Effect of Post-Extraction Ultrasonication on Compositional Features and Antioxidant Activities of Enzymatic/Alkaline Extracts of Palmaria palmata.

Palmaria palmata is a viable source of nutrients with bioactive properties. The present study determined the potential role of post-extraction ultrasonication on some compositional features and antioxidant properties of enzymatic/alkaline extracts of P. palmata (EAEP). No significant difference was detected in terms of protein content and recovery, as well as the amino acid composition of the extracts. The nitrogen-to-protein conversion factor of 5 was found to be too high for the seaweed and EAEP. The extracts sonicated by bath for 10 min and not sonicated showed the highest and lowest total phenolic contents (p < 0.05), respectively. The highest radical scavenging and lowest metal-chelating activities were observed for the non-sonicated sample, as evidenced by IC50 values. The extract sonicated by bath for 10 min showed the most favorable in vitro antioxidant properties since its radical scavenging was not significantly different from that of the not-sonicated sample (p > 0.05). In contrast, its metal-chelating activity was significantly higher (p < 0.05). To conclude, post-extraction ultrasonication by an ultrasonic bath for 10 min is recommended to increase phenolic content and improve the antioxidant properties of EAEP.

Ultrasound modification on milk fat globule membrane and soy lecithin to improve the physicochemical properties, microstructure and stability of mimicking human milk fat emulsions.

Starting from the consideration of the structure of human milk fat globule (MFG), this study aimed to investigate the effects of ultrasonic treatment on milk fat globule membrane (MFGM) and soy lecithin (SL) complexes and their role in mimicking human MFG emulsions. Ultrasonic power significantly affected the structure of the MFGM-SL complex, further promoting the unfolding of the molecular structure of the protein, and then increased solubility and surface hydrophobicity. Furthermore, the microstructure of mimicking MFG emulsions without sonication was unevenly distributed, and the average droplet diameter was large. After ultrasonic treatment, the droplets of the emulsion were more uniformly dispersed, the particle size was smaller, and the emulsification properties and stability were improved to varying degrees. Especially when the ultrasonic power was 300 W, the mimicking MFG emulsion had the highest encapsulation rate and emulsion activity index and emulsion stability index were increased by 60.88 % and 117.74 %, respectively. From the microstructure, it was observed that the spherical droplets of the mimicking MFG emulsion after appropriate ultrasonic treatment remain well separated without obvious flocculation. This study can provide a reference for the screening of milk fat globules mimicking membrane materials and the further utilization and development of ultrasound in infant formula.

Combining thermosonication microstress and pineapple peel extract addition to achieve quality and post-acidification control in yogurt fermentation.

This work investigated the effects of the combined use of thermosonication-preconditioned lactic acid bacteria (LAB) with the addition of ultrasound-assisted pineapple peel extracts (UU group) on the post-acidification potential, physicochemical and functional qualities of yogurt products, aimed at achieving prolonged preservation and enhancing functional attributes. Accordingly, the physical-chemical features, adhesion properties, and sensory profiles, acidification kinetics, the contents of major organic acids, and antioxidant activities of the differentially processed yogurts during refrigeration were characterized. Following a 14-day chilled storage process, UU group exhibited acidity levels of 0.5-2 oT lower than the control group and a higher lactose content of 0.07 mg/ml as well as unmodified adhesion potential, indicating that the proposed combination method efficiently inhibited post-acidification and delayed lactose metabolism without leading to significant impairment of the probiotic properties. The results of physicochemical analysis showed no significant changes in viscosity, hardness, and color of yogurt. Furthermore, the total phenolic content of UU-treated samples was 98 µg/mL, 1.78 times higher than that of the control, corresponding with the significantly lower IC50 values of DPPH and ABTS radical scavenging activities of the UU group than those of the control group. Observations by fluorescence inverted microscopy demonstrated the obvious adhesion phenomenon with no significant difference found among differentially prepared yogurts. The results of targeted metabolomics indicated the proposed combination strategy significantly modified the microbial metabolism, leading to the delayed utilization of lactose and the inhibited conversion into glucose during post-fermentation, as well as the decreased lactic acid production and a notable shift towards the formation of relatively weak acids such as succinic acid and citric acid. This study confirmed the feasibility of thermosonication-preconditioned LAB inocula, in combination with the use of natural active components from fruit processing byproducts, to alleviate post-acidification in yogurt and to enhance its antioxidant activities as well as simultaneously maintaining sensory features.

