ABSTRACT
The 2021 FSIS Stabilization Guidelines for Meat and Poultry Products (Appendix B) Option 1.2 limits Phase 1 cooling from 48.8 to 26.7 °C in uncured meats to 1 h. However, this time restriction is impractical to achieve in large-diameter whole-muscle products. The objective of this study was to compare the inhibitory effect of commercial dry vinegars (DVs) and cultured sugar-vinegar blends (CSVs) on Clostridium perfringens and Bacillus cereus in uncured beef and poultry products during extended cooling. Treatments (beef: 72-73% moisture, pH 6.2-6.3, 0.85-0.95% NaCl; turkey: 76-77% moisture, pH 6.5-6.7, 1.3-1.6% NaCl) included Controls without antimicrobials, and four DV and four CSV, each tested at 0.75 and 1.25%. Batches were inoculated with 2.5-log C. perfringens or B. cereus spores, vacuum-packaged, and cooked to 73 °C. Packages were cooled from 48.8 to 27 °C (Phase 1) in 3, 4, or 5 h; Phase 2 (27-12.8 °C) and Phase 3 (12.8-4 °C) were standardized for 5-h cooling each. Pathogens were enumerated on selective agar in triplicate samples assayed at precook, postcook, and at the end of Phase 1, 2, and 3 cooling. Experiments were conducted twice. B. cereus did not grow (<0.5-log increase) in any treatment when Phase 1 cooling was extended to 5 h. C. perfringens grew rapidly (2.5 to >4.5 log) in Control treatments when Phase 1 cooling was extended to ≥3 h. All 1.25% DV ingredients limited C. perfringens growth to ≤1-log when Phase 1 cooling was extended to 3 h but supported a >1-log increase when Phase 1 cooling was extended to 5 h. All 1.25% CSV inhibited growth under 3-h Phase 1 cooling; 1.25% CSV-A and ≥0.75% CSV-D inhibited growth in turkey during 5-h Phase 1 cooling, but inhibition with 1.25% CSV-C was inconsistent in beef. This study revealed that formulating uncured meats with 1.25% DV or certain CSV can extend Phase 1 cooling to 3 h. Although all ingredients inhibited growth when used at 0.75% or greater compared to a control, greater variability of inhibition was observed among CSV than for DV.
Subject(s)
Acetic Acid , Bacillus cereus , Clostridium perfringens , Food Microbiology , Clostridium perfringens/drug effects , Animals , Bacillus cereus/drug effects , Cattle , Acetic Acid/pharmacology , Colony Count, Microbial , Meat Products/microbiology , Poultry , Poultry Products/microbiology , Food Preservation/methodsABSTRACT
Cooked, uncured meat products packaged under reduced oxygen packaging conditions require the control of anaerobic and facultative anaerobic pathogens if they are held at temperatures greater than 3°C at retail or consumer level. The objective of this study was to determine the inhibition of Listeria monocytogenes and Clostridium botulinum in cooked, uncured shredded turkey and pork formulated with synthetic or clean-label antimicrobials. Treatments of shredded meat products were prepared with or without antimicrobials using turkey thigh or breast that were cooked to 85°C, shredded, and chilled before inoculation with the target pathogen. L. monocytogenes inoculated samples were stored at 7.2°C, whereas C. botulinum samples were stored at 12.8°C; triplicate samples were assayed every 2 weeks. In the first set of experiments, L. monocytogenes populations increased 2 to 3 logs within 2 weeks of storage at 7.2°C in both meat control treatments without antimicrobials and in pork with 4% lactate-diacetate blend (LD). A 1-log increase was observed in turkey with 4% LD and Pork with 2% cultured dextrose-vinegar-rosemary (CDVR) under the same storage conditions; a 1-log increase was observed in turkey with CDVR at 4 weeks. The second set of experiments tested the effect of pH reduction (to less than 5.5 by the addition of 0.5% citric acid) in combination with 2% CDVR when added to the brine precook or postcook during shredding. Populations of L. monocytogenes increased 4-log within 2 and 4 weeks at 7.2°C for the control turkey and pork formulations, respectively. No growth was observed in 12 weeks for any antimicrobial CDVR-CA treatments regardless of how antimicrobial was added. Similarly, botulinum toxin was detected in both control treatments at week 2 at 12.8°C, but no toxicity was observed in either antimicrobial treatment through 12 weeks. These data suggest that a combination of 2% cultured dextrose-vinegar-rosemary extract plus 0.5% citric acid to reduce pH inhibits the growth of L. monocytogenes and toxin production of C. botulinum in uncured shredded turkey and pork products stored under mild temperature abuse conditions for up to 12 weeks in reduced oxygen packaging.
