Effects of ultraviolet irradiation on chemical and sensory properties of goat milk.

Sensory and chemical consequences of treating goat milk using an UV fluid processor were assessed. Milk was exposed to UV for a cumulative exposure time of 18 s and targeted UV dose of 15.8 +/- 1.6 mJ/cm2. A triangle test revealed differences between the odor of raw milk and UV irradiated milk. Oxidation and hydrolytic rancidity was measured by thiobarbituric acid reactive substances and acid degree values (ADV). As UV dose increased, there was an increase in thiobarbituric acid reactive substance values and ADV of the milk samples. A separate set of samples were processed using the fluid processor but with no UV exposure to see if lipase activity and agitation from pumping contributed to the differences in odor. The ADV increased at the same rate as samples exposed to UV; however, sensory studies indicated that the increase of free fatty acids was not enough to cause detectable differences in the odor of milk. Solid phase microextraction and gas chromatography were utilized for the analysis of volatile compounds as a result of UV exposure. There was an increase in the concentration of pentanal, hexanal, and heptanal (relative to raw goat milk) after as little as 1.3 mJ/cm2 UV dose. Ultraviolet irradiation at the wavelength 254 nm produced changes in the sensory and chemical properties of fluid goat milk.

Efficacy of UV light for the reduction of Listeria monocytogenes in goat's milk.

Certain types of goat's cheeses are produced using unpasteurized milk, which increases the food safety concerns for these types of products. Popularity and consumption of goat's milk products have increased, and the niche market includes gourmet goat's cheeses. The U.S. Code of Federal Regulations and the Pasteurized Milk Ordinance both address the possibility for processing alternatives to heat treatment, and the use of UV light treatment may be a viable alternative that still ensures the safety of the product. Fresh goat's milk was inoculated with Listeria monocytogenes (L-2289) at 10(7) CFU/ml and exposed to UV light using the CiderSure 3500 apparatus (FPE Inc., Macedon, NY). Inoculated milk was exposed to a UV dose range between 0 and 20 mJ/cm2 to determine the optimal UV dose. A greater than 5-log reduction was achieved (P < 0.0001) when the milk received a cumulative UV dose of 15.8 +/- 1.6 mJ/cm2. The results of this study indicate that UV irradiation could be used for the reduction of L. monocytogenes in goat's milk.

Effect of hydrogen peroxide and other protease inhibitors on Cryptosporidium parvum excystation and in vitro development.

This study was undertaken to observe the effects of hydrogen peroxide on Cryptosporidium parvum oocysts with respect to protease activity in comparison to known protease inhibitors. In assessing the possible mechanisms of action of hydrogen peroxide, treatment effectiveness was analyzed using 3 assays and the potential roles of proteases and cations were considered. Treatment of C. parvum oocysts with hydrogen peroxide inhibited protease activity up to 50% compared with untreated controls. Treatment of oocysts with chemicals that affect sulfhydryls, including N-ethylmaleimide and dithiolthreitol, inhibited protease activity by >90%. Treatment of oocysts with these chemicals, along with the protease inhibitors, phenylmethylsulfonyl fluoride (PMSF), ethylenediamine-tetraacetic acid, and cystatin, inhibited protease activity as well as in vitro excystation and infection in a cell culture assay. Several mechanisms may result in the successful inhibition of infection and excystation by hydrogen peroxide treatment, including: oxidation of oocyst wall proteins or lipids, chelating of cations necessary for infection, or hydroxyl radical-induced DNA damage to sporozoites, or both.

Penetration of surface-inoculated bacteria as a result of hydrodynamic shock wave treatment of beef steaks.

The top surface of the raw eye of round steaks was inoculated with either green fluorescent protein (GFP)-labeled Escherichia coli (E. coli-GFP) or rifampin-resistant E. coli (E. coli-rif). Cryostat sampling in concert with laser scanning confocal microscopy (LSCM) or plating onto antibiotic selective agar was used to determine if hydrodynamic shock wave (HSW) treatment resulted in the movement of the inoculated bacteria from the outer inoculated surface to the interior of intact beef steaks. HSW treatment induced the movement of both marker bacteria into the steaks to a maximum depth of 300 microm (0.3 mm). Because popular steak-cooking techniques involve the application of heat from the exterior surface of the steak to achieve internal temperatures ranging from 55 to 82 degrees C, the extent of bacterial penetration observed in HSW-treated steaks does not appear to pose a safety hazard to consumers.

Levels of Vibrio vulnificus and organoleptic quality of raw shellstock oysters (Crassostrea virginica) maintained at different storage temperatures.