Production and evaluation of total phenolics, antioxidant activity, viscosity, color, and sensory attributes of quince tea infusion: Effects of drying method, sonication, and brewing process.

This study aimed to examine the influence of drying approaches (convective and infrared (IR)), sonication, and brewing time on the total phenolic content (TPC), antioxidant activity (AA), viscosity, color indexes, and sensory attributes of quince tea infusion (QTI). The AA and TPC in the QTI dried in the IR dryer were higher than in the convective dryer. The TPC and AA of QTI prepared by convective and IR dryers increased when the ultrasound treatment and brewing time were increased. In terms of viscosity and Brix, there was no differences between the QTIs and the average viscosity and density of the samples were 1.79 ± 0.28 mPa.s and 3.18 ± 0.07°Brix, respectively. The QTI prepared by the IR has a reddish-brown hue (higher a* value), but the samples prepared with the convective dryer were yellow (higher b* value). The sensory attributes scores of QTI prepared by IR were higher than those of convection-dried samples. In general, the use of an IR dryer for drying grated quince, ultrasound treatment for 8 min, and brewing time for 30 min is a promising condition for the production of QTI with higher TPC and AA, and with appropriate color and sensorial acceptance.

Sonication and heat-mediated synthesis, characterization and larvicidal activity of sericin-based silver nanoparticles against dengue vector (Aedes aegypti).

Fabrication, characterization and evaluation of the larvicidal potential of novel silk protein (sericin)-based silver nanoparticles (Se-AgNPs) were the prime motives of the designed study. Furthermore, investigation of the sericin as natural reducing or stabilizing agent was another objective behind this study. Se-AgNPs were synthesized using sonication and heat. Fabricated Se-AgNPs were characterized using particle size analyzer, UV spectrophotometry, FTIR and SEM which confirmed the fabrication of the Se-AgNPs. Size of sonication-mediated Se-AgNPs was smaller (7.49 nm) than heat-assisted Se-AgNPs (53.6 nm). Being smallest in size, sonication-assisted Se-AgNPs revealed the significantly highest (F4,10 = 39.20, p = .00) larvicidal activity against fourth instar lab and field larvae (F4,10 = 1864, p = .00) of dengue vector (Aedes aegypti) followed by heat-assisted Se-AgNPs and positive control (temephos). Non-significant larvicidal activity was showed by silver (without sericin) which made the temperature stability of silver, debatable. Furthermore, findings of biochemical assays (glutathione-S transferase, esterase, and acetylcholinesterase) showed the levels of resistance in field strain larvae. Aforementioned findings of the study suggests the sonication as the best method for synthesis of Se-AgNPs while the larvicidal activity is inversely proportional to the size of Se-AgNPs, i.e., smallest the size, highest the larvicidal activity. Conclusively, status of the sericin as a natural reducing/stabilizing agent has been endorsed by the findings of this study. RESEARCH HIGHLIGHTS: Incorporation of biocompatible and inexpensive sericin as a capping/reducing agent for synthesis of Se-AgNPs. A novel sonication method was used for the fabrication of Se-AgNPs which were thoroughly characterized by particle size analyzer, UV-visible spectrophotometry, SEM and FTIR. Analysis of enzymatic (GSTs, ESTs) levels in field and lab strains of Aedes aegypti larvae for evaluation of insecticides resistance.

