Brevibacillus themoruber: a promising microbial cell factory for exopolysaccharide production.

AIMS: This study aims to identify a high level exopolysaccharide (EPS) producer thermophile that in turn could be used as a model organism to study the biological mechanisms and whole genome organization of EPS-producing thermophilic bacteria. METHODS AND RESULTS: Thermophilic isolates were screened, and then growth and EPS production of the best producer Brevibacillus thermoruber strain 423 were investigated under different carbon and nitrogen sources, temperature, pH and agitation rates. Rheological characterization revealed that the EPS behaved like a typical Newtonian fluid and viscosity of the EPS solution increased with increasing Ca(2+) ion concentration. Chemical characterization by TLC, GC-MS, FT-IR and NMR suggested a heteropolymer structure with glucose as major monomer unit. High biocompatibility of pure EPS fractions suggested their potential use in biomedical applications. CONCLUSIONS: This study reports on the comprehensive description of microbial production conditions as well as chemical, rheological and biological characterization of the EPS produced by B. thermoruber strain 423. The bioreactor cultures were found to reach two times higher yields and three times higher productivities when compared with literature. SIGNIFICANCE AND IMPACT OF THE STUDY: Brevibacillus thermoruber strain 423 combined the advantages of its nonpathogenicity with the advantages of fast productivity and hence proved to be a very promising model organism and cell factory for microbial EPS production.

Extremophiles survival to simulated space conditions: an astrobiology model study.

In this work we investigated the ability of four extremophilic bacteria from Archaea and Bacteria domains to resist to space environment by exposing them to extreme conditions of temperature, UV radiation, desiccation coupled to low pressure generated in a Mars' conditions simulator. All the investigated extremophilic strains (namely Sulfolobus solfataricus, Haloterrigena hispanica, Thermotoga neapolitana and Geobacillus thermantarcticus) showed a good resistance to the simulation of the temperature variation in the space; on the other hand irradiation with UV at 254 nm affected only slightly the growth of H. hispanica, G. thermantarcticus and S. solfataricus; finally exposition to Mars simulated condition showed that H. hispanica and G. thermantarcticus were resistant to desiccation and low pressure.

Production and chemical characterization of an exopolysaccharide synthesized by psychrophilic yeast strain Sporobolomyces salmonicolor AL1 isolated from Livingston Island, Antarctica.

The exopolysaccharide (EPS) production by psychrophilic Antarctic yeast Sporobolomyces salmonicolor AL1 reached the maximum yield in medium containing sucrose (50 g/L) and diammonium sulfate (2.5 g/L) after a 5-d fermentation (5.64 g/L) at 22 °C, the dynamic viscosity of the culture broth reaching (after 5 d) 15.4 mPa s. EPS showed a mannan-like structure and high molar mass, and did not affect cellular viability and proliferation of murine macrophages. It exhibited also a protective effect against the toxic activity of Avarol.

Chemical composition and biotechnological properties of a polysaccharide from the peels and antioxidative content from the pulp of Passiflora liguralis fruits.

A new polysaccharide with a high molecular weight (greater than 1 x 106 Da) was extracted and characterized from the peels of Passiflora liguralis (granadilla) fruits. Chemical composition of the biopolymer, performed by using a high pressure anion exchange-pulsed amperometric detector (HPAE-PAD), showed the presence of six different sugar residues: xylose, glucose, galactose, galactosamine, an unknown component, and fucose in the relative ratio of 1:0.5:0.2:0.06:0.05:trace. The optical rotation of this xyloglucan was [alpha](D)(25) degrees C = -186.42 (concentration of 1.4 mg/mL of H(2)O), and the viscosity was dependent on the concentration and pH, showing a maximum value of 1.4 eta at a concentration of 3% in distilled water and a maximum value of 7.0 eta in citrate buffer solution. Thermogravimetric analysis indicated that this biopolymer was very stable at high temperatures, showing a degradation temperature at 280 degrees C. The characterization of the polysaccharide was also investigated by spectroscopic methods (1H NMR and IR) pointing out the complexity of this biopolymer and the presence of sugar residues in alpha-manno, alpha-gluco-galacto, and beta-gluco-galacto configurations. The formation of a biodegradable film using this novel xyloglucan was reported, and the anticytotoxic activity of the polysaccharide was studied in a brine shrimp bioassay. Considerable antioxidant activity (Trolox equivalent antioxidant capacity (TEAC) value of 0.32 microM/mg fresh product) was noted in the lipophilic extracts of Passiflora liguralis fruits, indicating, in this fruit, an alternative source of bioactive compounds.

