Systematic evaluation of characteristics of the membrane-based fed-batch shake flask.

BACKGROUND: The initial part of process development involves extensive screening programs to identify optimal biological systems and cultivation conditions. For a successful scale-up, the operation mode on screening and production scale must be as close as possible. To enable screening under fed-batch conditions, the membrane-based fed-batch shake flask was developed. It is a shake flask mounted with a central feed reservoir with an integrated rotating membrane tip for a controlled substrate release. Building on the previously provided proof of principle for this tool, this work extends its application by constructive modifications and improved methodology to ensure reproducible performance. RESULTS: The previously limited operation window was expanded by a systematic analysis of reservoir set-up variations for cultivations with the fast-growing organism Escherichia coli. Modifying the initial glucose concentration in the reservoir as well as interchanging the built-in membrane, resulted in glucose release rates and oxygen transfer rate levels during the fed-batch phase varying up to a factor of five. The range of utilizable membranes was extended from dialysis membranes to porous microfiltration membranes with the design of an appropriate membrane tip. The alteration of the membrane area, molecular weight cut-off and liquid volume in the reservoir offered additional parameters to fine-tune the duration of the initial batch phase, the oxygen transfer rate level of the fed-batch phase and the duration of feeding. It was shown that a homogeneous composition of the reservoir without a concentration gradient is ensured up to an initial glucose concentration of 750 g/L. Finally, the experimental validity of fed-batch shake flask cultivations was verified with comparable results obtained in a parallel fed-batch cultivation in a laboratory-scale stirred tank reactor. CONCLUSIONS: The membrane-based fed-batch shake flask is a reliable tool for small-scale screening under fed-batch conditions filling the gap between microtiter plates and scaled-down stirred tank reactors. The implemented reservoir system offers various set-up possibilities, which provide a wide range of process settings for diverse biological systems. As a screening tool, it accurately reflects the cultivation conditions in a fed-batch stirred tank reactor and enables a more efficient bioprocess development.

An insight into the heat and mass transfer mechanisms of eggshells hatching broiler chicks and its effects to the hatcher environment.

Thermodynamic study of incubated eggs is an important component in the optimisation of incubation processes. However, research on the interaction of heat and moisture transfer mechanisms in eggs is rather limited and does not focus on the hatching stage of incubation. During hatch, both the recently hatched chick and the broken eggshell add extra heat and moisture contents to the hatcher environment. In this study, we have proposed a novel way to estimate thermodynamically the amount of water evaporated from a broken eggshell during hatch. The hypothesis of this study considers that previously reported drops in eggshell temperature during hatching of chicks is the result remaining water content evaporating from the eggshell, released on the inner membrane by the recently hatched wet chick, just before hatch. To reproduce this process, water was sprayed on eggshells to mimic the water-fluid from the wet body of a chick. For each sample of eggshell, the shell geometry and weight, surface area and eggshell temperature were measured. Water evaporation losses and convection coefficient were calculated using a novel model approach considering the simultaneous heat and mass transfer profiles in an eggshell. The calculated average convective coefficient was 23.9 ± 7.5 W/m(2) °C, similar to previously reported coefficients in literature as a function of 0.5-1m/s air speed range. Comparison between measured and calculated values for the water evaporation showed 68% probability accuracy, associated to the use of an experimentally derived single heat transfer coefficient. The results support our proposed modelling approach of heat and mass transfer mechanisms. Furthermore, by estimating the amount of evaporated water in an eggshell post-hatch, air humidity levels inside the hatcher can be optimised to ensure wet chicks dry properly while not dehydrating early hatching chicks.

Effect of species-specific sound stimulation on the development and hatching of broiler chicks.

