Performance of a Handheld Near-Infrared Spectroscopy Device to Predict Pork Primal Belly Fat Iodine Value and Loin Lean Intramuscular Fat Content.

The increase in market demand and economic value of Canadian pork primal cuts has led to a need to assess advanced technologies capable of measuring quality traits. Fat and lean composition were measured using a Tellspec near-infrared (NIR) spectroscopy device to predict the pork belly fat iodine value (IV) and loin lean intramuscular fat (IMF) content in 158 pork belly primals and 419 loin chops. The calibration model revealed a 90.6% and 88.9% accuracy for the Tellspec NIR to predict saturated fatty acids (SFA) and IV, respectively, in the belly fat. The calibration model accuracy for the other belly fatty acids revealed an accuracy of 66.3-86.1%. Using the Tellspec NIR to predict loin lean IMF reported a lower accuracy for moisture (R2 = 60) and fat % (R2 = 40.4). This suggests that Tellspec NIR spectroscopy measures on the pork belly primal offers a cost-efficient, rapid, accurate, and non-invasive indicator of pork belly IV and could be used for the classification for specific markets.

Can In-Line Iodine Value Predictions (NitFomTM) Be Used for Early Classification of Pork Belly Firmness?

Commercial technologies for assessing meat quality may be useful for performing early in-line belly firmness classification. This study used 207 pork carcasses to measure predicted iodine value (IV) at the clear plate region of the carcass with an in-line near-infrared probe (NitFomTM), calculated IV of belly fat using wet chemistry methods, determined the belly bend angle (an objective method to measure belly firmness), and took dimensional belly measurements. A regression analysis revealed that NitFomTM predicted IV (R2 = 0.40) and belly fat calculated IV (R2 = 0.52) separately contributed to the partial variation of belly bend angle. By testing different NitFomTM IV classification thresholds, classifying soft bellies in the 15th percentile resulted in 5.31% false negatives, 5.31% false positives, and 89.38% correctly classified soft and firm bellies. Similar results were observed when the classification was based on belly fat IV calculated from chemically analyzed fatty acid composition. By reducing the level of stringency on the percentile of the classification threshold, an increase in false positives and decrease in false negatives was observed. This study suggests the IV predicted using the NitFomTM may be useful for early in-line presorting of carcasses based on expected belly firmness, which could optimize profitability by allocating carcasses to specific cutout specifications.

A Comparison of Fresh Pork Colour Measurements by Using Four Commercial Handheld Devices.

The objective of this study was to evaluate the performance of different low-cost instruments to measure pork colour in comparison to Minolta spectrophotometers and industry subjective standards. Canadian pork colour standards and commercial meat (252 loin chops and 46 tenderloins) were measured using two Minolta (CM 700D) spectrophotometers, four Nix sensors (two Nix Pro II and two Nix QC), and four Spectro devices (two Spectro 1 and two Spectro 1 Pro). Using Bland-Altman plots, all hand-held devices revealed similar performance on colour coordinates, except for the Nix Pro II, which had more variability on a* value, and Spectro 1 Pro on b* value, when compared to Minolta measurements. Low RSD values (< 5%) were obtained from repeated measurements on Canadian colour standards. The trend of colour coordinates on colour scores (0-6) were similar for all four commercial instruments, except for a* from Nix Pro and b* from Spectro 1. The correlation coefficients between subjective standards and colour coordinates from the Nix and Spectro devices were slightly higher than the Minolta spectrophotometers. Even though Nix and Spectro 1 series instruments generated different absolute colour coordinate values on meat samples, these pocket-size instruments presented great reliability to measure pork surface colour. However, operational limitations of the instruments, such as the internal calibration time between samples for the Spectro 1 series, should also be considered.

An image analysis approach to identification and measurement of marbling in the intact pork loin.

An image analysis method for identifying marbling on exposed boneless pork loin surfaces was developed, solving the problem of influences from uneven lean colour. Comparing results from RAW and JPEG images of the mid-loin pork chop showed that, except at very high marbling levels, estimation of %IMF (intramuscular fat) was similar with both image types (R2 = 0.72 and 0.74 respectively). Marbling calculated from JPEGs was positively related to %IMF, but also diverged as %IMF increased. Estimations of %IMF at the mid-loin chop from JPEGs of external loin sites showed marbling on the posterior face to be the most strongly related (r = 0.72, P < 0.0001), followed by the ventral surface (r = 0.62-0.64, P < 0.0001), and the anterior face (r = 0.56, P < 0.0001). For on-line application, computing speed is important. This study suggested that an image capture system could be reduced to the capture of a cyan-filtered monochrome JPEG image for analysis.

Evaluation of fresh meat quality by Hyperspectral Imaging (HSI), Nuclear Magnetic Resonance (NMR) and Magnetic Resonance Imaging (MRI): A review.

