Effect of immunological castration management strategy on lipid oxidation and sensory characteristics of bacon stored under simulated food service conditions.

The objectives of this study were to determine the effect of 1) immunological castration (Improvest, a gonadotropin releasing factor analog-diphtheria toxoid conjugate) management strategy (age at slaughter and time of slaughter after second dose) and 2) sex on lipid oxidation and sensory characteristics of bacon stored under simulated food service conditions. For Objective 1, immunological castration management strategies included 24-wk-old immunologically castrated (IC) barrows 4, 6, 8, or 10 wk after the second Improvest dose (ASD); 26-wk-old IC barrows 6 wk ASD; and 28-wk-old IC barrows 8 wk ASD ( = 63). Objective 2 ( = 97) included IC barrows, physically castrated (PC) barrows, and gilts slaughtered at 24, 26, and 28 wks of age. Bellies from 2 slaughter dates were manufactured into bacon under commercial conditions. Bacon slices were laid out on parchment paper, packaged in oxygen-permeable poly-vinyl-lined boxes, and frozen (-33°C) for 1, 4, 8, or 12 wk to simulate food service conditions. At the end of each storage period, bacon was evaluated for lipid oxidation, moisture and lipid content, and sensory characteristics. Data from both objectives were analyzed using the MIXED procedure in SAS with belly as the experimental unit. For both objectives, as storage time increased, lipid oxidation of bacon increased ( < 0.01), regardless of management strategy or sex. Also, there was no sex or management strategy × week of frozen storage interaction for any traits evaluated ( ≥ 0.25). For Objective 1, lipid content of bacon from IC barrows increased as time of slaughter ASD increased ( < 0.05), regardless of age at slaughter. Additionally, there were no differences in sensory attributes of bacon across management strategies. For the evaluation of sex effects in Objective 2, lipid oxidation was greater ( < 0.05) in IC barrows compared with PC barrows but was not different than gilts ( > 0.05). After 12 wk of frozen storage, lipid oxidation values for IC barrows, PC barrows, and gilts were still below 0.5 mg malondialdehyde/kg of meat, the threshold at which trained panelists may deem a food to be rancid. In conclusion, bacon shelf life characteristics were not altered by the immunological castration management strategy and bacon from IC barrows was similar to bacon from gilts. Therefore, bacon from IC barrows would result in shelf life and sensory quality similar to PC barrows and gilts.

Effects of time after a second dose of immunization against GnRF (Improvest) independent of age at slaughter on commercial bacon slicing characteristics of immunologically castrated barrows.

The objective was to determine the effects of time after a second dose of anti-GnRF immunization on fresh belly characteristics and slicing yields of immunologically castrated (IC) barrows, physically castrated (PC) barrows and gilts slaughtered at 24 weeks of age. The second dose was staggered so that IC barrows were slaughtered at 4, 6, 8, or 10 weeks after the second dose. Fresh belly characteristics (N=141) were collected at slaughter and bacon was manufactured commercially. The main effects in the model were treatment and the random effects of block and block within replication. Thickness, flop distance, and lipid content increased (L; P<0.04) and iodine value tended to decrease (L; P=0.08) with time after the second dose in IC barrows. Slicing yields increased with time after the second dose (L; P<0.01), but were similar (P=0.11) among sexes. Increasing time of slaughter after second anti-GnRF dose improves fresh belly and bacon slicing characteristics in IC barrows.

Color stability and sensory characteristics of fresh and enhanced pork loins from immunologically castrated barrows.

