Replacing maize silage with hydroponic barley forage in lactating water buffalo diet: impact on milk yield and composition, water and energy footprint, and economics.

This study investigated the feasibility of integrating hydroponic barley forage (HBF) production into dairy ruminant production, focusing on its effect on milk yield and components, energy and water footprints, and economic implications. Maize silage (MS) was used as a benchmark for comparison. The research was conducted on a water buffalo dairy farm equipped with a fully automated hydroponic system producing approximately 6,000 kg/d of HBF as fed (up 1,000 kg/d on DM basis). Thirty-three lactating water buffaloes were assigned to 3 dietary treatments based on the level of MS or HBF in the diet: D0 (100% MS), D50 (50% MS and 50% HBF), and D100 (100% HBF). The feeding trial lasted 5 weeks plus a 2-week adaptation period during which each cow underwent a weighing, BCS scoring, recording of milk yield and components, including somatic cell count and coagulation characteristics. Based on the data obtained from the in vivo study, the water and energy footprints for the production of MS and HBF and buffalo milk, as well as income over feed cost, were evaluated. Complete replacement of MS with HBF resulted in a slight increase in milk yield without significant impact on milk component. The resource footprint analysis showed potential benefits associated with HBF in terms of water consumption. However, the energy footprint assessment showed that the energy ratio of HBF was less than 1 (0.88) compared with 11.89 for MS. This affected the energy efficiency of milk yield in the 3 diets, with the D50 diet showing poorer performance due to similar milk yield compared with D0, but higher energy costs due to the inclusion of HBF. The production cost of HBF was about 4 times higher than that of farm-produced MS, making feed costs for milk yield more expensive. Nevertheless, HBF can potentially improve income over feed costs if it increases milk yield enough to offset its higher production costs. Overall, the results suggest that the current practice of using HBF to replace high quality feedstuffs as concentrates is likely to result in energy and economic losses.

Hay or silage? How the forage preservation method changes the volatile compounds and sensory properties of Caciocavallo cheese.

The aim of this study was to determine the effect of the forage preservation method (silage vs. hay) on volatile compounds and sensory properties of a traditional Caciocavallo cheese during ripening. A brown-midrib sudangrass hybrid was cultivated on a 7-ha field and at harvesting it was half ensiled in plastic silo bags and half dried to hay. Forty-four lactating cows were equally allotted into 2 groups fed a isonitrogenous and isoenergetic total mixed ration containing as the sole forage either sorghum hay (H group) or sorghum silage (S group). Milk from the 2 groups was used to produce 3 batches/diet of Caciocavallo ripened for 30, 60, and 90 d. Milk yield and composition as well as cheese chemical and fatty acid composition were not markedly affected by the diet treatment and ripening time. By contrast, ripening induced increased levels of the appearance attribute "yellowness," along with the "overall flavor," the odor/flavor attributes "butter" and "hay," the "salty," "bitter," and "umami" tastes, and the texture attribute "oiliness," whereas the appearance attribute "uniformity" and the texture attribute "elasticity" were reduced. The silage-based diet induced higher perceived intensities of several attributes such as "yellowness"; "overall flavor"; "butter"; "grass" and "hay" odor/flavors; "salty," "bitter," and "umami" tastes; and "tenderness" and "oiliness" textures. In S cheese we also observed higher amounts of ketones and fatty acids. Conversely, H cheese showed the terpene α-pinene, which was not detected in S cheese, and a higher intensity of the appearance attribute "uniformity." These differences allowed the trained panel to discriminate the products, determined an increased consumer liking for 90-d ripened cheese, and tended to increase consumer liking for hay cheese.

Effects of an automatic milking system on milk yield and quality of Mediterranean buffaloes.

A study was carried out to evaluate the effects of an automatic milking system (AMS) on milk yield and composition of buffalo (Mediterranean-type Bubalus bubalis) cows. Performed from January 2015 to December 2015 in an organic buffalo dairy farm equipped with both a traditional tandem milking parlor and an AMS, the study involved 90 primiparous buffaloes randomly allotted to a tandem or AMS group from 5 to 10 d of lactation onward. Number of milkings per day and daily milk yield of each cow were recorded, and individual milk sampling was carried out twice a month. Compared with the tandem, the AMS group showed significantly higher daily milk yield and persistence of lactation. Use of the AMS resulted in higher protein and casein contents, and lower somatic cell and total bacterial counts, whereas fat, freezing point, and pH were unaffected by the system. We conclude that, in terms of milk yield and quality, automatic milking may be a suitable alternative to conventional milking for buffaloes.

The inclusion of fresh forage in the lactating buffalo diet affects fatty acid and sensory profile of mozzarella cheese.

The aim of this study was to determine the effect of inclusion of fresh forage in diet for lactating buffalo on properties of mozzarella cheese under intensive farming conditions. Thirty-two buffalo cows were equally allotted into 2 groups fed diets with (fresh group, FRS) or without (control group, CTL) fresh sorghum. The study consisted of 2 trials. In the first one, animals from group FRS were fed a diet containing 10 kg of fresh sorghum (10-FRS diet) that was doubled to 20 kg (20-FRS diet) in the second trial. All diets were isonitrogenous and isoenergetic, and fresh forage accounted for 13.4 and 26.5 of dietary dry matter, respectively, for the 10-FRS and 20-FRS diet. In each trial, milk from the 2 groups was used to produce 3 batches/diet of Mozzarella di Bufala Campana Protected Designation of Origin cheese. Milk yield and composition were not influenced by dietary treatment. The use of 10-FRS diet did not affect any properties of mozzarella. As the inclusion rate of fresh sorghum doubled to 20 kg, an increment of unsaturated fatty acid percentages and a lowering of short-chain and saturated fatty acids were observed. Moreover, the sensory characteristics of mozzarella were modified, although no effects were observed on consumer acceptance. We conclude that the use of green fodder can represent a low-cost feeding strategy to improve the healthiness of buffalo mozzarella under intensive farming conditions with no detrimental effect on consumer blind acceptance.