Temperature abuse during raw oyster harvesting and storage may allow for the multiplication of natural spoilage flora as well as microbial pathogens, thus posing a potential health threat to susceptible consumers and compromising product quality. The objective of this study was to provide a scientific basis for determining whether different refrigeration and abuse temperatures for raw oysters would result in a spoiled product before it became unsafe. Raw shellstock oysters (Crassostrea virginica) purchased from a commercial Virginia processor were subjected to different temperature abuse conditions (7, 13, and 21 degrees C) over a 10-day storage period. Salinity, pH, halophilic plate count (HPC), total culturable Vibrio counts, and culturable Vibrio vulnificus counts were determined at each abuse condition. V. vulnificus isolates were confirmed by a specific enzyme-linked immunosorbent assay. Olfactory analysis was performed to determine consumer acceptability of the oysters at each abuse stage. The pH of the oysters decreased over time in each storage condition. The HPC increased 2 to 4 logs for all storage conditions, while olfactory acceptance decreased over time. V. vulnificus levels increased over time, reaching 10(5) to 10(6) CFU/g by day 6. The length of storage had a greater effect on the bacterial counts and olfactory acceptance of the oysters (P < 0.05) over time than did the storage temperature (P < 0.05).

Microbiological quality and safety of quahog clams, Mercenaria mercenaria, during refrigeration and at elevated storage temperatures.

The effects of storage temperatures and times on the microbiological quality and safety of hard-shelled quahog clams (Mercenaria mercenaria) were examined. Samples were stored at four different incubation temperatures (3.3, 7.2, 10.0, and 12.8 degrees C) for a period of 3 weeks, following their harvest from summer growing waters (> or = 27 degrees C) and winter waters (< or = 4 degrees C). Clams were analyzed for two naturally occurring pathogens, Vibrio parahaemolyticus and Vibrio vulnificus. During the summer, V. parahaemolyticus was isolated from 56% of the stored samples, with the highest concentration, 6,100/g, occurring on day 12 at 12.8 degrees C. Also, during the summer, V. vulnificus was isolated from 11% of the stored samples, with the highest concentration of 1,500/g occurring on day 15 at 7.2 degrees C. No Vibrio spp. were detected during the winter. During summer storage, aerobic mesophilic counts on plate count agar (PCA) containing 2% NaCl ranged from 10(4) to 10(8) CFU/g, and during storage of the winter samples, aerobic mesophilic PCA (with added NaCl) counts ranged from <100 to 10(4) CFU/g. Comparatively, summer storage mesophilic counts on PCA containing no added NaCl ranged from <100 to 10(5) CFU/g, and for the winter samples the range was <100 to 10(2) CFU/g. Coliform and fecal coliform counts ranged from <0.3 to 61.1/g and <0.3 to 24.4/g, respectively. There was no statistical correlation between the length of storage or the temperature of incubation and the presence of V. parahaemolyticus, V. vulnificus, coliforms, or fecal coliforms. However, storage time and incubation temperature affected the PCA counts (P < or = 0.05) in quahog clams.

Growth and histamine formation of Morganella morganii in determining the safety and quality of inoculated and uninoculated bluefish (Pomatomus saltatrix).

The objective of this study was to determine the effect of normal microflora and Morganella morganii on histamine formation and olfactory acceptability in raw bluefish under controlled storage conditions. Fillets inoculated with and without M. morganii were stored at 5, 10, and 15 degrees C for 7 days. Microbial isolates from surface swabs were identified and screened for histidine decarboxylase activity. Olfactory acceptance was performed by an informal sensory panel. Histamine levels were quantified using high-performance liquid chromatography and fluorescence detection. While olfactory acceptance decreased, histamine concentration and bacterial counts increased. Storage temperature had a significant effect on histamine levels, bacterial counts, and olfactory acceptance of the bluefish. Inoculation with M. morganii had a positive significant effect on histamine formation for bluefish held at 10 and 15 degrees C (P < 0.0001). The results of the study will serve in supporting U.S. Food and Drug Administration (FDA) regulations regarding guidance and hazard levels of histamine in fresh bluefish.

Nonproteolytic Clostridium botulinum toxigenesis in cooked turkey stored under modified atmospheres.