Subject(s)
Clostridium botulinum , Colony Count, Microbial , Food Microbiology , Listeria monocytogenes , Oxygen , Turkeys , Listeria monocytogenes/drug effects , Animals , Clostridium botulinum/drug effects , Swine , Humans , Food Packaging/methods , Meat Products/microbiology , Food Preservation/methods , Food Contamination/analysis , TemperatureABSTRACT
Botulinum neurotoxins are a varied group of protein toxins that share similar structures and modes of activity. They include at least seven serotypes and over forty subtypes that are produced by seven different clostridial species. These bacterial species are not limited strictly to BoNT-producers as neuro-toxigenic and non-neuro-toxigenic members have been identified within each species. The nomenclature surrounding these toxins and associated bacteria has been evolving as new isolations and discoveries have arisen, resulting in challenges in diagnostic reporting, epidemiology and food safety studies, and in the application of therapeutic products. An understanding of the intricacies regarding the nomenclature of BoNTs and BoNT-producing clostridia is crucial for communication that allows for accurate reporting of information that is pertinent to each situation.
Subject(s)
Botulinum Toxins , Clostridium , Firmicutes , Food Safety , SerogroupABSTRACT
Cooking temperature of poultry meat is typically inadequate to inactivate the heat resistant spores of Clostridium botulinum. The purpose of this study is to develop a predictive model for C. botulinum during cooling of cooked ground chicken. Cooked chicken was inoculated with a cocktail of five strains of proteolytic C. botulinum type A and five strains of proteolytic C. botulinum type B to yield a final spore concentration of approximately 2 log CFU/g. The growth of C. botulinum was determined at constant temperatures from 10 to 46 °C. Dynamic temperature experiments were performed with continued cooling from 54.4 to 4.4 °C or 7.2 °C in mono- or bi-phasic cooling profiles, respectively. The Baranyi primary model was used to fit growth data and the modified Ratkowsky secondary model was used to fit growth rates with respect to temperature. The primary models fitted the growth data well (R2 values ranging from 0.811 to 0.988). The R2 and root mean square error (RMSE) of the modified Ratkowsky secondary model were 0.95 and 0.06, respectively. Out of 11 prediction error values calculated in this study, ten were within the limit of acceptable prediction zone (-1.0 to 0.5), indicating a good fit of the model. The predictive model will assist institutional food service operations in determining the safety of cooked ground chicken subjected to different cooling periods.
Subject(s)
Clostridium botulinum , Meat Products , Animals , Chickens , Colony Count, Microbial , Cooking , Food Microbiology , Models, Biological , Spores, BacterialABSTRACT
At least 40 toxin subtypes of botulinum neurotoxins (BoNTs), a heterogenous group of bacterial proteins, are produced by seven different clostridial species. A key factor that drives the diversity of neurotoxigenic clostridia is the association of bont gene clusters with various genomic locations including plasmids, phages and the chromosome. Analysis of Clostridium sporogenes BoNT/B1 strain CDC 1632, C. argentinense BoNT/G strain CDC 2741, and Clostridium parabotulinum BoNT/B1 strain DFPST0006 genomes revealed bont gene clusters within plasmid-like sequences within the chromosome or nested in large contigs, with no evidence of extrachromosomal elements. A nucleotide sequence (255,474 bp) identified in CDC 1632 shared 99.5% identity (88% coverage) with bont/B1-containing plasmid pNPD7 of C. sporogenes CDC 67071; CDC 2741 contig AYSO01000020 (1.1 MB) contained a ~140 kb region which shared 99.99% identity (100% coverage) with plasmid pRSJ17_1 of C. argentinense BoNT/G strain 89G; and DFPST0006 contig JACBDK0100002 (573 kb) contained a region that shared 100% identity (99%) coverage with the bont/B1-containing plasmid pCLD of C. parabotulinum Okra. This is the first report of full-length plasmid DNA-carrying complete neurotoxin gene clusters integrated in three distinct neurotoxigenic species: C. parabotulinum, C. sporogenes and C. argentinense.