1. Previous research has reported that chicken embryos develop a functionary auditory system during incubation and that prenatal sound may play an important role in embryo development and alter the hatch time. In this study the effects of prenatal auditory stimulation on hatch process, hatch performance, the development of embryo and blood parameters were investigated. 2. Four batches of Ross 308 broiler breeder eggs were incubated either in control or in sound-stimulated groups. The sound-stimulated embryos were exposed to a discontinuous sound of species-specific calls by means of a speaker at 72 dB for 16 h a day: maternal calls from d 10 to d 19 of incubation time and embryo/chick calls from d 19 until hatching. The species-specific sound was excluded from the control group. 3. The onset of hatch was delayed in the sound-stimulated group compared to the controls. This was also supported by comparison of the exact hatching time of individual focal chicks within the two groups. However, the sound-stimulated embryos had a lower hatchability than the control group, mainly due to significantly increased numbers of late deaths. 4. The embryos exhibited a similar growth pattern between the sound-stimulated group and the control group. Although sound exposure decreased body weight at d 16, no consistent effect of sound on body weight at incubation stage was observed. Species-specific sound stimulation also had no impact on chick quality, blood values and plasma corticosterone concentrations during hatch.

Higher levels of CO2 during late incubation alter the hatch time of chicken embryos.

1. It has been reported that the increasing CO2 tension triggers the embryo to pip the air cell and emerge from the egg. However, the mechanism by which higher CO2 concentrations during the last few days of incubation affect chick physiology and the hatching process is unclear. This study investigated the effect of CO2 concentrations up to 1% during pipping, on the onset and length of the hatch window (HW) and chick quality. 2. Four batches of Ross 308 broiler eggs (600 eggs per batch) were incubated in two small-scale custom-built incubators (Petersime NV). During the final 3 d of incubation, control eggs were exposed to a lower CO2 concentration (0.3%), while the test eggs experienced a higher CO2 concentration programme (peak of 1%). 3. There were no significant differences in blood values, organ weight and body weight. There was also no difference in hatchability between control and test groups. However, a small increase in the chick weight and the percentage of first class chicks was found in the test groups. Furthermore, plasma corticosterone profiles during hatching were altered in embryos exposed to higher CO2; however, they dropped to normal levels at d 21 of incubation. Importantly, the hatching process was delayed and synchronised in the test group, resulting in a narrowed HW which was 2.7 h shorter and 5.3 h later than the control group. 4. These results showed that exposing chicks to 1% CO2 concentration during pipping did not have negative impacts on physiological status of newly hatched chicks. In addition, it may have a significant impact on the physiological mechanisms controlling hatching and have benefits for the health and welfare of chickens by reducing the waiting time after hatching.

The effect of routine hoof trimming on locomotion score, ruminating time, activity, and milk yield of dairy cows.

The objective of this study was to quantify the effect of hoof trimming on cow behavior (ruminating time, activity, and locomotion score) and performance (milk yield) over time. Data were gathered from a commercial dairy farm in Israel where routine hoof trimming is done by a trained hoof trimmer twice per year on the entire herd. In total, 288 cows spread over 6 groups with varying production levels were used for the analysis. Cow behavior was measured continuously with a commercial neck activity logger and a ruminating time logger (HR-Tag, SCR Engineers Ltd., Netanya, Israel). Milk yield was recorded during each milking session with a commercial milk flow sensor (Free Flow, SCR Engineers Ltd.). A trained observer assigned on the spot 5-point locomotion scores during 19 nighttime milking occasions between 22 October 2012 and 4 February 2013. Behavioral and performance data were gathered from 1wk before hoof trimming until 1wk after hoof trimming. A generalized linear mixed model was used to statistically test all main and interactive effects of hoof trimming, parity, lactation stage, and hoof lesion presence on ruminating time, neck activity, milk yield, and locomotion score. The results on locomotion scores show that the proportional distribution of cows in the different locomotion score classes changes significantly after trimming. The proportion of cows with a locomotion score ≥3 increases from 14% before to 34% directly after the hoof trimming. Two months after the trimming, the number of cows with a locomotion score ≥3 reduced to 20%, which was still higher than the baseline values 2wk before the trimming. The neck activity level was significantly reduced 1d after trimming (380±6 bits/d) compared with before trimming (389±6 bits/d). Each one-unit increase in locomotion score reduced cow activity level by 4.488 bits/d. The effect of hoof trimming on ruminating time was affected by an interaction effect with parity. The effect of hoof trimming on locomotion scores was affected by an interaction effect with lactation stage and tended to be affected by interaction effects with hoof lesion presence, indicating that cows with a lesion reacted different to the trimming than cows without a lesion did. The results show that the routine hoof trimming affected dairy cow behavior and performance in this farm.