The ability of nonproteolytic Clostridium botulinum type B spores to grow and produce toxin in cooked, uncured turkey packaged under modified atmospheres was investigated at refrigeration and mild to moderate abuse temperatures. Cook-in-bag turkey breast was carved into small chunks, surface-inoculated with a mixture of nonproteolytic C. botulinum type B spores, packaged in O2-impermeable bags under two modified atmospheres (100% N2 and 30% CO2:70% N2), and stored at 4, 10, and 15 degrees C. Samples were analyzed for botulinal toxin and indigenous microorganisms, as well as subjected to sensory evaluation, on days 0, 7, 14, 28, 42, and 60. Given sufficient incubation time, nonproteolytic C. botulinum type B grew and produced toxin in all temperature and modified atmosphere treatment combinations. At moderate temperature abuse (15 degrees C), toxin was detected by day 7, independent of packaging atmosphere. At mild temperature abuse (10 degrees C), toxin was detected by day 14, also independent of packaging atmosphere. At refrigeration temperature (4 degrees C), toxin was detected by day 14 in product packaged under 100% N2 and by day 28 in product packaged under 30% CO2:70% N2. Reduced storage temperature significantly delayed toxin production and extended the period of sensory acceptability of cooked turkey, but even strict refrigeration did not prevent growth and toxigenesis by nonproteolytic C. botulinum. At all three storage temperatures, toxin detection preceded or coincided with development of sensory characteristics of spoilage, demonstrating the potential for consumption of toxic product when spoilage-signaling sensory cues are absent.

Efficacy of ultraviolet light for reducing Escherichia coli O157:H7 in unpasteurized apple cider.

This study examined the efficacy of UV light for reducing Escherichia coli O157:H7 in unpasteurized cider. Cider containing a mixture of acid-resistant E. coli O157:H7 (6.3 log CFU/ml) was treated using a thin-film UV disinfection unit at 254 nm. Dosages ranged from 9,402 to 61,005 microW-s/cm2. Treatment significantly reduced E. coli O157:H7 (P < or = 0.0001). Mean reduction for all treated samples was 3.81 log CFU/ml. Reduction was also affected by the level of background microflora in cider. Results indicate that UV light is effective for reducing this pathogen in cider. However, with the dosages used in this experiment, additional reduction measures are necessary to achieve the required 5-log reduction.

Biogenic amine survey and organoleptic changes in fresh, stored, and temperature-abused bluefish (Pomatomus saltatrix).

Changes in histamine, putrescine, and cadaverine concentrations in bluefish filets (Pomatomus saltatrix) stored at 5, 10, and 15 degrees C were determined using high-performance liquid chromatography. An organoleptic assessment was conducted simultaneously with the biogenic amine analyses. The histamine levels found in fresh bluefish obtained from wholesale seafood distributors ranged between <1 ppm and 99 with an average of 39 ppm. Putrescine and cadaverine were not found in fresh bluefish. Fish fillets stored at each of the three temperatures developed histamine. The greatest accumulation of histamine was observed in fish stored at 15 degrees C, which developed histamine levels as high as 2,200 ppm. Putrescine levels increased at each temperature during storage. Cadaverine was present only in uninoculated bluefish stored at 15 degrees C. Histamine achieved higher levels in bluefish pieces inoculated with Morganella morganii, which demonstrates that bluefish support bacterial histamine formation. Histamine levels at each temperature exceeded the 50-ppm advisory level established by the Food and Drug Administration before 100% sensory rejection. Standard plate counts increased during storage of fish at all temperatures, but the correlation between histamine levels and standard plate count was not significant.

Influence of environmental stress on the kinetics and strength of attachment of Listeria monocytogenes Scott A to Buna-N rubber and stainless steel.

Attachment and detachment of Listeria monocytogenes Scott A to Buna-N rubber and stainless steel under varying conditions of temperature and pH were investigated using model systems. Numbers of attached cells increased with increasing attachment temperature (10 to 45 degrees C) and time (up to 120 min) for both test surfaces. Compared to Buna-N rubber, the rate of attachment to stainless steel was markedly more rapid for all temperature and pH conditions studied and could not be calculated. Rate of attachment to Buna-N rubber was found to be significantly lower when cells were attached at 10 degrees C. Growth temperature did not significantly affect rates of adhesion to Buna-N rubber. Altering the medium pH during attachment between 4 and 9 demonstrated that rates of adhesion were slower under alkaline conditions. Growth pH was also found to significantly affect rates of attachment to Buna-N rubber. Detachment of cells adhered to Buna-N rubber was significantly affected by growth temperature but not growth pH. Significant differences in detachment were also found between Buna-N rubber and stainless steel, inferring stronger attachment to Buna-N rubber. Cell surface hydrophobicity was found to be affected by both growth temperature and growth pH. However, changes in hydrophobicity could not be correlated to differences in rates of attachment. Addition of 0.01% trypsin to the attachment medium during cell exposure to either test surface resulted in a 99.9% reduction in the adhered cell population when compared to controls. This would suggest that proteins play a role in the initial attachment process of L. monocytogenes.

