic antivenom (BAv) production. Furthermore, it is well known that antivenom therapy has limited efficacy against venom-induced local effects, making the search for complementary alternatives to treat snakebites an important task. Jatropha gossypiifolia is a medicinal plant widely indicated in folk medicine as an antidote for snakebites, whose effectiveness against Bothrops jararaca venom (BjV) has been previously demonstrated in mice. In this context, this study assessed the effectiveness of the aqueous extract (AE) of this plant and of the BAv against local effects induced by B. erythromelas venom (BeV). Inhibition of BeV-induced edematogenic and hemorrhagic local effects was assayed in mice in pre-treatment (treatment prior to BeV injection) and post-treatment (treatment post-envenomation) protocols. Inhibition of proteolytic, phospholipase A2 (PLA2) and hyaluronidase enzymatic activities of BeV were evaluated in vitro. BAv cross-reactivity and estimation of antibody titers against BeV and BjV were assessed by Ouchterlony double diffusion test. The results show that in pre-treatment protocol AE and BAv presented very similar effects (about 70% of inhibition for edematogenic and 40% for hemorrhagic activities). However, BAv poorly inhibited edema and hemorrhage in post-envenomation protocol, whilst, in contrast, AE was significantly active even when used after BeV injection. AE was able to inhibit all the tested enzymatic activities of BeV, while BAv was active only against hyaluronidase activity, which could justify the low effectiveness of BAv against BeV-induced local effects in vivo. Ouchterlony's test showed positive cross-reactivity against BeV, but the antibody titers were slightly higher against BjV. Together, these data indicate that despite the presence of immunological cross-reactivity, Brazilian polyvalent bothropic antivenom presented low inhibitory potential against biological and enzymatic effects of BeV, illustrating the need for new strategies in the production of antivenom with broad neutralizing potential in the treatment of Bothrops spp. envenomation throughout the country. Together, the results highlight the antiophidic potential of J. gossypiifolia, suggesting that it can be considered a potential adjuvant in the treatment of bothropic envenomation local effects.

Cocoa pod husk: A new source of CLEA-lipase for preparation of low-cost biodiesel: An optimized process.

Enzymatic reactions involving lipases as catalyst in transesterification can be an excellent alternative to produce environmental-friendly biodiesel. In this study, lipase extracted from Cocoa Pod Husk (CPH) and immobilized through cross linked enzyme aggregate (CLEA) technology catalysed the transesterification of Jatropha curcas oil successfully. Face centered central composite design (FCCCD) under response surface methodology (RSM) was used to get the optimal conditions of 3% (w/w) enzyme loading, 4h reaction time and 1:6 oil/ethanol ratio to achieve the highest conversion of free fatty acid and glycerides into biodiesel (93%). The reusability of CLEA-lipase was tested and after seven cycles, the conversion percentage reduced to 58%. The results revealed that CLEA lipase from CPH is a potential catalyst for biodiesel production.

Utilization of biodiesel by-products for mosquito control.

The current paper has elaborated the efficient utilization of non-edible oil seed cakes (NEOC), by-products of the bio-diesel extraction process to develop a herbal and novel mosquitocidal composition against the Aedes aegypti larvae. The composition consisted of botanical active ingredients, inerts, burning agents and preservatives; where the botanical active ingredients were karanja (Pongamia glabra) cake powder and jatropha (Jatropha curcas) cake powder, products left after the extraction of oil from karanja and jatropha seed. The percentage mortality value recorded for the combination with concentration, karanja cake powder (20%) and jatropha cake powder (20%), 1:1 was 96%. The coil formulations developed from these biodiesel by-products are of low cost, environmentally friendly and are less toxic than the synthetic active ingredients.

The potential of using low cost naturally available biogenic substrates for biological removal of chlorophenol.

