Presence of pathogen DNA in milk harvested from quarters is associated to changes in cows' milk yield and composition.

BACKGROUND: Intramammary infection is the result of invasion and multiplication of microorganisms in the mammary gland and commonly leads to mastitis in dairy animals. Although much has been done to improve cows' udder health, mastitis remains a significant and costly health issue for dairy farmers, especially if subclinical. In this study, quarter milk samples from clinically healthy cows were harvested to detect pathogens via quantitative PCR (qPCR) and evaluate changes in individual milk traits according to the number of quarters infected and the type of microorganism(s). A commercial qPCR kit was used for detection of Mycoplasma bovis, Mycoplasma spp., Staphylococcus aureus, coagulase-negative staphylococci (CNS), Streptococcus agalactiae, Streptococcus dysgalactiae, Streptococcus uberis, Prototheca spp., Escherichia coli, Klebsiella spp., Enterococcus spp. and Lactococcus lactis ssp. lactis. Quarter and pooled milk information of 383 Holstein, 132 Simmental, 129 Rendena, and 112 Jersey cows in 9 Italian single-breed herds was available. RESULTS: Among the cows with pathogen(s) present in at least 1 quarter, CNS was the most commonly detected DNA, followed by Streptococcus uberis, Mycoplasma bovis, and Streptococcus agalactiae. Cows negative to qPCR were 206 and had the lowest milk somatic cell count. Viceversa, cows with DNA isolated in ≥ 3 quarters were those with the highest somatic cell count. Moreover, when major pathogens were isolated in ≥ 3 quarters, milk had the lowest casein index and lactose content. In animals with pathogen(s) DNA isolated, the extent with whom milk yield and major solids were impaired did not significantly differ between major and minor pathogens. CONCLUSIONS: The effect of the number of affected quarters on the pool milk quality traits was investigated in clinically healthy cows using a commercial kit. Results remark the important negative effect of subclinical udder inflammations on milk yield and quality, but more efforts should be made to investigate the presence of untargeted microorganisms, as they may be potentially dangerous for cows. For a smarter use of antimicrobials, analysis of milk via qPCR is advisable - especially in cows at dry off - to identify quarters at high risk of inflammation and thus apply a targeted/tailored treatment.

The ability of a handheld near-infrared spectrometer to do a rapid quality assessment of bovine colostrum, including the immunoglobulin G concentration.

Portable infrared-based instruments have made important contributions in different research fields. Within the dairy supply chain, for example, most of portable devices are based on near-infrared spectroscopy (NIRS) and are nowadays an important support for farmers and operators of the dairy sector, allowing fast and real-time decision-making, particularly for feed and milk quality evaluation and animal health and welfare monitoring. The affordability, portability, and ease of use of these instruments have been pivotal factors for their implementation on farm. In fact, pocket-sized devices enable nonexpert users to perform quick, low-cost, and nondestructive analysis on various matrixes without complex preparation. Because bovine colostrum (BC) quality is mostly given by the IgG level, evaluating the ability of portable NIRS tools to measure antibody concentration is advisable. In this study we used the wireless device SCiO manufactured by Consumer Physics Inc. (Tel Aviv, Israel) to collect BC spectra and then attempt to predict IgG concentration and gross and fine composition in individual samples collected immediately after calving (<6 h) in primiparous and pluriparous Holstein cows on 9 Italian farms. Chemometric analyses revealed that SCiO has promising predictive performance for colostral IgG concentration, total Ig concentration, fat, and AA. The coefficient of determination of cross-validation (R2CV) was in fact ≥0.75). Excellent accuracy was observed for dry matter, protein, and S prediction in cross-validation and good prediction ability in external validation (R2CV ≥ 0.93; the coefficient of determination of external validation, R2V, was ≥0.82). Nonetheless, SCiO's ability to discriminate between good- and low-quality samples (IgG ≥ vs. < 50 g/L) was satisfactory. The affordable cost, the accurate predictions, and the user-friendly design, coupled with the increased interest in BC within the dairy sector, may boost the collection of extensive BC data for management and genetic purposes in the near future.

The effects of dietary iodine content, milking system, and farming practices on milk iodine concentration and quality traits.

