Anthocyanin extract from Lycium ruthenicum enhanced production of biomass and polysaccharides during submerged fermentation of Agaricus bitorquis (Quél.) Sacc. Chaidam.

Agaricus bitorquis (Quél.) Sacc. Chaidam (ABSC) is a wild edible fungus uniquely found in the Tibet Plateau. ABSC is rich in polysaccharides that are considered biologically active. This study aimed to determine the feasibility of enhancing exopolysaccharide (EPS) production by ABSC in shake flask culture by supplementing the fermentation medium with anthocyanin extract. Different concentrations of Lycium ruthenicum Murr. (LRM) anthocyanin crude extract were tested on ABSC fermentation. The activity of phosphoglucose isomerase (PGI), phosphoglucose mutase (PGM), and phosphomannose isomerase (PMI), enzymes presumably involved in EPS synthesis by ABSC, was determined. ABSC transcriptomic profile in response to the presence of anthocyanins during fermentation was also investigated. LRM anthocyanin crude extract (0.06 mg/mL) was most effective in increasing EPS content and mycelial biomass (by 208.10% and 105.30%, respectively, P < 0.01). The activity of PGI, PGM, and PMI was increased in a medium where LRM anthocyanin extract and its main components (proanthocyanidins and petunia anthocyanin) were added. RNA-Seq analysis showed that 349 genes of ABSC were differentially expressed during fermentation in the medium containing anthocyanin extract of LRM; 93 genes were up-regulated and 256 genes down-regulated. From gene ontology enrichment analysis, differentially expressed genes were mostly assigned to carbohydrate metabolism and signal transduction categories. Collectively, LRM anthocyanins extract positively affected EPS production and mycelial biomass during ABSC fermentation. Our study provides a novel strategy for improving EPS production and mycelial growth during ABSC liquid submerged fermentation.

Statistical Optimization of Polysaccharides Production by the Lingzhi or Reishi Medicinal Mushroom Ganoderma lucidum (Agaricomycetes) in Solid-State Fermentation Using Highland Barley Grains.

Ganoderma lucidum is a widely used medicinal mushroom in traditional Chinese medicine that creates a diverse set of bioactive compounds. Highland barley, a typical nutrition-balanced crop, is not convenient for direct consumption but its nutritional characteristics meet the modern requirements of health food. In the present study, barley grains were used as substrates on solid-state fermentation (SSF) of G. lucidum. Statistical optimization of media composition was employed for enhancing the production of polysaccharides. Peptone, medlar, and KH2PO4 were identified as the most important components for producing polysaccharide. Based on the one-factor-at-a-time experimentation, a quadratic regression model with the polysaccharide contents as the response value was established by central composite design (CCD). The results showed that the predicted variables were 2.38% peptone, 1.14% medlar, and 0.25% KH2PO4 for the maximum yield of predicted polysaccharides of 11.64% in the fermented substrate. The experimental polysaccharides obtained using the predicted optimum media composition constituted 11.61% of the fermented substrate, which validates the high degree of accuracy of optimization for enhanced production of polysaccharides by SSF. This study suggested that in the process of barley grains fermentation by G. lucidum for polysaccharides production, the optimized SSF substrate consists of 71.4% barley grains, 2.38% peptone, 1.14% medlar, 0.25% KH2PO4, 2.5% glucose, 0.25% MgSO4 · 7H2O, and 1% CaCO3. According to this study, the strain G. lucidum 00679 showed a good fermentation property by optimizing the media. It might be a candidate industrial strain for further process optimization and scale-up study.

Enhanced ß-glucan and pullulan production by Aureobasidium pullulans with zinc sulfate supplementation.

The effects of mineral salts on the production of exopolysaccharides, including ß-glucan and pullulan, by Aureobasidium pullulans CCTCC M 2012259 were investigated. Zinc sulfate at certain concentrations decreased dry biomass but favored to the biosynthesis of both exopolysaccharides. When 100 mg/L zinc sulfate was added to the fermentation medium, production of ß-glucan and pullulan increased by 141.7 and 10.2%, respectively, when compared with that noted in the control without zinc sulfate addition. To reveal the physiological mechanism underlying improved ß-glucan and pullulan production, key enzymes activities, energy metabolism substances, intracellular uridine diphosphate glucose (UDPG) levels, and gene expression were determined. The results indicated that zinc sulfate up-regulated the transcriptional levels of pgm1, ugp, fks, and kre6 genes, increased activities of key enzymes involved in the biosynthesis of UDPG, ß-glucan and pullulan, enhanced intracellular UDPG content, and improved energy supply, all of which contributed to the increment in ß-glucan and pullulan production. The present study not only provides a feasible approach to improve the production of exopolysaccharides but also contributes to better understanding of the physiological characteristics of A. pullulans.

