Gamma radiation sensitivity of Enterobacter sakazakii in dehydrated powdered infant formula.

The observed Enterobacter sakazakii D10-values for tryptic soy broth and dehydrated powdered infant formula were 0.27 +/- 0.05 and 0.76 +/- 0.08 kGy, respectively. A decrease of approximately 3 log in the dehydrated powdered infant formula was obtained by irradiation with 3.0 kGy or rehydration with hot water at 80 degrees C. No recoverable bacteria were found in the powdered infant formula irradiated at 5.0 kGy and stored, either before or after rehydration. A radiation dose of up to 5.0 kGy had no marked effect on the sensory properties of the dehydrated powdered infant formula after rehydration and heating. Gamma radiation could potentially be used to inactivate E. sakazakii in dehydrated powdered infant formula; however, nutritional studies need to be conducted before the use of radiation can be recommended.

Studies on the development of functional powder from citrus peel.

The suitability of citrus peels, generated as a by-product of the juice industry, as a source of antioxidants was investigated. Citrus peel powder was prepared by lyophilizing 70% ethanol extract from citrus peels. Extraction was carried out at room temperature (20 degrees C) for 72 h. The extract was subjected to gamma-irradiation treatment (20 kGy). The aqueous solutions of citrus peel powder were examined for color characteristics and antioxidant potential in terms of 1,1-diphenyl-2-picrylhydrazyl (DPPH) radical scavenging, beta-carotene bleaching and nitrite scavenging activities. There were significant changes in Hunter color values due to irradiation. The a*- and b*-values decreased due to radiation treatment. DPPH radical scavenging, beta-carotene bleaching and nitrite scavenging activities were not affected by irradiation treatment. Nitrite scavenging activity was the highest in the extract at pH 1.2 followed by pH 4.2 and 6.0. These functional properties of the aqueous solution were found to be stable in heat treatment. It could significantly improve oxidative stability of lipids in fish meat system. Based on these results there may be opportunities to use citrus peel powder as a functional component in the food processing industry with gamma irradiation treatment improving its color characteristics without adversely influencing the functional properties.

Effect of gamma irradiation on the survival of pathogens in kwamegi, a traditional Korean semidried seafood.

Kwamegi (semidried raw Pacific saury) is traditional seafood available in Korea. It has water activity in the range of 0.90 to 0.95. Spoilage and the growth of most pathogenic bacteria is retarded because of low water activity, low temperature, and packaging. However, it is contaminated with bacteria of public health significance and poses a hazard to the consumer because it is consumed raw without any cooking. The effectiveness of these hurdles in preventing the growth of Staphylococcus aureus, Bacillus cereus, Salmonella Typhimurium, and Escherichia coli and the efficacy of irradiation treatment in eliminating these bacteria from kwamegi using inoculated pack studies was examined. Radiation sensitivity of S. aureus, B. cereus, Salmonella Typhimurium, and E. coli in kwamegi was investigated. D10-values of these organisms in kwamegi were 590 +/- 13.6, 640 +/- 14.9, 560 +/- 45.4, and 550 +/- 8.6 Gy, respectively. The growth of all four test organisms inoculated into these foods during 4 weeks of storage at an ambient winter temperature (ranging from -5 degrees C to +5 degrees C) was recorded. All four pathogens (inoculated at 10(6) CFU/g) were eliminated by irradiation at 4 kGy. These studies unequivocally demonstrate that irradiation, with a combination of low water activity and low temperature, results in microbiologically safe kwamegi.

Irradiation effects on embryotoxicity and oxidative properties of gossypol dissolved in methanol.

Gossypol dissolved in methanol (0.25 and 0.5 mg/ml) was gamma-irradiated at 0, 5, 10, and 20 kGy. The gossypol content was significantly reduced by irradiation in a dose-dependent manner. Ames test performed with nonirradiated and irradiated gossypol solutions was negative at the level of 0.1, 0.5, 1, 10, 50, and 100 microg gossypol/plate. At the gossypol concentration of 2.5 microg/ml, the blastocysts formation rate of mice embryo were decreased by a factor of two as compared with the control, but irradiation at 20 kGy increased the blastocysts formation, resulting in no difference from the control. Addition of gossypol to oil emulsion system or oil showed a prooxidative effect of lipids at the beginning stage by increasing 2-thiobarbituric acid reactive substances (TBARS) and peroxide value but irradiation of the gossypol solution decreased the oxidative changes significantly as compared with the nonirradiated one. Results indicated that irradiation decreased the gossypol concentration dissolved in methanol, resulting in a reduction of embryotoxicity in mice.