This study details the application of naturally available biogenic substrates (NABS) in microbial degradation of 2-chlorophenol (CP). Jatropha deoiled cakes (JDC) and Karanja deoiled cakes (KDC) are used as NABS. The potential of NABS is compared with standard biogenic substrate, glucose. The study was carried out with both acclimatized mixed culture and pure culture, Pseudomonas putida. Microbial activity of the culture was monitored by measuring reduction in chlorophenol concentration, COD, toxicity and Cl(-) ions evolution. The study was carried out for a total of 42days. It was observed that culture having NABS has shown similar chlorophenol reduction but higher COD and toxicity reduction. Amongst NABS, Jatropha deoiled cake (JDC) has shown superior results of 71% COD reduction compared to glucose and KDC. This study is one of the first kind illustrating the potential of these substrates in removing toxic chemicals from wastewaters.

Assessment of Jatropha curcas L. biodiesel seed cake toxicity using the zebrafish (Danio rerio) embryo toxicity (ZFET) test.

Consequent to the growing demand for alternative sources of energy, the seeds from Jatropha curcas remain to be the favorite for biodiesel production. However, a significant volume of the residual organic mass (seed cake) is produced during the extraction process, which raises concerns on safe waste disposal. In the present study, we assessed the toxicity of J. curcas seed cake using the zebrafish (Danio rerio) embryotoxicity test. Within 1-h post-fertilization (hpf), the fertilized eggs were exposed to five mass concentrations of J. curcas seed cake and were followed through 24, 48, and 72 hpf. Toxicity was evaluated based on lethal endpoints induced on zebrafish embryos namely egg coagulation, non-formation of somites, and non-detachment of tail. The lowest concentration tested, 1 g/L, was not able to elicit toxicity on embryos whereas 100 % mortality (based also on lethal endpoints) was recorded at the highest concentration at 2.15 g/L. The computed LC50 for the J. curcas seed cake was 1.61 g/L. No further increase in mortality was observed in the succeeding time points (48 and 72 hpf) indicating that J. curcas seed cake exerted acute toxicity on zebrafish embryos. Sublethal endpoints (yolk sac and pericardial edema) were noted at 72 hpf in zebrafish embryos exposed to higher concentrations. The observed lethal endpoints induced on zebrafish embryos were discussed in relation to the active principles, notably, phorbol esters that have remained in the seed cake even after extraction.

Chemical characterisation of kernels, kernel meals and oils from Jatropha cordata and Jatropha cardiophylla seeds.

BACKGROUND: Jatropha cordata and Jatropha cardiophylla are native to northwestern Mexico and are adapted to arid and semi-arid conditions (<500 mm of precipitation and temperatures from 8 to 45 °C). The aim of this study was to evaluate the chemical composition of J. cordata and J. cardiophylla kernels and oils as well as antinutrients in the defatted kernel meals of these species. RESULTS: Kernels of J. cordata and J. cardiophylla seeds analysed in this study were rich in crude protein (283 and 289 g kg(-1) respectively) and lipid (517 and 537 g kg(-1) respectively). The main fatty acids in J. cordata and J. cardiophylla oils were linoleic and oleic acids. High levels of trypsin inhibitor and phytates and low levels of saponins were present in the meals. The phorbol ester contents in J. cordata and J. cardiophylla kernel meals were 2.73 and 1.46 mg g(-1) respectively. CONCLUSION: For both J. cordata and J. cardiophylla it could be inferred that (a) the oil and kernel meal were toxic and the kernel meal could be used as livestock feed only after detoxification, (b) the oil could be used for non-alimentary purposes, i.e. biodiesel production, and (c) the seed or oil could be used for isolating various bioactive compounds for pharmaceutical and agricultural applications.

Experimental assessment of toxic phytochemicals in Jatropha curcas: oil, cake, bio-diesel and glycerol.

