Advances and challenges in the fractionation of edible oils and fats through supercritical fluid processing.

Petrochemical solvents are widely used for the extraction and fractionation of biomolecules from edible oils and fats at an industrial scale. However, owing to its safety concerns, toxicity, price fluctuations, and sustainability, alternative solvents and technologies have been actively explored in recent years. Technologies, such as ultrasound and microwave-assisted extraction, supercritical carbon dioxide extraction, supercritical fluid fractionation, and sub-critical water extraction, and solvents, like ionic liquids and deep eutectic solvents, are reported for extraction and fractionation of biomolecules. Among them, supercritical carbon dioxide extraction and fractionation are some of the most promising green technologies with the potential to replace petrochemical-based conventional techniques. The addition of cosolvents, such as water, ethanol, and acetone, improves the extraction of amphiphilic and polar compounds from edible oils and fats. Supercritical fluid processing has diverse applications, including concentration of solutes, selective separation of desired molecules, and separation of undesirable compounds from the feed material. Temperature, pressure, particle size, porosity, flow rate, solvent-to-feed ratio, density, viscosity, diffusivity, solubility, partition coefficient, and separation factor are the fundamental factors governing the extraction and fractionation of desired biomolecules from lipids. Supercritical fluids stand alone compared to conventional fluids, because of their tunable solvent properties. Overall, it is to be noted that supercritical fluid-based methods have lots of scope to replace conventional solvent-based methods and progress toward the creation of sustainable food-processing techniques. This review critically evaluates the parameters responsible for the extraction and fractionation of biomolecules from edible oils and fats under supercritical conditions.

Effective grease separator management is the key to enhancing bioenergy recovery of fat, oil, and grease (FOG) and contributing to a circular bio-economy.

Management of fat, oil and grease (FOG) is crucial for the recovery of renewable resources and the protection of sewer systems. This study aims to identify the potential quantities and qualities of FOG that can be acquired through optimised grease separator (GS) management approaches in hotels and restaurants during seasonal tourism. A technical survey of 20 GS from hotels and restaurants in the federal state of Tyrol, Austria was conducted. The findings revealed that 55 % of the GS were in poor condition, often due to infrequent maintenance and limited operator's knowledge. The FOG layer quality and quantity was monitored over three years and physicochemical parameters including total residue, volatile solids, total organic carbon, lipid content, and biomethane yield, were analysed. An optimised management approach, which involved up to 4 GS emptying per season, revealed a significant increase in FOG quantity for the majority of the inspected establishments, with an overall doubling of the acquired FOG volume. Based on these results, the energy potential of GS is presented in three potential management scenarios. The energy recovered from GS increased by 246 %. This highlights the importance of proper GS management in the hospitality sector, which can play a critical role in promoting environmental sustainability and renewable energy production.

Physicochemical properties and flavor substances analyses of refined beef tallow with dry fractionation treatment.

Dry fractionation represents a significant technique for separation of diverse fractions from beef tallow. The objective of this study was to undertake a systematic investigation of alterations in physicochemical properties, crystallization behavior, thermal properties, and flavor compounds that occur during the beef tallow dry fractionation process. The solid component yielded at 40, 30, and 15 °C were 44.88%, 33.72%, and 13.04% respectively, with an 8.36% liquid content at 15 °C, which was consistent with the characteristics of saturated fatty acids content. The ß - ß' transformation in the dry fractionation process was clearly revealed by X-ray diffraction. Differential scanning calorimetry curves exhibited alterations in exothermic and endothermic peak, as well as enthalpy. Electronic nose identified short-chain compounds, aldehydes, ketones, and nitrogen-containing substances as flavor compounds. Volatile compounds were quantified using HS-SPME-GC-MS. Overall, dry fractionation produces beef tallow fractionated compounds with diverse physicochemical properties and aromatic-active substances, thereby expanding its potential utilization.

Analytical approaches for the determination of adulterated animal fats and vegetable oils in food and non-food samples.