Lycopene in association with alpha-tocopherol or tomato lipophilic extracts enhances acyl-platelet-activating factor biosynthesis in endothelial cells during oxidative stress.

Lipophilic compounds contained in tomato can prevent cardiovascular diseases by modulating the atherogenic processes in vascular endothelium mediated by oxidized low-density lipoproteins (LDLs). We investigated the effects of lycopene on the metabolism of platelet-activating factor (PAF) and its much less biologically active acyl analog, acyl-PAF, known to prevent LDL oxidation. Lycopene, or lycopene in association with alpha-tocopherol, or whole tomato lipophilic extracts (containing more than 80% lycopene) were used in experiments in which endothelial cells (ECs) are known to synthesize PAF following H(2)O(2)-induced oxidative stress. The results indicated that in each case H(2)O(2)-stimulated PAF biosynthesis in ECs, which is catalyzed by acetyl-CoA acetyltransferase (AT), appeared strongly inhibited. However, acyl-PAF biosynthesis, which also occurs through the PAF-dependent transacetylase (TA), was significantly increased by lycopene only when it was in association with alpha-tocopherol or with the minor compounds present in the whole lipophilic tomato extract. These findings suggest that alpha-tocopherol or lipophilic compounds present in tomato juice potentiate the effects of lycopene on the modulation of PAF and acyl-PAF biosynthesis in ECs during oxidative stress.

Polysaccharides from extremophilic microorganisms.

Several marine thermophilic strains were analyzed for exopolysaccharide production. The screening process revealed that a significant number of thermophilic microorganisms were able to produce biopolymers, and some of them also revealed interesting chemical compositions. We have identified four new polysaccharides from thermophilic marine bacteria, with complex primary structures and with different repetitive units: a galacto-mannane type from strain number 4004 and mannane type for the other strains. The thermophilic Bacillus thermantarcticus produces two exocellular polysaccharides (EPS 1, EPS 2) that give the colonies a typical mucous character. The exopolysaccharide fraction was produced with all substrates assayed, although a higher yield 400 mg liter(-1) was obtained with mannose as carbon and energy source. NMR spectra confirmed that EPS 1 was a heteropolysaccharide of which the repeating unit was constituted by four different alpha-D-mannoses and three different beta-D-glucoses. It seems to be close to some xantan polymers. EPS 2 was a mannan. Four different alpha-D-mannoses were found as the repeating unit. Production and chemical studies of biopolymers produced by halophilic archaea, Haloarcula species were also reported.

Production of exopolysaccharides from a thermophilic microorganism isolated from a marine hot spring in flegrean areas.

A thermophilic strain isolated from sea sand at Maronti, near Sant' Angelo (Ischia), is described. The organism grows well at an optimal temperature of 60 degrees C at pH 7.0. The thermophilic bacterium, named strain 4004, produces an exocellular polysaccharide (EPS) in yields of 90 mg/l. The EPS fraction was produced with all substrates tested, although a higher yield was obtained with sucrose or trehalose as sole carbon source. During growth, the EPS content was proportional to the biomass. Three fractions (EPS1, EPS2, EPS3) were obtained after purification. Quantitative monosaccharide analysis of the EPSs revealed the presence of mannose:glucose:galactose in a relative ratio of 0.5:1.0:0.3 in EPS1, mannose:glucose:galactose in a relative ratio of 1.0:0.3:trace in EPS2, and galactose:mannose:glucosamine:arabinose in a relative ratio of 1.0:0.8:0.4:0.2 in EPS3. The average molecular mass of EPS3 was determined to be 1x10(6) Da. From comparison of the chemical shift values in (1)H and (13)C spectra, we conclude that EPS3 presents a pentasaccharide repeating unit.

Purification and characterization of thermostable xylose(glucose) isomerase from Bacillus thermoantarcticus.

Xylose isomerase produced by Bacillus thermoantarcticus was purified 73-fold to homogeneity and its biochemical properties were determined. It was a homotetramer with a native molecular mass of 200 kDa and a subunit molecular mass of 47 kDa, with an isoelectric point at 4.8. The enzyme had a K(m) of 33 mM for xylose and also accepted D-glucose as substrate. Arrhenius plots of the enzyme activity of xylose isomerase were linear up to a temperature of 85 degrees C. Its optimum pH was around 7.0, and it had 80% of its maximum activity at pH 6.0. This enzyme required divalent cations for its activity and thermal stability. Mn(2+), Co(2+) or Mg(2+) were of comparable efficiency for xylose isomerase reaction, while Mg(2+) was necessary for glucose isomerase reaction.

Prevention of neointimal proliferation by immunosuppression in synthetic vascular grafts.