Lameness detection based on multivariate continuous sensing of milk yield, rumination, and neck activity.

The objective of this study was to develop and validate a mathematical model to detect clinical lameness based on existing sensor data that relate to the behavior and performance of cows in a commercial dairy farm. Identification of lame (44) and not lame (74) cows in the database was done based on the farm's daily herd health reports. All cows were equipped with a behavior sensor that measured neck activity and ruminating time. The cow's performance was measured with a milk yield meter in the milking parlor. In total, 38 model input variables were constructed from the sensor data comprising absolute values, relative values, daily standard deviations, slope coefficients, daytime and nighttime periods, variables related to individual temperament, and milk session-related variables. A lame group, cows recognized and treated for lameness, to not lame group comparison of daily data was done. Correlations between the dichotomous output variable (lame or not lame) and the model input variables were made. The highest correlation coefficient was obtained for the milk yield variable (rMY=0.45). In addition, a logistic regression model was developed based on the 7 highest correlated model input variables (the daily milk yield 4d before diagnosis; the slope coefficient of the daily milk yield 4d before diagnosis; the nighttime to daytime neck activity ratio 6d before diagnosis; the milk yield week difference ratio 4d before diagnosis; the milk yield week difference 4d before diagnosis; the neck activity level during the daytime 7d before diagnosis; the ruminating time during nighttime 6d before diagnosis). After a 10-fold cross-validation, the model obtained a sensitivity of 0.89 and a specificity of 0.85, with a correct classification rate of 0.86 when based on the averaged 10-fold model coefficients. This study demonstrates that existing farm data initially used for other purposes, such as heat detection, can be exploited for the automated detection of clinically lame animals on a daily basis as well.

Analysis of individual classification of lameness using automatic measurement of back posture in dairy cattle.

Currently, diagnosis of lameness at an early stage in dairy cows relies on visual observation by the farmer, which is time consuming and often omitted. Many studies have tried to develop automatic cow lameness detection systems. However, those studies apply thresholds to the whole population to detect whether or not an individual cow is lame. Therefore, the objective of this study was to develop and test an individualized version of the body movement pattern score, which uses back posture to classify lameness into 3 classes, and to compare both the population and the individual approach under farm conditions. In a data set of 223 videos from 90 cows, 76% of cows were correctly classified, with an 83% true positive rate and 22% false positive rate when using the population approach. A new data set, containing 105 videos of 8 cows that had moved through all 3 lameness classes, was used for an ANOVA on the 3 different classes, showing that body movement pattern scores differed significantly among cows. Moreover, the classification accuracy and the true positive rate increased by 10 percentage units up to 91%, and the false positive rate decreased by 4 percentage units down to 6% when based on an individual threshold compared with a population threshold.

Embryonic development and the physiological factors that coordinate hatching in domestic chickens.

Embryonic growth and development is influenced by both endogenous and exogenous factors. The purpose of this review is to discuss the critical stages of chick embryonic development in relation to functional maturation of numerous organ systems, the acquisition of thermoregulation, and the hatching process. In addition, the mechanism of hatching, including sound synchronization and hormonal and environmental stimulation, will be discussed. Finally, the importance of effective hatching synchronization mechanisms will also be highlighted.

Effect of transportation duration of 1-day-old chicks on postplacement production performances and pododermatitis of broilers up to slaughter age.

This experiment studied the effect of transportation duration of 1-d-old chicks on dehydration, mortality, production performance, and pododermatitis during the growout period. Eggs from the same breeder flock (Ross PM3) were collected at 35, 45, and 56 wk of age, for 3 successive identical experiments. In each experiment, newly hatched chicks received 1 of 3 transportation duration treatments from the hatchery before placement in the on-site rearing facility: no transportation corresponding to direct placement in less than 5 min (T00), or 4 (T04) or 10 h (T10) of transportation. The chicks were housed in 35-m(2) pens (650 birds each) and reared until 35 d old. Hematocrit and chick BW were measured on sample chicks before and after transportation. During the growout period, bird weight, feed uptake, and feed conversion ratio were measured weekly until slaughter. Transportation duration affected BW; T00 groups had a significantly higher BW than T04 and T10 transported birds but this effect lasted only until d 21. No clear effect on hematocrit, feed uptake, feed conversion ratio, or mortality was observed for birds transported up to 10 h. The decrease in weight in T10 birds was associated with less severe pododermatitis. Increasing age of the breeder flock was correlated with reduced egg fertility and hatchability, and also with higher quality and BW of hatched chicks. Chicks from older breeders also exhibited reduced mortality during the growout period.