Effect of environmental stress on the ability of Listeria monocytogenes Scott A to attach to food contact surfaces.

Attachment of Listeria monocytogenes Scott A to Buna-N rubber and stainless steel under different temperature and pH conditions at the time of cell growth or at the time of attachment was investigated. All experiments were conducted using sterile phosphate buffer to avoid cell growth during exposure to the test surfaces. Numbers of attached cells increased with increasing attachment temperature (10 to 45 degrees C) and exposure time for both test surfaces. Maximum levels of attached cells were obtained when cell growth occurred at 30 degrees C. Downward, but not upward, shifts in the cell suspension holding temperature prior to attachment to Buna-N rubber resulted in reduced adhered cell populations. Maximum levels of adhered cells to Buna-N rubber were not affected by adjustments of the attachment medium pH between 4 and 9. However, after short contact times (i.e., less than 30 min), levels of attached cells were lower when attachment occurred under alkaline conditions. Growth pH was also found to affect the levels of adhered cell populations to Buna-N rubber. L. monocytogenes Scott A attached to stainless steel at higher levels for all temperature and pH parameters evaluated in this study.

Growth and survival of Listeria monocytogenes in vacuum-packaged ground beef inoculated with Lactobacillus alimentarius FloraCarn L-2.

A culture of the psychotrophic strain FloraCarn L-2 of Lactobacillus alimentarius was added to ground beef (pH 5.4) inoculated with two isolates of Listeria monocytogenes able to grow in refrigerated ground beef. The ground beef was vacuum-packaged and stored for 9 weeks at 4 degrees C. Populations of inoculated L. monocytogenes initially were 6.3 to 6.4 log10 CFU/g and increased to 7.4 log10 CFU/g in ground beef with no added lactobacilli. Addition of L. alimentarius L-2 or its antibiotic-resistant mutant SRL-2 reduced the final populations of L. monocytogenes to 4.3 or 4.1 log10 CFU/g, respectively. L. alimentarius L-2 did not produce bacteriocins or hydrogen peroxide in vitro. The antilisterial effect of L. alimentarius observed in laboratory media and ground beef is attributed to lactic acid (ca. 50 mM) produced by growing cultures.

Sensitization of Escherichia coli to nisin by maltol and ethyl maltol.

When used separately, 20 mmol l-1 maltol or 1600 AU ml-1 nisin resulted in a 0-0.6 log10 reduction in viable counts of Escherichia coli in a buffer system. However, when added in combination they yielded a 1.8-5.5-log-cycle reduction in viable counts of E. coli at pH 5.0 and 6.8 respectively. It is postulated that maltol (and ethyl maltol) destabilizes the cell outer membrane by chelation of Mg2+ and/or Ca2+, thus permeabilizing the E. coli cell to nisin.

Use of a Modified Gompertz Equation to Predict the Effects of Temperature, pH, and NaCl on the Inactivation of Listeria monocytogenes Scott A Heated in Infant Formula.

The heat resistance of Listeria monocytogenes was determined in infant formula for all possible combinations of temperature (50, 55, and 60°C), pH level (5, 6, and 7), and NaCl concentration (0, 2, and 4%). Survival curves were fit using nonlinear regression with a Gompertz equation. The Gompertz equation was flexible enough to fit the three most commonly observed survival curves: linear curves, those with an initial lag region followed by a linear region, and sigmoidal shaped. Parameter estimates obtained by the method of nonlinear least squares were used to describe the effect(s) of different heating treatments on the lag region, death rate, and tailing region of survival curves. These estimates were further used to predict single and interactive effects of temperature, pH, and percentage of NaCl on the log of the surviving fraction (LSF) of bacteria. Interactions among these variables significantly (P ≤ .05) affected the LSF. Generally, increased pH or NaCl concentration lead to an increased LSF, whereas increased time or temperature lead to a decreased LSF. All multiple-factor interactions significantly (P ≤ .05) affected the LSF. The correlation of observed LSF versus predicted LSF (R2 = .92) indicated that the estimated Gompertz equation was in close agreement with the observation. This study demonstrated that the Gompertz equation and nonlinear regression can be used as an effective means to predict survival curve shape and response to heat of L. monocytogenes under many different environmental conditions.

Use of a Modified Gompertz Equation to Model Nonlinear Survival Curves for Listeria monocytogenes Scott A.