OBJECTIVE: Immunosuppressive agents have been proposed to reduce neointimal hyperplasia in synthetic vascular grafts. Thus, the purpose of the present study was to evaluate the safety and efficacy of rapamycins (systemic vs. local vs. oral administration) and mycophenolate mofetil (MMF) to reduce intimal hyperplasia in infrarenal synthetic vascular grafts of the rat. METHODS: Fifty-four Wistar rats (250 g) completed the study after a synthetic vascular graft (ePTFE, Gore-tex, 2 mm diameter, 10 mm length) was implanted end-to-end in the infrarenal aorta. The animals were divided into three groups: group 1 consisted of 12 control animals, group 2 consisted of 37 rats receiving rapamycins, either per os (RAD, 1.5 or 3 mg/kg), intraperitoneally (RPM, 1.5 or 3 mg/kg) or locally (RPM soaking of the graft); and in group 3 (n=5), MMF (40 mg/kg) was administered orally. The animals were followed weekly with weight controls and signs of toxicity for 30 (n=37) and 60 (n=17) days, respectively. All animals were sacrificed and underwent histological examination at completion of the study. RESULTS: All animals survived in groups 1 and 3, but five died in group 2. The weight gain was normal in all groups, except for the subgroup 2a receiving high dose rapamycins orally. All rats in group 3 suffered from diarrhea, whereas animals receiving high dose rapamycins showed toxic signs (hair loss, wound healing problems). Histological examination showed a significant increase in intimal hyperplasia in group 1 (0.03+/-0.01 and 0.14+/-0.05 microm after 30 and 60 days, respectively; P<0.01). Rapamycins in either application or dosage had no significant effect on intimal hyperplasia. CONCLUSIONS: Local or systemic administration of rapamycins has no effect on intimal hyperplasia in synthetic vascular grafts. In contrast, toxic signs with weight loss were observed in animals treated with high dose rapamycins, but not in those treated with MMF. Thus, in the rat model, immunosuppression with rapamycins or MMF cannot be recommended for the prevention of intimal hyperplasia in the synthetic vascular graft model.

Accumulation of osmoprotectants and lipid pattern modulation in response to growth conditions by Halomonas pantelleriense.

The effects of salinity, growth temperature, pH and composition of the medium on the accumulation of intracellular organic solutes, by nuclear magnetic resonance spectroscopy (NMR) in Halomonas pantelleriense were examined. The modulation of lipid pattern in different growth conditions was also reported. H. pantelleriense accumulated glycine betaine, ectoine, hydroxyectoine and glutamate. The type of osmoprotectant and the relative proportion depended on growth conditions. The main lipids identified by NMR studies were 1,2 diacylglycero-3-phosphorylethanolamine (PEA), 1,2 diacylglycero-3-phosphoryl-glycerol (PG) and cardiolipin, (DPG). The predominant fatty acids were C16:0 and C18:1, minor fatty acids were C16:1 and C18:0. The relative percentage of polar lipids and fatty acids were affected by growth conditions.

A thermophilic Bacillus isolated from an Eolian shallow hydrothermal vent, able to produce exopolysaccharides.

A thermophilic aerobic microorganism, able to produce two exocellular polysaccharides (EPS1 and EPS2), was isolated from a shallow hydrothermal vent at Vulcano island (Eolian Islands, Italy). EPS1 and EPS2 were based on mannose and glucose although in a different ratio. EPS2 possessed a trisaccharide repeating unit with a manno-pyranoside configuration. New isolate phenotype was studied by physiological and morphological observations, including biochemical and antimicrobial susceptibility tests (134). Previous analyses carried out on 87 field isolates and 8 thermophilic reference bacilli displayed low phenotypic similarity level (S(SM) = 65%) with Bacillus thermodenitrificans DSM 465. Optimal growth occurs at 65 degrees C and pH 7.0. Oxidase and catalase are negative. The guanine-plus-cytosine (G+C) content of DNA is 52.7%. Genotypic investigations demonstrated the diversity of the isolate with fifteen selected thermophilic Bacillus spp. when we compared the restriction patterns of the amplified 16S rDNA. The membrane lipids are based on fatty acids mainly belonging to the iso-family.

Comparison of the ADP-ribosylating thermozyme from Sulfolobus solfataricus and the mesophilic poly(ADP-ribose) polymerases.