Green synthesized silver nanoparticles demonstrating enhanced in vitro and in vivo antibiofilm activity against Candida spp.

Candida species are opportunistic fungal pathogens, which are known for their biofilm associated infections on implanted medical devices in clinical settings. Broad spectrum usage of azole groups and other antifungal agents leads to the occurrence of drug resistance among Candida species. Most of the antifungal agents have failed to treat the biofilm mediated Candida infections. In the present study, silver nanoparticles (AgNPs) were synthesized using Dodonaea viscosa and Hyptis suoveolens methanolic leaf extracts and characterized by ultraviolet-visible absorption spectroscopy, X-ray diffraction analysis, Fourier transform infrared spectroscopy and Scanning electron microscopy, Dynamic light scattering, and Zeta potential analysis. The main goal of this study was to assess the AgNPs for their antibiofilm efficacy against Candida spp. through microscopic analysis and in vitro virulence assays. The results revealed that AgNPs strongly inhibited more than 80% biofilm formed by Candida spp. Furthermore, the AgNPs also reduced the yeast-to-hyphal transition, exopolysaccharide biosynthesis, secreted aspartyl proteinase production which are the major virulence factors of Candida species. This study reveals that biosynthesized AgNPs can be considered for the treatment of biofilm related Candida infections.

Effect of heat stress on production and in-vitro antioxidant activity of polysaccharides in Ganoderma lucidum.

Ganoderma lucidum is a traditional Chinese medicine, and its polysaccharides possess diverse and significant pharmacological activities. This study aimed to investigate the polysaccharide production, molecular characteristics and in-vitro antioxidant activity of G. lucidum fruiting body after the mushroom was harvested and treated with heat stress (HS). HS enhanced the production of polysaccharides after harvest and treatment of 42 °C HS for 2 h, and that resulted in the highest polysaccharide yield of 10.50%, which was 45.63% higher than that of the control, while 37, 45 °C HS had no significant effect on the production. In terms of molecular characteristics, 42 °C HS significantly changed monosaccharide ratio of polysaccharides, but no apparent molecular weight and functional group changes were found in polysaccharides after HS treatment. The results of in-vitro antioxidant activity assay revealed that 42 °C HS significantly improved the antioxidant activities of polysaccharides at the concentration of 2 mg/mL. In conclusion, this study provides a promising strategy to improve the production of G. lucidum fruiting body polysaccharides.

Sucrose fed-batch strategy enhanced biomass, polysaccharide, and ganoderic acids production in fermentation of Ganoderma lucidum 5.26.

Ganoderma, as a Chinese traditional medicine, has multiple bioactivities. However, industrial production was limited due to low yield during Ganoderma fermentation. In this work, sucrose was found to greatly enhance intracellular polysaccharide (IPS) content and specific extracellular polysaccharide (EPS) production rate. The mechanism was studied by analyzing the activities of enzymes related to polysaccharide biosynthesis. The results revealed that sucrose regulated the activities of phosphoglucomutase and phosphoglucose isomerase. When glucose and sucrose mixture was used as carbon source, biomass, polysaccharide and ganoderic acids (GAs) production was greatly enhanced. A sucrose fed-batch strategy was developed in 10-L bioreactor, and was scaled up to 300-L bioreactor. The biomass, EPS and IPS production was 25.5, 2.9 and 4.8 g/L, respectively, which was the highest biomass and IPS production in pilot scale. This study provides information for further understanding the regulation mechanism of Ganoderma polysaccharide biosynthesis. It demonstrates that sucrose fed-batch is a useful strategy for enhancing Ganoderma biomass, polysaccharide and GAs production.

Effect of Carbon Source on Properties and Antioxidant Potential of Exopolysaccharides Produced by Trametes robiniophila (Higher Basidiomycetes).