Application of the Welfare Quality protocol to dairy buffalo farms: Prevalence and reliability of selected measures.

Within the general aim of developing a Welfare Quality system for monitoring dairy buffalo welfare, this study focused on prevalence and interobserver reliability of the animal-related variables to be included in the scheme. As most of the measures were developed for cattle, the study also aimed to verify their prevalence for buffaloes. Thirty animal-based measures (22 clinical and 8 behavioral measurements) and 20 terms used for qualitative behavior assessment were assessed in 42 loose-housed buffalo farms. All farms were located in central-southern Italy. Two assessors were used (1 male and 1 female). The time needed to record all measures (animal-, resource-, and management-based) was 5.47 ± 0.48 h (mean ± SD). Interobserver reliability of animal-based measures was evaluated using Spearman rank correlation coefficient test (rs). If 0.7 is considered as threshold for high interobserver reliability, all animal-based measures were above this level. In particular, most of the coefficients were above 0.85, with higher values observed for prevalence of animals that can be touched (rs = 0.99) and prevalence of animals with iatrogenic abscess (rs = 0.97), whereas lower coefficients were found for the prevalence of vulvar discharge (rs = 0.74) and dewlap edema (rs = 0.73). Twelve out of the 20 terms used for the qualitative behavior assessment reached a satisfactory interobserver reliability (rs = 0.65). Principal component analysis of qualitative behavior assessment scores was conducted for each assessor. Both principal component 1 and principal component 2 showed high interobserver reliability (rs = 0.80 and 0.79, respectively). In addition, relevant proportions of animals were affected by welfare issues specific to buffaloes, such as overgrown claws (median = 34.1%), withers hygroma (median = 13.3%), and vulvar or uterine prolapse (median = 9.3%). We concluded that most of the investigated measures could be reliably included in the final scheme, which can be used as such to monitor buffalo welfare. However, to inform consumers about the welfare status of the animals, the data should be integrated into a single overall assessment of animal welfare, as already performed in the Welfare Quality project for dairy cattle.

Fatty acid and sensory profiles of Caciocavallo cheese as affected by management system.

The effect of season of the year associated with changes in feeding and management system (pasture-based vs. confinement) on milk and cheese fatty acid profile and on sensory properties of Caciocavallo cheese was evaluated on 3 mountain dairy farms. Each farm used a pasture-based feeding system from April to June and from September to October (PS), and a confinement system for the rest of the year (CS). As a consequence of grazing, PS milk showed higher percentages of C18:3, cis-9,trans-11 conjugated linoleic acid, and trans-11 C18:1, and a reduced percentage of C16:0. The fatty acid profile of cheese largely reflected that of the corresponding raw milk from which cheese was made. This led to a significant decrease of atherogenic index in cheeses produced from cows on pasture. Based on sensory analysis, cheese from animals kept on pasture was more yellow and had a lower intensity of butter and smoked odors than did CS cheese. In addition, grazing induced a lower intensity of bitter and a higher intensity of spicy flavors compared with cheese from CS animals. In regard to texture, pasture feeding resulted in higher intensity of friability and graininess. All cheeses performed well in consumer tests; the panel found all samples more than acceptable for overall liking, and for liking according to appearance, taste/flavor, and texture. Overall liking of Caciocavallo cheese, as assessed by slope analysis, was affected primarily by taste/flavor (raw slope k=0.88) and texture (k=0.97), whereas appearance had a lesser effect (k=0.72). The acidic and sensory profiles of cheese were well discriminated, with healthier cheeses produced by grazing cows. Therefore, wider use of pasture should be promoted to accentuate this favorable feature. Based on the specific nutritional and sensory characteristics of mountain Caciocavallo cheese, particularly that obtained from grazing animals, efforts should be made to indicate the quality of this cheese to the consumer and improve product recognition.

Effect of group size and maize silage dietary levels on behaviour, health, carcass and meat quality of Mediterranean buffaloes.

The effects of different dietary levels of maize silage (10% v. 36% DM) and group size (7 v. 14 animals) were assessed on growth performance and in vivo digestibility of 28 male fattening buffaloes. In addition, the effects of diet on meat quality and group size on behaviour and immune response were separately evaluated. Animals were weighed and assigned to three groups. The high silage - low size group (HL) was fed a total mixed ration (TMR) containing 36% DM of maize silage and consisted of seven animals (age 12.7±2.6 months; BW 382.2±67.7 kg at the start of the study). The low silage - low size group (LL) was fed a TMR containing 10% DM of maize silage and consisted of seven animals (age 13.0±2.7 months; BW 389.4±72.3 kg). The high silage - high size group (HH) was fed the 36% maize silage DM diet and consisted of 14 animals (age 13.9±3.25 months; BW 416.5±73.9 kg). Total space allowance (3.2 indoor+3.2 outdoor m2/animal) was kept constant in the three groups, as well as the ratio of animals to drinkers (seven animals per water bowl) and the manger space (70 cm per animal). Growth performance, carcass characteristics and digestibility were influenced neither by dietary treatment nor by group size, even if the group fed 36% maize silage diet showed a higher fibre digestibility. No effect of diet was found on meat quality. Group size did not affect the behavioural activities with the exception of drinking (1.04±0.35% v. 2.60±0.35%; P<0.01 for groups HL and HH, respectively) and vigilance (2.58±0.46% v. 1.20±0.46%; P<0.05 for groups HL and HH, respectively). Immune responses were not affected by group size.