Edible oils and fats are crucial components of everyday cooking and the production of food products, but their purity has been a major issue for a long time. High-quality edible oils are contaminated with low- and cheap-quality edible oils to increase profits. The adulteration of edible oils and fats also produces many health risks. Detection of main and minor components can identify adulterations using various techniques, such as GC, HPLC, TLC, FTIR, NIR, NMR, direct mass spectrometry, PCR, E-Nose, and DSC. Each detection technique has its advantages and disadvantages. For example, chromatography offers high precision but requires extensive sample preparation, while spectroscopy is rapid and non-destructive but may lack resolution. Direct mass spectrometry is faster and simpler than chromatography-based MS, eliminating complex preparation steps. DNA-based oil authentication is effective but hindered by laborious extraction processes. E-Nose only distinguishes odours, and DSC directly studies lipid thermal properties without derivatization or solvents. Mass spectrometry-based techniques, particularly GC-MS is found to be highly effective for detecting adulteration of oils and fats in food and non-food samples. This review summarizes the benefits and drawbacks of these analytical approaches and their use in conjunction with chemometric tools to detect the adulteration of animal fats and vegetable oils. This combination provides a powerful technique with enormous chemotaxonomic potential that includes the detection of adulterations, quality assurance, assessment of geographical origin, assessment of the process, and classification of the product in complex matrices from food and non-food samples.

Developmental programming of production and reproduction in dairy cows: V. Association of the main and interactive effects of maternal level of milk production and milk fat to protein ratio with offspring's birth weight, survival, and productive and reproductive performance from birth to the first lactation period.

Level of dam milk production (DMP) and dam milk fat to protein ratio (DFPR), as an indicator of metabolic status in dairy cows, have been identified to be associated with productive and reproductive performance of the offspring. Yet whether the interaction of DMP by DFPR can be associated with performance of the offspring have not been studied to our knowledge. Therefore, the present study was conducted to investigate the association of the main and interactive effects of DMP and DFPR with offspring's birth weight, survival, milk yield and fertility. To this end, data of birth weight, culling rate, milk yield and reproductive variables of offspring born to lactating dams (n = 14,582) and data associated with DMP and DFPR during 305-day lactation were retrieved. Afterwards, offspring were classified in three categories of DMP, including DMP1 (dams with <10.00 × 103 kg of 305-day milk production), DMP2 (dams with ≥10.00 × 103 kg and <14.00 × 103 kg of 305-day milk production), DMP3 (dams with ≥14.00 × 103 kg of 305-day milk production), and three categories of DFPR, including DFPR1 (offspring born to dams with <1.00 FPR), DFPR2 (offspring born to dams with ≥1.00 and < 1.40 FPR) and DFPR3 (offspring born to dams with ≥1.40 FPR). Statistical analysis revealed no association of the interaction effect of DMP by DFPR with investigated variables in the offspring (P > 0.05). However, the main effect of DMP was positively associated with milk yield, but negatively associated with survival, age at first insemination and conception during nulliparity, and transgenerational improvement in milk yield in the offspring (P < 0.05). Moreover, the main effect of DFPR was positively associated with birth weight, survival and first service conception rate during nulliparity, but negatively associated with metabolic status and reproductive performance during primiparity in the offspring (P < 0.05). In conclusion, the present study did not find any interaction effect of DMP by DFPR on productive and reproductive variables in the offspring. This finding implicates the association of DMP with milk production in the offspring was regardless of DFPR. Moreover, this finding implies the association of DFPR with postpartum metabolic status and reproductive performance in the offspring was regardless of DMP.

Improved physicochemical properties of bigels produced with ethyl cellulose-based oleogel and moderately deacetylated konjac glucomannan hydrogel.

The ideal physicochemical properties of bigels are important for food applications. Therefore, a new bigel was prepared based on mixed beef tallow and soybean oil oleogel and deacetylated konjac glucomannan (KGM) hydrogel. The effect of the deacetylation degree of KGM on the physicochemical properties and microstructure of bigels was studied. The bigel containing moderate deacetylation degree of KGM had better rheological properties and hardness (319.84 g) than that with low and high deacetylation degrees of KGM. The interactions among the bigel components were analyzed by Fourier transform infrared spectroscopy and molecular dynamics simulation, indicating that the formation of the bigels was dominated by electrostatic interactions. Overall, the bigels containing moderate deacetylation degree of KGM had better physical properties, which may provide a theoretical foundation to develop bigels with low cholesterol, trans and saturated fats levels to replace traditional solid fats in food industry.