Various management practices can influence milk quality traits in dairy cattle. As an example, an increasing investment in automatic milking system to substitute milking parlors has been observed in the last 2 decades in dairy farms which could have affected certain bulk milk quality traits. What is more, milking practices can also affect certain milk parameters; as an example, teat disinfectants containing I are used in commercial farms where pre- or postdipping is performed, leading to presence of some I in the bulk milk. However, this trace mineral is also supplied in cows' diet to fulfill their nutritional requirements, partly contributing to the milk I final concentration. Therefore, the aim of this study was to evaluate the sources of variation of milk I along with other traditional milk quality traits. A total of 91 dairy farms in northeastern Italy were enrolled in the study. In each farm, diet and bulk milk samples were collected on the same day for chemical analysis. Concentration of I, in particular, was determined in both milk and feed with gold standard. Pearson correlations were calculated among the traits available for milk and diet, and a general linear model was used to test significance of fixed effects (feeding system, milking system, farming system, herd size, herd stage of lactation, and sampling month) on milk quality traits including the I concentration. In the case of milk I, diet I and presence of I-based predipping and postdipping teat disinfect application were also tested as fixed effects. Results showed a positive linear correlation between milk and diet I content (correlation coefficient [r] = 0.78). Although milk I was also positively correlated with lactose content (r = 0.25), dietary I was not correlated with other milk traits. Milk I content was significantly affected by dietary I, I-based predipping teat disinfectant application, and herd composition. Compared with conventional farms, organic farms showed lower protein content and greater somatic cell score (SCS) but similar milk I. Milking system significantly affected only lactose content and SCS of milk. Sampling month was only significant for milk urea nitrogen and herd composition, feeding system, herd size, and herd average days in milk did not modify milk gross composition and SCS. In conclusion, dietary supply of I is the main factor affecting milk I concentration and findings suggest that I level in milk can be naturally improved in dairy cows by modulating the I content in the diet administered. However, further research is needed to evaluate the effect of I-based sanitizers on milk I.

Application of a short-wave pocket-sized near-infrared spectrophotometer to predict milk quality traits.

Portable handheld devices based on near-infrared (NIR) technology have improved and are gaining popularity, even if their implementation in milk has been barely evaluated. Thus, the aim of the present study was to assess the feasibility of using short-wave pocket-sized NIR devices to predict milk quality. A total of 331 individual milk samples from different cow breeds and herds were collected in 2 consecutive days for chemical determination and spectral collection by using 2 pocket-sized NIR spectrophotometers working in the range of 740 to 1,070 nm. The reference data were matched with the corresponding spectrum and modified partial least squares regression models were developed. A 5-fold cross-validation was applied to evaluate individual device performance and an external validation with 25% of the dataset as the validation set was applied for the final models. Results revealed that both devices' absorbance was highly correlated but greater for instrument A than B. Thus, the final models were built by averaging the spectra from both devices for each sample. The fat content prediction model was adequate for quality control with a coefficient of determination (R2ExV) and a residual predictive deviation (RPDExV) in external validation of 0.93 and 3.73, respectively. Protein and casein content as well as fat-to-protein ratio prediction models might be used for a rough screening (R2ExV >0.70; RPDExV >1.73). However, poor prediction models were obtained for all the other traits with an R2ExV between 0.43 (urea) and 0.03 (SCC), and a RPDExV between 1.18 (urea) and 0.22 (SCC). In conclusion, short-wave portable handheld NIR devices accurately predicted milk fat content, and protein, casein, and fat-to-protein ratio might be applied for rough screening. It seems that there is not enough information in this NIR region to develop adequate prediction models for lactose, SCC, urea, and freezing point.

Milking system and diet's forage type impact on milk quality of Italian Holstein-Friesian.