Cavitation with low-energy sonication during focused ultrasound thalamotomy for a patient with tremor-dominant Parkinson's disease: a potential risk.

We report a patient with tremor-dominant Parkinson's disease who had a mild cavitation bioeffect during magnetic resonance-guided focused ultrasound thalamotomy. During the aligning phase with low-energy sonication, cavitation caused mild dysarthria and paresthesia, prompting treatment cessation. At the same time, tremor and rigidity improved. MRI revealed extensive high-intensity lesions in the thalamus 1 day after the procedure followed by steroid infusion, which resulted in resolution of adverse events. Tremor and rigidity improved 1.5 years after the procedure. Although cavitation can relieve tremors and rigidity, it should be carefully monitored due to potential permanent adverse events by unpredictable and unknown behaviors.

Bactericidal potential of different size sericin-capped silver nanoparticles synthesized by heat, light, and sonication.

Present study was aimed to assess the bactericidal potential of sericin-capped silver nanoparticles (Se-AgNPs) synthesized by heat, light, and sonication. Se-AgNPs were characterized by size analyzer, UV spectrophotometry, energy-dispersive X-ray spectroscopy, and Fourier transform infrared spectroscopy. Average size of Se-AgNPs synthesized by heat, light and sonication was 53.60, 78.12, and 7.49 nm, respectively. All (10) bacterial strains were exposed to Se-AgNPs prepared from different methods to compare their antibacterial potentials. Largest zone of inhibition (13 ± 1.15 mm) was observed for sonication-based nanoparticles (NPs) against Klebseilla pneumoniae while the smallest zone of light assisted NPs against Serratia rubidaea (5 ± 1 mm). Bacterial strains were also exposed to different concentrations (0.2%, 0.3%, and 0.6%) of Se-AgNPs which showed largest zone (12 ± 1 mm) of inhibition for 0.4% of Se-AgNPs against Protius mirabilis and smallest zone (5 ± 1.154 mm) for 0.3% of Se-AgNPs against Escherichia coli. Furthermore, effect of different temperatures (5°C, 37°C, and 60°C) and pH (3, 7, and 12) on the efficacy and stability of Se-AgNPs was also evaluated against different bacterial strains. Sonication mediated NPs showed highest bactericidal results against K. pneumoniae (F3,8 = 6.154; p = 0.018) with smallest size NPs (7.49 nm) while lowest bactericidal results against S. rubidaea (5 ± 1 mm) were shown with largest size (78.12 nm) NPs prepared by natural light. These variations of bactericidal activities of NPs with difference size endorse that the Se-AgNPs with smallest size have highest antibacterial activity than larger size NPs. Moreover, Se-AgNPs maintain their bactericidal potency at wide range of temperature and pH, hence seemed stable.

Pretreatment of herbal waste using sonication.

The effect of hydrodynamic cavitation (HC) and the manner it affects the biodegradability of herbal waste suspended on municipal wastewater subjected to mechanical pre-treatment was examined in this paper. The HC was performed at an optimal inlet pressure equal to 3.5 bar and with the cavitation number of 0.11; the number of recirculation passes through the cavitation zone amounted to 30.5. The BOD5/COD ratio was enhanced by more than 70% between the 5th and 10th minute of the process, indicating the enhanced biodegradability of herbal waste shortly. Fiber component analysis, FT-IR/ATR, TGA and SEM analysis were conducted to check the findings and to demonstrate changes in the chemical and morphological structure of herbal waste. It confirmed that hydrodynamic cavitation visibly influenced the herbal composition and their structural morphology, decreased hemicellulose, cellulose and lignin content, but did not form the by-products affecting the subsequent biological treatment of herbal waste.

Mutivariate optimization strategy for the sonication-based extraction of Nardostachys jatamansi roots and analysis for chemical composition, anti-oxidant and acetylcholinesterase inhibitory potential.

