Influence of Growth Process on Suppression of Surface Morphological Defects in 4H-SiC Homoepitaxial Layers.

To address surface morphological defects that have a destructive effect on the epitaxial wafer from the aspect of 4H-SiC epitaxial growth, this study thoroughly examined many key factors that affect the density of defects in 4H-SiC epitaxial wafer, including the ratio of carbon to silicon, growth time, application of a buffer layer, hydrogen etching and other process parameters. Through systematic experimental verification and data analysis, it was verified that when the carbon-silicon ratio was accurately controlled at 0.72, the density of defects in the epitaxial wafer was the lowest, and its surface flatness showed the best state. In addition, it was found that the growth of the buffer layer under specific conditions could effectively reduce defects, especially surface morphology defects. This provides a new idea and method for improving the surface quality of epitaxial wafers. At the same time, we also studied the influence of hydrogen etching on the quality of epitaxial wafers. The experimental results show that proper hydrogen etching can optimize surface quality, but excessive etching may lead to the exposure of substrate defects. Therefore, it is necessary to carefully control the conditions of hydrogen etching in practical applications to avoid adverse effects. These findings have important guiding significance for optimizing the quality of epitaxial wafers.

Research on the Influence of Carbon Sources and Buffer Layers on the Homogeneous Epitaxial Growth of 4H-SiC.

In this study, a 4H-SiC homoepitaxial layer was grown on a 150 mm 4° off-axis substrate using a horizontal hot wall chemical vapor deposition reactor. Comparing C3H8 and C2H4 as C sources, the sample grown with C2H4 exhibited a slower growth rate and lower doping concentration, but superior uniformity and surface roughness compared to the C3H8-grown sample. Hence, C2H4 is deemed more suitable for commercial epitaxial wafer growth. Increasing growth pressure led to decreased growth rate, worsened thickness uniformity, reduced doping concentration, deteriorated uniformity, and initially improved and then worsened surface roughness. Optimal growth quality was observed at a lower growth pressure of 40 Torr. Furthermore, the impact of buffer layer growth on epitaxial quality varied significantly based on different C/Si ratios, emphasizing the importance of selecting the appropriate conditions for subsequent device manufacturing.

Effect of TCS gas flow and pre-etching on homopitaxial growth of 4H-SiC.

In this study, the epitaxial growth of 6-inch n-type 4° off-axis Si-face substrates using a horizontal hot-wall LPCVD system was investigated. The study explored the epitaxial growth under different source gas flow rates, growth pressures, and pre-etching times, with particular emphasis on their effects on epitaxial growth rate, epitaxial layer thickness uniformity, doping concentration and uniformity, and epitaxial layer surface roughness. The observation was made that the increase in source gas flow rate led to variations in dopant concentration due to different transport models between nitrogen gas and source gas. Additionally, with the increase in etching time, overetching phenomena occurred, resulting in changes in both dopant concentration and uniformity. Furthermore, the relationships between these three factors and their corresponding indicators were explained by combining the CVD growth process with the laminar flow model. These observed patterns are beneficial for further optimizing growth conditions in industrial settings, ultimately enhancing the quality of the growth process.

Genetic perturbation of postsynaptic activity regulates synapse elimination in developing cerebellum.

In many parts of the vertebrate nervous system, synaptic connections are remodeled during early postnatal life. Neural activity plays an important role in regulating one such rearrangement, synapse elimination, in the developing neuromuscular system, but there is little direct evidence on roles of pre- or postsynaptic activity in regulating synapse elimination in the developing brain. To address this issue, we expressed a chloride channel-yellow fluorescent protein fusion in cerebellar Purkinje cells (PCs) of transgenic mice to decrease their excitability. We then assessed elimination of supernumerary climbing fiber inputs to PCs. Individual PCs are innervated by multiple climbing fibers at birth; all but one are eliminated during the first three postnatal weeks in wild-type mice, but multiple innervation persists for at least three months in the transgenic mice. The normal redistribution of climbing fiber synapses from PC somata to proximal dendrites was also blunted in transgenics. These results show that normal electrical activity of the postsynaptic cell is required for it to attain a mature innervation pattern.

Phorbol ester and endothelin-1 alter functional expression of Na+/Ca2+ exchange, K+, and Ca2+ currents in cultured neonatal rat myocytes.