Subject(s)
Botulinum Toxins/genetics , Clostridium/genetics , Botulinum Toxins, Type A , Chromosomes , Clostridium botulinum/genetics , DNA, Bacterial/genetics , Multigene Family , Neurotoxins/genetics , Phylogeny , PlasmidsABSTRACT
Unpasteurized milk is used to produce aged artisanal cheeses, which presents a safety concern due to possible contamination with foodborne pathogens, especially Listeria monocytogenes. The objective of this study was to examine the composition of the bacterial community in unpasteurized milk used to prepare Gouda cheese artificially contaminated with L. monocytogenes (~1 log CFU/ml) and assess the community dynamics and their potential interaction with L. monocytogenes during a 90-day ripening period using targeted 16S rRNA sequencing. The diversity of bacterial taxa in three batches of unpasteurized milk was not significantly different, and the microbiomes were dominated by species of Lactococcus, Streptomyces, Staphylococcus, and Pseudomonas. The highest relative abundances were observed for Pseudomonas fluorescens (31.84-78.80%) and unidentified operational taxonomic units (OTUs) of Pseudomonas (7.56-45.27%). After manufacture, both with and without L. monocytogenes-contaminated unpasteurized milk, Gouda cheese was dominated by starter culture bacteria (including Lactococcus lactis subsp. cremoris, lactis, lactis bv. diacetylactis, and Streptococcus thermophilus), in addition to unassigned members in the taxa L. lactis and Streptococcus. During ripening there was an overall decrease in L. lactis abundance and an increase in the number of taxa with relative abundances >0.1%. After 90-day ripening, a total of 82 and 81 taxa were identified in the Gouda cheese with and without L. monocytogenes, respectively. Of the identified taxa after ripening, 31 (Gouda cheese with L. monocytogenes) and 56 (Gouda cheese without L. monocytogenes) taxa had relative abundances >0.1%; 31 were shared between the two types of Gouda cheese, and 25 were unique to the Gouda cheese without added L. monocytogenes. No unique taxa were identified in the Gouda cheese with the added L. monocytogenes. This study provides information on the dynamics of the bacterial community in Gouda cheese during ripening, both with and without the addition of L. monocytogenes.
ABSTRACT
The microbial safety concern associated with thermally processed extended shelf life (ESL) refrigerated foods is based on adequate elimination of spore-forming pathogens such as nonproteolytic Clostridium botulinum types B, E, and F. These pathogens are traditionally regarded as targets for validation of thermally processed ESL foods. However, their use for research is restricted due to their designation as select agents. In this study, the thermal resistances of spores of 10 nonproteolytic C. botulinum types B and F and seven psychrotrophic Bacillus cereus strains were evaluated in ACES (N-(2-acetamido)-2-aminoethanesulfonic acid) buffer (0.05 M, pH 7.00) and compared to determine whether any of the B. cereus strains could serve as a nonselect agent for establishing thermal processes for ESL refrigerated foods. Thermal decimal reduction times (DT-values) of both nonproteolytic C. botulinum types B and F and psychrotrophic B. cereus strains decreased as process temperature increased from 80 to 91°C, and the highest values were obtained at 80°C. All psychrotrophic B. cereus strains tested were more thermally resistant than nonproteolytic C. botulinum types B and F. DT-values of nonproteolytic C. botulinum types B and F decreased to <1.0 min at 87°C, whereas all psychrotrophic B. cereus strains had higher DT-values (i.e., 52.35 to 133.69 min) at the same temperature. Among all psychrotrophic B. cereus strains tested, BC-6A16 had the highest DT-values at any given temperature. The DT-values indicated that the psychrotrophic B. cereus strains were more thermally resistant than the nonproteolytic C. botulinum strains and therefore may be potential target pathogens for thermal process validation of ESL refrigerated foods. However, further comparative challenge studies are needed with a model food system or an ESL refrigerated food to confirm these results.