Bta-miR-200a Regulates Milk Fat Biosynthesis by Targeting IRS2 to Inhibit the PI3K/Akt Signal Pathway in Bovine Mammary Epithelial Cells.

Milk fat synthesis has garnered significant attention due to its influence on the quality of milk. Recently, an increasing amount of proofs have elucidated that microRNAs (miRNAs) are important post-transcriptional factor involved in regulating gene expression and play a significant role in milk fat synthesis. MiR-200a was differentially expressed in the mammary gland tissue of dairy cows during different lactation periods, which indicated that miR-200a was a candidate miRNA involved in regulating milk fat synthesis. In our research, we investigated the potential function of miR-200a in regulating milk fat biosynthesis in bovine mammary epithelial cells (BMECs). We discovered that miR-200a inhibited cellular triacylglycerol (TAG) synthesis and suppressed lipid droplet formation; at the same time, miR-200a overexpression suppressed the mRNA and protein expression of milk fat metabolism-related genes, such as fatty acid synthase (FASN), peroxisome proliferator-activated receptor gamma (PPARγ), sterol regulatory element-binding protein 1 (SREBP1), CCAAT enhancer binding protein alpha (CEBPα), etc. However, knocking down miR-200a displayed the opposite results. We uncovered that insulin receptor substrate 2 (IRS2) was a candidate target gene of miR-200a through the bioinformatics online program TargetScan. Subsequently, it was confirmed that miR-200a directly targeted the 3'-untranslated region (3'-UTR) of IRS2 via real-time fluorescence quantitative PCR (RT-qPCR), western blot analysis, and dual-luciferase reporter gene assay. Additionally, IRS2 knockdown in BMECs has similar effects to miR-200a overexpression. Our research set up the mechanism by which miR-200a interacted with IRS2 and discovered that miR-200a targeted IRS2 and modulated the activity of the PI3K/Akt signaling pathway, thereby taking part in regulating milk fat synthesis in BMECs. Our research results provided valuable information on the molecular mechanisms for enhancing milk quality from the view of miRNA-mRNA regulatory networks.

Rancid rumors or Native wisdom: Evaluating the efficacy of animal fats as insect repellents attributed to historic-period Native Americans.

Little is known about Native American adaptations to blood-sucking arthropods prior to and following European contact. Multiple accounts starting in the 16th century suggest that rancid animal grease was employed by Gulf Coast indigenes as a mosquito repellent. Although many Native American ethnobotanical remedies for biting insects have been recorded, the use of animal products for this purpose is not well documented. Moreover, few traditional Native American mosquito repellents have been examined using controlled laboratory methods for repellency testing. In this study, we tested the repellent efficacy of fats derived from alligator, bear, cod, and shark that were aged to various stages of rancidity. Using yellow fever mosquitoes, (Aedes aegypti), we performed an arm-in-cage assay to measure the complete protection times resulted from these fats, when applied to human skin. We used a Y-tube olfactometer assay to evaluate long-distance repellency and tested tick-repellency in a crawling assay. Our results suggest that rancid animal fats from cod, bear, and alligator are potent albeit short-lived mosquito repellents. We found that both rancid and fresh fats do not repel ticks. Our findings show the validity of traditional ethnozoological knowledge of Native American people and support aspects of the ethnohistorical record.

Carrageenan-induced conjugated oat protein isolate microgel particles as structure modulators in fat analogues and their digestion behaviors.

HYPOTHESIS: Engineering plant-based microgel particles (MPs) at a molecular scale is meaningful to prepare functional fat analogues. We hypothesize that oat protein isolate (OPI) and κ-carrageenan (CA) have synergy in MPs formation, using MPs with controllable structure, and further to fabricate fat analogues with adjustable characteristics is feasible. Their digestion fate will also be possibly modulated by interfacial coatings. EXPERIMENTS: OPI-based conjugated MPs with tunable rigidities by changing crosslinking densities were designed. The relationship between microgel structures, and emulsion gel properties was explored through spectroscopy, microstructure, rheology and tribology. The delivery to lycopene, as well as inhibiting digestion behaviors of fat analogues was evaluated in a simulated gastro-intestinal tract. FINDINGS: The rigidity of conjugated MPs could be tailored to optimize the performance of fat analogues. OPI-1 %CA MPs could stabilize emulsions up to 95 % oil fraction with fine texture. Tribological behaviors had a dependence on microgel elasticity and interfacial coatings, medium hard MP-stabilized emulsion was less disrupted without coalescence after oral processing. Digestion was delayed by denser and harder MPs by softening the interfacial particle layer or limiting lipase accessibility. Softer conjugated MPs possessed better flexibility and were broken down more easily leading to a higher rate of lipid digestion.