Extracts from medicinal plants are generally obtained by conventional methods like percolation and maceration. Owing to limitations of traditional methods and to meet the rising demand of extracts, the development of new green approaches is need of hour. In the present research, we have developed an ultrasound-assisted extraction (UAE) method for the Nardostachys jatamansi (NJ) D. Don, DC roots and optimized the extraction parameters for possible improved extract yield. A multivariate optimization strategy using the Centre Composite Design coupled with response surface methodology was applied. A numerical optimization approach accurately predicted the extraction conditions (sonication time âˆ¼ 20 min, ethanol âˆ¼ 70 % and a liquid/solid ratio of about 21:1). Scanning electron microscopy of the plant samples after UAE also indicated the cavitation effect due to sound waves. GC-MS analysis of the optimized ultrasound extract (OUNJ) confirmed improvement in the concentration of various secondary metabolites like jatamansone (91.8 % increase), spirojatamol (42.3 % increase), globulol (130.4 % increase), sitosterol (84.6 % increase) as compared to the soxhlet extract (SXNJ). Different anti-oxidant parameters (DPPH, Glutathione, Catalase SOD and NO) were also significantly altered (p < 0.05) in the optimized extracts. The IC50 to inhibit acetylcholinesterase activity (AChE) in vitro and its concentration in brain homogenates were significantly (p < 0.05) improved by OUNJ extract as compared to the SXNJ ones. To conclude, we can say that established optimized conditions for UAE of N. jatamansi roots not only reduce the extraction time but also improved the pharmacological potential of the extracts.

Ultra-sonication-enhanced green synthesis of silver nanoparticles using Barleria buxifolia leaf extract and their possible application.

The main aim of the study, green route to the synthesis of silver nanoparticles (AgNPs) is a new technique that has recently gained popularity due to several advantages over conventional chemical methods. The objective of the study was focused on the green synthesis of AgNPs using Barleria buxifolia leaf extract via a rapid and eco-friendly ultrasonic-assisted technique. The obtained AgNPs were characterized using ultraviolet-visible (UV-Vis) absorption spectrum of the organically reduced silver showed a surface plasmon peak at 435 nm, characteristic for silver colloidal solutions. UV-Vis absorption spectrum, scanning electron microscopy (SEM), transmission electron microscopy (TEM), and energy-dispersive X-ray spectroscopy (EDS) analysis showed that the obtained AgNPs were dispersed spheres with a uniform size of 80 nm. Furthermore, the Fourier-transform infrared spectroscopy (FTIR) and X-ray powder diffraction (XRD) analysis indicated that the surface of the obtained AgNPs was covered with organic molecules in plant extracts. Green synthesized AgNPs showed the highest antioxidant, antibacterial and anti-biofilm activity than a plant extract. In vitro anticancer assay demonstrated half-maximal inhibitory concentration (IC50) values of 31.42, 30.67, 51.07 and 56.26 µg/mL against MCF-7, HeLa and HepG2 cancer cell lines, respectively, which confirms its potent anticancer action. The biocompatibility of green synthesized AgNPs is confirmed by their lack of cytotoxicity against normal human cells. The potent bioactivity exhibited by the green synthesized AgNPs leads towards the multiple use as antioxidant, antibacterial, anti-biofilm and cytotoxic agent.

Study on model plant based functional beverage emulsion (non-dairy) using ultrasound - A physicochemical and functional characterization.