Effect of modified atmosphere packaging and irradiation in combination on content of nitrosamines in cooked pork sausage.

The effect of modified atmosphere packaging and irradiation in combination on nitrosodimethylamine (NDMA) and nitrosopyrrolidine (NPYR) levels in pork sausage was studied. Emulsion-type cooked pork sausage was manufactured and packaged in aerobic, CO2 (100%), N2 (100%), and CO2/N2 (25%/75%) environments, respectively, and irradiated at 0, 5, 10, and 20 kGy with gamma irradiation. The nitrosamine contents were significantly reduced by irradiation, and the reduction of nitrosamines was more extensive with modified atmosphere packaging than with aerobic packaging. The correlation coefficient between irradiation dose and nitrosamine content indicated that irradiation can reduce the levels of nitrosamines. The combination of irradiation and modified atmosphere packaging is effective in enhancing the chemical safety of sausage by reducing nitrosamines, if present, as well as enhancing the microbial safety of cooked pork sausage.

Effects of gamma radiation on the allergenic and antigenic properties of milk proteins.

This study was carried out to evaluate the application of food irradiation technology as a method for reducing milk allergies. Bovine alpha-casein (ACA) and beta-lactoglobulin (BLG) were used as milk proteins. Using milk-hypersensitive patients' immunoglobulin E (IgE) and rabbit IgGs individually produced to ACA and BLG, the changes of allergenicity and antigenicity of irradiated proteins were observed by competitive indirect enzyme-linked immunosorbent assay. Allergenicity and antigenicity of the irradiated proteins were changed with different slopes of the inhibition curves. The disappearance of the band on sodium dodecyl sulfate-polyacrylamide gel electrophoresis and increase of the turbidity showed that solubility of the proteins decreased by radiation, and this decrease might be caused by agglomeration of the proteins. These results indicated that epitopes on milk allergens were structurally altered by gamma irradiation.

Quality properties of sausage made with gamma-irradiated natural pork and lamb casing.

Quality properties in emulsion-type sausage stuffed into irradiated natural casing were studied. Fresh salted and semidried natural pork and lamb casing was washed and irradiated at 0, 3, and 5 kGy by gamma-ray and emulsion-type pork sausage (Brattella Weiss Wurst) was manufactured. The sausage was stored in a 4°C refrigerator. The numbers of total aerobic bacteria, Enterococcus and coliform bacteria in the irradiated natural casing or sausage prepared from irradiated casing were significantly decreased or eliminated compared to those of the nonirradiated control. The D(10) values of total aerobic bacteria of the pork and lamb casing were 0.87 and 0.92 kGy, respectively. The vacuum-packaged sausages made with irradiated casings had a higher 2-thiobarbituric acid reactive substances value than that of the nonirradiated controls only at 5-day with pork casing and at 10-day with lamb casing. The total working force for shear of the sausages was decreased in both irradiated casings but the sensory evaluation showed no difference. Therefore, the gamma irradiation was a useful technique to sanitize the natural pork and lamb casings and to extend shelf-life, primarily microbial quality, of the sausage made with natural casings.

Quality properties of pork sausage prepared with water-soluble chitosan oligomer.

Emulsion type sausage was prepared with the addition of a chitosan oligomer (molecular weight 5000, 0.2%) and compared to a control. Sausages were aerobic- or vacuum-packaged and stored in a 4°C refrigerator for 3 weeks. Difference of microbial growth between the sample with added chitosan oligomer or control was not observed (P>0.05). Lipid oxidation was lower in the sausage with chitosan oligomer at 3 weeks in aerobic packaging (P<0.05) than in the control sausage. The surface color of the sausage with chitosan oligomer had higher Hunter color L*- and b*-value. Hunter color a*-values were lower in the chitosan oligomer-added sausage and the a*-value increased during storage regardless of packaging (P<0.05). Sensory panels did not detect any difference in color, flavor, texture, and overall acceptance, and mechanical texture analysis also showed no difference. Therefore, the quality of the sausage with added chitosan oligomer (0.2%) was acceptable.