Dietary fat lowers ileal endogenous amino acid losses in broiler chickens.

1. An experiment was conducted to determine the effect of the source of fat (soybean oil or tallow) on the ileal endogenous amino acid (EAA) losses in broilers.2. Three nitrogen (N)-free diets; a control diet with no added fat and test diets with 60 g/kg of either soybean oil or tallow were formulated. Titanium dioxide (5 g/kg) was added to all diets as an indigestible marker. Each diet was assigned to six replicate cages (eight birds per cage) from d 18 to 21 post-hatch. On d 21, the digesta were collected from the lower half of the ileum.3. The endogenous losses of nitrogen and amino acids (AA) were lower (p = 0.08; p = 0.001) in broilers fed diets with soybean oil or tallow, respectively, compared to those fed the diet with no fat. Source of fat had no influence (p > 0.05) on EAA losses.4. The most abundant AA in the ileal endogenous protein was glutamic acid, followed by aspartic acid, threonine, leucine, serine, valine and proline. In general, the concentrations of AA in the endogenous protein were lower (p < 0.05) with added fat. The exceptions were methionine, cysteine, proline and serine, which were unaffected. The effect of fat source on the AA contents of endogenous protein were inconsistent and differed depending on the AA.5. The inclusion of fats decreased EAA losses which implied they have beneficial effects beyond direct energy contribution. It can be proposed that the reduction of EAA flow may be an additional mechanism contributing to the extra-caloric effect of dietary fats.

Impact of Holder Pasteurization and Preanalytical Handling Techniques on Fat Concentration in Donor Human Milk: A Scoping Review.

BACKGROUND: Donor human milk (DHM) is an essential source of nutrition among high-risk infants (e.g., premature and low-birth weight). Holder pasteurization, a common step in DHM processing, is known to partially alter the composition of DHM; however, the impact on fat composition is historically inconsistent. OBJECTIVES: This scoping review aimed to broadly review the literature on the impact of Holder pasteurization on the fat content in DHM, with a focus on preanalytical sample mixing. METHODS: A systematic search of original, peer-reviewed research articles was conducted on 11 July, 2022. Articles were included if they compared matched raw (control) and Holder-pasteurized human milk samples and measured total lipids, cholesterol, and individual classes of fatty acids. Article review and selection was conducted by 2 independent reviewers. RESULTS: The search yielded 26 original, peer-reviewed research articles published between 1978 and 2022. Overall methodology varied considerably between studies. When study methods described any mixing for collecting raw milk, 1 (17%) of the 6 of studies reported a small change in total fat concentration following pasteurization (<5%). Alternatively, among studies that did not describe methods for mixing raw milk to ensure a representative sample, 10 (56%) of the 18 reported a significant change (≥± 5%) in total fat concentration, with changes ranging from -28.6% to +19.4%. CONCLUSIONS: This review suggests that inconsistent findings regarding the impact of Holder pasteurization on fat may be related to study methodologies, particularly preanalytical sample mixing. More research considering the role of preanalytical handling procedures and methodologies is necessary to help clarify the impact of Holder pasteurization on human milk composition.

Analysis of the lipidomic profile of vegetable oils and animal fats and changes during aging by UPLC-Q-exactive orbitrap mass spectrometry.