Moving from conventional (CMS) to automatic (AMS) milking systems could impact milk quality. Moreover, the type and preservation methods of the forages used in the total mixed ration (TMR) (such as alfalfa hay -HTMR- or corn silage -STMR-) have been demonstrated to modify milk composition. Thus, this study investigated the effect of implementing AMS and different diet forage types on the quality of Italian Holstein-Friesian bulk milk. Milk samples (n = 168) were collected monthly from 21 commercial farms in northern Italy during a period of 8 mo. Farms were categorized into 4 groups according to their milking system (CMS vs AMS) and diet's forage type (HTMR vs STMR). Milk quality data were analyzed through the mixed procedure for repeated measurement of SAS with the milking system, diet's forage type, and sampling day as fixed effects. Milking through the AMS led to lower milk fat, freezing point and ß-lactoglobulin A, longer coagulation time, and higher K content, pH and ß-lactoglobulin B than CMS. Cows fed STMR produced milk with greater fat, protein, casein, Mg content, titratable acidity and ß-lactoglobulin A, while reduced curd firming time, freezing point and ß-lactoglobulin B than those fed with HTMR. In conclusion, milk quality is not only altered by the diet's forage type and characteristics but also by the milking system.

Teat morphology across five buffalo breeds: a multi-country collaborative study.

The buffalo (Bubalus bubalis) is a species of worldwide importance, raised to produce milk, meat, and hides, and often used as a working animal in rural contexts with low access to hi-tech solutions. In the present study, 100 lactating buffaloes (50 primiparous and 50 pluriparous) of five popular breeds were recruited to characterize and compare teat morphology. In particular, the focus was put on the Nili Ravi, Mediterranean, Egyptian, Bulgarian Murrah, and Azeri buffaloes raised in Pakistan, Italy, Egypt, Bulgaria, and Iran, respectively. In all countries, a longitudinal cross-section ultrasound was obtained before the milking to measure teat parameters at individual level: overall, teat canal length (TCL) averaged 24.13 mm, teat diameter (TD) 30.46 mm, cisternal diameter (CD) 17.80 mm, and teat wall (TW) 7.12 mm. The most variable trait across breeds was TCL which was positively correlated with CD and TD and negatively with TW, regardless of the teat position (front/rear or left/right). A strong negative correlation was found between TW and CD (- 0.43). The analysis of variance revealed that the fixed effect of breed significantly affected all the traits except TD. In fact, Bulgarian Murrah, Azeri, and Egyptian buffaloes presented the greatest estimate of TCL, whereas NR the smallest (14.70 mm). The TW was maximum in Nili Ravi, Egyptian, and Mediterranean buffaloes, with estimates equal to 8.19, 7.59, and 8.74 mm, respectively. Nili Ravi also showed the greatest TL (82.39 mm). In terms of CD, the lowest least square mean was that of Mediterranean buffaloes (12.14 mm). Primiparous and pluriparous buffaloes differed in terms of TD, TW, and TL, with older animals presenting the highest least square mean. In terms of position, instead, significant differences were observed for TD, CD, and TL when comparing front and rear teats, as left and right teats did not differ. Teat anatomy includes a set of heritable morphological features and is therefore breed-dependent. Differences presented in this study could be attributed to the divergent breeding objective and selective pressure across the five breeds; e.g., in some cases such as Mediterranean buffalo, selection for decades was oriented to improve milk production and milkability and achieve optimal conformation for mechanical milking. A better understanding of the mammary gland anatomical descriptors can be informative of the history of a breed and could provide useful insights to guide possible selection.

ß-Casein A1 and A2: Effects of polymorphism on the cheese-making process.

