Optimization of Vacuum-Microwave-Assisted Extraction of Natural Polyphenols and Flavonoids from Raw Solid Waste of the Orange Juice Producing Industry at Industrial Scale.

Orange pomace (OP) is a solid waste produced in bulk as a byproduct of the orange juice industry and accounts for approximately 50% of the quantity of the fruits processed into juice. In numerous literature references there is information about diverse uses of orange pomace for the production of high-added-value products including production of natural antioxidant and antimicrobial extracts rich in polyphenols and flavonoids which can substitute the hazardous chemical antioxidants/antimicrobials used in agro-food and cosmetics sectors. In this work and for the first time, according to our knowledge, the eco-friendly aqueous vacuum microwave assisted extraction of orange pomace was investigated and optimized at real industrial scale in order to produce aqueous antioxidant/antimicrobial extracts. A Response Surface Optimization methodology with a multipoint historical data experimental design was employed to obtain the optimal values of the process parameters in order to achieve the maximum rates of extraction of OP total polyphenols and/or total flavonoids for economically optimum production at industrial scale. The three factors used for the optimization were: (a) microwave power (b) water to raw pomace ratio and (c) extraction time. Moreover, the effectiveness and statistical soundness of the derived cubic polynomial predictive models were verified by ANOVA.

Optimization of the Vacuum Microwave Assisted Extraction of the Natural Polyphenols and Flavonoids from the Raw Solid Waste of the Pomegranate Juice Producing Industry at Industrial Scale.

Pomegranate pomace (PP) is the solid waste produced in bulk by the pomegranate juice industry which is rich in polyphenols and flavonoids that can replace the hazardous chemical antioxidants/antimicrobials currently used in the agro-food and cosmetics sectors. In the present work, the vacuum microwave assisted extraction (VMAE) of natural antioxidants from raw pomegranate pomace was investigated and successfully optimized at an industrial scale. For the optimization of PP VMAE a novel, highly accurate response surface methodology (RSM) based on a comprehensive multi-point historical design was employed. The optimization showed that the maximum recovery of PP total polyphenols as well as total PP flavonoids were obtained at microwave power = 4961.07 W, water to pomace ratio = 29.9, extraction time = 119.53 min and microwave power = 4147.76 W, water to pomace ratio = 19.32, extraction time = 63.32 min respectively. Moreover, the optimal VMAE conditions on economic grounds were determined to be: microwave power = 2048.62 W, water to pomace ratio = 23.11, extraction time = 15.04 min and microwave power = 4008.62 W, water to pomace ratio = 18.08, extraction time = 15.29 min for PP total polyphenols and PP total flavonoids respectively. The main conclusion of this study is that the VMAE extraction can be successfully used at industrial scale to produce, in economic manner, high added value natural extracts from PP pomace.

Biofabrication of Tobacco mosaic virus-nanoscaffolded supercapacitors via temporal capillary microfluidics.

This paper reports the implementation of temporal capillary microfluidic patterns and biological nanoscaffolds in autonomous microfabrication of nanostructured symmetric electrochemical supercapacitors. A photoresist layer was first patterned on the substrate, forming a capillary microfluidics layer with two separated interdigitated microchannels. Tobacco mosaic virus (TMV) macromolecules suspended in solution are autonomously delivered into the microfluidics, and form a dense bio-nanoscaffolds layer within an hour. This TMV layer is utilized in the electroless plating and thermal oxidation for creating nanostructured NiO supercapacitor. The galvanostatic charge/discharge cycle showed a 3.6-fold increase in areal capacitance for the nanostructured electrode compared to planar structures. The rapid creation of nanostructure-textured microdevices with only simple photolithography and bionanostructure self-assembly can completely eliminate the needs for sophisticated synthesis or deposition processes. This method will contribute to rapid prototyping of wide range of nano-/micro-devices with enhanced performance.

Autoinducer-2 analogs and electric fields - an antibiotic-free bacterial biofilm combination treatment.