Vegetable oil and animal fat residues are common evidence in the cases of homicide, arson, theft, and other crimes. However, the lipid composition and content changes during aging on complex carriers remain unclear. Therefore, this study dynamically monitored the lipid composition and content changes during aging of 13 different types of vegetable oils and animal fats on five different carriers using the UPLC-Q-Exactive Orbitrap MS method. A total of 6 subclasses of 93 lipids including lysophosphatidylcholine (2 species), phosphatidylcholine (2 species), diglyceride (5 species), triglyceride (81 species), acylGlcCampesterol ester (2 species), and acylGlcSitosterol ester (1 species), were first identified in fresh vegetable oils and animal fats. By comparing the LC-MS/MS chromatograms of fresh vegetable oils and animal fats, it was found that there were significant differences between the chromatograms of vegetable oils and animal fats, but it was difficult to distinguish between the chromatograms of vegetable oils or animal fats. After aging at 60 °C for 200 days, there was a significant decrease in the content of diglyceride, triglyceride, acylGlcCampesterol ester, and acylGlcSitosterol ester, while the content of lysophosphatidylcholine and phosphatidylcholine initially increased and then decreased. Furthermore, statistical analysis of lipid differences between vegetable oils and animal fats was performed using cluster heat maps, volcanic maps, PCA, and OPLS-DA. On average, 33 significantly different lipids were screened (VIP > 1, p < 0.05), which could serve as potential biomarkers for distinguishing vegetable oils and animal fats. It was found that the potential biomarkers still existed during aging of vegetable oils and animal fats (100 and 200 days). This research provides important reference information for the identification of vegetable oil and animal fat residues in complex carriers at crime scenes.

ALG5 Regulates STF-62247-Induced Milk Fat Synthesis via the mTOR Signaling Pathway.

Milk fat content is a critical indicator of milk quality. Exploring the key regulatory genes involved in milk fat synthesis is essential for enhancing milk fat content. STF-62247 (STF), a thiazolamide compound, has the potential to bind with ALG5 and upregulate lipid droplets in fat synthesis. However, the effect of STF on the process of milk fat synthesis and whether it acts through ALG5 remains unknown. In this study, the impact of ALG5 on milk fat synthesis and its underlying mechanism were investigated using bovine mammary epithelial cells (BMECs) and mouse models through real-time PCR, western blotting, Oil Red O staining, and triglyceride analysis. Experimental findings revealed a positive correlation between STF and ALG5 with the ability to synthesize milk fat. Silencing ALG5 led to decreased expression of FASN, SREBP1, and PPARγ in BMECs, as well as reduced phosphorylation levels in the PI3K/AKT/mTOR signaling pathway. Moreover, the phosphorylation levels of the PI3K/AKT/mTOR signaling pathway were restored when ALG5 silencing was followed by the addition of STF. These results suggest that STF regulates fatty acid synthesis in BMECs by affecting the PI3K/AKT/mTOR signaling pathway through ALG5. ALG5 is possibly a new factor in milk fat synthesis.

Thermal resistance of Listeria monocytogenes, Escherichia coli O157:H7 and Salmonella in animal fat - Kinetic analysis and mathematical modeling.

The objective of this study was to evaluate the effect of fat on thermal resistance of L. monocytogenes, E. coli O157:H7, and Salmonella spp. A 4-strain cocktail of each microorganism was inoculated to beef tallow and heated isothermally at temperatures between 55 and 80℃. All survival curves did not follow the 1st-order inactivation kinetics but conformed to a two-stage linear pattern. The first stage was markedly less heat-resistant than the second, as manifested by significantly lower D values. The z values of E. coli O157 H7 and Salmonella spp. were 11.8 °C and 12.3 °C in the first stage (z1) but increased to 23.7 °C and 20.8 °C in the second stage (z2), respectively. For L. monocytogenes, while the z values were similar for both stages (z1 = 19.6 °C and z2 = 18.5 °C), the second stage D values are 3.6-5.9 times of those in the first stage. One-step analysis was used to fit the nonlinear curves to the Weibull model, yielding < 1 exponents for the model (0.495, 0.362, and 0.282, respectively, for L. monocytogenes, E. coli O157:H7, and Salmonella spp.), suggesting gradually increased thermal resistance during heating. The experimental results showed that these microorganisms could resist heating for longer time and at higher temperatures in tallow than they do in regular meats containing lower levels of fat. The kinetic models can be used to develop thermal processes to properly inactivate pathogens contaminated in the fat portions of meat products or other high fat products.

The relationship between nonlinear viscoelasticity and baking performance in low-saturated puff pastry margarine.