The heat resistance of Listeria monocytogenes was determined in 0.1 M KH2PO4 buffer at three temperatures (50, 55, and 60°C), three pH levels (5, 6, and 7), and three NaCl concentrations (0, 2, and 4%). Survival curves were fit using nonlinear regression with a modified Gompertz equation. The Gompertz equation is capable of fitting survival curves which are linear, those which display an initial lag region followed by a linear region, and those which are sigmoidal. Parameter estimates were used to describe the lag region, death rate, and the tailing region of a survival curve. These estimates were also used to predict single and interactive effects of temperature, pH, and percentage of NaCl on the log surviving fraction (LSF) of bacteria. Interactions among these variables significantly (P < .05) affected the LSF. Generally, increased pH or NaCl concentration lead to an increased (P < .05) LSF, where as increased time or temperature lead to a decreased (P < .05) LSF. All multiple factor interactions significantly (P < .05) affected the LSF. These interactions differed depending on the heating medium and the region of the survival curve. The correlation of observed LSF and predicted LSF (R2 = .89) indicated that the Gompertz equation was in close agreement with the observations. This study demonstrated that the Gompertz equation and nonlinear regression can be used as an effective means to predict survival curve shape and response to heat of L. monocytogenes in many different environmental conditions.

The Effect of Sublethal Heat Shock and Growth Atmosphere on the Heat Resistance of Listeria monocytogenes Scott A.

Log phase cells of Listeria monocytogenes Scott A were heat shocked in Trypticase Soy + 0.6% yeast extract (TSYE) broth at 48°C for 10 min, followed by heating at 55°C for up to 50 min. Heat resistance was determined using nonselective (TSYE) and selective (McBride Listeria ) enumeration media which were incubated under aerobic and anaerobic environments. D55°C-values for heat shocked cells were 2.1-fold higher than nonheat shocked cells (18.7 min vs. 8.89 min) when cells were enumerated on TSYE agar aerobically and 2.2-fold higher (26.4 min vs. 12.0 min) for cells enumerated anaerobically on TSYE agar. When cells were enumerated aerobically on McBride Listeria (ML) agar, D55°C-values for heat shocked cells were 1.4-fold higher than nonheat shocked cells (9.55 min vs. 6.69 min). No growth was observed on ML agar anaerobically. The physiological condition of the microorganism, the enumeration medium, and the growth environment greatly affected the heat resistance of logphase cells of Listeria monocytogenes Scott A.

Sodium hypophosphite inhibition of the growth of selected gram-positive foodborne pathogenic bacteria.

Sodium hypophosphite (SHP) was evaluated for inhibition of growth of selected Gram-positive foodborne pathogenic bacteria in Trypticase Soy Broth. In addition, the effects of pH and sodium chloride (NaCl) alone and in combination with (SHP) were also examined. All inhibition studies were performed with optimal or nearly optimal growth conditions for each bacterium. Growth was monitored by determining culture optical density at 600 nm, and a time to significant growth determined for each test media. Ratios of time to significant growth for each control over that in test variables were used to evaluate the effect of SHP and other variables on growth. SHP was effective in inhibiting growth of Clostridium perfringens and Clostridium botulinum strains 62A 52A and Lamanna B, but generally ineffective against Staphylococcus aureus and Bacillus cereus. Results from this investigation show that SHP has potential as a food ingredient for the inhibition of certain Gram-positive foodborne pathogens.

Inhibition of Germination, Outgrowth, and Vegetative Growth of Clostridium botulinum 67B by Spice Oils.

The oils of clove, thyme, black pepper, pimenta, origanum, garlic, onion, and cinnamon were tested for their activity on germination, outgrowth, and vegetative growth of Clostridium botulinum 67B in broth media. Garlic, onion, cinnamon, thyme, origanum, and black pepper oils at a concentration of 100 ppm prevented germination of C. botulinum 67B spores. Clove and pimenta oils at a concentration of 150 ppm prevented germination. The effect of spice oils on spore germination was reversible. The oils of black pepper and clove had a greater inhibitory effect on vegetative growth than the other oils. None of the oils had a significant effect on outgrowth.

Hypophosphite: A Review.

Efforts to find a suitable sparing agent for nitrite in cured meat products have brought sodium hypophosphite (SHP) to the attention of the scientific community. Hypophosphites were introduced in the mid 1800s as a cure for tuberculosis, but recent reports have suggested SHP could possess antibotulinal and antimicrobial properties. Sodium hypophosphite has good potential as an antimicrobial food ingredient and it is Generally Recognized As Safe (GRAS). This review summarizes SHP chemistry, history, toxicology, regulatory status, applications, and antimicrobial properties.