Our objective was to evaluate color changes during storage of fresh pork chops and enhanced and nonenhanced loin quality from anti-gonadotropin-releasing factor (Improvest) immunologically castrated (IC) barrows. In study 1, treatments evaluated were IC barrows, IC barrows fed ractopamine (IC+RAC), physically castrated (PC) barrows, intact males (IM), and gilts. Fresh loins were evaluated for sensory characteristics and instrumental tenderness including both Warner-Bratzler Shear force (WBSF) and star probe force. In study 2, treatments evaluated were IC barrows fed 0.55% and 0.65% standard ileal digestible (SID) lysine and PC barrows fed 0.55% SID lysine. Loin chops were displayed for 7 d, and color was evaluated. The remaining loin was halved, and one half was enhanced with a 3.5% salt and phosphate solution. Enhanced loins were evaluated for sensory characteristics and instrumental tenderness. In both studies, pen served as the experimental unit for all traits measured. Data from individual animals were averaged by pen and analyzed, per study, as a 1-way ANOVA using the MIXED procedure of SAS. In study 1, there were no differences ( 0.05) between treatments for juiciness, tenderness, chewiness, or off-flavor. Intact males had the most intense ( 0.05) boar aroma. Gilts had the most intense ( < 0.05) pork flavor, whereas IM had the least intense pork flavor; all other treatments were intermediate. Tenderness (WBSF) was similar between treatments at 1 d of aging; however, at 7, 14, and 21 d of aging, loins from IC barrows were more tender ( 0.05) than those from gilts, IM, and IC+RAC but were similar ( 0.05) to those from PC. In study 2, discoloration of fresh loin chops during storage was similar ( 0.42) between PC and IC barrows. Chops from enhanced loins were more tender and juicy but had more off-flavor than nonenhanced loins ( 0.01). Star probe and WBSF were also reduced ( 0.01) in enhanced loins compared with nonenhanced loins. Sensory characteristics and tenderness were not different between treatments of IC and PC barrows ( > 0.05), and there were no interactions of enhancement with castration treatments. These data suggest that immunological castration does not negatively impact the color stability, sensory characteristics, or tenderness of enhanced or nonenhanced pork loins.

Effects of the porcine IGF2 intron 3-G3072A mutation on carcass cutability, meat quality, and bacon processing.

A SNP in a regulatory region of intron 3 within the porcine IGF2 gene (IGF2-G3072A) is associated with increased lean deposition and decreased fat deposition in pigs with paternal A alleles (APat) compared with pigs with paternal G alleles (GPat). However, data regarding fresh and processed meat quality characteristics of pigs with different alleles for this polymorphism are limited. A single heterozygote (AG) boar was bred to homozygous (AA) commercial Yorkshire-cross sows producing F1 barrows and gilts with either GPat or APat. Two farrowing groups of barrows and gilts were group housed, provided ad libitum access to a diet that met or exceeded NRC nutrient recommendations throughout production, and slaughtered at 176 d (±4 d) of age. Fresh LM quality and estimated percent fat-free lean measurements were taken on the left side of carcasses, while carcass cutouts were completed with right sides. Fresh belly and bacon processing traits were characterized for only block 1 pigs. Pig was treated as the experimental unit for all analyses. Ending live weight and HCW were not affected by IGF2 allele; however, 10th rib backfat thickness was 0.41 cm less (P=0.01), loin eye area was 4.0 cm2 greater (P=0.01), and predicted fat-free lean was over 2 percentage units greater (P<0.01) in APat pigs compared with GPat pigs. Furthermore, boneless lean cuts from the shoulder, loin, and ham were heavier (P<0.05) in APat pigs compared with GPat pigs. Minolta L* value was 2.36 units greater (P=0.03) but cooking loss was 1.82 percentage units greater (P<0.01) in APat pigs compared with GPat pigs. Additionally, despite reductions in subcutaneous fat, extractable intramuscular lipid from the LM was 0.64 percentage units greater (P=0.02) in APat pigs compared with GPat pigs. Bellies were 7.17 mm thinner (P=0.01), had 7.27 cm less flop distance (P=0.05), and tended to have 1.34 units greater iodine value (P=0.09) in APat pigs compared with GPat pigs. While not statistically different (P=0.30), the magnitude of difference in slicing yield as a percentage of green weight was 1.57 percentage units between bellies from APat pigs (85.83%) and bellies from GPat pigs (87.40%). Pigs with GPat had superior belly quality that may positively impact commercial bacon production. However, pigs with APat yielded a greater amount of lean product at the expense of producing lighter LM color and increased cooking loss.