Monitoring the hatch time of individual chicken embryos.

This study investigated variations in eggshell temperature (T(egg)) during the hatching process of broiler eggs. Temperature sensors monitored embryo temperature by registering T(egg) every minute. Measurements carried out on a sample of 40 focal eggs revealed temperature drops between 2 to 6°C during the last 3 d of incubation. Video cameras recorded the hatching process and served as the gold standard reference for manually labeling the hatch times of chicks. Comparison between T(egg) drops and the hatch time of individuals revealed a time synchronization with 99% correlation coefficient and an absolute average time difference up to 25 min. Our findings suggest that attaching temperature sensors to eggshells is a precise tool for monitoring the hatch time of individual chicks. Individual hatch monitoring registers the biological age of chicks and facilitates an accurate and reliable means to count hatching results and manage the hatch window.

[Results of a structural diagnosis of patients with chronic dyspnoea recruited from two cardiological practices]. / Ergebnisse einer strukturierten Diagnostik bei Patienten mit chronischer Dyspnoe in zwei kardiologischen Facharztpraxen.

While well validated algorithms exist for the diagnosis of patients with acute dyspnoea, such generally valid procedural instructions are lacking for patients with chronic dyspnoea. The diagnostic approach presented here is based on investigations of 246 patients with chronic dyspnoea recruited from two cardiological practices using a self-developed multi-level procedure. Besides anamnestic and clinical examinations, different diagnostic procedures, available in the ambulant range, are included. The results suggest that in over 50 % of the cases the cause of chronic dyspnoea can be determined from anamnestic and clinical examinations as well as from electrocardiogram and echocardiography. Additional inclusion of lung function and capillary blood gas analysis permitted a sufficient clarification in over 80 % of the cases. In a further step, cardiopulmonary exercise testing clarified the reasons for chronic dyspnoea in approximately 10 % of the remaining patients. Threshold values of lung function parameters as used for the differentiation of acute dyspnoea, do not seem suitable for the diagnosis of patients with chronic dyspnoea. By means of a simple step-wise diagnostic algorithm, applicable under ambulant conditions, the cause of chronic dyspnoea could sufficiently be clarified in more than 95 % of the cases.

Automatic measurement of touch and release angles of the fetlock joint for lameness detection in dairy cattle using vision techniques.

This paper describes a synchronized measurement system combining image and pressure data to automatically record the angle of the metacarpus and metatarsus bones of the cow with respect to a vertical line, which is useful for lameness detection in dairy cattle. A camera system was developed to record the posture and movement of the cow and the timing and position of hoof placement and release were recorded using a pressure sensitive mat. Experiments with the automatic system were performed continuously on a farm in Ghent (Belgium) for 5 wk in September and October 2009. In total, 2,219 measurements were performed on 75 individual lactating Holstein cows. As a reference for the analysis of the calculated variables, the locomotion of the cows was visually scored from recorded videos by a trained observer into 3 classes of lameness [53.5% were scored with gait score (GS)1, 33.3% were scored with GS2, and 9.3% were scored with GS3]. The contact data of the pressure mat and the camera images recorded by the system were synchronized and combined to measure different angles of the legs of the cows, together with the range of motion of the leg. Significant differences were found between the different gait scores in the release angles of the front hooves, in the range of motion of the front hooves, and in the touch angles of the hind hooves. The contact data of the pressure mat and the camera images recorded by the system were synchronized and combined to measure different angles of the legs of the cows, together with the range of motion of the leg. With respect to the classification of lameness, the range of motion of the front hooves (42.1 and 42.8%) and the release angle of the front hooves (41.7 and 42.0%) were important variables. In 83.3% of the cows, a change in GS led to an increase in within-cow variance for the range of motion or the release angle of the front hooves. In 76.2% of the cows, an increase in GS led to a decrease in range of motion or an increase in release angle of the front hooves.