This study reports the development of non-dairy functional beverage emulsion employing ultrasound (US) of 20 kHz at 130 W and 195 W at processing times of 2 to 8 min using chickpea milk extract and bioactive, flaxseed oil (4%). The pre-emulsion was formed with high shear homogenizer followed by main sonication process. The sonicated emulsions were stored at 4 ±â€¯2 °C till 14 days and characterized for physicochemical and functional properties. A comparative study was carried out using conventional high shear homogenizer (UT) at 10,000 RPM for 5 min. Upon optimization, 130 W - 8 min, 195 W - 6 min and 195 W - 8 min sono-emulsions showed creaming stability of 100%; with particle sizes as 1.12, 0.97 and 0.78 µm; and zetapotential values as - 40.4 mV, -37.52 and -36.91 mV, respectively. The improvement in protein solubility by 86% proved the emulsifying capability of chickpea proteins, which had partially denatured upon physical effects of acoustic cavitation producing stable and finer emulsion droplets. The reduced sedimentation values of sonicated chickpea extract in comparison to UT showed improvement in physical stability of plant-based milk. Oxidative stability is observed for 130 W - 8 min sonicated emulsions with no change in conjugated dienes, indicating the absence of process generated free radicals. The US process did not have any effect on reduction of stachyose content. But extracted chickpea milk had lower amount of stachyose in comparison to raw chickpeas, reducing the flatulence problem, mainly due to adaptation of high temperature pressure cooking process.

The effect of sonication-synergistic natural deep eutectic solvents on extraction yield, structural and physicochemical properties of pectins extracted from mango peels.

In this study, eco-friendly deep eutectic solvents (DESs) were used as extracting agents for the first time in the extraction of pectins from mango peel. Two novel green solvents including betaine-citric acid (Bet-CA) and choline chloride-malic acid (ChCl-MaA) were screened, and the extraction conditions were further optimized by full factor design experimental along with RSM. In addition, ultrasound treatment also had an influence on extraction yield, structural and physicochemical properties of extracted pectins. Two DES-extracted pectins had significantly higher yield, larger molecular weight and particles size than HCl-extracted pectin. High intensity ultrasound power enhanced the yield of low-ester pectins, but decreased the molecular weight and particles size of the pectins extracted. Monosaccharide compositions analysis showed that higher content of galacturonic acid (GalA) and larger HG region were observed in two DESs-extracted pectins. Fourier transform infrared spectra (FT-IR) of all pectins extracted were similar, with slight differences. Two DESs-extracted pectins exhibited higher DE values than HCl-extracted pectin. Thermal analysis and zeta potential results showed that HCl-extracted pectin had better stability than ChCl-MaA-extracted pectin. Additionally, HCl-extracted pectin had higher viscosity properties than two DESs-extracted pectins or commercial pectin (CP). Moreover, it was found that HCl-extracted pectin was in a colloid state, while two DESs-extracted pectins or CP were in a flow state. Ultrasound treatment significantly improved the yields of pectin/low-ester pectin. Additionally, ultrasound treatment remarkably decreased the viscosity and viscoelastic properties of the pectins extracted. The results were conducive to our understanding of the relationship between extraction conditions and physicochemical properties of the pectins extracted, which provides theoretical basis for the functional application of mango peel pectins in the food and pharmaceutical industry.

Optimization of an Ultra-Sonication Extraction Method for Major Compounds Found in Mondia whitei Using Design of Experiment.

Optimum extraction conditions are vital in quality control methods to enable accurate quantification of the compounds of interest. An ultra-sonication method was developed for the extraction of seven major compounds found in Mondia whitei. Extraction temperature, time, power, frequency, percentage of ethanol in water and solvent to sample ratio were screened to access their significance on the percentage recovery of the compounds of interest. These parameters were screened using Descriptive screening design. Extraction temperature, solvent to sample ratio and the interaction between temperature and percentage ethanol in water were found to have a significant effect on the response. These parameters were then optimized using central composite design. The optimum conditions were found to be 66.1% ethanol in water, 70 °C temperature and 3 mL: 5 mg solvent to sample ratio. This method was successfully applied in the development of a quality control method for the seven compounds in Mondia whitei samples.

Ultrasound-Assisted Extraction of Total Saponins from Aralia taibaiensis: Process Optimization, Phytochemical Characterization, and Mechanism of α-Glucosidase Inhibition.