Of late, "A2 milk" has gained prominence in the dairy sector due to its potential implications in human health. Consequently, the frequency of A2 homozygous animals has considerably increased in many countries. To elucidate the potential implications that beta casein (ß-CN) A1 and A2 may have on cheese-making traits, it is fundamental to investigate the relationships between the genetic polymorphisms and cheese-making traits at the dairy plant level. Thus, the aim of the present study was to evaluate the relevance of the ß-CN A1/A2 polymorphism on detailed protein profile and cheese-making process in bulk milk. Based on the ß-CN genotype of individual cows, 5 milk pools diverging for presence of the 2 ß-CN variants were obtained: (1) 100% A1; (2) 75% A1 and 25% A2; (3) 50% A1 and 50% A2; (4) 25% A1 and 75% A2; and (5) 100% A2. For each cheese-making day (n = 6), 25 L of milk (divided into 5 pools, 5 L each) were processed, for a total of 30 cheese-making processes. Cheese yield, curd nutrient recovery, whey composition, and cheese composition were assessed. For every cheese-making process, detailed milk protein fractions were determined through reversed-phase HPLC. Data were analyzed by fitting a mixed model, which included the fixed effects of the 5 different pools, the protein and fat content as a covariate, and the random effect of the cheese-making sessions. Results showed that the percentage of κ-CN significantly decreased up to 2% when the proportion of ß-CN A2 in the pool was ≥25%. An increase in the relative content of ß-CN A2 (≥50% of total milk processed) was also associated with a significantly lower cheese yield both 1 and 48 h after cheese production, whereas no effects were observed after 7 d of ripening. Concordantly, recovery of nutrients reflected a more efficient process when the inclusion of ß-CN A2 was ≤75%. Finally, no differences in the final cheese composition obtained by the different ß-CN pools were observed.

Genetic characteristics of colostrum refractive index and its use as a proxy for the concentration of immunoglobulins in Holstein cattle.

BACKGROUND: Colostral concentration of immunoglobulins (Ig) is crucial for the passive transfer of antibodies from the cow to the new-born calf. Direct determination of Ig by the gold standard radial immunodiffusion method is demanding in terms of time and costs. For this reason, a refractometer is commonly used at the farm level for an indirect estimation of colostrum quality, which is given as the Ig concentration. In this study, colostrum samples were collected from 548 Italian Holstein cows within 6 h of calving. The refractive index (BRIX, %) of these samples was assessed using a portable optical refractometer, as well as the concentration of total protein, IgG, IgA, and IgM by radial immunodiffusion. A four-trait animal model was used to estimate genetic parameters for BRIX and the different immunoglobulin isotypes. A receiver operating characteristic analysis was carried out to evaluate the BRIX diagnostic accuracy. RESULTS: Colostral BRIX was moderately heritable (0.26) and its genetic and phenotypic correlations with IgG (0.91, 0.78), IgA (0.57, 0.57), and IgM (0.71, 0.61) were all positive and of similar order, although the genetic correlations were generally higher than the phenotypic correlations. Low-quality colostrum samples, defined as those with an IgG concentration lower than 50 g/L, were accurately identified by the refractive index on the BRIX scale, with an area under the curve of 0.90. CONCLUSIONS: The use of a refractometer is recommended on dairy farms to produce a proxy for colostral Ig concentration. BRIX is a useful phenotyping tool that can be used in cattle to improve the quality of colostrum for first feeding of calves through both traditional genetic and genomic strategies. Improving colostrum quality will reduce the incidence of failure of passive transfer of immunity in young stock.

Breeding for improved protein fractions and free amino acids concentration in bovine milk.

Considerable resources are required to routinely measure detailed milk compositional traits. Hence, an insufficient volume of phenotypic data can hinder genetic progress in these traits within dairy cow breeding programmes. The objective of the present study was to quantify the opportunities for breeding for improved milk protein and free amino acid (FAA) composition by exploiting mid-infrared spectroscopy (MIRS) predictions routinely recorded from milk samples. Genetic parameters for protein fractions and FAA composition were estimated using 134,546 test-day records from 16,166 lactations on 9,572 cows using linear mixed models. Heritability of MIRS-predicted protein fractions ranged from 0.19 (α-lactalbumin) to 0.55 (ß-lactoglobulin A), while heritability of MIRS-predicted FAA ranged from 0.08 for glycine to 0.29 for glutamic acid. Genetic correlations among the MIRS-predicted FAA were moderate to strong ranging from -0.44 (aspartic acid and lysine) to 0.97 (glutamic acid and total FAA). Adjustment of the genetic correlations for the genetic merit of 24-h milk yield did not greatly affect the correlations. Results from the current study highlight the presence of exploitable genetic variation for both protein fractions and FAA in dairy cow milk. Besides, the direction of genetic correlations reveals that breeding programmes directly selecting for greater milk protein concentration carry with them favourable improvement in casein and whey fractions.

The concentrations of immunoglobulins in bovine colostrum determined by the gold standard method are genetically correlated with their near-infrared prediction.