Endothelin-1 (ET-1) and activation of protein kinase C (PKC) have been implicated in alterations of myocyte function in cardiac hypertrophy and heart failure. Changes in cellular Ca2+ handling and electrophysiological properties also occur in these states and may contribute to mechanical dysfunction and arrhythmias. While ET-1 or PKC stimulation induces cellular hypertrophy in cultured neonatal rat ventricular myocytes (NRVMs), a system widely used in studies of hypertrophic signaling, there is little data about electrophysiological changes. Here we studied the effects of ET-1 (100 nM) or the PKC activator phorbol 12-myristate 13-acetate (PMA, 1 µM) on ionic currents in NRVMs. The acute effects of PMA or ET-1 (≤30 min) were small or insignificant. However, PMA or ET-1 exposure for 48-72 h increased cell capacitance by 100 or 25%, respectively, indicating cellular hypertrophy. ET-1 also slightly increased Ca2+ current density (T and L type). Na+/Ca2+ exchange current was increased by chronic pretreatment with either PMA or ET-1. In contrast, transient outward and delayed rectifier K+ currents were strongly downregulated by PMA or ET-1 pretreatment. Inward rectifier K+ current tended toward a decrease at larger negative potential, but time-independent outward K+ current was unaltered by either treatment. The enhanced inward and reduced outward currents also result in action potential prolongation after PMA or ET-1 pretreatment. We conclude that chronic PMA or ET-1 exposure in cultured NRVMs causes altered functional expression of cardiac ion currents, which mimic electrophysiological changes seen in whole animal and human hypertrophy and heart failure.

Functional role of the fast transient outward K+ current IA in pyramidal neurons in (rat) primary visual cortex.

A molecular genetic approach was exploited to directly test the hypothesis that voltage-gated K+ (Kv) channel pore-forming (alpha) subunits of the Kv4 subfamily encode the fast transient outward K+ current (IA) in cortical pyramidal neurons and to explore the functional role of IA in shaping action potential waveforms and in controlling repetitive firing in these cells. Using the biolistic gene gun, cDNAs encoding a mutant Kv4.2 alpha subunit (Kv4.2W362F), which functions as a dominant negative (Kv4.2DN), and enhanced green fluorescent protein (EGFP) were introduced in vitro into neurons isolated from postnatal rat primary visual cortex. Whole-cell voltage-clamp recordings obtained from EGFP-positive pyramidal neurons revealed that IA is selectively eliminated in cells expressing Kv4.2DN. The densities and properties of the other Kv currents are unaffected. In neurons expressing Kv4.2DN, input resistances are increased and the (current) thresholds for action potential generation are decreased. In addition, action potential durations are prolonged, the amplitudes of afterhyperpolarizations are reduced, and the responses to prolonged depolarizing inputs are altered markedly in cells expressing Kv 4.2DN. At low stimulus intensities, firing rates are increased in Kv4.2DN-expressing cells, whereas at high stimulus intensities, Kv4.2DN-expressing cells adapt strongly. Together, these results demonstrate that Kv4alpha subunits encode IA channels and that IA plays a pivotal role in shaping the waveforms of individual action potentials and in controlling repetitive firing in visual cortical pyramidal neurons.

Optimization of polyhydroxybutyrate (PHB) production by excess activated sludge and microbial community analysis.

In this study, a high value-added and biodegradable thermoplastic, polyhydroxybutyrate (PHB), was produced by excess activated sludge. The effects of the nutritional condition, aeration mode, sodium acetate concentration and initial pH value on PHB accumulation in the activated sludge were investigated. The maximum PHB content and PHB yield of 67.0% (dry cell weight) and 0.740gCODgCOD(-1) (COD: chemical oxygen demand), respectively, were attained by the sludge in the presence of 6.0gL(-1) sodium acetate, with an initial pH value of 7.0 and intermittent aeration. The analysis of the polymerase chain reaction (PCR)-denaturing gradient-gel-electrophoresis (DGGE) sequencing indicated that the microbial community of the sludge was significantly different during the process of PHB accumulation. Three PHB-accumulating microorganisms, which were affiliated with the Thauera, Dechloromonas and Competibacter lineages, were found in the excess activated sludge under different operating conditions for PHB accumulation.