Screening of antimicrobial synergism between phenolic acids derivatives and UV-A light radiation.

The objective of this study was to investigate synergistic antibacterial activity based on a combination of UV-A light and three classes of food grade compounds: benzoic acid derivatives, cinnamic acid derivatives, and gallates. By using Escherichia coli O157:H7 as the model strain, it was observed that three cinnamic acid derivatives (ferulic acid, coumaric acid, and caffeic acid) and one benzoic acid derivative (2,5-dihydroxybenzoic acid) presented strong synergistic antibacterial activity with UV-A light radiation, where 1 mM levels of these compounds plus with 15 min of UV-A light (total light dose of 6.1 cm-2) led to more than 7-log CFU mL-1 of bacterial inactivation. In contrast, synergistic antibacterial activity between UV-A light and most benzoic acid derivatives (benzoic acid, gallic acid, vanillic acid, and 2,5-dimethoxybenzoic acid) were only observed after higher concentrations of these compounds were applied (10 mM). Lastly, from the three gallates tested (methyl gallate, ethyl gallate, and propyl gallate), only propyl gallate showed strong antibacterial synergism with UV-A light, where 10 mM of propyl gallate plus 15 min of UV-A light led to approximately 6.5-log of bacterial reduction. Presence of antioxidant compounds mitigated the light-mediated antibacterial activity of gallic acid, 2,5-dihydroxybenzoic acid, and propyl gallate. Similarly, the light-mediated antibacterial activity of these compounds was significantly (P < 0.05) reduced against metabolic-inhibited bacterial cells (sodium azide pretreatment). On the other hand, the antibacterial synergism between ferulic acid and UV-A light was not affected by the presence of antioxidants or the metabolic state of the bacterial cells. Due to the increasing concerns of antimicrobial resistant (AMR) pathogens, the study also investigated the proposed synergistic treatment on AMR Salmonella. Combinations of 1 mM of ferulic acid or 1 mM of 2,5-dihydroxybenzoic acid with UV-A light radiation was able to inactivate more than 6-log of a multi-drug resistant Salmonella Typhimurium strain.

The effect of different ultraviolet-C light doses on microbial reduction and the components of camel milk.

As a result of increasing interest in non-thermal technologies as a possible alternative or complementary to milk pasteurization processing, the objectives of this study were to determine the effects of different ultraviolet-C light doses on the viability of Escherichia coli O157:H7 and Salmonella enterica serovar Typhimurium and chemical changes to camel milk components. Pasteurized and inoculated camel milk samples were ultraviolet-C treated in a continuous flow system. The viability of E. coli O157:H7 and S. Typhimurium was evaluated with both in vivo imaging system and traditional plate count agar method. Samples subjected to the 4.15, 8.30, and 12.45 mJ/cm2 of ultraviolet-C treatment resulted in 1.9, 3.3, and 3.9-log reductions in E. coli O157:H7 and 0.9, 3, and 3.9-log reductions in S. Typhimurium, respectively. The measurement of secondary lipid peroxidation products (or ThioBarbituric Acid Reactive Substance values) showed no significant (P > 0.05) differences between the raw and ultraviolet-C treated milk samples. Additionally, no changes (P > 0.05) in the protein profiles of αs1-casein, α-lactalbumin, and lactoferrin were observed between both samples. Compared to the untreated raw milk, c9t11 conjugated linoleic acid decreased (P < 0.01) while t10c12 conjugated linoleic acid increased (P < 0.01) in the ultraviolet-C treated milk. Furthermore, three new volatile compounds were identified in the ultraviolet-C treated milk compared to the control. In conclusion, milk treated with the ultraviolet-C light at a dose of 12.45 mJ/cm2 did not meet the Food and Drug Administration (FDA) requirements for the 5-log pathogen reduction. The ultraviolet-C treatment, on the other hand, had minimal effects on camel milk components.