BACKGROUND: The quality of colostrum administered to calves is based on its concentration in immunoglobulins G (IgG, g/L). Immunoglobulins A (IgA) and M (IgM) are also present but at a lower level. The gold standard reference analysis for these traits, radial immunodiffusion, is time-consuming and expensive. In order to define breeding strategies that are aimed at improving colostrum quality in dairy cattle, a large amount of data is needed, and the use of indicator traits would be beneficial. In the study presented here, we explored the heritabilities of reference (radial immunodiffusion) and near infrared-predicted IgG, IgA, and IgM concentrations and estimated their genetic correlations. First, the colostrum of 765 Holstein cows from nine herds was sampled to perform a reference analysis and the near-infrared spectra (400-2500 nm) were stored. We used a calibration set (28% of the initial samples) that was representative of the herds and cow parity orders to develop prediction equations for IgG, IgA, and IgM concentrations. Finally, these traits were predicted in the validation set (72% of the initial samples) to estimate genetic parameters for the predictions. Genetic correlations between reference and predicted values of each trait were estimated through bivariate linear animal models. RESULTS: The three near-infrared-predicted immunoglobulin fractions were genetically correlated with their reference value. In particular, the reference and predicted IgG concentrations were strongly correlated at both the genetic (0.854 ± 0.314) and phenotypic level (0.767 ± 0.019). Weaker associations were observed for IgA and IgM concentrations, which were predicted with lower accuracy compared to IgG. Simulation analyses suggested that improving colostrum quality by selective breeding in Holstein cattle based on near-infrared predicted colostrum immunoglobulins concentrations is feasible. In addition, less than 10 mL of colostrum are needed for spectra acquisition and thus implementation of such analyses is possible in the near future. CONCLUSIONS: The concentrations of colostrum immunoglobulins can be predicted from near-infrared spectra and the genetic correlation between the reference and the predicted traits is positive and favourable, in spite of the large standard errors of the estimates. Near-infrared spectroscopy can be exploited in selective breeding of dairy cattle to improve colostral immunoglobulins concentration.

Development of Fourier-transformed mid-infrared spectroscopy prediction models for major constituents of fractions of delactosated, defatted milk obtained through ultra- and nanofiltration.

Milk filtration procedures are gaining relevance in the dairy industry because milk ultra- and nanofiltrates are used to increase milk processing efficiency, and as additives for products with improved nutraceutical properties. This study aimed to develop Fourier-transformed mid-infrared spectroscopy calibrations for ultra- and nanopermeate and retentate fractions of defatted and delactosated milk. A total of 154 samples from different milk fractions were collected and analyzed using reference methods to determine protein, solids-not-fat, glucose, and galactose content. The obtained values were matched with their respective Fourier-transformed mid-infrared spectroscopy spectra to develop new prediction models. Calibrations for each trait were built following 3 different approaches to get the best prediction models: (1) using the entire data set, (2) using 3 subsets based on component concentrations (level approach), and (3) using hierarchical clusters calculated with pairwise Mahalanobis distance among spectra (cluster approach). Calibrations were developed using partial least squares regression, after removing low signal-to-noise ratio wavelengths, and validated through a leave-one-out cross-validation procedure. In addition, the accuracy of the predicted values within each fraction was checked for each approach. Dividing the data set into subsets improved prediction models for each trait and for the samples in each milk fraction. Without considering milk fraction, the best improvement was observed for glucose and galactose. Glucose ratio performance deviation in cross-validation (RPD) increased from 7.42 to 11.31 and 11.06, for cluster and level approaches, respectively, whereas galactose RPD increased from 8.86 to 11.69 and 11.27 for cluster and level approaches, respectively. Considering milk fractions, the best improvement was observed for protein content, where RPD ranged from 0.08 to 6.06 for the whole data set calibration, whereas it ranged from 0.43 to 40.34 for the subset calibration approaches. Cluster and level approaches to build calibration models were comparable for samples from different fractions, suggesting that the 2 subsetting protocols should be both investigated to get the best prediction performances.

Feasibility of near infrared transmittance spectroscopy to predict fatty acid composition of commercial processed meat.