Bacterial biofilms are a common cause of chronic medical implant infections. Treatment and eradication of biofilms by conventional antibiotic therapy has major drawbacks including toxicity and side effects associated with high-dosage antibiotics. Additionally, administration of high doses of antibiotics may facilitate the emergence of antibiotic resistant bacteria. Thus, there is an urgent need for the development of treatments that are not based on conventional antibiotic therapies. Presented herein is a novel bacterial biofilm combination treatment independent of traditional antibiotics, by using low electric fields in combination with small molecule inhibitors of bacterial quorum sensing - autoinducer-2 analogs. We investigate the effect of this treatment on mature Escherichia coli biofilms by application of an alternating and offset electric potential in combination with the small molecule inhibitor for 24 h using both macro and micro-scale devices. Crystal violet staining of the macro-scale biofilms shows a 46 % decrease in biomass compared to the untreated control. We demonstrate enhanced treatment efficacy of the combination therapy using a high-throughput polydimethylsiloxane-based microfluidic biofilm analysis platform. This microfluidic flow cell is designed to reduce the growth variance of in vitro biofilms while providing an integrated control, and thus allows for a more reliable comparison and evaluation of new biofilm treatments on a single device. We utilize linear array charge-coupled devices to perform real-time tracking of biomass by monitoring changes in optical density. End-point confocal microscopy measurements of biofilms treated with the autoinducer analog and electric fields in the microfluidic device show a 78 % decrease in average biofilm thickness in comparison to the negative controls and demonstrate good correlation with real-time optical density measurements. Additionally, the combination treatment showed 76 % better treatment efficacy compared to conventional antibiotic therapy. Taken together these results suggest that the antibiotic-free combination treatment described here may provide an effective alternative to traditional antibiotic therapies against bacterial biofilm infections. Use of this combination treatment in the medical and environmental fields would alleviate side effects associated with high-dosage antibiotic therapies, and reduce the rise of antibiotic-resistant bacteria.

NASBA Coupled to Paper Microfluidics for RNA Detection.

The analysis of RNA sequences is crucial to obtain invaluable insights into disease prognosis. Reliable and rapid diagnostic solutions at the site of sample collection contribute toward optimal delivery of medical treatment. For this reason, the development of more sensitive and portable RNA detection techniques are expected to advance current point-of-care (POC) diagnostic capabilities. Advancements of POC diagnostic technologies will also contribute to counter the spread of emerging viruses. Reverse transcriptase polymerase chain reaction (RT-PCR) is the most commonly used technique to identify etiological organisms of infections. However, the need for thermocycler and fluorescent measurement renders RT-PCR less suitable for POC applications. Here, we provide a step-by-step protocol of Nucleic Acid Sequence-Based Amplification (NASBA), a robust isothermal RNA amplification technique, coupled with a portable paper microfluidics detection format.

UV-cured gel polymer electrolytes with improved stability for advanced aqueous Li-ion batteries.

We report the development of a new class of "water-in-salt" electrolytes based on UV photopolymerized acrylic polymers. Incorporation of "water-in-bisalt" in a polymer matrix reduces water activity, expands the electrochemical stability window to 4.1 V, and dramatically improves cycle life in full cells with lithium titanate anodes compared to liquid water-based electrolytes.

Effects of Engineered Wettability on the Efficiency of Dew Collection.

Surface wettability plays an important role in dew collection. Nucleation is faster on hydrophilic surfaces, while droplets slide more readily on hydrophobic surfaces. Plants and animals in coastal desert environments appear to overcome this trade-off through biphilic surfaces with patterned wettability. In this study, we investigate the effects of millimeter-scale wettability patterns, mimicking those of the Stenocara beetle, on the rate of water collection from humid air. The rate of water collection per unit area is measured as a function of subcooling (ΔT = 1, 7, and 27 °C) and angle of inclination (from 10° to 90°). It is then compared for superbiphilic, hydrophilic, hydrophobic, and surperhydrophobic surfaces. For large subcooling, neither wettability nor tilt angle has a significant effect because the rate of condensation is so great. For 1 °C subcooling and large angles, hydrophilic surfaces perform best because condensation is the rate-limiting step. For low angles of inclination, superhydrophobic samples are best because droplet sliding is the rate-limiting step. Superbiphilic surfaces, in contrast to their superior fog collecting capabilities, generally collected dew at the slowest rate due to their inherent contact angle hysteresis. Theoretical considerations suggest that this finding may apply more generally to surfaces with patterned wettability.