BACKGROUND: Jatropha curcas seed is a rich source of oil; however, it can not be utilised for nutritional purposes due to presence of toxic and anti-nutritive compounds. The main objective of the present study was to quantify the toxic phytochemicals present in Indian J. curcas (oil, cake, bio-diesel and glycerol). RESULTS: The amount of phorbol esters is greater in solvent extracted oil (2.8 g kg⁻¹) than in expeller oil (2.1 g kg⁻¹). Liquid chromatography-mass spectroscopy analysis of the purified compound from an active extract of oil confirmed the presence of phorbol esters. Similarly, the phorbol esters content is greater in solvent extracted cake (1.1 g kg⁻¹) than in cake after being expelled (0.8 g kg⁻¹). The phytate and trypsin inhibitory activity of the cake was found to be 98 g kg⁻¹ and 8347 TIU g⁻¹ of cake, respectively. Identification of curcin was achieved by sodium dodecyl sulfate-polyacrylamide gel electrophoresis and the concentration of curcin was 0.95 g L⁻¹ of crude concentrate obtained from cake. CONCLUSION: Higher amounts of phorbol esters are present in oil than cake but bio-diesel and glycerol are free of phorbol esters. The other anti-nutritional components such as trypsin inhibitors, phytates and curcin are present in cake, so the cake should be detoxified before being used for animal feed.

Benchmarking the environmental performance of the Jatropha biodiesel system through a generic life cycle assessment.

In addition to available country or site-specific life cycle studies on Jatropha biodiesel we present a generic, location-independent life cycle assessment and provide a general but in-depth analysis of the environmental performance of Jatropha biodiesel for transportation. Additionally, we assess the influence of changes in byproduct use and production chain. In our assessments, we went beyond the impact on energy requirement and global warming by including impacts on ozone layer and terrestrial acidification and eutrophication. The basic Jatropha biodiesel system consumes eight times less nonrenewable energy than conventional diesel and reduces greenhouse gas emissions by 51%. This result coincides with the lower limit of the range of reduction percentages available in literature for this system and for other liquid biofuels. The impact on the ozone layer is also lower than that provoked by fossil diesel, although eutrophication and acidification increase eight times. This study investigates the general impact trends of the Jatropha system, although not considering land-use change. The results are useful as a benchmark against which other biodiesel systems can be evaluated, to calculate repayment times for land-use change induced carbon loss or as guideline with default values for assessing the environmental performance of specific variants of the system.

Are Jatropha curcas phorbol esters degraded by rumen microbes?

BACKGROUND: Jatropha curcas, a non-edible oil plant, is being promoted as a biofuel plant in a number of countries in tropical and subtropical regions. The kernel meal left after extraction of the oil is a potentially protein-rich feed ingredient. However, the presence of highly toxic phorbol esters limits its use. Degradation of J. curcas phorbol esters by rumen microbes, using an in vitro rumen fermentation system, has been investigated in this study. RESULTS: The difference between phorbol ester contents in the residues obtained with and without substrates at 0, 24, 48 or 72 h of the incubations was statistically similar. Phorbol esters did not affect either the gas or short chain production in the in vitro rumen fermentation system. CONCLUSIONS: Rumen microbes can not degrade phorbol esters. In addition, the phorbol esters do not adversely affect rumen fermentation. Ruminants are expected to be as prone as monogastric animals to the toxicity of Jatropha seeds.

A new 2S albumin from Jatropha curcas L. seeds and assessment of its allergenic properties.

Significant effort has been made world-wide to boost biofuels with the expectation of a positive contribution to renewable fuel and greenhouse gas reduction. Jatropha curcas L. has proved to be an opportunistic crop in tropical areas, particularly in unfavorable environments. For this reason, analyses of toxicity and allergy caused by its seeds and pollen are necessary. A 12kDa, allergenic 2S albumin, denoted Jat c 1, was isolated from Physic nut (J. curcas) seeds. Jat c 1 binds IgE attached to rat mast cells, inducing histamine release. It also showed strong cross-reactivity with the major allergens from castor bean, Ric c 1 and Ric c 3.