Improving the Microbial Safety of Fresh-Cut Endive with a Combined Treatment of Cinnamon Leaf Oil Emulsion Containing Cationic Surfactants and Ultrasound.

Endive is widely consumed in a fresh-cut form owing to its rich nutritional content. However, fresh-cut vegetables are susceptible to contamination by pathogenic bacteria. This study investigated the antibacterial activities of the combined treatment of cinnamon leaf oil emulsion containing cetylpyridinium chloride or benzalkonium chloride (CLC and CLB, respectively) as a cationic surfactant and ultrasound (US) against Listeria monocytogenes and Escherichia coli O157:H7 on endive. The combined treatment of CLC or CLB with US reduced the population of L. monocytogenes by 1.58 and 1.47 log colony forming units (CFU)/g, respectively, and that of E. coli O157:H7 by 1.60 and 1.46 log CFU/g, respectively, as compared with water washing treatment. The reduction levels of both pathogens were higher than those observed with 0.2 mg/ml sodium hypochlorite. In addition, the combined treatment showed no effect on the quality of the fresh-cut endive (FCE). In particular, the degree of browning in FCE was less for the treatment group than for the control and water washing treatment groups. Thus, cationic surfactant-based cinnamon leaf oil emulsions combined with US may be an effective washing treatment for the microbial safety of FCE.

Microbial decontamination of onion powder using microwave-powered cold plasma treatments.

The effects of microwave-integrated cold plasma (CP) treatments against spores of Bacillus cereus and Aspergillus brasiliensis and Escherichia coli O157:H7 on onion powder were investigated. The growth of B. cereus, A. brasiliensis, and E. coli O157:H7 in the treated onion powder was assessed during storage at 4 and 25 °C, along with the physicochemical and sensory properties of the powder. Onion powder inoculated with B. cereus was treated with CP using helium as a plasma-forming gas, with simultaneous exposure to low microwave density at 170 mW m-2 or high microwave density at 250 mW m-2. High microwave density-CP treatment (HMCPT) was more effective than low microwave density-CP treatment (LMCPT) in inhibiting B. cereus spores, but induced the changes in the volatile profile of powder. Increase in treatment time in HMCPT yielded greater inhibition of B. cereus spores. Vacuum drying led to greater inhibition of spores of B. cereus and A. brasiliensis than hot-air drying. HMCPT at 400 W for 40 min, determined as the optimum conditions for B. cereus spore inhibition, initially reduced the numbers of B. cereus, A. brasiliensis, and E. coli O157:H7 by 2.1 log spores/cm2, 1.6 log spores/cm2, and 1.9 CFU/cm2, respectively. The reduced number of B. cereus spores remained constant, while the number of A. brasiliensis spores in the treated powder increased gradually during storage at 4 and 25 °C and was not different from the number of spores in untreated samples by the end of storage at 4 °C. The E. coli counts in the treated powder fell below the level of detection after day 21 at both temperatures. HMCPT did not affect the color, antioxidant activity, or quercetin concentration of the powder during storage at both temperatures. The microwave-integrated CPTs showed potential for nonthermal decontamination of onion powder.

Decontamination of Escherichia coli O157:H7 on green onions using pulsed light (PL) and PL-surfactant-sanitizer combinations.