PURPOSE: Aralia taibaiensis, a medicinal food plant, and total saponins from its root bark extract inhibit α-glucosidase activity, which is associated with type 2 diabetes; however, the inhibitory mechanism is unknown. Furthermore, a green extraction technique superior to conventional hot reflux extraction (HRE) is needed for the rapid and easy extraction of A. taibaiensis total saponins (TSAT) to exploit and utilize this resource. Our aim was to develop a green extraction method for obtaining TSAT and to investigate the mechanism by which TSAT inhibits α-glucosidase. MATERIALS AND METHODS: In this study, the ultrasound-assisted extraction (UAE) process was optimized using a Box-Behnken design, and the extraction mechanism was investigated using scanning electron microscopy (SEM). High-performance liquid chromatography (HPLC) was used for qualitative and quantitative analyses of TSAT. In vitro glycosylation assays, enzyme kinetics, fluorescence spectroscopy measurements, atomic force microscopy (AFM), Fourier transform infrared spectroscopy (FT-IR) and molecular docking techniques were used to investigate the mechanism by which the A. taibaiensis active ingredients inhibit α-glucosidase. RESULTS: The optimal parameters for the extraction yield were obtained as an ethanol concentration of 73%, ultrasound time of 34 min, ultrasound temperature of 61 °C and solid-liquid ratio of 16 g/mL, which were better than HRE. The SEM analysis showed that UAE effectively disrupted plant cells, thus increasing the TSAT yield. In vitro α-glucosidase inhibition experiments showed that both TSAT and its active ingredient, araloside A, inhibited α-glucosidase activity by binding to α-glucosidase, thereby changing the conformation and microenvironment of α-glucosidase to subsequently inhibit enzyme activity. CONCLUSION: The optimal extraction conditions identified here established a basis for future scale-up of ultrasound extraction parameters with the potential for obtaining maximum yields. In vitro enzyme inhibition experiments investigated the mechanism of the TSAT interaction with α-glucosidase and further explored whether araloside A may be the main contributor to the good inhibition of α-glucosidase activity by TSAT.

Response Surface Methodology (RSM)-Based Optimization of Ultrasound-Assisted Extraction of Sennoside A, Sennoside B, Aloe-Emodin, Emodin, and Chrysophanol from Senna alexandrina (Aerial Parts): HPLC-UV and Antioxidant Analysis.

In this study, ultrasound-assisted extraction conditions were optimized to maximize the yields of sennoside A, sennoside B, aloe-emodin, emodin, and chrysophanol from S. alexandrina (aerial parts). The three UAE factors, extraction temperature (S1), extraction time (S2), and liquid to solid ratio (S3), were optimized using response surface methodology (RSM). A Box-Behnken design was used for experimental design and phytoconstituent analysis was performed using high-performance liquid chromatography-UV. The optimal extraction conditions were found to be a 64.2 °C extraction temperature, 52.1 min extraction time, and 25.2 mL/g liquid to solid ratio. The experimental values of sennoside A, sennoside B, aloe-emodin, emodin, and chrysophanol (2.237, 12.792, 2.457, 0.261, and 1.529%, respectively) agreed with those predicted (2.152, 12.031, 2.331, 0.214, and 1.411%, respectively) by RSM models, thus demonstrating the appropriateness of the model used and the accomplishment of RSM in optimizing the extraction conditions. Excellent antioxidant properties were exhibited by S. alexandrina methanol extract obtained using the optimized extraction conditions with a DPPH assay (IC50 = 59.7 ± 1.93, µg/mL) and ABTS method (47.2 ± 1.40, µg/mL) compared to standard ascorbic acid.

Effect of Ultrasound and Enzymatic Mash Treatment on Bioactive Compounds and Antioxidant Capacity of Black, Red and White Currant Juices.