The oil phase obtained by blending and oleogel methods has potential for the production of non­hydrogenated and low-saturated puff pastry margarine, thereby reducing intakes of both types of dietary fat. The crystal form, microstructure, rheology, and baking applications of puff pastry margarines prepared with anhydrous milk fat (AMF)/palm stearin (POs), POs/palm oil (PO), beef tallow (BT)/PO, or AMF/POs/diacetyl tartaric acid ester of mono(di)glycerides (DATEM) oleogels were investigated using X-ray scattering, polarized light microscope, and rheometer, respectively. All margarines exhibited ß'-form crystal and strongly viscoelastic at low strain. With the addition of DATEM oleogel, their crystal microstructure became more uniform and finer, and the croissants were less hard (1690) and chewiness (160). The chewiness of croissants produced using the margarines was significantly improved with POs content. The theoretical basis for preparation and application in non­hydrogenated and low-saturated puff pastry margarine was provided in the present study.

Interactive Effects of Dietary Fiber and Lipid Types Modulate the Predicted Production and Absorption of Cecal and Colorectal Short-Chain Fatty Acids in Growing Pigs.

BACKGROUND: High-fiber diets are supplemented with lipids to meet the required energy content, but data on the interactions between dietary fiber (DF) and lipid types on gastrointestinal fermentation in pigs are scant. OBJECTIVES: This study aimed to use a combination of in vivo and in vitro fermentation methodologies to determine the interactive effects of DF and lipid types on short-chain fatty acid (SCFA) production and absorption and organic matter (OM) fermentability in the cecum and colorectal tract of pigs. METHODS: Eight ileal- and cecal-cannulated Yorkshire barrows were fed either pectin- or cellulose-containing diets that were supplemented with either corn oil or beef tallow in 2 independent Youden squares with a 2 × 2 factorial arrangement of treatments (n = 6). Ileal and cecal digesta were collected, freeze-dried, and fermented using inoculum from fresh cecal digesta and feces, respectively, to determine individual SCFA production and absorption and fermentability of OM. RESULTS: Interactions (P < 0.001) between DF and lipid types were observed in which the addition of beef tallow decreased the quantity of cecal and colorectal acetic acid production and cecal acetic absorption, cecal butyric production, predicted cecal OM fermentability, and predicted colorectal propionic acid in pectin diets, but the effects were not observed for cellulose diets. The addition of beef tallow increased (P < 0.001) the production of cecal butyric and propionic acids during in vitro fermentation in cellulose diets and apparent total tract digestibility (ATTD) of OM in pectin diets. CONCLUSIONS: The interactions between DF and lipids on gastrointestinal fermentation largely depend on the degree of saturation of fatty acids in dietary lipids. The addition of beef tallow selectively decreased the production and absorption of individual SCFAs in pectin and cellulose diets but increased cecal butyric and propionic acid production in cellulose diets and the ATTD of OM in pectin diets.

Crystallization behavior and compatibility analysis of palm kernel stearin/anhydrous milk fat blends and application.

In this paper, the compatibility, phase behavior, and crystallization properties of the binary blends of palm kernel stearin (PKS) and anhydrous milk fat (AMF) were investigated by analyzing the solid fat content (SFC), thermal properties, polymorphism, and microstructure, with the aim of providing theoretical guidance for the blending of oils. The results showed that the PKS content primarily determined the SFC trend of the binary blends. However, the binary blends demonstrated poor miscibility and eutectic behavior was predominantly observed in the system, particularly at higher temperatures. Only α and ß' forms appeared in this blended system. Simultaneously, the addition of PKS elevated the liquid phase transition temperature of the binary blends, considerably significantly increased their crystallization rate when the addition of PKS was more than 20% and increased the density and size of the fat crystals. Finally, the mixing design optimization method was used to get the most suitable ratio of the binary blends in the refrigerated cream system with PKS:AMF to be 0.914:0.086. The cream prepared with the above binary blends was indeed superior in overrun and firmness and had high stability. PRACTICAL APPLICATION: Some fats with special advantages are often limited in their wide application because of their poor crystallization ability. In this paper, the crystallization ability of fats is improved, and their application scenarios are increased through the combination of fats, so as to provide reference for the production of special fats for food.

Elucidating the impact of sanitary waste on the formation of fat, oil and grease deposits in sewer systems.