Wearable Sensor System for Detection of Lactate in Sweat.

Increased development of wearable sensors for physiological monitoring has spurred complementary interest in the detection of biochemical indicators of health and performance. We report a wearable sensor system for non-invasive detection of excreted human biomarkers in sweat. The system consists of a thin, flexible, kapton patch (2.5 × 7.5 cm) that can be coated with adhesive and affixed to the skin. The system can be controlled by a cell phone via a near-field communications protocol, charged wirelessly, and the data can be downloaded and displayed in a smart phone app. The system is designed such that the sensing element plugs into a low-profile socket, and can easily be removed and replaced as needed due to saturation or aging effects. As a demonstration case, we examined using an organic electrochemical transistor (OECT) within this system to monitor lactate concentration. Several different methods for optimizing the sensor performance were compared, including altering electrode materials, employing various immobilization techniques, and tailoring operating voltages. Resulting functional response of the lactate oxidase enzyme was compared as a function of the sensor variables. The OECT sensor was shown to have high sensitivity to lactate, however the sensing range is limited to lactate concentrations below approximately 1 mM.

Effects of Dietary Grape Pomace Supplementation on Performance, Carcass Traits and Meat Quality of Lambs.

BACKGROUND/AIM: A previous study revealed that the inclusion of grape pomace (GP) in the diet for growing lambs had beneficial effects on the redox status and fecal microbiota. Herein, we investigated the effect of GP inclusion on performance, carcass traits and fatty acid composition of meat. MATERIALS AND METHODS: In the experimental trial of 55 days, lambs were fed with standard or diet supplemented with GP. Performance, carcass traits and fatty acid profile of quadriceps muscle were assessed. RESULTS: GP inclusion in the diet improved growth performance, since the average daily gain was significantly increased by 2-fold in GP group. Regarding the fatty acid composition of meat, GP inclusion significantly increased the content of long chain n-3 fatty acids, eicosapentaenoic acid and docosahexaenoic acid, and reduced the n-6/n-3 ratio compared to the control group. CONCLUSION: GP supplementation in lamb diet may improve performance and may have beneficial effects on meat quality.

Novel Feed Including Olive Oil Mill Wastewater Bioactive Compounds Enhanced the Redox Status of Lambs.

BACKGROUND/AIM: The aim of the present study was to investigate the antioxidant effects of a feed supplemented with polyphenolic additives from olive mill wastewater (OMW) on lambs. MATERIALS AND METHODS: Lambs received breast milk until the postnatal period, and then they were divided into two groups and received control and OMW feed for 55 days. Redox biomarkers were measured in blood and tissues at days 15, 42 and 70 after feeding. RESULTS: Feed supplemented with OMW reduced thiobarbituric acid reactive species and protein carbonyls and increased total antioxidant capacity, glutathione and catalase activity in both blood and tissues. CONCLUSION: The administration of OMW-containing feed reinforced the antioxidant defense of lambs, which may improve their wellbeing and productivity. Additionally, this exploitation of OMW may solve problems of environmental pollution in areas with olive oil industries.

Three-Dimensional Solid-State Lithium-Ion Batteries Fabricated by Conformal Vapor-Phase Chemistry.