Subject(s)
Bacillus cereus , Clostridium botulinum , Food Microbiology , Hot Temperature , Spores, BacterialABSTRACT
Botulinum neurotoxins (BoNTs) are potent toxins produced by Clostridium bacteria that are responsible for the illness botulism and are listed as bioterrorism agents. BoNT serotype E (BoNT/E) is one of four BoNT serotypes that cause human botulism and is the second most frequent cause of foodborne botulism. Rapid detection and discrimination of BoNT serotypes implicated in human disease are critical for ensuring timely treatment of patients and identifying sources of toxins, but there have been few reported detection methods for BoNT/E and even fewer methods usable for BoNT serotyping. We report a nanobiosensor based on Förster resonance energy transfer (FRET) between semiconductor nanocrystals (quantum dots, QDs) and dark quencher-labeled peptide probes to detect biologically active BoNT/E in aqueous media. The peptide probes contain a specific cleavage site for active BoNT/E. QD photoluminescence, which changes intensity due to FRET when the peptide probe is cleaved, was used to indicate toxin presence and quantity. The detection of a BoNT/E light chain (LcE) and holotoxin was observed within 3 h. The limits of detection were 0.02 and 2 ng/mL for LcE and holotoxin, respectively. The nanobiosensor shows good specificity toward the target in tests with nontarget BoNT serotypes. The high sensitivity, simple operation, short detection time, and ability to be used in parallel with probes developed for other BoNT serotypes indicate that the nanobiosensor will be useful for rapid BoNT/E detection and serotype discrimination in food analysis.
Subject(s)
Botulinum Toxins , Botulism , Quantum Dots , Fluorescence Resonance Energy Transfer , Humans , SerogroupABSTRACT
ABSTRACT: Cheeses made with unpasteurized milk are a safety concern due to possible contamination with foodborne pathogens. Listeria monocytogenes and Escherichia coli O157:H7 have been implicated in several outbreaks and recalls linked to Gouda cheese made with unpasteurized milk. The U.S. Food and Drug Administration Code of Federal Regulations requires cheeses made with unpasteurized milk to be aged at a minimum of 1.7°C for at least 60 days before entering interstate commerce. The goal of this study was (i) to assess the population dynamics of L. monocytogenes and E. coli O157:H7 during aging of Gouda cheese when the pathogens were inoculated into the unpasteurized milk used for manufacture and (ii) to compare the native microbial populations throughout manufacture and aging. Unpasteurized milk was inoculated with L. monocytogenes at 1 or 3 log CFU/mL or with E. coli O157:H7 at 1 log CFU/mL, and Gouda cheese was manufactured in laboratory-scale or pilot plant-scale settings. Cheeses were stored at 10°C for at least 90 days, and some cheeses were stored up to 163 days. Initial native microflora populations in unpasteurized milk did not differ significantly for laboratory-scale or pilot plant-scale trials, and population dynamics trended similarly throughout cheese manufacture and aging. During manufacture, approximately 81% of the total L. monocytogenes and E. coli O157:H7 populations was found in the curd samples. At an inoculation level of 1 log CFU/mL, L. monocytogenes survived in the cheese beyond 60 days in four of five trials. In contrast, E. coli O157:H7 was detected beyond 60 days in only one trial. At the higher 3-log inoculation level, the population of L. monocytogenes increased significantly from 3.96 ± 0.07 log CFU/g at the beginning of aging to 6.00 ± 0.73 log CFU/g after 150 days, corresponding to a growth rate of 0.04 ± 0.02 log CFU/g/day. The types of native microflora assessed included Enterobacteriaceae, lactic acid bacteria, mesophilic bacteria, and yeasts and molds. Generally, lactic acid and mesophilic bacterial populations remained consistent at approximately 8 to 9 log CFU/g during aging, whereas yeast and mold populations steadily increased. The data from this study will contribute to knowledge about survival of these pathogens during Gouda cheese production and will help researchers assess the risks of illness from consumption of Gouda cheese made with unpasteurized milk.