The effects of carbon source on properties and antioxidant potential of exopolysaccharides (EPS) produced by Trametes robiniophila were investigated in this study. The results indicated that the EPS production varied with five different carbon sources. The predominant carbohydrate compositions in EPSs identified were glucose and mannose. Then, FT-IR spectral analysis revealed prominent characteristic groups in the EPSs. Furthermore, thermogravimetric analysis (TGA) indicated the EPS with lactose as the carbon source showed different degradation behavior as compared to the other four EPSs, probably due to larger ribose content as one of major monosaccharides in the EPS. The variation also affects the antioxidant activities investigated by using hydroxyl and DPPH radical scavenging assay. Sucrose was the best carbon source from the viewpoint of antioxidant activity due to the relatively high xylose content in the EPS.

Ultrastructural changes in the mycelium of Hericium erinaceum (Bull.; Fr.) Pers. under selenium-induced oxidative stress.

BACKGROUND: In this study we examined the influence of various forms of selenium (organic and inorganic) on the vivacity of Hericium erinaceum mycelium and structural changes and ultrastructure occurring during its development in submerged culture. RESULTS: The mycelium was grown on sodium selenite (Na2SeO3), Selol (with 20 and 50 g kg⁻¹ Se, respectively) and a mixture of Na2SeO3 and Selol. Samples of the mycelium were collected on day 3 and day 24 of the incubation and viewed under an electron microscope. Selol at concentration 20 g kg⁻¹ did not cause any damage to the cell ultrastructure, but it contributed to the thickening of the cell wall, which implied an influence on polysaccharide production. In the other cases, degradation changes appeared in the protoplasm and the thickness of the cell wall did not increase. CONCLUSION: The nature of the effect exerted by various sources of selenium in the culture medium on the formation of polysaccharides probably results from the differences in their chemical composition and differences in the toxicity of these compounds towards the cells, but is also connected with the decomposition of the wall surrounding degraded fungal cells.

Optimization for production of exopolysaccharides with antitumor activity in vitro from Paecilomyces hepiali.

In the present study, optimal medium for the growth of mycelia and the production of exopolysaccharides from Paecilomyces hepiali HN1 (PHEPS) in submerged culture was investigated. As a result, the maximum production of mycelia (12.98 ± 0.14 g/L) and PHEPS (5.33 ± 0.11 g/L) were achieved under the optimal medium of sucrose 46.08 g/L, yeast extract 4.71 g/L, (NH4)2SO4 5.72 g/L, KH2PO4 1.70 g/L, CaCl2 0.50 g/L, MgSO4 0.50 g/L, potato extract 1% and malt extract 1%. Furthermore, the antitumor activity of PHEPS in vitro was evaluated by using three cell lines of human liver tumor HepG2 cells, breast cancer MCF-7 cells and cervical cancer Hela cells. It was found that PHEPS exhibited relative higher anti-proliferative activity against HepG2 cells than MCF-7 cells and Hela cells. At a concentration of 500 µg/mL and 72 h treatment, the inhibition rate of PHEPS on HepG2 cells reached to 62.58%. All these results suggested that PHEPS could be explored as novel natural antitumor agent with great potential application.

Fermentation characteristics in stirred-tank reactor of exopolysaccharides with hypolipidemic activity produced by Pleurotus geesteranus 5#.

In this study, the hypolipidemic effect of exopolysaccharides (EPS) from Pleurotus geesteranus 5# fermenting liquor by the optimal culture conditions in a 5-L stirred-tank reactor was investigated. The hypolipidemic effect of the polysaccharide, investigated in streptozotocin induced diabetic mice, decreased plasma glucose, total cholesterol and triacylglycerol concentrations by 17.1 %, 18.8 % and 12.0 %, respectively. The results of the present investigation strongly demonstrate the potential of this polysaccharide to prevent hyperglycemia in the experimental animals. Under optimal culture conditions, the maximum concentrations of mycelial and EPS were 22.63 g/L after 7 d cultivation and 11.09 g/L after 10 d, respectively. Furthermore, the morphological parameters (i.e. mean diameter, circularity, roughness and compactness) of the pellets and the broth viscosity were characterized. It was proved that compactness of the pellet morphology (R²=0.963, p<0.01) was significantly and positively determined with mycelial biomass. Moreover, mean diameter (R²=93.3, p<0.01) and broth viscosity (R²=0.950, p<0.01) were significantly and positively determined with EPS content.