The poly(ADP-ribose) polymerase-like thermozyme purified from Sulfolobus solfataricus was characterised with respect to some physico-chemical properties. The archaeal protein exhibited a scarce electrophoretic mobility at both pH 2.9 and pH 7.5. Determination of the isoelectric point (pI=7.0-7.2) allowed us to understand the reason for the limited migration at pH 7.5, while amino acid composition analysis showed a moderate content of basic residues, which reduced mobility at pH 2.9. With respect to the charge, the archaeal enzyme behaved differently from the eukaryotic thermolabile poly(ADP-ribose) polymerase, described as a basic protein (pI=9.5). Well known inhibitors of the mesophilic polymerase like Zn(2+), nicotinamide and 3-aminobenzamide exerted a smaller effect on the enzyme from S. solfataricus, reducing the activity by at most 50%. Mg(2+) was a positive effector, although in a dose-dependent manner. It influenced the fluorescence spectrum of the archaeal protein, whereas NaCl had no effect.

Lipid profile: a useful chemotaxonomic marker for classification of a new cyanobacterium in Spirulina genus.

The morphological, physiological and genetic characteristics of an isolate cyanobacterium from hard sand of the lake Venere in the Pantelleria island (Italy) were described. The isolate with a small-size coiled helix shape, growing optimally at pH 9.2-9.5 at 30 degrees C under continuous illumination and aeration, possessed a 61.5 mol% of Guanine + Cytosine content of DNA. The lipid profile showed the presence of mono-, di-glycosyl, sulphoquinovolosyl and phosphatidyl (MGDG, DGDG, SQDG and PG). The fatty acid profile was also studied, characterized by the absence of gamma-linolenic acid and the presence of saturated and monounsaturated C16 and C18. The latter was also present as a dienoic component. The fatty acid composition was affected by growth temperature by increasing the degree of desaturation at a lower temperature and the biosynthesis of shorter acyl chains. The effects of growth conditions other than temperature, physical, nutritional and chemical on lipid composition were also studied. The overall features of the cyanobacterium isolated from Pantelleria clustered it into Spirulina genus.

Purification of the ADP-ribosylating enzyme from S. solfataricus by SDS-polyacrylamide gel electrophoresis and electroelution.

The ADPribosylating enzyme from the thermophilic archaeon S. solfataricus was purified by a simple procedure which included preparative electrophoresis on a 0.1% SDS- polyacrylamide gel. The gel slice containing the enzymatic protein was cut out and the enzyme was solubilized by electroelution. The pure enzyme was obtained by chromatography of the electroeluted sample on a DNA-Sepharose column. The purified enzyme retained both its full activity and the structuring ability as a function of temperature increase.

Identification and characterization of a recombinant metallothionein protein from a marine alga, Fucus vesiculosus.

A cDNA library was constructed from macroalgae adapted to prolonged elevated environmental copper levels. To investigate the possible existence of a metallothionein (MT) gene, the library was screened with degenerate probes designed using plant MT cysteine-rich motifs. A gene was identified (1229 bp) with a putative open reading frame (204 bp) encoding a 67-amino-acid protein exhibiting several characteristic features of MT proteins, including 16 cysteine residues (24%) and only one aromatic residue. Although the protein sequence showed high identity with plant and invertebrate MTs, it contained a unique 'linker' region (14 amino acid residues) between the two putative metal-binding domains which contained no cysteine residues. This extended linker is larger than the tripeptide found in archetypal vertebrate MTs, but does not conform either with the 40-amino-acid linkers commonly found in plant MT sequences. An S-peptide Fucus MT fusion protein expressed in Escherichia coli exhibited a relative molecular mass of approximately 14 kDa. The recombinant fusion bound seven Cd ions, of which 50% were dissociated at pH 4.1. Under anaerobic conditions, the Cd ions were displaced by Cu(I), which associated with the protein at a ratio of 13:1. Laboratory exposure of F. vesiculosus to elevated copper resulted in induction of the MT gene. Thus this paper describes, for the first time, an MT gene identified from macroalgae which is induced by copper exposure and whose encoded protein product binds cadmium and copper.

Assessment of cardiac rejection by MR-imaging and MR-spectroscopy.