ABSTRACT
BACKGROUND: The microbiome of cheese is diverse, even within a variety. The metagenomics of cheese is dependent on a vast array of biotic and abiotic factors. Biotic factors include the population of microbiota and their resulting cellular metabolism. Abiotic factors, including the pH, water activity, fat, salt, and moisture content of the cheese matrix, as well as environmental conditions (temperature, humidity, and location of aging), influence the biotic factors. This study assessed the metagenomics of commercial Gouda cheese prepared using pasteurized or unpasteurized cow milk or pasteurized goat milk via 16S rDNA sequencing. RESULTS: Results were analyzed and compared based on milk pasteurization and source, spatial variability (core, outer, and under the rind), and length of aging (2-4 up to 12-18 months). The dominant organisms in the Gouda cheeses, based on percentage of sequence reads identified at the family or genus levels, were Bacillaceae, Lactococcus, Lactobacillus, Streptococcus, and Staphylococcus. More genus- or family-level (e.g. Bacillaceae) identifications were observed in the Gouda cheeses prepared with unpasteurized cow milk (120) compared with those prepared with pasteurized cow milk (92). When assessing influence of spatial variability on the metagenomics of the cheese, more pronounced differences in bacterial genera were observed in the samples taken under the rind; Brachybacterium, Pseudoalteromonas, Yersinia, Klebsiella, and Weissella were only detected in these samples. Lastly, the aging length of the cheese greatly influenced the number of organisms observed. Twenty-seven additional genus-level identifications were observed in Gouda cheese aged for 12-18 months compared with cheese only aged 2-4 months. CONCLUSIONS: Collectively, the results of this study are important in determining the typical microbiota associated with Gouda cheese and how the microbiome plays a role in safety and quality.
Subject(s)
Bacteria/genetics , Bacteria/isolation & purification , Cheese/microbiology , DNA, Bacterial/genetics , Milk/chemistry , RNA, Ribosomal, 16S/genetics , Animals , Bacteria/classification , Bacteria/metabolism , Cattle , Cheese/analysis , Food Microbiology , Goats , Metagenomics , Milk/microbiology , PasteurizationABSTRACT
Clostridium botulinum is a strictly anaerobic, Gram-positive, spore-forming bacterium that produces botulinum neurotoxin, a potent and deadly proteinaceous exotoxin. Clostridium botulinum strain CFSAN064329 (62A) produces an A1 serotype/subtype botulinum neurotoxin and is frequently utilized in food challenge and detection studies. We report here the closed genome sequence of Clostridium botulinum strain CFSAN064329 (62A).
ABSTRACT
The genome of Listeria monocytogenes strain DFPST0073, isolated from imported fresh Mexican soft cheese in 2003, was sequenced using the Illumina MiSeq platform. Reads were assembled using SPAdes, and genome annotation was performed using the NCBI Prokaryotic Genome Annotation Pipeline.
ABSTRACT
The impact of high pressure processing on the inactivation of spores of nonproteolytic Clostridium botulinum is important in extended shelf life chilled low-acid foods. The three most resistant C. botulinum strains (Ham-B, Kap 9-B, and 610-F) were selected for comparison of their thermal and pressure-assisted thermal resistance after screening 17 nonproteolytic C. botulinum strains (8 type B, 7 type E, and 2 type F). Spores of strains Ham-B, Kap 9-B, and 610-F were prepared using a biphasic media method, diluted in N-(2-acetamido)-2-aminoethanesulfonic acid (ACES) buffer (0.05 M, pH 7.00) to 105 to 106 CFU/mL, placed into a modified sterile transfer pipette, heat sealed, and subjected to a combination of high pressures (600 to 750 MPa) and high temperatures (80 to 91°C) using laboratory and pilot-scale pressure test systems. Diluted spores from the same crops were placed in nuclear magnetic resonance tubes, which were heat sealed, and subjected to 80 to 91°C in a Fluke 7321 high precision bath with Duratheram S oil as the heat transfer fluid. After incubation for 3 months, survivors in both studies were determined by the five-tube most-probable-number method using Trypticase-peptone-glucose-yeast extract broth. The highest (>5.0) log reductions in spore counts for Ham-B, Kap 9-B, and 610-F occurred at the highest temperature and pressure combination tested (91°C and 750 MPa). Thermal D-values of Ham-B, Kap 9-B, and 610-F decreased as the process temperature increased from 80 to 87°C, decreasing to <1.0 min at 87°C for these strains. Pressure-assisted thermal D-values of Ham-B, Kap 9-B, and 610-F decreased as the process temperature increased from 80 to 91°C with any pressure combination and decreased to <1.0 min as the pressure increased from 600 to 750 MPa at 91°C. Based on the pressure-assisted thermal D-values, pressure exerted a more protective effect on spores of Ham-B, Kap 9-B, and 610-F when processed at 83 to 91°C combined with pressures of 600 to 700 MPa when compared with thermal treatment only. No protective effect was observed when the spores of Ham-B, Kap9-B, and 610-F were treated at lower temperatures (80 to 83°C) in combination with 750 MPa. However, at higher temperatures (87 to 91°C) in combination with 750 MPa, a protective effect was seen for Ham-B, Kap9-B, and 610-F spores based on the calculated pressure-assisted thermal D-values.