Effects of immunocastration and time after second Improvest dose on adipose tissue fatty acid profile of finishing barrows.

The effects of immunocastration and time after second Improvest dose on proximate composition and fatty acid profile of adipose tissue from jowl and belly of finishing barrows were determined. Physically castrated (PC) and immunologically castrated (IC) barrows were assigned to treatments at birth. Within 5 d of age, PC barrows were physically castrated and IC barrows were administered Improvest (gonadotropin-releasing factor analog; Zoetis, Kalamazoo, MI) at 16 and 20 wk of age. Diets were formulated with corn and soybean meal and did not contain ethanol coproducts. Subsequently, PC (n = 23) and IC (n = 24) barrows were slaughtered biweekly from 22 to 28 wk of age, 2 to 8 wk following second Improvest dose. Adipose tissue samples were collected from the jowl and belly. Main effects of castration method and time after second Improvest dose and their interaction were analyzed with the MIXED procedure of SAS. Overall, IC barrows were heavier at slaughter (136.1 vs. 100.6 kg; P < 0.01), had similar HCW (P = 0.13), and were leaner (50.9 vs. 48.9%; P < 0.01) than PC barrows. In jowl adipose tissue, IC barrows had less lipid content (64.7 vs. 80.2%; P < 0.01) than PC barrows at 2 wk. However, there were no differences (P ≥ 0.75) in lipid content between IC and PC barrows from 4 to 8 wk. Total MUFA content was reduced (42.5 vs. 44.8%; P = 0.04) and PUFA content was greater (16.9 vs. 14.8%; P < 0.01) in IC compared to PC barrows. Increasing time after second dose reduced (P = 0.04) PUFA content from 17.5% at 2 wk to 15.4% at 8 wk. In IC barrows, iodine value (IV) was increased by 6.9 and 3.3 g/100 g compared with PC barrows at 2 and 4 wk, but IV was not different between castration methods (P ≥ 0.95) at both 6 and 8 wk. Meanwhile, in belly adipose tissue, IC barrows had less lipid content than PC barrows (75.3 vs. 82.7%; P < 0.01). Lipid content was unchanged over time (P = 0.34) in either PC or IC barrows. Total SFA and MUFA content of the belly were similar for both IC and PC barrows. Belly adipose tissue from IC barrows had greater concentrations of PUFA than PC barrows (16.2 vs. 14.7%; P < 0.01). In IC barrows, IV was increased by 5.3 g/100 g compared with PC barrows at 2 wk, but IV was not different between castration methods (P ≥ 0.91) from 4 to 8 wk. Results indicate that as time after second Improvest dose progressed, IV of jowl and belly was reduced. This was accompanied by an increase in lipid deposition in jowl, while lipid content remained constant in belly.

Effects of immunological castration and distiller's dried grains with solubles on carcass cutability and commercial bacon slicing yields of barrows slaughtered at two time points.