Detection of radiation-induced hydrocarbons and 2-alkylcyclobutanones in irradiated perilla seeds.

The method consists of the extraction of fat from perilla seeds, separation of hydrocarbons and 2-alkylcyclobutanones with florisil column chromatography, and identification of hydrocarbons and 2-alkylcyclobutanones by gas chromatography-mass spectroscopy (GC-MS). Concentrations of hydrocarbons and 2-alkylcyclobutanones increased with the irradiation dose. The major hydrocarbons in the irradiated perilla seeds were 8-heptadecene and 1,7-hexadecadiene from oleic acid and 6,9-heptadecadiene and 1,7,10-hexadecatriene from linoleic acid. One of the 2-alkylcyclobutanones, 2-(5'-tetradecenyl)cyclobutanone, was found in the highest concentration in the irradiated perilla seeds. Radiation-induced hydrocarbons in the perilla seeds were detected at doses of 0.5 kGy and higher, and radiation-induced 2-alkylcyclobutanones were detected at doses of 1 kGy and higher. These compounds were not detected in nonirradiated perilla seeds.

Effects of gamma radiation on sensory qualities, microbiological and chemical properties of salted and fermented squid.

The effects of gamma radiation on sensory quality, microbial population, and chemical properties of salted and fermented squid were investigated. Squid (Todarodes pacificus) was sliced, washed, and then salted with 5, 10, and 20% (wt/wt) sodium chloride. Salted squid was irradiated with dosages of 0, 2.5, 5.0, and 10 kGy of gamma radiation and fermented at 15 degrees C for 50 days. Proximate composition, salinity, water activity, sensory evaluation, and total microbiological populations were examined. Chemical analyses providing information on degree of fermentation, such as amino nitrogen (AN), volatile basic nitrogen (VBN), trimethylamine (TMA), and hypoxanthine (Hx) were also conducted. Irradiated squid was not different in proximate composition, salinity, and water activity from nonirradiated squid. Sensory evaluation scores, total bacteria populations, and pH values were variable depending on salt concentration and irradiation dose. During fermentation, AN, VBN, TMA, and Hx contents increased rapidly as the salt concentration and irradiation dose decreased. Specifically, these chemical compounds of salted and fermented squid prepared with 10% salt and 10 kGy of gamma radiation maintained the appropriate level of fermentation. The present results showed that the combination of low salt concentration (10%) and gamma radiation was effective in processing salted and fermented squid and extending its shelf life compared to control (20% of salt) without adding any food additives.

Effects of gamma radiation on the conformational and antigenic properties of a heat-stable major allergen in brown shrimp.

This study was performed to evaluate the application of food irradiation technology as a method for reducing shrimp allergy without adverse effects. Shrimp heat-stable protein (HSP) was isolated and gamma irradiated at 0, 1, 3, 5, 7, or 10 kGy in the condition of solution (1 mg/ml), and fresh shrimp was also irradiated. Conformational change of irradiated HSP was monitored by means of spectrometric measures, enzyme-linked immunosorbent assay with mouse monoclonal antibody, or human patients' sera and sodium dodecyl sulfate-polyacrylamide gel electrophoresis. The ability of the immunoglobulin E of patients allergic to shrimp to bind to irradiated HSP was dose dependently reduced. The amount of intact HSP in an irradiated solution was reduced by gamma irradiation, depending on the dose. Sodium dodecyl sulfate-polyacrylamide gel electrophoresis showed that the main band disappeared and the traces induced from coagulation appeared at a higher molecular weight zone. The binding ability of immunoglobulin E to allergens in the extracts from irradiated shrimp decreased, depending on the dose. The results provide a new method so that food irradiation technology can be applied to reduce allergenicity of shrimp.

Radioprotective effects of two traditional Chinese medicine prescriptions: si-wu-tang and si-jun-zi-tang.