BACKGROUND: The new European Regulation 1169/2011 concerning nutrition declaration of food products compels the addition of saturated fatty acids, whereas the declaration of monounsaturated and polyunsaturated fatty acids remains voluntary. Therefore, the industry is interested in a more rapid, easy and less cost-effective analysis method for accomplishing this labelling regulation. The present study aimed to evaluate the ability of near infrared transmittance spectroscopy (wavelengths between 850 and 1050 nm) to predict the fatty acid (FA) composition of commercial processed meat samples (n = 310). RESULTS: Good predictions were achieved for the absolute content of saturated, unsaturated, monounsaturated and polyunsaturated FA, as well as ω-6 groups, and also for a few individual FA (C16:0, C18:0, C18:1n9, C18:2n6 and 18:1n7), with the coefficient of determination in cross-validation being > 0.90 and the residual prediction deviation being > 3.15. Unsatisfactory models were obtained for the relative content of FA. CONCLUSION: Near infrared transmittance spectroscopy can be considered as a reliable method for predicting the main groups of FA in processed meat products, whereas predictions of individual FA are less reliable. © 2017 Society of Chemical Industry.

Quantification of whey proteins by reversed phase-HPLC and effectiveness of mid-infrared spectroscopy for their rapid prediction in sweet whey.

In the dairy industry, membrane filtration is used to reduce the amount of whey waste and, simultaneously, to recover whey proteins (WP). The composition of WP can strongly affect the filtration treatment of whey, and rapid determination of WP fractions would be of interest for dairy producers to monitor WP recovery. This study aimed to develop mid-infrared spectroscopy (MIRS) prediction models for the rapid quantification of protein in sweet whey, using a validated rapid reversed phase (RP)-HPLC as a reference method. Quantified WP included α-lactalbumin (α-LA), ß-lactoglobulin (ß-LG) A and B, bovine serum albumin, caseinomacropeptides, and proteose peptone. Validation of RP-HPLC was performed by calculating the relative standard deviation (RSD) in repeatability and reproducibility tests for WP retention time and peak areas. Samples of liquid whey (n=187) were analyzed by RP-HPLC and scanned through MIRS to collect spectral information (900 to 4,000 cm(-1)); statistical analysis was carried out through partial least squares regression and random cross-validation procedure. Retention times in RP-HPLC method were stable (RSD between 0.03 and 0.80%), whereas the RSD of peak area (from 0.25 to 8.48%) was affected by WP relative abundance. Higher coefficients of determination in validation for MIRS model were obtained for protein fractions present in whey in large amounts, such as ß-LG (0.58), total identified WP (0.58), and α-LA (0.56). Results of this study suggest that MIRS is an easy method for rapid quantification of detail protein in sweet whey, even if better resolution was achieved with the method based on RP-HPLC. The prediction of WP in sweet whey by MIRS might be used for screening and for classifying sweet whey according to its total and individual WP contents.

Effects of dairy factory, milk casein content and titratable acidity on coagulation properties in Trentingrana dairy industry.

The objective of the present study was to investigate the effect of environmental factors, milk casein content and titratable acidity on milk coagulation properties (MCP) of samples routinely collected in the Trento province (northeast Italy) under field conditions. Rennet coagulation time (RCT, min), curd-firming time (k20, min) and curd firmness (a30, mm) were determined by Formagraph on 14 971 samples from 635 herds associated to 17 dairy factories. Besides MCP, fat, protein, and casein percentages, titratable acidity (TA), and somatic cell and bacterial counts were available. A standardised index of milk aptitude to coagulate (IAC) was derived using information of RCT and a30. An analysis of variance was conducted on MCP and IAC using a fixed effects linear model. Approximately 3% of milk samples did not form a curd within the testing time (30 min) and k20 was missing for 26% of milks. The percentage of samples without information on k20 largely differed among dairy factories (1·7-20·9%). Significant differences were estimated between the best and the worst dairy factory for RCT (-2 min), k20 (-1·2 min), a30 (+3·4 mm) and IAC (+2·6 points). Milk casein content and TA were important factors in explaining the variation of MCP and IAC, supporting the central role of these two traits on technological properties. The Trento province is heterogeneous in terms of dairy systems and this could explain the differences among dairy factories.