Imported green onion has been associated with three large outbreaks in the USA. Contamination has been found on both domestic and imported green onions. The objective of our study was to investigate Escherichia coli O157:H7 inactivation efficacy of pulsed light (PL) as well as its combination with surfactant and/or sanitizers on green onions. Green onions were cut into two segments, stems and leaves, to represent two different matrixes. Stems were more difficult to be decontaminated. Spot and dip inoculation methods were compared and dipped inoculated green onions were found to be more difficult to be decontaminated. Results showed that 5s dry PL (samples were not immersed in water during PL treatment) and 60s wet PL (samples were immersed in water and stirred during PL treatment) treatments provided promising inactivation efficacy (>4log10CFU/g) for spot inoculated stems and leaves. For dip inoculated green onions, 60s wet PL treatment was comparable with 100ppm chlorine washing, demonstrating that PL could be used as an alternative to chlorine. To further increase the degree of microbial inactivation, combined treatments were applied. PL combined with surfactant (SDS) was found to be more effective than single treatments of PL, SDS, chlorine, citric acid, thymol, and hydrogen peroxide, and binary combined treatments of PL with one of those chemicals. Addition of chlorine or hydrogen peroxide to the PL-SDS combination did not further enhanced its microbial inactivation efficacy. The combination of PL and 1000ppm of SDS reduced the E. coli O157:H7 populations dip inoculated on the stems and leaves of green onions by 1.4 and 3.1log10CFU/g, respectively. Our findings suggest that PL could potentially be used for decontamination of E. coli O157:H7 on green onions, with wet PL added with SDS being the most effective PL treatment.

Efficacy of integrated treatment of UV light and low-dose gamma irradiation on inactivation of Escherichia coli O157:H7 and Salmonella enterica on grape tomatoes.

The study evaluated the efficacy of integrated ultraviolet-C light (UVC) and low-dose gamma irradiation treatments to inactivate mixed strains of Escherichia coli O157:H7 and Salmonella enterica on inoculated whole grape tomatoes. A mixed bacterial cocktail composed of a 3 strain mixture of E. coli O157:H7 (C9490, E02128, and F00475) and a 3 serotype mixture of S. enterica (S. Montevideo G4639, S. Newport H1275, and S. Stanley H0558) was used based on their association with produce-related outbreaks. Spot inoculation (50 to 100 µmL) on tomato surfaces was performed to achieve a population of appropriately 10(7-8) CFU/tomato. Inoculated tomatoes were subjected to UVC (253.7 nm) dose of 0.6 kJ/m(2) followed by 4 different low doses of gamma irradiations (0.1 kGy, 0.25 kGy, 0.5 kGy, 0.75 kGy). The fate of background microflora (mesophilic aerobic) including mold and yeast counts were also determined during storage at 5 °C over 21 d. Integrated treatment significantly (P < 0.05) reduced the population of target pathogens. Results indicate about 3.4 ± 0.3 and 3.0 ± 0.1 log CFU reduction of E. coli O157:H7 and S. enterica, respectively, per tomato with UVC (0.6 kJ/m(2) ) and 0.25 kGy irradiation. More than a 4 log and higher reduction (>5 log) per fruit was accomplished by combined UVC treatment with 0.5 kGy and 0.75 kGy irradiation, respectively, for all tested pathogens. Furthermore, the combined treatment significantly (P < 0.05) reduced the native microflora compared to the control during storage. The data suggest efficacious treatment strategy for produce indicating 5 or higher log reduction which is consistent with the recommendations of the Natl. Advisory Committee on Microbiological Criteria for Foods.

Efficacy of UV, acidified sodium hypochlorite, and mild heat for decontamination of surface and infiltrated Escherichia coli O157:H7 on green onions and baby spinach.