Three-dimensional thin-film solid-state batteries (3D TSSB) were proposed by Long et al. in 2004 as a structure-based approach to simultaneously increase energy and power densities. Here, we report experimental realization of fully conformal 3D TSSBs, demonstrating the simultaneous power-and-energy benefits of 3D structuring. All active battery components-electrodes, solid electrolyte, and current collectors-were deposited by atomic layer deposition (ALD) onto standard CMOS processable silicon wafers microfabricated to form arrays of deep pores with aspect ratios up to approximately 10. The cells utilize an electrochemically prelithiated LiV2O5 cathode, a very thin (40-100 nm) Li2PO2N solid electrolyte, and a SnN x anode. The fabrication process occurs entirely at or below 250 °C, promising compatibility with a variety of substrates as well as integrated circuits. The multilayer battery structure enabled all-ALD solid-state cells to deliver 37 µAh/cm2·µm (normalized to cathode thickness) with only 0.02% per-cycle capacity loss. Conformal fabrication of full cells over 3D substrates increased the areal discharge capacity by an order of magnitude while simulteneously improving power performance, a trend consistent with a finite element model. This work shows that the exceptional conformality of ALD, combined with conventional semiconductor fabrication methods, provides an avenue for the successful realization of long-sought 3D TSSBs which provide power performance scaling in regimes inaccessible to planar form factor cells.

Capillary Microfluidics-Assembled Virus-like Particle Bionanoreceptor Interfaces for Label-Free Biosensing.

A capillary microfluidics-integrated sensor system is developed for rapid assembly of bionanoreceptor interfaces on-chip and label-free biosensing. Genetically engineered Tobacco mosaic virus (TMV) virus-like particles (VLPs), displaying thousands copies of identical receptor peptides FLAG-tags, are utilized as nanoceptors for antibody sensing. Controlled and accelerated assembly of VLP receptor layer on impedance sensor has been achieved using capillary action and surface evaporation from an open-channel capillary microfluidic system. VLPs create a dense and localized receptor monolayer on the impedance sensor using only 5 µL of VLP sample solution (0.2 mg/mL) in only 6 min at room temperature. The VLP-functionalized impedance sensor is capable of label-free detection of target antibodies down to 55 pM concentration within 5 min. These results highlight the significant potentials of an integrated microsystem for rapid and controlled receptor-transducer interface creation and the nanoscale VLP-based sensors for fast, accurate, and decentralized pathogen detection.

Tissue specific effects of feeds supplemented with grape pomace or olive oil mill wastewater on detoxification enzymes in sheep.

The aim of the present study was to investigate the effects of livestock feed supplemented with grape pomace (GP) or olive oil mill wastewater (OMW) byproducts on the enzymatic activity and protein expression of antioxidants enzymes, in liver and spleen tissue of sheep. Thus, 36 male sheep of Chios breed were divided into 3 homogeneous groups, control group (n = 12), GP group (n = 12) and OMW group (n = 12), receiving standard or experimental feed. Liver and spleen tissues were collected at 42 and 70 days post-birth. The enzymatic activity of superoxide dismutase (SOD) and glutathione-s-transferase (GST) and also the protein expression of γ-synthase glutamyl custeine (γ-GCS) were determined in these tissues. The results showed GP group exhibited increased enzymatic activity of GST and protein expression of γ-GCS in liver compared to control group. In GP group's spleen, GST activity was increased compared to control but γ-GCS expression was not affected. In OMW group's liver, GST activity was increased and γ-GCS expression was reduced compared to control. In OMW group's spleen, GST activity was increased but GCS expression was not affected. SOD activity was not affected in both tissues either in GP or OMW group.

Flexible Aqueous Li-Ion Battery with High Energy and Power Densities.

A flexible and wearable aqueous symmetrical lithium-ion battery is developed using a single LiVPO4 F material as both cathode and anode in a "water-in-salt" gel polymer electrolyte. The symmetric lithium-ion chemistry exhibits high energy and power density and long cycle life, due to the formation of a robust solid electrolyte interphase consisting of Li2 CO3 -LiF, which enables fast Li-ion transport. Energy densities of 141 Wh kg-1 , power densities of 20 600 W kg-1 , and output voltage of 2.4 V can be delivered during >4000 cycles, which is far superior to reported aqueous energy storage devices at the same power level. Moreover, the full cell shows unprecedented tolerance to mechanical stress such as bending and cutting, where it not only does not catastrophically fail, as most nonaqueous cells would, but also maintains cell performance and continues to operate in ambient environment, a unique feature apparently derived from the high stability of the "water-in-salt" gel polymer electrolyte.

