RESUMEN
Microalgae have almost unlimited applications due to their versatility and robustness to grow in different environmental conditions, their biodiversity and variety of valuable bioactive compounds. Wastewater can be used as a low-cost and readily available medium for microalgae, while the latter removes the pollutants to produce clean water. Nevertheless, since the most valuable metabolites are mainly located inside the microalga cell, their release implies rupturing the cell wall. In this study, Tetradesmus obliquus grown in 5% piggery effluent was disrupted using high-pressure homogenization (HPH). Effects of HPH pressure (100, 300, and 600 bar) and cycles (1, 2 and 3) were tested on the membrane integrity and evaluated using flow cytometry and microscopy. In addition, wheat seed germination trials were carried out using the biomass at different conditions. Increased HPH pressure or number of cycles led to more cell disruption (75% at 600 bar and 3 cycles). However, the highest increase in wheat germination and growth (40-45%) was observed at the lowest pressure (100 bar), where only 46% of the microalga cells were permeabilised, but not disrupted. Non-treated T. obliquus cultures also revealed an enhancing effect on root and shoot length (up to 40%). The filtrate of the initial culture also promoted shoot development compared to water (21%), reinforcing the full use of all the process fractions. Thus, piggery wastewater can be used to produce microalgae biomass, and mild HPH conditions can promote cell permeabilization to release sufficient amounts of bioactive compounds with the ability to enhance plant germination and growth, converting an economic and environmental concern into environmentally sustainable applications.
Asunto(s)
Chlorophyceae , Microalgas , Biomasa , Germinación , Microalgas/metabolismo , Semillas/química , Aguas Residuales/química , Agua/metabolismoRESUMEN
The ability of microalgae to grow in nutrient-rich environments and to accumulate nutrients from wastewaters (WW) makes them attractive for the sustainable and low-cost treatment of WW. The valuable biomass produced can be further used for the generation of bioenergy, animal feed, fertilizers, and biopolymers, among others. In this study, Scenedesmus obliquus was able to remove nutrients from different wastewaters (poultry, swine and cattle breeding, brewery and dairy industries, and urban) with removal ranges of 95-100% for nitrogen, 63-99% for phosphorus and 48-70% for chemical oxygen demand. The biomass productivity using wastewaters was higher (except for poultry) than in synthetic medium (Bristol), the highest value being obtained in brewery wastewater (1025â¯mg/(L.day) of freeze-dried biomass). The produced biomass contained 31-53% of proteins, 12-36% of sugars and 8-23% of lipids, regardless of the type of wastewater. The potential of the produced Scenedesmus obliquus biomass for the generation of BioH2 through batch dark fermentation processes with Enterobacter aerogenes was evaluated. The obtained yields ranged, in mL H2/g Volatile Solids (VS), from 50.1 for biomass from anaerobically digested cattle WW to 390 for swine WW, whereas the yield with biomass cultivated in Bristol medium was 57.6â¯mL H2/gVS.
Asunto(s)
Biocombustibles , Biotecnología , Microalgas , Scenedesmus , Animales , Biomasa , Bovinos , Nitrógeno , Fósforo , Aves de Corral , Porcinos , Aguas ResidualesRESUMEN
Dairy industries have a high environmental impact, with very high energy and water consumption and polluting effluents. To increase the sustainability of these industries it is urgent to implement technologies for wastewater treatment allowing water recycling and energy savings. In this study, dairy wastewater was processed by ultrafiltration and nanofiltration or ultrafiltration and reverse osmosis (UF/RO) and retentates from the second membrane separation processes were assessed for bioenergy production. Lactose-fermenting yeasts were tested in direct conversion of the retentates (lactose-rich streams) into bioethanol. Two Kluyveromyces strains efficiently fermented all the lactose, with ethanol yields higher than 90% (>0.47 g/g yield). Under severe oxygen-limiting conditions, the K. marxianus PYCC 3286 strain reached 70 g/L of ethanol, which is compatible with energy-efficient distillation processes. In turn, the RO permeate is suitable for recycling into the cleaning process. The proposed integrated process, using UF/RO membrane technology, could allow water recycling (RO permeate) and bioenergy production (from RO retentate) for a more sustainable dairy industry.
RESUMEN
The aim of the present work was the simultaneous treatment of urban wastewater using microalgae and the energetic valorization of the obtained biomass. Chlorella vulgaris (Cv), Scenedesmus obliquus (Sc) and a naturally occurring algal Consortium C (ConsC) were grown in an urban wastewater. The nutrient removals were quite high and the treated water fits the legislation (PT Dec-Lei 236/98) in what concerns the parameters analysed (N, P, COD). After nutrient depletion the microalgae remained two more weeks in the photobioreactor (PBR) under nutritional stress conditions, to induce sugar accumulation (22-43%). The stressed biomass was converted into biohydrogen (bioH2), a clean energy carrier, through dark fermentation by a strain of the bacteria Enterobacter aerogenes. The fermentation kinetics were monitored and fitted to a modified Gompertz model. The highest bioH2 production yield was obtained for S. obliquus (56.8 mL H2/gVS) which was very similar when using the same algae grown in synthetic media.