Male pigs were randomly assigned to a castration method at birth and allotted to 48 pens (28 pigs/pen). Physically castrated (PC) barrows were castrated at 2 d of age; immunologically castrated (IC) barrows were administered Improvest (GnRF analog diphtheria toxoid conjugate; Zoetis, Kalamazoo, MI) at 16 and 20 wk of age. Distiller's dried grains with solubles (DDGS) feeding strategies included either 0% DDGS (control), 30% DDGS (30% DDGS) fed from 6 wk of age to slaughter, or 30% DDGS fed from 6 wk of age to second dose of Improvest and then fed 0% DDGS until slaughter (withdrawal). Four barrows closest to the median pen weight at 4.5 wk after second dose were selected for evaluation; two were randomly selected and slaughtered at 5 wk and the other two at 7 wk after second dose. Data from each slaughter time were analyzed independently as a 2 × 3 factorial design with pen as the experimental unit. At 5 wk after second dose, bone-in lean cutting yields were 2.63% units greater (P < 0.01) in IC when compared to PC. Bellies were thicker (P < 0.01) and tended to have greater belly flop distances (P = 0.07) in PC compared to IC, however iodine values (IV) were not altered (P = 0.84). Carcass traits (P ≥ 0.10), cutting yields (P ≥ 0.43), and fresh belly characteristics (P ≥ 0.08) were minimally affected by DDGS feeding strategy. Bacon slicing yields (percentage of green weight) were 6.10% units less (P < 0.01) in IC compared with PC. At 7 wk after second dose, bone-in lean cutting yields were 1.57% units greater (P = 0.03) in IC compared with PC. Distiller's grains feeding strategy had no effect (P ≥ 0.83) on boneless carcass cutting yields in IC; while in PC, these yields were 2.32% units less (P < 0.02) in control-fed barrows when compared to other feeding strategies (castration method × feeding strategy; P = 0.03). Bellies from PC tended to be thicker (P = 0.07) and have similar flop distances (P = 0.44) and IV (P = 0.54) when compared with IC. Iodine value was greater (P = 0.03) in 30% DDGS-fed barrows compared with control-fed barrows. Bacon slicing yields (percentage of green weight) were 4.27% units less (P = 0.05) in IC compared with PC. These data suggested that while bacon slicing yield was reduced in IC barrows fed control and 30% DDGS compared with PC barrow counterparts, withdrawal of DDGS improved bacon slicing yields of IC barrows.

The effects of immunological castration and corn dried distillers grains with solubles withdrawal on growth performance, carcass characteristics, fatty acid analysis, and iodine value of pork fat depots.

A total of 1,360 pigs were used in a 125-d study to determine the effects of corn dried distillers grains with solubles (DDGS) withdrawal after immunological castration (Improvest, Zoetis, Kalamazoo, MI) on growth performance and carcass fat quality of pigs. Pens of male pigs (initially 24 kg) were randomly allotted by BW and castration method (physically castrated [PC] or immunologically castrated [IC] barrows) to 1 of 3 diets with 8 replications per treatment and 27 to 29 pigs per pen. Treatments were arranged in a 2 × 3 factorial with main effects of castration method and diet (0% DDGS throughout, 30% DDGS throughout, or 30% DDGS through d 75 then no DDGS to d 125). Intact males were injected with Improvest on d 39 and 74 (IC). No castration method × diet interactions (P > 0.12) were observed for growth performance. Before the second Improvest injection (d 0 to 74), PC barrows had increased (P < 0.05) ADFI but were less efficient (P < 0.05) than intact males. After the second Improvest injection until the first marketing event (d 74 to 107), IC barrows had improved (P < 0.05) ADG and G:F compared with PC barrows. From d 0 to 107, IC barrows had improved (P < 0.05) ADG, G:F, and lower ADFI than PC barrows. The inclusion of 30% DDGS decreased (P < 0.05) G:F compared with pigs fed the control diet. For the period after the second Improvest injection (d 74 to 125), IC barrows had increased (P < 0.05) ADG, ADFI, and G:F compared with PC barrows. Overall (d 0 to 125), IC barrows had improved (P < 0.05) ADG and G:F and lower ADFI than PC barrows. The inclusion of 30% DDGS decreased (P < 0.05) G:F. Carcass yield was lower (P < 0.05) for IC than PC barrows. Pigs fed 30% DDGS throughout had decreased (P < 0.05) carcass yield; however, withdrawing DDGS from the diet on d 74 was effective at fully recovering the yield loss. Carcass fat iodine values (IV) were consistently higher (P < 0.05), regardless of fat depot or harvest time when 30% DDGS were included in the diet. Multiple 2-way interactions (P < 0.05) were detected between castration method, DDGS, depot, and time. Interactions were a result of fatty acid profiles changing more rapidly in backfat and belly fat than in jowl fat from d 107 to 125 and more dramatically in IC than PC barrows in the same period. This improvement from d 107 to 125 could be caused by the dilution of unsaturated fatty acids, specifically C18:2 and C18:3, due to rapid deposition of fat from de novo synthesis in IC barrows.

Fresh meat quality and further processing characteristics of shoulders from finishing pigs fed ractopamine hydrochloride (Paylean).