Novel feed including bioactive compounds from winery wastes improved broilers' redox status in blood and tissues of vital organs.

Currently, there is a great interest in the production of animal feed with antioxidant activity. The aim of this study was to examine the potential antioxidant effects of a feed supplemented with grape pomace (GP), a winery by-product with high environmental load, in chickens. Broilers of 15 days post birth were separated into two groups fed either with standard diet or with diet supplemented with GP for 35 days. Blood and tissues collections were performed after feeding for 15 and 35 days with the experimental diet (i.e. at 30 and 50 days post birth). Free radical toxicity markers, namely thiobarbituric acid reactive substances, protein carbonyls, total antioxidant capacity, reduced glutathione, catalase activity and rate of H2O2 decomposition were determined in blood and tissues of vital organs. The results indicated that feed supplemented with GP decreased oxidative stress-induced toxic effects and improved chickens' redox status, and so it may also improve their wellness and productivity. On the other hand, this exploitation of GP may solve problems of environmental pollution in areas with wineries.

Enhancement of Antioxidant Mechanisms and Reduction of Oxidative Stress in Chickens after the Administration of Drinking Water Enriched with Polyphenolic Powder from Olive Mill Waste Waters.

The aim of the study was to examine the effects of a polyphenolic powder from olive mill wastewater (OMWW) administered through drinking water, on chickens' redox status. Thus, 75 chickens were divided into three groups. Group A was given just drinking water, while groups B and C were given drinking water containing 20 and 50 µg/ml of polyphenols, respectively, for 45 days. The antioxidant effects of the polyphenolic powder were assessed by measuring oxidative stress biomarkers in blood after 25 and 45 days of treatment. These markers were total antioxidant capacity (TAC), protein carbonyls (CARB), thiobarbituric acid reactive species (TBARS) and superoxide dismutase activity (SOD) in plasma, and glutathione (GSH) and catalase activity in erythrocytes. The results showed that CARB and TBARS were decreased significantly in groups B and C, and SOD decreased in group B compared to that in group A. TAC was increased significantly in group C and GSH was increased in group B, while catalase activity was increased in groups B and C compared to that in group A. In conclusion, this is the first study showing that supplementation of chickens with polyphenols from OMWW through drinking water enhanced their antioxidant mechanisms and reduced oxidative stress-induced damage.

Real-time monitoring of macromolecular biosensing probe self-assembly and on-chip ELISA using impedimetric microsensors.

This paper presents a comprehensive study of the self-assembly dynamics and the biosensing efficacy of Tobacco mosaic virus-like particle (TMV VLP) sensing probes using an impedimetric microsensor platform. TMV VLPs are high surface area macromolecules with nanorod structures constructed from helical arrangements of thousands of identical coat proteins. Genetically modified TMV VLPs express both surface attachment-promoting cysteine residues and FLAG-tag antibody binding peptides on their coat protein outer surfaces, making them selective biosensing probes with self-assembly capability on sensors. The VLP self-assembly dynamics were studied by the continuous monitoring of impedance changes at 100Hz using interdigitated impedimetric microsensors. Electrical impedance spectroscopy revealed VLP saturation on impedance sensor surface with the coverage of 68% in self-assembly process. The VLP-functionalized impedance sensors responded to 12ng/ml to 1.2µg/ml of target anti-FLAG IgG antibodies in the subsequent enzyme-linked immunosorbent assays (ELISA), and yielded 18-35% total impedance increases, respectively. The detection limit of the target antibody is 9.1ng/ml using the VLP-based impedimetric microsensor. These results highlight the significant potential of genetically modified VLPs as selective nanostructured probes for autonomous sensor functionalization and enhanced biosensing.