We performed this study to determine the effect of Si-Wu-Tang, a basic prescription of traditional Oriental medicine as a blood-building decoction (Chinese medical concept: Bu-Xie), Si-Jun-Zi-Tang, a basic prescription as an energy tonic (Chinese medical concept: Bu-Qi) and its major ingredients on jejunal crypt survival, endogenous spleen colony formation, and apoptosis in jejunal crypt cells of mice irradiated with high and low dose of gamma-irradiation. Si-Wu-Tang administration before irradiation protected the jejunal crypts (p < 0.0005), increased the formation of endogenous spleen colonies (p < 0.05) and reduced the frequency of radiation-induced apoptosis (p < 0.05). In an experiment on the effect of ingredients of Si-Wu-Tang, the result indicated that extract of Danggui and Baishaoyao might have a major radioprotective effect. The radioprotective effect of Si-Jun-Zi-Tang and its ingredients were not as significant as that of Si-Wu-Tang. Although the mechanisms of this inhibitory effect remain to be elucidated, these results indicate that Si-Wu-Tang might be a useful radioprotector, especially since it is a relatively nontoxic natural product. Further studies are needed to characterize better the protective nature of Si-Wu-Tang extract and its ingredients.

The improvement of color and shelf life of ham by gamma irradiation.

This study was undertaken to determine if gamma irradiation can circumvent the need for sodium nitrite to obtain and maintain the desired color of pork loin ham. A dose of 5 kGy was observed to be as effective as the use of 200 ppm of sodium nitrite to provide and maintain the desired color of the product for 30 days. Peroxidation of the product was reduced with addition of sodium nitrite but increased with irradiation. However, organoleptic quality of the irradiated ham without added sodium nitrite was acceptable.

Effects of antioxidants and gamma irradiation on the shelf life of beef patties.

To improve the storage safety of two types of ground beef patty popular in Korea (general beef patties and bulgogi patties), we added various antioxidants (200 ppm; including butylated hydroxyanisole, ascorbyl palmitate, alpha-tocopherol, and beta-carotene) to typical formulations of patties, cooked the patties to 70 degrees C, and irradiated them at a dose of 1.5 or 3 kGy. During 30 d of storage at 5 degrees C, the number of aerobic bacteria and lactic acid bacteria were determined using total aerobic plate count and phenyl ethyl alcohol-sucrose agar, respectively. The concentration of thiobarbituric acid was also determined in each type of patty. No colonies were observed in patties irradiated at 3 kGy regardless of which antioxidant was added. In control patties and patties with butylated hydroxyanisole that were irradiated at a dose of 1.5 kGy, growth of microorganisms appeared to be more rapid than in patties with natural antioxidants. The microbiological safety of nonirradiated patties could not be ensured for a period of 20 d. Lipid oxidation was retarded in both types of patty when an antioxidant was added. Ascorbyl palmitate had the strongest antioxidant effect among the natural antioxidants. However, butylated hydroxyanisole was more effective than ascorbyl palmitate when used in an equal amount.

Changes in microbiological and physicochemical properties of bee pollen by application of gamma irradiation and ozone treatment.

The effects of gamma irradiation and ozone treatment on microbiological and physicochemical properties of bee pollen were investigated. Gamma irradiation at 7.5 kGy reduced the total microbial loads below detection levels (>10(2) CFU g(-1)), but after ozone treatment of up to 18 ppm for 8 h the total aerobic bacteria were found in concentrations of more than 10(3) CFU g(-1). Physicochemical properties such as amino acid and fatty acid composition, thiobarbituric acid value, mineral content, and pigment were not significantly changed by gamma irradiation, whereas ozone treatment caused significant changes in fatty acid composition, thiobarbituric acid value, and pigment by lipid oxidation and decoloration (P < 0.05).

Gamma irradiation and ozone treatment for inactivation of Escherichia coli O157:H7 in culture media.

A study was conducted to investigate the reduction and elimination of Escherichia coli O157:H7 by the effects of gamma irradiation and ozone treatment. Log phase cells were found to be more sensitive to gamma irradiation than stationary phase cells. E. coli O157:H7 was found to be considerably more resistant to irradiation at -18 degrees C than at 20 degrees C. The D values for this organism for treatment with ozone in tryptic soy agar were higher than those for treatment with ozone in phosphate buffer. Gamma irradiation at a dose of 1.5 kGy or ozone treatment at a concentration of 3 to 18 ppm for 20 to 50 min was required to assure the elimination of E. coli O157:H7.