Relationships between European carcass evaluation and Meat Standards Australia grading scheme applied to young beef cattle.

The European carcass grading scheme (EUROP) places large emphasis on meat yield and therefore on quantitative traits such as carcass conformation and superficial fat coverage. However, it falls short in considering sensory properties and consumer satisfaction. In contrast, the Meat Standards Australia (MSA) grading scheme considers, among others, animals' ossification, marbling, and ultimate pH as primary indicators of beef eating quality. This study aims to characterize MSA carcass grading scheme applied to the Italian beef production system, considering its significant role in European beef market. The study involved 3204 Charolais, Limousin, and crossbred young bulls and heifers slaughtered in a commercial Italian abattoir. Data collection spanned a broad range of variables, including animal characteristics, MSA traits, and EUROP carcass grading traits. Regardless of the sex of the animal, no significant relationship was observed between MSA traits and EUROP carcass grading scores. Factors such as sex, age, and arrival season at the fattening unit significantly affected most of MSA traits. Females had significantly higher marbling score, and lower ossification score and hump height than males. Animals imported in autumn and winter had significantly lower marbling score, but similar ossification score compared to those imported in spring and summer. Older females had the highest marbling scores. While further research is needed to assess whether the MSA grading scheme can be adapted to all different European rearing systems, results of this study are a prelude to the potential benefits that the MSA grading scheme can bring to the European beef industry.

The Meat Standards Australia carcass grading site affects assessment of marbling and prediction of meat-eating quality in growing European beef cattle.

The lack of consumer feedback on beef eating quality contributes to reduced beef consumption in Europe. The Meat Standards Australia (MSA) grading scheme can assess the palatability of beef carcasses usually graded at the 10th thoracic vertebrae. However, the European beef industry relies on late-maturing breeds usually cut at the 5th vertebrae due to commercial reasons. Data from 55 young bulls and heifers of late-maturing breeds were collected in an Italian slaughterhouse following the MSA guidelines at both carcass grading sites and sides. Intramuscular fat levels were assessed through two scores and used with other variables to feed the MSA model, which predicts the MSA index, the meat-eating quality scores (MQ4) for 5 muscles and for each carcass grading site × side combination. The scores were analyzed using a mixed linear model. A correlation analysis was conducted to predict the variables measured at the 10th site using their correspondent at the 5th carcass grading site. A stepwise regression was conducted to understand the weight of each measured variable on marbling and MQ4 scores measured both at 5th and 10th carcass grading sites. Results showed significantly higher value for the studied traits at the 5th carcass grading site, while carcass side had no significant impact. The equations had high predictive capability and MSA marbling score played a key role in explaining the variability across carcass grading sites. The differences in marbling and MQ4 scores between the carcass grading sites suggest considering this factor if the MSA grading system will be applied to Europe.

Effects of vaccination timing and target pathogens on performances and antimicrobial use in long-transported Charolais beef cattle from France to Italy - A retrospective study.