[Number of patients with chronic dyspnea in three German specialist practices]. / Häufigkeit von Patienten mit chronischer Dyspnoe in drei deutschen Facharztpraxen.

In the second quarter 2011 the incidence of the symptoms "chronic dyspnea" among the patients in three specialist practices was determined by means of a self-developed questionnaire. 1286 anonymised questionnaires with full information could be evaluated. The proportion of the patients with a chronic dyspnea (inclusive "dyspnea and weakness feeling") in the practices amounted to between 15.3 and 57.7 %. An exclusive assessment of chronic dyspnea could be assigned to 10.4 to 31.4 % of the patients evaluated. From the view point of the treating physicians, the cause of the chronic dyspnea was sufficiently explained by the available information.

Acetaminophen: potentially toxic metabolite formed by human fetal and adult liver microsomes and isolated fetal liver cells.

A reactive metabolite of acetaminophen is hepatotoxic in humans when the drug is ingested in large overdoses. The ability of the human fetal and adult liver to oxidize acetaminophen by trapping the potentially toxic metabolite as a glutathione conjugate has been measured. Oxidation by fetal liver was approximately ten times slower than by adult liver. However, there was a definite increase in acetaminophen oxidation with fetal age. Isolated human fetal liver cells conjugated acetaminophen with sulfate but not with glucuronic acid. The results indicate that the human fetal liver is able to detoxify acetaminophen by conjugation. However, it also catalyzes the formation of an active metabolite of acetaminophen through oxidation. Hence the fetus remains at risk should a large dose of the drug cross into the fetal circulation.

SUVA as control parameter for the effective ozonation of organic pollutants in secondary effluent.

Recent research projects have shown a good suitability of the ozonation process to transform trace concentrations of most pharmaceuticals in wastewater treatment plant (WWTP) effluents. The concentrations of carbamazepine and 17 alpha-ethinylestradiol, for instance, were reduced below their detection limits by use of ozone dosages resulting in a specific ozone consumption of 0.5 mg O3/mg DOC0. At the same time a good disinfection performance was achieved. The given hygienic requirements of the EU bathing water directive (e.g. 2,000 N/100 mL faecal coliforms) are fulfilled without the formation of bromate (<10 microg/L). As technical control parameter of the ozonation process usually the residual ozone in the liquid phase or in the off-gas are used. However, at very low specific ozone consumptions, ozone reacts instantaneously with dissolved compounds and cannot be detected. Hence, alternative parameters should be used for effective operation control. The present paper evaluates the relation between UVA decrease and the removal of different compounds (endocrine disrupting compounds, pharmaceuticals, iodinated X-ray contrast media), microbial parameters and bromate formation. The results can be used as a guideline for the control of the oxidation performance at large scale ozonation units.

A decision-tree model to detect post-calving diseases based on rumination, activity, milk yield, BW and voluntary visits to the milking robot.

Early detection of post-calving health problems is critical for dairy operations. Separating sick cows from the herd is important, especially in robotic-milking dairy farms, where searching for a sick cow can disturb the other cows' routine. The objectives of this study were to develop and apply a behaviour- and performance-based health-detection model to post-calving cows in a robotic-milking dairy farm, with the aim of detecting sick cows based on available commercial sensors. The study was conducted in an Israeli robotic-milking dairy farm with 250 Israeli-Holstein cows. All cows were equipped with rumination- and neck-activity sensors. Milk yield, visits to the milking robot and BW were recorded in the milking robot. A decision-tree model was developed on a calibration data set (historical data of the 10 months before the study) and was validated on the new data set. The decision model generated a probability of being sick for each cow. The model was applied once a week just before the veterinarian performed the weekly routine post-calving health check. The veterinarian's diagnosis served as a binary reference for the model (healthy-sick). The overall accuracy of the model was 78%, with a specificity of 87% and a sensitivity of 69%, suggesting its practical value.

Lameness detection in dairy cattle: single predictor v. multivariate analysis of image-based posture processing and behaviour and performance sensing.