BACKGROUND: Detection of cardiac rejection is a major problem in cardiac transplantation. The gold standard is, and remains, endomyocardial biopsy. PURPOSE: Evaluation of MR-imaging and MR-spectroscopy for detection of cardiac rejection. METHODS: Orthotopic cardiac transplantation (HTX) was performed in 13 pigs (body weight 30 kg). All animals obtained immunosuppressive (triple) therapy for 1 week after the operation. Thereafter immunosuppression was stopped to induce cardiac rejection. MRI and MRS (1.5 Tesla General Electrics Signa) were performed pre- and post-operatively on days 10, 17, 24 and 31. The degree of rejection was determined post-operatively using endomyocardial biopsy (Texas grading score). RESULTS: (1) MR-imaging: LV function remained unchanged after HTX. LV mass increased (+42%; P < 0.05) with cardiac rejection. (2) MR-spectroscopy: a marked reduction in the ratio of phosphocreatine and adenosine triphosphate, respectively, to inorganic phosphate was observed in the rejecting hearts. (3) Histologic grading confirmed cardiac rejection after stopping immunosuppression. The Texas score was 5.7+/-0.8 at autopsy. CONCLUSIONS: MR-imaging and MR-spectroscopy allow the detection of changes associated with cardiac rejection. Both techniques are correlated with histologic rejection. However, endomyocardial biopsy remains the gold standard for reliable detection of cardiac rejection.

Purification and biochemical characterization of a poly(ADP-ribose) polymerase-like enzyme from the thermophilic archaeon Sulfolobus solfataricus.

A poly(ADP-ribose) polymerase-like enzyme, detected in a crude homogenate from Sulfolobus solfataricus by means of activity and immunoblot analyses, was purified to electrophoretic homogeneity by a rapid procedure including two sequential affinity chromatographies, on NAD+-agarose and DNA-Sepharose. The latter column selected specifically the poly(ADP-ribosyl)ating enzyme with a 17% recovery of enzymic activity and a purification of more than 15000-fold. The molecular mass (54-55 kDa) assessed by SDS/PAGE and immunoblot was definitely lower than that determined for the corresponding eukaryotic protein. The enzyme was proved to be thermophilic, with a temperature optimum of approx. 80 degreesC, and thermostable, with a half-life of 204 min at 80 degreesC, in good agreement with the requirements of a thermozyme. It displayed a Km towards NAD+ of 154+/-50 microM; in the pH range 6.5-10.0 the activity values were similar, not showing a real optimum pH. The enzyme was able to bind homologous DNA, as evidenced by the ethidium bromide displacement assay. The product of the ADP-ribosylating reaction co-migrated with the short oligomers of ADP-ribose (less than 6 residues) from a eukaryotic source. Reverse-phase HPLC analysis of the products, after digestion with phosphodiesterase I, gave an elution profile reproducing that obtained by the enzymic digestion of the rat testis poly(ADP-ribose). These results strongly suggest that the activities of the purified enzyme include the elongation step.

ADPribosylation reaction by free ADPribose in Sulfolobus solfataricus, a thermophilic archaeon.

In the archaeon Sulfolobus solfataricus, protein ADPribosylation by free ADPribose was demonstrated by testing both [adenine-14C(U)]ADPR and [adenine-14C(U)]NAD as substrates. The occurrence of this process was shown by using specific experimental conditions. Increasing the incubation time and lowering the pH of the reaction mixture enhanced the protein glycation by free ADPribose. At pH 7.5 and 10 min incubation, the incorporation of free ADPribose into proteins was highly reduced. Under these conditions, the autoradiographic pattern showed that, among the targets of ADPribose electrophoresed after incubation with 32P-NAD, the proteins modified by free 32P-ADPribose mostly corresponded to high molecular mass components. Among the compounds known to inhibit the eukaryotic poly-ADPribose polymerase, only ZnCl2 highly reduced the ADPribose incorporation from NAD into the ammonium sulphate precipitate. A 20% inhibition was measured in the presence of nicotinamide or 3-aminobenzamide. No inhibition was observed replacing NAD with ADPR as substrate.

Chemical Composition of Two Exopolysaccharides from Bacillus thermoantarcticus.

The thermophilic bacterium Bacillus thermoantarcticus produces two exocellular polysaccharides (EPS 1 and EPS 2), which can be obtained from the supernatant of liquid cultures by cold-ethanol precipitation, in yields as high as 400 mg liter(sup-1). The EPS fraction was produced with all substrates tested, although a higher yield was obtained with mannose as the carbon and energy source. The EPS content was proportional to the total biomass. On a weight basis, EPS 1 and EPS 2 represented about 27 and 71%, respectively, of the total carbohydrate fraction. EPS 1 is a sulfate heteropolysaccharide containing mannose and glucose in a relative molar proportion of 1.0 and 0.7, respectively. EPS 2 is a sulfate homopolysaccharide containing mannose as the major component. The absolute configurations of hexoses were shown to be d for both EPSs. Nuclear magnetic resonance spectra confirmed the presence of (alpha)-d-mannose and (beta)-d-glucose in EPS 1 and only (alpha)-d-mannose in EPS 2. In addition, (sup1)H nuclear magnetic resonance analysis and chemical analysis indicated the presence of pyruvic acid in EPS 2.