The origin of waste activated sludge affects the enhancement of anaerobic digestion by free nitrous acid pre-treatment.

Anaerobic digestion is a common stabilization method for treating primary sludge (PS) and waste activated sludge (WAS). However, its application is often limited by the degradation of WAS. Recent studies have demonstrated FNA to be an effective pre-treatment for enhancing WAS degradability, while having limited effect on PS degradability. WAS characteristics are impacted by wastewater treatment plant (WWTP) configuration and this study is the first to compare the effectiveness of FNA pre-treatment on WAS from WWTP with and without primary treatment. In this study, WAS samples were collected from four full-scale WWTPs with or without primary treatment. Sludge characterization, biomethane potential tests and mathematical modeling were conducted to assess the impacts of FNA pre-treatment on anaerobic digestion. The results showed that FNA pre-treatment was consistently effective for WAS from different WWTPs, while the extent of enhancement varied between WWTPs. For WAS from WWTPs without primary treatment, FNA pretreatment increased the rate of hydrolysis by 54-66% compared to 22-33% increase for WAS without primary treatment. In contrast, WAS from WWTPs with primary treatment experienced greater increases in methane potential (22-24%) compared to WAS from WWTPs without primary treatment (14-16%). These variances could be associated with primary treatment impacting the wastewater COD/N ratio and thus portion of extracellular polymetric substances (EPS) and cells in WAS. FNA pre-treatment targets the destruction of polymetric substances and cells, therefore WAS with a higher proportion of cells (i.e., WAS with primary treatment) experienced greater improvements in methane yield. Similarly, greater improvements in hydrolysis rate were observed for WAS from WWTP without primary sedimentation which contain higher proportions of large EPS molecules. Despite its consistent effectiveness on WAS samples, FNA pre-treatment was ineffective for improving the digestibility of high-rate activated sludge (HRAS).

Enhancing anaerobic digestion using free nitrous acid: Identifying the optimal pre-treatment condition in continuous operation.

Free Nitrous Acid (FNA) pre-treatment is a promising technology demonstrated effective in improving waste activated sludge degradability and anaerobic digestion (AD) performance. Pre-treatment conditions including FNA concentration and treatment duration determine operational and capital cost of full-scale implementation, which have not been studied in long-term experiments. The knowledge of FNA pre-treatment conditions improving the AD performance is urgently required to determine suitable conditions for the technology implementation. In this work, five different FNA concentrations (2.2, 4.4, 7.2, 12 mgN/L and nitrite only without pH adjustment) and three treatment durations (8, 24 and 48 h) were studied in four lab-scale semi-continuous AD reactors for over 300 days. FNA pre-treatment was shown under all tested conditions effective in enhancing AD performances, while its effectiveness and resulted benefits varied substantially amongst different pre-treatment conditions. The long-term experiment demonstrated that the methane production, sludge reduction and digested sludge viscosity of AD are positively correlated with the FNA concentration and durations, until an optimal condition is reached, which was identified in this work to be FNA concentration of 7.2 mgN/L and treatment duration of 24 h. Microbial community changes supported the apparent observation of enhanced sludge degradation at elevating FNA concentrations applied during pre-treatment. The short-term sludge solubilization results were inconsistent with the long-term AD performance, which was potentially caused by inhibitions from stringent FNA pre-treatment conditions applied (FNA = 12 mgN/L with 24-hour treatment & FNA = 7.2 mgN/L with 48-hour treatment). Overall, results suggested FNA pre-treatment at the optimized condition is highly beneficial to WWTPs and competitive with other pre-treatment technologies, e.g., thermal hydrolysis pre-treatment. This work comprehensively evaluated the key design parameters of FNA pre-treatment process, reached a major milestone in the development and applications of FNA technologies.

An integrated strategy to enhance performance of anaerobic digestion of waste activated sludge.

Anaerobic digestion (AD) is an essential process in wastewater treatment plants as it can reduce the amount of waste activated sludge (WAS) for disposal, and also enables the recovery of bioenergy (i.e. methane). Here, a new pretreatment method to enhance anaerobic digestion was achieved by treating thickened WAS (TWAS) with ferric (as FeCl3) and nitrite simultaneously for 24-hour at room temperature. Biochemical methane potential tests showed markedly improved degradability in the pretreated TWAS, with a relative increase in hydrolysis rate by 30%. A comparative experiment with the operation of two continuous-flow anaerobic digesters further demonstrated the improvement in biogas quantity and quality, digestate disposal, and phosphorus recovery in the experimental digester. The dosed FeCl3 (i.e. ~6 mM) decreased the pH of TWAS to ~5, which led to the formation of free nitrous acid (FNA, HNO2) at parts per million levels (i.e. ~6 mg N/L), after dosing nitrite at 250 mg NO2--N/L. This FNA treatment caused a 26% increase in methane yield and volatile solids destruction, 55% reduction in the viscosity of sludge in digester, and 24% less polymer required in further digestate dewatering. In addition, the dosed Fe(III) was reduced to Fe(II) which precipitated sulfide and phosphorus, leading to decreased hydrogen sulfide concentration in biogas, and increased percentage of vivianite in the total crystalline iron species in digested sludge. Our study experimentally demonstrated that combined dosing of FeCl3 and nitrite is a useful pretreatment strategy for improving anaerobic digestion of WAS.