The accumulation of fat, oil and grease (FOG) deposits in sanitary sewer systems is a significant cause of sewer overflows, mainly due to their tendency to adhere to pipe walls. The aim of this study is to (i) develop laboratory-prepared FOG deposits using a mixture of iron (Fe) and aluminium (Al) metal ions, fatty acids, saccharides and cooked oils, in addition to various sanitary waste materials such as paper towels, wipes and pads and (ii) examine the characteristics of these FOG deposits. The goals of this study were to (i) gain a deeper understanding of the impact of sanitary waste on the formation of FOG deposits and (ii) discuss the detailed physiochemical properties of these FOG deposits. The findings revealed that FOG deposits can vary in nature, appearing as either a smooth, paste-like substance or a coarse, semi-solid material, depending on the types of waste present in the sewer. Analysis of the fatty acid profile indicated that the FOG deposits with wipes have the highest viscosity (3.2 × 104 Pa s) and larger composition of smaller chain saturated fatty acids (caprylic acid 0.64%, undecanoic acid 5.61%, lauric acid 4.65%, myristic acid 3.21% and palmitic 8.38%). In contrast, FOG deposits with Fe and Al metal impurities have higher heat resistance and thermal stability (melting point of 125 °C) and have larger composition of long chain fatty acids. Furthermore, FTIR analysis confirmed that these FOG deposits are composed of metallic salts of fatty acids, aligning with samples from sewer lines. Our results suggest that FOG deposit formation involves the aggregation of excess calcium, which compresses free fatty acid micelles, and a saponification reaction between the calcium aggregates and free fatty acids. This research illuminates the complex processes behind FOG deposit formation and their varied characteristics, providing valuable insights into potential strategies for preventing FOG-related sewer blockages.

Study of Processing Conditions during Enzymatic Hydrolysis of Deer By-Product Tallow for Targeted Changes at the Molecular Level and Properties of Modified Fats.

In most cases, the unused by-products of venison, including deer tallow, are disposed of in rendering plants. Deer tallow contains essential fatty acids and can be used to prepare products for everyday food and advanced applications. This work aimed to process deer tallow into hydrolyzed products using microbial lipases. A Taguchi design with three process factors at three levels was used to optimize the processing: amount of water (8, 16, 24%), amount of enzyme (2, 4, 6%), and reaction time (2, 4, 6 h). The conversion of the tallow to hydrolyzed products was expressed by the degree of hydrolysis. The oxidative stability of the prepared products was determined by the peroxide value and the free fatty acids by the acid value; further, color change, textural properties (hardness, spreadability, stickiness, and adhesiveness), and changes at the molecular level were observed by Fourier transform infrared spectroscopy (FTIR). The degree of hydrolysis was 11.8-49.6%; the peroxide value ranged from 12.3 to 29.5 µval/g, and the color change of the samples expressed by the change in the total color difference (∆E*) was 1.9-13.5. The conditions of enzymatic hydrolysis strongly influenced the textural properties: hardness 25-50 N, spreadability 20-40 N/s, and stickiness < 0.06 N. FTIR showed that there are changes at the molecular level manifested by a decrease in ester bonds. Enzymatically hydrolyzed deer tallow is suitable for preparing cosmetics and pharmaceutical matrices.

Removal of PAHs, TSS, oils and fats from ammonium-rich coke wastewater by granular filtration.

Coke wastewater is a complex industrial wastewater due to its high content of toxic compounds such as cyanides, thiocyanates, phenols, tar, oils, and fats. After a series of treatments, wastewater with a high ammonium content is obtained (around 4,150 mg·L-1). A stripping process is used to reduce it. Certain pollutants in the influent, such as tar, polycyclic aromatic hydrocarbons (PAHs), oils, fats and total suspended solids (TSS), interfere with stripping and therefore must be previously removed. In this study, the performance of a pilot-scale airlift sand filter was evaluated under real conditions for the reduction of the concentration of tar, PAHs, oils, fats and TSS, before stripping. Prior to the sand filter, a cationic flocculant was added to the influent (2 ppm). High (10 mm.min-1), medium (7.5 mm.min-1) and low sand speeds (1.9-2.6 mm.min-1) were assessed. The latter conditions gave the best results: a decrease of 98.2% in TSS, 99.7% in oils, fats and grease and 97.6% in PAHs. The final effluent (≤ 1.6 mg PAHs·L-1, ≤ 5 mg TSS·L-1 and ≤ 0.05 mg·L-1 of fats, oils and grease) was suitable for the stripping process.