The development of non-destructive methodologies based on Hyperspectral Imaging (HSI), Nuclear Magnetic Resonance (NMR) and Magnetic Resonance Imaging (MRI) techniques to determine quality characteristics of fresh meat has been reviewed in this study. It has been focused primarily on research published in the last decade, and has placed particular attention on the instrumentation, data acquisition and main applications of each technique, finding a wide variety of possibilities for systems and methodologies as well as evidence of accurate and promising results. Most samples analysed were pork and beef, followed by lamb and chicken, with few studies on fresh meat from rabbit and duck. The overall evaluation is that work has been performed primarily in an experimental way but generally still lacks real application in the meat industry. In that respect, these non-destructive techniques should be improved, especially regarding speed, price and influence of external factors.

Effects of a novel three-step sous-vide cooking and subsequent chilled storage on the microbiota of beef steaks.

This study aimed to evaluate a novel three-step sous-vide (SV) method on bacterial growth and diversity, and its relationship to product storage life. Vacuum-packed naturally contaminated steaks were sequentially cooked at 39 °C (1 h), 49 °C (1 h), and 59 °C (4 h), then stored at -1.5 and 2 °C for 28 d, with a single-step SV at 59 °C for 4 h for comparison. None of the seven indicator bacteria tested proliferated (P > .05) after incubation at 39 or 49 °C; microbial diversity was also unaffected. Bacterial load was reduced (P < .05) by up to 5 log units with both (P > .05) SV methods. The odour of all steaks remained acceptable on d 28. Unexpectedly, during storage, Pseudomonas, not lactic acid bacteria, dominated the microbiota on steaks cooked by either SV method, likely due to the temperature shift-induced lag phase and/or heat sensitivity of psychrotrophic bacteria. In conclusion, the three-step SV did not lead to bacterial proliferation or compromise the storage life of cooked products.

Determination of optimum oven cooking procedures for lean beef products.

In order to determine optimum oven cooking procedures for lean beef, the effects of searing at 232 or 260°C for 0, 10, 20 or 30 min, and roasting at 160 or 135°C on semimembranosus (SM) and longissimus lumborum (LL) muscles were evaluated. In addition, the optimum determined cooking method (oven-seared for 10 min at 232°C and roasted at 135°C) was applied to SM roasts varying in weight from 0.5 to 2.5 kg. Mainly, SM muscles seared for 0 or 10 min at 232°C followed by roast at 135°C had lower cooking loss, higher external browning color, more uniform internal color, and were more tender and flavorful (P < 0.05). Roast weights ≥1 kg had lesser cooking loss, more uniform internal color and tender compared to 0.5 kg (P < 0.05). Consequently, roasting at low temperature without searing is the recommended oven cooking procedure; with best response from muscle roast weight ≥1 kg.

Carcass yields and meat quality characteristics of adult emus (Dromaius novaehollandiae) transported for 6h before slaughter.

The meat quality characteristics of adult emus transported for 6h before slaughter were determined. Forty-two emus were used in two trials, undertaken under warm and cool weather conditions, respectively. Male emus had significantly higher fat yields than females (12.43kg vs 9.5kg, P=0.002). About 38.1% of the emus had no wounds or bruises, 40.5% had bruises, while 21.4% had small wounds after transport. Meat from injured emus had significantly higher pH45. In warm weather, emus experienced significantly higher loss in body weight than that under cool weather. Drip loss in meat after 24h of storage was higher in emus which had greater live weight loss after transport (r=0.66, P<0.0001), confirming the adverse effects of transport stress on meat quality. Nutrient supplementation did not significantly affect processing yield or meat quality characteristics. This study points to the need for optimizing transport conditions of emus to maintain meat quality.

Improving beef hamburger quality and fatty acid profiles through dietary manipulation and exploitation of fat depot heterogeneity.

BACKGROUND: Hamburger is the most consumed beef product in North America, but lacks in nutritional appeal due to its high fat content and high proportion of saturated fatty acids (SFA). Objectives of the present study were to improve the FA profiles of hamburgers made with perirenal fat (PRF) and subcutaneous fat (SCF) when feeding steers different diets along with examining differences in sensory attributes and oxidative stability. Diets included a control diet containing 70:30 red clover silage: barley based concentrate, a diet containing sunflower-seed (SS) substituted for barley, and diets containing SS with 15% wheat dried distillers' grain with solubles (DDGS-15) or 30% DDGS (DDGS-30). Hamburgers were made from triceps brachii and either PRF or SCF (80:20 w/w). RESULTS: Perirenal fat versus SCF hamburgers FA had 14.3% more (P <0.05) 18:0, 11.8% less cis (c)9-18:1 (P <0.05), and 1.82% more total trans (t)-18:1 mainly in the form of t11-18:1. During sensory evaluation, PRF versus SCF hamburgers had greater (P <0.05) mouth coating, but the difference was less than one panel unit. Examining effects of steer diet within PRF hamburgers, feeding the SS compared to the control diet increased (P <0.05) t-18:1 by 2.89% mainly in the form of t11-18:1, feeding DGGS-15 diet led to no further changes (P >0.05), but feeding DDGS-30 diet reduced the proportions of (P <0.05) of t-18:1 chiefly t11-18:1. Feeding SS and DDGS diets had small but significant (P <0.05) effects on hamburger sensory attributes and oxidative stability. CONCLUSIONS: Feeding high-forage diets including SS and 15% DDGS, and taking advantage of the FA heterogeneity between fat depots offers an opportunity to differentially enhance beef hamburgers with 18:2n-6 biohydrogenation products (i.e., t11-18:1) with potential human health benefits without compromising their sensory attributes and oxidative stability during retail display.