Subject(s)
Clostridium botulinum/physiology , Hot Temperature , Pressure , Spores, Bacterial/physiologyABSTRACT
Botulinum neurotoxin (BoNT) is the most potent toxin known. The ingestion of food contaminated with biologically active BoNT causes foodborne botulism, which can lead to respiratory paralysis, coma, and death after ingestion of as little as 70 µg for a 70 kg human. Because of its lethality and challenges associated with current detection methods, there is an urgent need for highly sensitive rapid screening techniques capable of detecting biologically active BoNT. Here, we describe a Förster resonance energy transfer-based nanobiosensor that uses quantum dots (QDs) and two specific quencher-labeled peptide probes to detect and differentiate two biologically active forms of BoNT, serotypes A and B, which were responsible for 80% of human foodborne botulism cases in the U.S. from 2012 to 2015. Each peptide probe contains an enzymatic cleavage site specific to only one serotype. QDs were selected based on the spectral overlap with the quenchers. In the presence of the target BoNT serotype, the peptide probe is cleaved and the quenching of QD photoluminescence (PL) is reduced, giving a signal that is easily detected by a PL spectrophotometer. This sensor performance was evaluated with light chains of BoNT/A and BoNT/B (LcA and LcB), catalytic domains of the respective serotypes. LcA and LcB were detected in 3 h with limits of detection of 0.2 and 2 ng/mL, respectively. The specificity of the sensor was evaluated, and no cross-reactivity from nontarget serotypes was observed with 2 h of incubation. Because each serotype-specific peptide is conjugated to a QD with a unique emission wavelength, multiple biologically active BoNT serotypes could be detected in one PL spectrum. The sensor was also shown to be responsive to BoNT/A and BoNT/B holotoxins. Good performance of this sensor implies its potential application as a rapid screening method for biologically active BoNT/A and BoNT/B in the laboratory and in the field.
Subject(s)
Quantum Dots , Botulinum Toxins, Type A , Botulism , Fluorescence Resonance Energy Transfer , Humans , Peptides , SerogroupABSTRACT
Clostridium sporogenes PA 3679 is a non-toxic endospore former that is widely used as a surrogate for Clostridium botulinum by the food processing industry to validate thermal processing strategies. PA 3679 produces spores of exceptionally high heat resistance without botulinum neurotoxins, permitting the use of PA 3679 in inoculated pack studies while ensuring the safety of food processing facilities. To identify genes associated with this heat resistance, the genomes of C. sporogenes PA 3679 isolates were compared to several other C. sporogenes strains. The most significant difference was the acquisition of a second spoVA operon, spoVA2, which is responsible for transport of dipicolinic acid into the spore core during sporulation. Interestingly, spoVA2 was also found in some C. botulinum species which phylogenetically cluster with PA 3679. Most other C. sporogenes strains examined both lack the spoVA2 locus and are phylogenetically distant within the group I Clostridium, adding to the understanding that C. sporogenes are dispersed C. botulinum strains which lack toxin genes. C. sporogenes strains are thus a very eclectic group, and few strains possess the characteristic heat resistance of PA 3679.
