Influence of Solubility on the Adsorption of Different Xyloglucan Fractions at Cellulose-Water Interfaces.

Xylogucan (XG) fractions with different molar masses were prepared while preserving the natural structure of the XG. The solubility of the fractions was investigated using light scattering, chromatography, and microscopy techniques. The conformational changes of the XG molecules and their association and phase separation were investigated together with concentration and molar mass changes. The knowledge gained was then applied to investigate the interaction of different XG fractions at cellulose model surfaces using a quartz crystal microbalance with dissipation. The results indicate that there is a cluster formation and phase separation of the XG molecules at the cellulose/water interface induced by the increase in XG concentration close to the surface. Concomitantly, the adsorption regimes are altered for the XG fractions depending on the solubility properties, indicating that the insolubility, association, and phase separation of XGs in aqueous media affect their interaction with cellulose. The study is of vital importance for improving the functionality of sustainable materials made from xyloglucan/cellulose natural composites.

Experimental and Theoretical Evaluation of the Solubility/Insolubility of Spruce Xylan (Arabino Glucuronoxylan).

The molecular solubility of softwood arabinoglucuronoxylan (AGX) has been thoroughly investigated, and it has been shown that the chemical and physical structures of the extracted hemicellulose are not significantly influenced by different purification steps, but a transient molecular solubility of AGX was observed in aqueous media at low concentrations (1 g/L) when the dissolved macromolecules had a hydrodynamic diameter of up to 10 nm. A phase separation was detected when the concentration was increased to 15 g/L leading to an association of the smaller molecules into fractal structures with a considerably larger diameter, even though the dispersions were still transparent to ocular inspection. Dynamic Light Scattering and Cryo-Transmission Electron Microscopy showed dimensions in the range of 1000 nm. The phase separation of the sample was further characterized by estimating the χ-interaction parameter of AGX in water using the Flory-Huggins theory, and the results supported that water is a poor solvent for AGX. This behavior is crucial when films and hydrogels based on these biopolymers are made, since the association will dramatically affect barrier and mechanical properties of films made from these materials.

Solubility of Softwood Hemicelluloses.

It is demonstrated that the molecular solubility of softwood hemicelluloses is significantly influenced by pretreatment of the fibers, extraction, and downstream processing. To quantify these effects, four hemicellulose samples were extracted from different thermomechanical pulps of Norway spruce. The molecular solubility of the samples was characterized by size and molar mass distributions, and the morphology of the molecules was studied using high resolution microscopy techniques. All extracted samples were well dispersed in aqueous media creating transparent dispersions, but dynamic light scattering measurements showed that molecular solubility can only be achieved using specific pretreatments and extractions. The procedure yields acetylated galactoglucomannan (AcGGM)-rich hemicelluloses with an average molar mass of 21-35 kDa and a diameter up to 10 nm but also shows that water is a poor solvent for this sample since an association is detected as soon as the concentration is about 20 g/L. These associated hemicellulose dispersions are still absolutely clear on visual inspection, underlining the need for careful measurement when assessing the solubility of wood hemicelluloses.

Tailormade Polysaccharides with Defined Branching Patterns: Enzymatic Polymerization of Arabinoxylan Oligosaccharides.

The heterogeneous nature of non-cellulosic polysaccharides, such as arabinoxylan, makes it difficult to correlate molecular structure with macroscopic properties. To study the impact of specific structural features of the polysaccharides on crystallinity or affinity to other cell wall components, collections of polysaccharides with defined repeating units are required. Herein, a chemoenzymatic approach to artificial arabinoxylan polysaccharides with systematically altered branching patterns is described. The polysaccharides were obtained by glycosynthase-catalyzed polymerization of glycosyl fluorides derived from arabinoxylan oligosaccharides. X-ray diffraction and adsorption experiments on cellulosic surfaces revealed that the physicochemical properties of the synthetic polysaccharides strongly depend on the specific nature of their substitution patterns. The artificial polysaccharides allow structure-property relationship studies that are not accessible by other means.

Entropy drives the adsorption of xyloglucan to cellulose surfaces - A molecular dynamics study.

The adsorption of nonionic polymers to cellulose is of large importance both in the plant cell wall during synthesis and for the development of sustainable materials from wood. Here, the thermodynamics of adsorption of the polysaccharide xyloglucan (XG) to both native and chemically modified cellulose with carboxyl groups was investigated using molecular dynamics simulations. The free energy of adsorption was calculated as the potential of mean force between an XG oligomer and model cellulose surfaces in a range of temperatures from 298 K to 360 K. It was found that the adsorption near room temperature is an endothermic process dominated by the entropy of released interfacial water molecules. This was corroborated by quantitative assessment of the absolute entropy per water molecule both at the interface and in the bulk. In the case of native cellulose, the adsorption became exothermic at higher temperatures, while the relatively strong interactions between water and the charged groups of the oxidized cellulose impede such a transition. The results also indicate that the extraction of strongly associated hemicelluloses would be facilitated by low temperature.