Produce-associated foodborne illnesses outbreaks have highlighted the need for more effective decontamination methods to ensure the safety of fresh produce. The main objective of this study was to evaluate the individual and combined efficacies of germicidal UV light (12.5 to 500 mJ/cm(2)), acidified sodium hypochlorite (ASC 10 to 200 ppm), and mild heat (40 to 50°C) for decontaminating green onions and baby spinach infected with Escherichia coli O157:H7. Samples were inoculated by spot and dip inoculation methods to mimic surface and infiltrated E. coli O157:H7 contamination, respectively. In green onions and baby spinach, the individual efficacies of UV, ASC, and mild-heat treatments varied based on the produce type and contamination method. Following analysis of the efficacies of the single treatments, a combined treatment with 125 mJ/cm(2) UV and 200 ppm of ASC at 50°C was selected for spot-inoculated green onions, and a combined treatment with 125 mJ/cm(2) UV and 200 ppm of ASC at 20°C was selected for spot- and dip-inoculated baby spinach. While a >5-log reduction was achieved with the combination treatment for spot-inoculated green onions with an initial contamination level of 7.2 log CFU per spot, the same treatment reduced E. coli O157:H7 populations below the detection limit (<1 log) on green onions spot inoculated at a lower contamination level (4.3 log CFU per spot). On spot- and dip-inoculated baby spinach, the combined treatment reduced E. coli O157:H7 populations by 2.8 log CFU per spot and 2.6 log CFU/g, respectively. The combined treatment of 500 mJ/cm(2) UV and 200 ppm of ASC at 50°C selected for the decontamination of dip-inoculated green onions resulted in a 2.2-log CFU/g reduction. These findings suggest that when foodborne pathogens contaminate produce and subsequently infiltrate, attach to, or become localized into protected areas, the individual or combined applications of UV, ASC, and mild-heat treatments have limited decontamination efficacies on both green onions and baby spinach (<3 log). However, treatments combining UV, ASC, and mild heat could be a promising application for reducing pathogen populations (>5 log) on E. coli O157:H7 surface-contaminated green onions. This study also highlights the importance of developing and optimizing produce-specific decontamination methods to ensure the safety of fresh produce commodities.

Inactivation of Escherichia coli O157:H7, Salmonella typhimurium, and Listeria monocytogenes on stored iceberg lettuce by aqueous chlorine dioxide treatment.

Inactivation of Escherichia coli O157:H7, Salmonella typhimurium, and Listeria monocytogenes in iceberg lettuce by aqueous chlorine dioxide (ClO(2)) treatment was evaluated. Iceberg lettuce samples were inoculated with approximately 7 log CFU/g of E. coli O157:H7, S. typhimurium, and L. monocytogenes. Iceberg lettuce samples were then treated with 0, 5, 10, or 50 ppm ClO(2) solution and stored at 4 degrees C. Aqueous ClO(2) treatment significantly decreased the populations of pathogenic bacteria on shredded lettuce (P < 0.05). In particular, 50 ppm ClO(2) treatment reduced E. coli O157:H7, S. typhimurium, and L. monocytogenes by 1.44, 1.95, and 1.20 log CFU/g, respectively. The D(10)-values of E. coli O157:H7, S. typhimurium, and L. monocytogenes in shredded lettuce were 11, 26, and 42 ppm, respectively. The effect of aqueous ClO(2) treatment on the growth of pathogenic bacteria during storage was evaluated, and a decrease in the population size of these pathogenic bacteria was observed. Additionally, aqueous ClO(2) treatment did not affect the color of lettuce during storage. These results suggest that aqueous ClO(2) treatment can be used to improve the microbial safety of shredded lettuce during storage.

Effect of gamma radiation and oregano essential oil on murein and ATP concentration of Escherichia coli O157:H7.

This study was carried out to evaluate the effects of gamma radiation alone or in combination with oregano essential oil on the murein composition of Escherichia coli O157:H7 and on the intracellular and extracellular concentrations of ATP. The bacterial strain was treated with three radiation doses: 0.4 kGy to induce cell damage, 1.1 kGy to obtain a viable but non-culturable state, and 1.3 kGy to cause cell death. Oregano essential oil was used at 0.006 and 0.025% (wt/vol), which is the MIC. All treatments had a significant effect (P < or = 0.05) on the murein composition, although some muropeptides did not seem to be affected by the treatment. Each treatment had a different effect on the relative percentage and number of muropeptides. There was a significant correlation (P < or = 0.05) between the decrease in intracellular ATP and the increase in extracellular ATP following treatment of the cells with oregano oil. The reduction of intracellular ATP was even more important when oregano oil was combined with irradiation, but irradiation alone at a high dose (< or = 1.1 kGy) significantly decreased (P < or = 0.05) the internal ATP without affecting the external ATP. Transmission electron microscopic examination revealed that oregano oil and irradiation have an effect on cell wall structure.