Assessment of Fatty Acid Allocation in Plasma and Tissues in Piglets, Using Feed Supplemented with Byproducts from Processed Olive Mill Wastewater.

BACKGROUND/AIM: A previous study revealed the improvement of redox status in blood and tissues of young piglets (ablactation period), that consumed feed containing polyphenolic additives from byproducts of processed olive mill wastewater (OMWW). The polyphenolic additives strengthened the antioxidant defense of the piglets. Herein we analyzed the fatty acid (FA) composition of these animals in various tissues. MATERIALS AND METHODS: The steps followed during the analysis were: Preparation and isolation of byproducts containing polyphenolic compounds from OMWW processing, silage and piglet feed preparation, blood and tissue collection, fatty acid methyl esters synthesis and GC/MS analysis. RESULTS: The young piglets, that consumed feed containing polyphenolic additives from byproducts of processed OMWW, were found to have a decreased ω6/ω3 ratio, compared to samples of the control group. For example, in the quadriceps tissue the control group has a ω6/ω3 ratio of 10.1, while in the polyphenolic group this ratio was decreased to 2.93. Regarding the ratio of UFA/SFA, no significant differences were observed. Finally, the polyphenolic group exhibited almost in all tissues lower values of the ratio of PUFA/MUFA than the control group.

Feed supplemented with polyphenolic byproduct from olive mill wastewater processing improves the redox status in blood and tissues of piglets.

In the present study, a polyphenolic byproduct from olive mill wastewater (OMWW) was used for making piglet feed with antioxidant activity. For examining the antioxidant capacity of the feed, 30 piglets of 20 d old were divided into two groups receiving basal or experimental feed for 30 d. Blood and tissue samples were drawn at days 2, 20, 35 and 50 post-birth. The tissues collected were brain, heart, kidney, liver, lung, quadriceps muscle, pancreas, spleen and stomach. The antioxidant effects of the experimental feed were assessed by measuring oxidative stress biomarkers in blood and tissues. The oxidative stress markers were total antioxidant capacity (TAC), glutathione (GSH), catalase activity (CAT), protein carbonyls (CARB) and thiobarbituric acid reactive species (TBARS). The results showed that piglets fed with diet supplemented with OMWW polyphenols had significantly increased antioxidant mechanisms in blood and the majority of the tested tissues as shown by increases in TAC, CAT and GSH compared to control group. Moreover, piglets fed with the experimental feed exhibited decreased oxidative stress-induced damage to lipids and proteins as shown by decreases in TBARS and CARB respectively. This is the first study in which OMWW polyphenols were used for making pig feed with antioxidant activity.

Feed supplemented with byproducts from olive oil mill wastewater processing increases antioxidant capacity in broiler chickens.

In the present study, a ceramic membrane microfiltration method was used for the separation of two liquid products, the downstream permeate and the upstream retentate, from olive mill wastewater (OMWW). These liquid products were examined for their antioxidant activity by incorporating them into broilers' feed. Twenty four broilers 13 d old were divided into two feeding groups receiving supplementation with OMWW retentate or permeate for 37 d. Blood was drawn at 17, 27 and 37 d, while tissues (muscle, heart, liver) were collected at 37 d. The antioxidant effects were assessed by measuring oxidative stress biomarkers in blood and tissues. The results showed that broilers given feed supplemented with OMWW retentate or permeate had significantly lower protein oxidation and lipid peroxidation levels and higher total antioxidant capacity in plasma and tissues compared to control group. In both OMWW groups, catalase activity in erythrocytes and tissues was significantly increased compared to control group. OMWW retentate administration increased significantly GSH in erythrocytes in broilers with low GSH, although both OMWW products significantly reduced GSH in broilers with high GSH. Thus, it has been demonstrated for the first time that supplementation with OMWW processing residues could be used for enhancing broilers' redox status.