Our objectives were to characterize the effects of ractopamine hydrochloride (RAC) on fresh meat and further processing characteristics of muscles (serratus ventralis and triceps brachii) from the shoulders of finishing pigs. Two hundred forty shoulders originating from 120 carcasses (60 barrows and 60 gilts) were selected from a commercial population of pigs. A 2 × 2 factorial in a completely randomized design was used, with factors of RAC inclusion in the diet (0 or 7.4 mg/kg, as-fed basis) and sex (barrow or gilt). Paired shoulders (120 rights and 120 lefts) were transported from a federally inspected slaughter facility under refrigeration to the University of Illinois Meat Science Laboratory for evaluation. Subsequently, right and left shoulders were separated and designated for 2 separate experiments. Shoulders from right side were used in Exp. 1 to determine further processing characteristics. Cellar trimmed (CT) butts from the Boston butt of the shoulders were cured and dried-cured to manufacture cottage bacon and coppa, respectively. Shoulders from left side were used in Exp. 2 to determine fresh meat characteristics. Pigs fed RAC had greater shoulder weights and increased yields of cuts from the shoulder. Feeding RAC decreased Boston butt fat content (P = 0.01) but had no effect on picnic fat content (P = 0.86). Pigs fed RAC had greater (P < 0.01) iodine values than controls (67.00 vs. 64.95, respectively). Inclusion of RAC in the diet had no effect on cottage bacon cooked yield (P = 0.33), but it decreased (P < 0.01) cottage bacon fat content without having an effect on protein content (P = 0.50). In addition, cottage bacon from RAC shoulders had greater slice total area (P = 0.01) and less seam fat (P = 0.01) than controls. Ractopamine hydrochloride had no detrimental effect on coppa processing characteristics and visual appearance. Cottage bacon and coppa from RAC pigs had sensory characteristics similar to controls. Shoulders from pigs fed RAC might be of benefit to the industry because they provide more pounds of sellable product with no detrimental effects on processing characteristics.

Effect of antioxidant inclusion and oil quality on broiler performance, meat quality, and lipid oxidation.

The objective of the present study was to evaluate the effect of antioxidant inclusion and oil quality on broiler performance, meat quality, shelf life, and tissue oxidative status. Ross 308 male broilers were allotted to a randomized complete block design in a 2 × 2 factorial arrangement. Factors consisted of antioxidant (ethoxyquin and propyl gallate) inclusion at 2 levels (0 or 135 mg/kg) and oil quality (fresh soybean oil, control diet peroxide value <1 mEq/kg, or oxidized soybean oil, diet peroxide value 7 mEq/kg). Each treatment included 12 pen replicates comprising 24 birds for a total of 1,152 birds on trial allotted to 48 pens. On the final day of the study, 1 bird from each pen was killed by cervical dislocation and used for determination of tissue oxidative status. Another 5 broilers from each pen were processed at a commercial slaughtering facility. Immediately after processing, carcasses were transported to the University of Illinois Meat Science Laboratory (Urbana) for further analysis. With the exception of 2 responses (liver vitamin A and serum vitamin A), no interactions were found between antioxidant inclusion and oil quality. Body weight and weight gain were increased by dietary antioxidant inclusion (P < 0.001) and fresh oil (P < 0.001). Feed intake was increased in broilers fed the antioxidant (P = 0.047) and fresh oil (P = 0.062). Antioxidant inclusion had no effect on G:F (P = 0.18). Antioxidant supplementation had no effect on carcass weight (P = 0.202), dressing percentage (P = 0.906), breast yield (P = 0.708), or breast ultimate pH (P = 0.625) and had minimal effect on breast color. Antioxidant supplementation (P = 0.057) reduced breast thiobarbituric acid reactive substances after 7 d of display. Fresh oil decreased liver thiobarbituric acid reactive substances, whereas antioxidant inclusion increased serum and liver vitamin A and E concentration. The presence of an antioxidant in the feed protects lipids from further oxidizing, therefore increasing broiler performance and improving shelf life when using oxidized oil.