ABSTRACT
The purpose of this study was to determine the inactivation kinetics of the spores of the most resistant proteolytic Clostridium botulinum strains (Giorgio-A and 69-A, as determined from an earlier screening study) and of Clostridium sporogenes PA3679 and to compare the thermal and pressure-assisted thermal resistance of these spores. Spores of these strains were prepared using a biphasic medium method. C. sporogenes PA3679 spores were heat treated before spore preparation. Using laboratory-scale and pilot-scale pressure test systems, spores of Giorgio-A, 69-A, and PA3679 suspended in ACES [N-(2-acetamido)-2-aminoethanesulfonic acid] buffer (pH 7.0) were exposed to various combinations of temperature (93 to 121°C) and pressure (0.1 to 750 MPa) to determine their resistance. More than a 5-log reduction occurred after 3 min at 113°C for spores of Giorgio-A and 69-A and after 5 min at 117°C for spores of PA3679. A combination of high temperatures (93 to 121°C) and pressures yielded greater log reductions of spores of Giorgio-A, 69-A, and PA3679 compared with reduction obtained with high temperatures alone. No survivors from initial levels (>5.0 log CFU) of Giorgio-A and 69-A were detected when processed at a combination of high temperature (117 and 121°C) and high pressure (600 and 750 MPa) for <1 min in a pilot-scale pressure test system. Increasing pressure from 600 to 750 MPa at 117°C decreased the time from 2.7 to 1 min for a >4.5-log reduction of PA3679 spores. Thermal D-values of Giorgio-A, 69-A, and PA3679 spores decreased (i.e., 29.1 to 0.33 min for Giorgio-A, 40.5 to 0.27 min for 69-A, and 335.2 to 2.16 min for PA3679) as the temperature increased from 97 to 117°C. Pressure-assisted thermal D-values of Giorgio-A, 69-A, and PA3679 also decreased as temperature increased from 97 to 121°C at both pressures (600 and 750 MPa) (i.e., 17.19 to 0.15 min for Giorgio-A, 9.58 to 0.15 min for 69-A, and 12.93 to 0.33 min for PA3679 at 600 MPa). At higher temperatures (117 or 121°C), increasing pressure from 600 to 750 MPa had an effect on pressure-assisted thermal D-values of PA3679 (i.e., at 117°C, pressure-assisted thermal D-value decreased from 0.55 to 0.28 min as pressure increased from 600 to 750 MPa), but pressure had no effect on pressure-assisted thermal D-values of Giorgio-A and 69-A. When compared with Giorgio-A and 69-A, PA3679 had higher thermal and pressure-assisted thermal D-values. C. sporogenes PA3679 spores were generally more resistant to combinations of high pressure and high temperature than were the spores of the C. botulinum strains tested in this study.
Subject(s)
Clostridium/growth & development , Disinfection/methods , Spores, Bacterial/growth & development , Clostridium/chemistry , Clostridium botulinum type A/drug effects , Clostridium botulinum type A/growth & development , Disinfection/instrumentation , Food Microbiology , Hot Temperature , Kinetics , Pressure , Spores, Bacterial/chemistryABSTRACT
Clostridium sporogenes PA 3679 is a nonpathogenic, nontoxic model organism for proteolytic Clostridium botulinum used in the validation of conventional thermal food processes due to its ability to produce highly heat-resistant endospores. Because of its public safety importance, the uncertain taxonomic classification and genetic diversity of PA 3679 are concerns. Therefore, isolates of C. sporogenes PA 3679 were obtained from various sources and characterized using pulsed-field gel electrophoresis (PFGE) and whole-genome sequencing. The phylogenetic relatedness and genetic variability were assessed based on 16S rRNA gene sequencing and whole-genome single nucleotide polymorphism (SNP) analysis. All C. sporogenes PA 3679 isolates were categorized into two clades (clade I containing ATCC 7955 NCA3679 isolates 1961-2, 1990, and 2007 and clade II containing PA 3679 isolates NFL, UW, FDA, and Campbell and ATCC 7955 NCA3679 isolate 1961-4). The 16S maximum likelihood (ML) tree clustered both clades within proteolytic C. botulinum strains, with clade I forming a distinct cluster with other C. sporogenes non-PA 3679 strains. SNP analysis revealed that clade I isolates were more similar to the genomic reference PA 3679 (NCTC8594) genome (GenBank accession number AGAH00000000.1) than clade II isolates were. The genomic reference C. sporogenes PA 3679 (NCTC8594) genome and clade I C. sporogenes isolates were genetically distinct from those obtained from other sources (University of Wisconsin, National Food Laboratory, U.S. Food and Drug Administration, and Campbell's Soup Company). Thermal destruction studies revealed that clade I isolates were more sensitive to high temperature than clade II isolates were. Considering the widespread use of C. sporogenes PA 3679 and its genetic information in numerous studies, the accurate identification and genetic characterization of C. sporogenes PA 3679 are of critical importance.