RESUMEN
Although commercial broiler feed is usually differently conditioned before pelleting, the nutritional consequences of fine grinding or expanding as pre-pelleting treatments are poorly defined so far. Therefore, the effects of these two pre-treatments on nutrient digestibility, broiler performance and digestive tract of broilers were tested. In order to investigate possible interactions between pre-treatments and diet composition two diets differing in rapeseed expeller proportion were tested in a two by two factorial design. Thus, four diets were designed including two diets containing 6% rapeseed expeller (RSE) which were pre-treated by fine grinding (6%FgP) or expanding (6%ExP), and two corresponding diets containing 12% RSE (12%FgP and 12%ExP). For the experiments, 864 male broilers were used. There was a significant diet-by-technical feed treatment (TFT) interaction in case of the digestibility of all considered crude nutrients (p < 0.05). Diet 6%ExP showed higher crude protein digestibility compared to other feeds (p < 0.001). The highest digestibility of organic matter, ether extract, crude fibre and N-free extractives achieved diet 12%FgP. Diets 6%ExP and 12%FgP showed higher N-corrected metabolisable energy content (p < 0.001). TFT affected daily feed intake (DFI) and body weight (BW) gain in a diet-dependent manner (p < 0.001). Feeding of 6%FgP enhanced DFI and BW gain compared to other feeds but 6%ExP reduced both parameters (p < 0.001). Weights of proventriculi and gizzards of animals fed 6%ExP were increased compared with 6%FgP (p < 0.01). In contrast, proventricular length in animals fed 6%FgP was increased compared with diet 6%ExP (p = 0.042). Moreover, animals fed 6%FgP had wider proventriculi than animals fed 12%FgP (p = 0.023). Feed 6%ExP increased proventricular weight compared to 12%ExP (p = 0.001). With regard to the strong relationships between diet and TFT no specific processing method can be recommended according to considered nutritional aspects. A marked prevention of proventricular dilatation due to pellet feeding could not be realised by various used TFT or feed formulations. Used amounts of RSE had no obvious adverse effects on considered nutritional aspects.
Asunto(s)
Alimentación Animal/análisis , Brassica napus/química , Brassica rapa/química , Pollos/fisiología , Dieta/veterinaria , Fenómenos Fisiológicos Nutricionales de los Animales , Animales , Relación Dosis-Respuesta a Droga , Tracto Gastrointestinal/fisiología , MasculinoRESUMEN
The aim of the experiment on 100 cross-bred barrows was to compare commercial diets for fattening pigs based on either soya bean meal (SBM) imported from non-European countries with diets based on a mixture of locally produced rape seed meal, distillers' dried grains with solubles and soya beans as main protein sources. In addition, these both types of diets were processed by two different technical feed treatments, i.e. coarse grinding without hydrothermal treatment or fine grinding and pelleting. With only few exceptions, nutrients of the diet without SBM were more digestible (p < 0.05) resulting in a higher metabolisable energy (ME) content. Fine grinding and pelleting increased also the ME content and the nutrient digestibility with the exception of crude fibre. Higher feed intake of animals that fed diets without SBM (p < 0.01) resulted in higher average daily gain (p < 0.01). However feeding this diet, the higher digestibility was not reflected in a decreased feed-to-gain ratio (FGR), but fine grinding and pelleting reduced FGR (p < 0.001). A higher pH value and a lower DM content of caecal chymus were detected in animals that received coarsely ground feed (p < 0.05). Animals that fed finely ground and pelleted feed had higher slaughter and relative liver weights and higher blood cholesterol concentrations (p = 0.040). The urea concentrations of blood were lower (p = 0.019) after feeding diets without SBM. In conclusion, SBM imported from non-European countries can be replaced by alternative local protein sources without compromising digestibility or performances of animals. Although fine grinding and thermal treatment particularly seemed to be advantageous for digestibility and performance, the possible risk of development of stomach lesions should be considered.