Fortification of pork loins with docosahexaenoic acid (DHA) and its effect on flavour.

Pork is traditionally low in docosahexanoic acid (DHA, C22:6n-3) and deficient in omega-3 fats for a balanced human diet. DHA as triglycerides was commercially prepared from the microalgae Schizochytrium and injected into fresh pork loins. Treatments of a mixed brine control (CON), 3.1% sunflower oil in mixed brine (SF) and a 3.1% DHA oil in mixed brine (DHA) were injected into pork loins at 10 mL/100 g and grilled at 205°C. After cooking, the CON and SF pork loins contained 0.03 to 0.05 mg DHA/g of pork and the DHA injected loins contained approximately 1.46 mg DHA/g. This also changed the fatty acid profile of omega-6: omega-3 from, 5 to 1 in the CON pork, to a ratio of 1.7 to 1 in DHA pork. The appearance, odor, oxidation rates and sensory taste, as judged by a trained panel, determined the DHA injected meat to be, 'slightly desirable' and gave lower 'off flavour' scores, relative to the CON and SF injected pork. Pork can be fortified with DHA oil to 146 mg/100 g serving, which would meet half the recommended daily omega 3 fatty acid requirements for adult humans and would be desirable in taste.

Type of packaging affects the colour stability of vitamin E enriched beef.

Colour stability is a very important parameter for meat retail display, as appearance of the product is the deciding factor for consumers at time of purchase. This study investigated the possibility of extending appearance shelf-life through the combined use of packaging method (overwrapping - OVER, modified atmosphere - MAP, vacuum skin packaging - VSP and a combination of modified atmosphere and vacuum skin packaging - MAPVSP) and antioxidants (vitamin E enriched beef). Retail attributes (appearance, lean colour, % surface discolouration), as well as colour space analysis of images for red, green and blue parameters were measured over 18days. MAPVSP provided the most desirable retail appearance during the first 4days of retail display, while VSP-HB had the best colour stability. Overall, packaging type was more influential than α-tocopherol levels on meat colour stability, although α-tocopherol levels (>4µgg(-1) meat) had a protective effect when using high oxygen packaging methods.

Effects of dry-ageing on pork quality characteristics in different genotypes.

Presumably, dry-ageing enhances flavour attributes of meat by surface desiccation to increase and modify fatty acid content and other organoleptic molecules. However information regarding dry-ageing of fresh pork is limited. To examine the effects of dry-ageing on pork quality, Large White (LW, n = 24) and Large White × Duroc (Duroc, n = 24) barrows were slaughtered and three longissimus thoracis et lumborum sections from each side of the carcass were wet or dry-aged for 2, 7 or 14 d. Dry-aged meat had lower (P < 0.001) moisture and higher (P < 0.001) protein content due to higher purge losses (P < 0.001) when compared with wet aged meat. However no dry-ageing effect (P > 0.05) was observed on sensory characteristics. The increase in the duration of ageing decreased moisture content and drip loss and increased (P < 0.001) protein content, purge loss and L*, chroma and hue values. These changes were more accentuated in dry-aged meat (P < 0.01). Days of ageing dependent increases (P < 0.001) were observed for instrumental and sensory tenderness and juiciness in both ageing types. Moreover, meat from Duroc barrows had lower (P < 0.001) moisture and protein content, and higher (P < 0.01) fat content, L* and hue values. Instrumental and sensory tenderness, juiciness and flavour were higher (P < 0.01) in meat from Duroc than LW barrows. Increases (P < 0.01) in flavour intensity and decreases in off-flavour of meat from LW barrows were greater (P < 0.05) in d 7 than in d 14. Therefore the duration of ageing affected most quality and sensory characteristics, while the changes to quality attributes of dry versus wet-aged pork were attributable to the differences in shrink losses in the present study.

Production of docosahexaenoic acid (DHA) enriched bacon.

North American consumers interested in improving their health through diet perceive red meat as a source of too much saturated and unhealthy fat in the diet. The purpose of this trial was to produce bacon enriched with the long-chain omega-3 fatty acid, docosahexaenoic acid (DHA). In this 25 day study, pigs were fed a standard finisher diet of canola, pea, corn, and barley, mixed with DHA, added in the form of alga biomass. Bacon content of DHA was increased to 97 mg/100 g when 1 g of DHA was added to a kilogram of feed. The pigs fed the highest diet level of alga biomass, containing 0.29% DHA, produced bacon with approximately 3.4 mg of DHA/g and 1.2% of the fat as omega-3 fatty acids. Feed to gain was significantly improved, and carcass quality was unaffected. However, problems of off-odors and off-flavors were reported in the bacon from the taste panel survey. Polyunsaturated fat and potential unsaturated fat oxidation as indicated by malonaldehyde levels were significantly higher in the pigs fed the higher concentrations of DHA.