Ultrasound treatment is recognized as a potential technique for improvement in the nutritional values of fruit juices. This study was initiated with the objective of evaluating bioactive compounds and some important quality parameters of black (BC), red (RC) and white (WC) currant juices obtained from fruit mash preliminarily treated by enzymes combined with ultrasound. Individual and total phenolic content (TPC), anthocyanins, color parameters, ascorbic acid, antioxidant capacity (TEAC), juice yield, pH, titratable acidity, and soluble solids were investigated. Significant increases in the levels of TPC and antioxidant capacity of sonicated samples were observed. However, ultrasound treatment had no effect on individual phenolic compounds of juices. Sonication of mash before juice pressing did not cause any noticeable changes in ascorbic acid content. Only in the case of WC was an increase in content of vitamin C noticed. The color of juices obtained after treatment was similar to the control sample. It was demonstrated that enzymatic combined with ultrasound treatment of mash for different colored currant fruit did not have any dismissive effect and could even improve some parameters of the juice obtained.

Incorporation of white tea extract in nano-liposomes: optimization, characterization, and stability.

BACKGROUND: In the present study, an extraction method affected by sonication intensity (40%, 70% and 100%), sonication time (5, 10 and 15 min) and different solvents (ethanol, methanol and a combination of ethanol/methanol) was optimized to extract the white tea with the greatest polyphenolic compounds using a response surface methodology. To prepare the nano-liposomal vesicles, phospholipids and cholesterol in various proportions (60:0, 40:20, 30:30 and 20:40) were applied based on thin-film hydration and ultrasound method. The nano-capsules enriched in bioactive compounds were examined through particle characteristics, encapsulation efficiency, morphological analysis, thermal properties and Fourier transform infrared spectroscopy. RESULTS: The observations showed that the extraction yield highly depended on the type of solvent with varying permeability, sonication time and power. The highest total phenolic content (68.38 mg GA g-1 ) and free radical scavenging activity (77.65%) were observed for the following optimal conditions: 70% for sonication intensity, 15 min for sonication time and methanol as solvent. Characteristics of nanoliposomes within a compositional ratio of lecithin/cholesterol (40:20) and with a zeta potential of -56 ± 0.01 mV, as well as white tea extract (WTE) samples with an average particle diameter of 82.20 ± 0.08, microencapsulation efficiency of 76.5% ± 0.081, polydispersity index of 0.06 ± 0.02 and span value of 0.69 ± 0.03. are used as the optimal formulation for microencapsulation of antioxidant WTE. The results demonstrated an increment in thermal stability of liposomal WTE samples compared to other samples. CONCLUSION: The findings of the present study indicated that nano-liposomes comprise an effective technology for coating the WTE, as well as to increasing its stability and thermal properties. © 2021 Society of Chemical Industry.

Sonication treatment of pomegranate juice containing Saccharomyces cerevisiae and Byssochlamys fulva: Thermodynamic and predictive modeling after treatment and during shelf life.

The effect of ultrasound treatment (100 W, 30 kHz; 50 and 100% amplitudes) on inactivation of Saccharomyces cerevisiae and Byssochlamys fulva in pomegranate juice and shelf life of the juice during storage at different temperatures (5, 15 and 30 °C) for 30 days was modeled using predictive and thermodynamics models. The Baranyi and square root type models were implemented to determine the growth rate of microorganisms. It was predicted that the minimum growth temperature (Tmin) of B. fulva increased by increasing sonication amplitude, however, the Tmin of S. cerevisiae was not function of sonication amplitude. The predicted shelf life was shown to be in good agreement with the measured sensorial shelf life. Increasing the temperature from 5 to 35 °C, reduced the shelf life from 17.5 to 3.5 days for B. fulva and from 15 to 5 days for S. cerevisiae. Moreover, for B. fulva, the activation energy (Ea) decreased from 43.4 to 27.5 kJ/mol by increasing the amplitude, while no significant change was observed for S. cerevisiae. Besides, thermodynamics properties of the shelf life such as enthalpy (ΔH++), entropy (ΔS++) and Gibbs free energy (ΔG++)  were proven to be suitable measures to determine the microbial spoilage reaction.