Asunto(s)
Alimentación Animal/análisis , Fenómenos Fisiológicos Nutricionales de los Animales/fisiología , Dieta/veterinaria , Proteínas en la Dieta/metabolismo , Digestión/fisiología , Manipulación de Alimentos/métodos , Sus scrofa/fisiología , Animales , Brassica rapa/química , Proteínas en la Dieta/clasificación , Grano Comestible/química , Europa (Continente) , Masculino , Glycine max/química , Sus scrofa/crecimiento & desarrolloRESUMEN
Effects of grinding and hydro-thermal treatment of feed on growth performance, slaughter traits, nutrient digestibility, stomach content and stomach health were examined by using 96 crossbred fattening pigs. Pigs were fed a grain-soybean meal-based diet processed by various technical treatments. Feeding groups differed in particle size after grinding (finely vs. coarsely ground feed) and hydro-thermal treatment (without hydro-thermal treatment, pelleting, expanding, expanding and pelleting). Fine grinding and hydro-thermal treatment showed significant improvements on the digestibility of crude nutrients and content of metabolisable energy. Hydro-thermal treatment influenced average daily gain (ADG) and average daily feed intake (DFI) significantly. Finely ground pelleted feed without expanding enhanced performances by increasing ADG and decreasing feed-to-gain ratio (FGR) of fattening pigs. Coarsely ground feed without hydro-thermal treatment resulted in the highest ADG and DFI, however also in the highest FGR. Expanded feed decreased DFI and ADG. Slaughter traits were not affected by treatments. Coarsely ground feed without hydro-thermal treatment had protective effects on the health of gastric pars nonglandularis, however, pelleting increased gastric lesions. Hydro-thermal treatment, especially expanding, resulted in clumping of stomach content which possibly induced satiety by slower ingesta passage rate and thus decreased feed intake. Pigs fed pelleted feed showed less pronounced development of clumps in stomach content compared with expanded feed.
Asunto(s)
Alimentación Animal/análisis , Digestión , Manipulación de Alimentos/métodos , Sus scrofa/fisiología , Alimentación Animal/economía , Fenómenos Fisiológicos Nutricionales de los Animales , Animales , Dieta/veterinaria , Manipulación de Alimentos/economía , Contenido Digestivo/química , Tamaño de la Partícula , Sus scrofa/crecimiento & desarrolloRESUMEN
Pelleted feed is associated with improved broiler performance but also with a higher incidence of proventricular dilatation and ascites. The present study aimed to investigate influences of expanded and pelleted (ExP) or finely ground and pelleted feeds (FgP) containing either 6% rapeseed expeller (RSE) or 12% RSE on these adverse effects by studying performance, visceral organ, and immunological traits in 36 broilers. ExP reduced daily feed intake compared to FgP when feeding a 6% RSE diet (P < 0.05) but did not affect the daily feed intake when feeding a 12% RSE diet, which was also reflected in the body weight gain. There were no significant differences in the size of proventriculus and gizzard between feeding groups but significant diet-by-technical feed treatment interactions in case of proventricular and gizzard weights and the proventricular length (P < 0.05). Proventriculi and gizzards were heavier in birds fed 6%ExP than proventriculi or gizzards of animals from all other groups except for birds of the group 12%FgP. A total of three animals (1 from 6%ExP, 1 from 6%FgP, and 1 from 12%ExP) developed ascites during the study. Pooled LsMeans of peripheral blood leucocyte proportions of CD3+/CD4-/CD8- cells were increased in birds fed FgP compared to birds fed ExP (P = 0.048). Pooled LsMeans of CD3+/CD4+/CD8+ T cell subsets in jejunal lamina propria were higher in birds fed 12% RSE compared to birds fed 6% RSE (P = 0.024). Concluding, technical feed treatment or diet did not inhibit adverse effects of pelleting on gizzard and proventricular development. Morphometric alterations of proventriculus and gizzard might modify the local immune system of the distal digestive tract and promote the development of ascites; however, further studies are required to confirm this hypothesis since in the present study only three birds developed ascites.
RESUMEN
Influences of feed particle size (coarse, fine) and hydro-thermal processing methods (HTPM) (without-non-compacted feed, pelleting, expanding and pelleting) on feeding value and the performance and digestive tract of 624 broilers were studied. HTPM increased the starch disintegration of feed. Starch disintegration and electron microscopy indicated the highest degree of starch modification in expanded and pelleted feed. HTPM affected ether extract digestibility (p < 0.05). A grinding-by-HTPM interaction was found in case of crude protein digestibility (p = 0.008). Non-compacted feed reduced daily feed intake (DFI) and body weight gain and increased the feed to gain ratio compared to compacted feeds (p < 0.001). Compacted feeds increased proventricular size and the risk of Isthmus gastrici dilatation compared to coarsely ground non-compacted feed, except for finely ground expanded and pelleted feed. Finely ground feed reduced proventricular weights compared to coarsely ground feed and pelleted feed compared to other feeds. Non-compacted feed increased gizzard weights compared to compacted feeds. Relationships between proventricular size and Isthmus gastrici dilatation and the DFI were detected. Summarizing, the beneficial effects of pelleted feed were mainly based on the reduction of feed wastage and selection. However, the high DFI caused by pellet feeding is also a main risk factor for proventricular dilatation.