Antimicrobial use (AMU) in the livestock sector is a major driver of antimicrobial resistance. Italian beef industry strongly relies on the import of young cattle from France, which are commingled in sorting facilities before transportation to Italy. Both commingling and transportation are stressors for animals and lead to higher risk of bovine respiratory disease (BRD), which in turn increases the risk of AMU. This study aimed to investigate how the timing of first BRD vaccination and the different vaccination target pathogens affect AMU and performance of young Charolais beef cattle imported from France to Italy. Information on animal performance, antimicrobial treatments, and vaccinations was available for 60,726 Charolais cattle belonging to 1449 batches in 33 Italian specialised fattening farms between January 2016 and December 2021. Antimicrobial use was estimated using the treatment incidence 100 adapted for Italy (TI100it). A mixed linear model was used to quantify the effects of the vaccination and the time of first administration on slaughter age, carcase weight, and average daily carcase gain. Similarly, a generalised linear mixed model was used to analyse the TI100it. The vaccination programme was usually applied the first day after the animals' arrival to the Italian fattening farms. Most animals were vaccinated with a polyvalent vaccine against infectious bovine rhinotracheitis (IBR), bovine parainfluenza type 3 virus (PI-3), bovine viral diarrhoea virus type 1 and 2 (BVDV), and bovine respiratory syncytial virus (BRSV). The most used class of antimicrobials to treat BRD were the macrolides, followed by aminoglycosides, amphenicols, tetracyclines, aminopenicillins, and fluoroquinolones. Animals that got vaccinated against any of the considered BRD pathogens upon arrival had significantly lower TI100it, greater average daily carcase gain, and reached slaughter age earlier than animals that got vaccinated later. Animals that received the vaccination against BVDV had lower TI100it and greater average daily carcase gain, and animals that received the vaccination against BRSV were younger at slaughter than unvaccinated animals. The vaccination against Mannheimia haemolytica significantly decreased the slaughter age and increased the carcase weight and average daily carcase gain, and the vaccination against PI-3 and Histophilus somni significantly increased the slaughter age. Thus, even if the vaccination programme is essential to tackle BRD, this practice is questionable if applied at arrival to the Italian fattening farms and it is advisable that the vaccination programme is planned before the commingling procedure in France.

Comparative analysis of microbial succession and proteolysis focusing on amino acid pathways in Asiago-PDO cheese from two dairies.

In this study, a comprehensive and comparative analysis was conducted on Italian Asiago-PDO cheese obtained from two different dairies named Dairy I and Dairy II using industrial and natural fermented milk, respectively. The analysis encompassed the evaluation of chemical composition, the succession of the microbiota during manufacture and ripening, and proteolysis mainly focusing on free individual amino acid (FAA) profiles. A metagenomic approach was used to investigate the cheese microbiome functionality. Differences in gross chemical composition were more evident during ripening, with Dairy II showing higher variability within batches. The microbiota varied significantly between the two dairies and ripening stages. The choice of starter culture shaped the microbiota during production and affected the microbial diversity of non-starter lactic acid bacteria (NSLAB) originated from the raw milk during ripening. Peptide chromatographic profiles and FAA concentrations increased as ripening progressed, with Dairy I showing higher production of FAA. Functional analysis of the metagenomes linked species to specific amino acid metabolism/catabolism pathways. The amino acid metabolism pathways, particularly those related to aromatic amino acids, lysine, and branched-chain amino acids, were affected by the presence of specific NSLAB species, which differed between the two dairies. The results obtained in this study reveal the impact of starter culture on peculiar cheese microbiota assemblies, which selectively targets amino acid pathways, providing insights into the potential flavor and aroma characteristics of Asiago-PDO cheese.

Effect of milk composition and coagulation traits on Grana Padano cheese yield under field conditions.

The aim of this study was to assess the effect of chemical composition, coagulation properties, pH, and titratable acidity (TA, SH°/50 ml) of vat milk on Grana Padano cheese yield (CY) under field conditions. Twelve cheese-making sessions were carried out from February to December 2009 in a dairy cooperative of Grana Padano Consortium (Italy), for a total of 96 vats of milk processed. For each vat, samples of raw milk were collected and analysed for quality traits (fat, protein, and casein contents), pH, TA, and milk coagulation properties (MCP), measured as rennet coagulation time (RCT, min), curd-firming time (k(20), min), and curd firmness (a(30), mm). Cheese yield was expressed as kilograms of cheese per 100 kg milk transformed, and was measured after 2 d of drainage. Fat, protein, and casein contents were positively and strongly correlated with CY (coefficients of correlation, r = 0.72, 0.88, and 0.84, respectively; P < 0.001). Coagulation properties were moderately and significantly (P < 0.001) related to CY: milk that coagulated earlier and had stronger a(30) was associated to greater CY. Cheese yield was analysed with a model that accounted for fixed effects of cheese-making day, fat and protein content, TA, and a(30). Significance was found for all the effects (P < 0.05). Milk characterised by high values of a(30) resulted in higher CY than milk with low values of a 30, indicating that MCP could be used as indicators of cheese-making efficiency. Future research should investigate the relationships between MCP and quality of cheese, and explore the feasibility of including MCP in multiple component milk pricing system for Grana Padano cheese production.