Ultrasound-assisted extraction of oil from hempseed (Cannabis sativa L.): Part 1.

BACKGROUND: Ultrasound-assisted extraction of the intermediate product from the mechanical expression of hemp (Cannabis sativa L.) seed oil was investigated to improve the overall expression yield without compromising oil quality. Complementary ultrasound technology was used as an out-of-line treatment carried out at 20 kHz frequency and optimized with respect to amplitude (80 and 152 µm), sonication time (2, 10, 20 min) and to the hemp paste properties, in particular its particle size and hydration, which drive the compressibility of the press cake. RESULTS: Under the conditions evaluated, the optimal ultrasound treatment was found to be the one applied on the hydrated press cake for 2 min at 152 µm, which resulted in an oil yield of 13.4%, with an increase in extraction efficiency equal to 73% with respect to the control (untreated press cake). Sonication had a positive effect on the press cake texture and on the extracted oil antioxidant activity. Soaked samples treated for 2 min at 152 µm yielded the lowest hardness. Oil recovered from soaked samples treated at 80 µm and 152 µm ultrasound for 2 min had the highest antioxidant capacity. CONCLUSIONS: The technological results gathered in the present investigation are preliminary to the design and engineering of scaled-up equipment that combines the mechanical screw expression and the in-line ultrasound unit. © 2021 The Authors. Journal of The Science of Food and Agriculture published by John Wiley & Sons Ltd on behalf of Society of Chemical Industry.

Green extraction optimization of triterpenoid glycoside-enriched extract from Centella asiatica (L.) Urban using response surface methodology (RSM).

Centella asiatica (L.) Urban extracts are widely used as food, drugs and cosmetics, and the main active compounds are glycosides (madecassoside and asiaticoside) and aglycones (madecassic acid and asiatic acid). Green extraction is an interesting concept that can produce safe and high-quality extracts that use less solvent, time and energy with the environmental friendly. This study investigated the optimum conditions for extracting a triterpenoid glycoside-enriched C. asiatica extract using microwave-assisted extraction (MAE) and ultrasound-assisted extraction (UAE). Central composite design and response surface methodology (RSM) were used for the experimental design and data analysis. Four-month-old C. asiatica tetraploid plants were selected as the elite raw material containing high amount of triterpenoid glycosides for the extraction experiments, and the triterpenoid content was determined by a validated HPLC method. The results demonstrated that the RSM models and equations were reliable and could predict the optimal conditions to enhance C. asiatica extract yield, glycoside and aglycone amounts. The percent of ethanol was the major factor that had a significant effect on C. asiatica yield and glycoside and aglycone content during MAE and UAE. The maximum triterpenoids content in extract; 7.332 ± 0.386% w/w madecassoside and 4.560 ± 0.153% w/w asiaticoside 0.357 ± 0.013% w/w madecassic acid and 0.209 ± 0.025% w/w asiatic acid were obtained by MAE with 80% ethanol at 100 watts for 7.5 min, whereas the optimal conditions for highest total triterpenoids extraction from dry plant was UAE with 80% ethanol, temperature 48 °C, 50 min enhanced 2.262 ± 0.046% w/w madecassoside, 1.325 ± 0.062% w/w asiaticoside, 0.082 ± 0.009% w/w madecassic acid and 0.052 ± 0.007% w/w asiatic acid as secondary outcome. Moreover, it was found that MAE and UAE consumed energy 59 and 54%, respectively, lower than that of the conventional method, maceration, in term of kilowatt-hour per gram of total triterpenoids. These optimized green conditions could be recommended for C. asiatica extraction for triterpenoid glycoside-enriched extracts production for the pharmaceutical or cosmeceutical industries and triterpenoids quantitative analysis in raw materials.