The objective of this study was to evaluate if a multi-sensor system (milk, activity, body posture) was a better classifier for lameness than the single-sensor-based detection models. Between September 2013 and August 2014, 3629 cow observations were collected on a commercial dairy farm in Belgium. Human locomotion scoring was used as reference for the model development and evaluation. Cow behaviour and performance was measured with existing sensors that were already present at the farm. A prototype of three-dimensional-based video recording system was used to quantify automatically the back posture of a cow. For the single predictor comparisons, a receiver operating characteristics curve was made. For the multivariate detection models, logistic regression and generalized linear mixed models (GLMM) were developed. The best lameness classification model was obtained by the multi-sensor analysis (area under the receiver operating characteristics curve (AUC)=0.757±0.029), containing a combination of milk and milking variables, activity and gait and posture variables from videos. Second, the multivariate video-based system (AUC=0.732±0.011) performed better than the multivariate milk sensors (AUC=0.604±0.026) and the multivariate behaviour sensors (AUC=0.633±0.018). The video-based system performed better than the combined behaviour and performance-based detection model (AUC=0.669±0.028), indicating that it is worthwhile to consider a video-based lameness detection system, regardless the presence of other existing sensors in the farm. The results suggest that Θ2, the feature variable for the back curvature around the hip joints, with an AUC of 0.719 is the best single predictor variable for lameness detection based on locomotion scoring. In general, this study showed that the video-based back posture monitoring system is outperforming the behaviour and performance sensing techniques for locomotion scoring-based lameness detection. A GLMM with seven specific variables (walking speed, back posture measurement, daytime activity, milk yield, lactation stage, milk peak flow rate and milk peak conductivity) is the best combination of variables for lameness classification. The accuracy on four-level lameness classification was 60.3%. The accuracy improved to 79.8% for binary lameness classification. The binary GLMM obtained a sensitivity of 68.5% and a specificity of 87.6%, which both exceed the sensitivity (52.1%±4.7%) and specificity (83.2%±2.3%) of the multi-sensor logistic regression model. This shows that the repeated measures analysis in the GLMM, taking into account the individual history of the animal, outperforms the classification when thresholds based on herd level (a statistical population) are used.

Lower-extremity amputation. Incidence, risk factors, and mortality in the Oklahoma Indian Diabetes Study.

Oklahoma Indians with NIDDM (n = 1012) underwent a baseline examination in 1972-1980. The incidence of and risk factors for first lower-extremity amputation were estimated. The mortality rates of amputees using data from 875 patients who had no previous history of amputation and who underwent follow-up examination between 1987 and 1991 are presented. The mean age of the 875 patients was 51.6 +/- 10.8 yr, and the mean duration of diabetes was 6.6 +/- 6.1 yr. After a mean follow-up time of 9.9 +/- 4.3 yr, the incidence rate of first LEA among diabetic Oklahoma Indians was 18.0/1000 person-yr. The incidence rate was two times higher in men than in women. In both sexes, significant risk factors (P < 0.05) were retinopathy and duration of diabetes. Fasting plasma glucose, use of insulin, and systolic blood pressure were significant for men only. For women, plasma cholesterol and diastolic blood pressure were additional risk factors. Compared with the mortality rate of 33.5/1000 person-yr among nonamputees, the rate among amputees was 55.5/1000 person-yr. The 5-yr survival rate after first amputation was 40.4%. For the amputees, the most common causes of death were diabetes (37.3%), cardiovascular disease (29.1%), and renal disease (7.3%). The incidence and mortality rates in diabetic Oklahoma Indians were higher than those reported in Pima Indians and other diabetic populations. To lower the incidence of lower-extremity amputation in this high-risk population, preventive action through education, foot care programs, and early detection of lesions must be intensified.

Diabetes, parental diabetes, and obesity in Oklahoma Indians.

The relationship between diabetes and parental diabetes status and obesity in Oklahoma Indians was studied. Data from 2095 adult Oklahoma Indians (1085 type II diabetic subjects and 1010 nondiabetic subjects) through a complete physical examination and personal interview showed a strong association between diabetes and parental diabetes status. Frequency of diabetes among siblings was significantly higher in families with affected parents than those without diabetic parents. No significant difference was found between families with one diabetic parent and those with two diabetic parents. The diabetic individuals were more obese than the nondiabetic individuals at age 18 and at interview. Obesity was defined as percent body mass index greater than 120. After adjusting for possible age and sex effects, the risk of diabetes for the obese was estimated as almost twice that for the nonobese.