Campylobacter, Salmonella, and Escherichia coli on broiler carcasses subjected to a high pH scald and low pH postpick chlorine dip.

The objective of this study was to determine the individual and combined effects of a high pH scald and a postpick chlorine dip on bacteria present on broiler carcasses. In each of 3 replications, a flock was sampled at several sites within a commercial broiler processing plant. Carcasses were sampled by whole carcass rinse before and after treated scalding at mean pH 9.89 or control scalding at mean pH 6.88. Other carcasses from the same flock run on both the treated and control scald lines were collected and sampled before and after a chlorine dip tank operated at mean total chlorine level of 83.3 mg/kg and pH 6.04. Rinses were cultured for numbers of Campylobacter and Escherichia coli and presence or absence of Salmonella. High pH scald was more effective than standard scald to lessen the prevalence and numbers of Campylobacter on broiler carcasses; a lower prevalence was maintained through the postpick chlorine dip tank. The pH of the scald tank made no difference in numbers of E. coli recovered from broiler carcasses at any tested point on the processing line. High pH scald was not more effective than standard scald to lessen Salmonella prevalence. Furthermore, it is unclear why the postpick chlorine dip effectively lessened Salmonella prevalence on only the control scald line. Although no evidence exists that these treatments have an additive effect when used in series, each treatment shows some promise individually. Further optimization may result in more effective decontamination of broiler carcasses.

Ionized hypercalcemia in dogs: a retrospective study of 109 cases (1998-2003).

BACKGROUND: Serum hypercalcemia in dogs has been reported in association with a variety of diseases. Serum-ionized calcium (iCa) concentration is a more accurate measure of hypercalcemia than total serum calcium or corrected serum calcium concentrations. The severity of hypercalcemia has been utilized to suggest the most likely differential diagnosis for the hypercalcemia. HYPOTHESIS: Diseases causing ionized hypercalcemia may be different than those that cause increases in total or corrected serum calcium concentrations. The severity of ionized hypercalcemia in specific diseases cannot be used to determine the most likely differential diagnosis for ionized hypercalcemia. ANIMALS: One-hundred and nine client-owned dogs with a definitive cause for their ionized hypercalcemia evaluated between 1998 and 2003 were included in this study. METHODS: Retrospective, medical records review. RESULTS: Neoplasia, specifically lymphosarcoma, followed by renal failure, hyperparathyroidism, and hypoadrenocorticism were the most common causes of ionized hypercalcemia. Dogs with lymphoma and anal sac adenocarcinoma have higher serum iCa concentrations than those with renal failure, hypoadrenocorticism, and other types of neoplasia. The magnitude of serum-ionized hypercalcemia did not predict specific disease states. CONCLUSIONS AND CLINICAL IMPORTANCE: Serum-ionized hypercalcemia was most commonly associated with neoplasia, specifically lymphosarcoma. Although dogs with lymphosarcoma and anal sac adenocarcinoma had higher serum iCa concentrations than dogs with other diseases, the magnitude of the serum iCa concentration could not be used to predict the cause of hypercalcemia. Total serum calcium and corrected calcium concentrations did not accurately reflect the calcium status of the dogs in this study.

Prediction of physical, color, and sensory characteristics of broiler breasts by visible/near infrared reflectance spectroscopy.

The feasibility of predicting pH, color, shear force, and sensory characteristics of chicken breasts deboned at 2, 4, 6, and 24 h postmortem by visible/near infrared reflectance spectroscopy (NIRS) in the 400 to 1850 nm region was determined. Prediction of physical attributes of Commission Internationale de l'Eclairage (CIE) color values (L*, a*, and b*), pH, and shear force had better accuracies than those of individual sensory attributes. Calibration and validation statistics for shear force and sensory traits indicated that visible/near infrared models were not significantly improved for cooked muscles compared with predictions based on raw muscle characteristics. On the basis of predicted shear values from the partial least squares (PLS) model, breast samples were classified into "tender" and "tough" classes with a correct classification of 74.0% if the boundary was set at 7.5 kg. The model developed from measured shears using soft independent modeling of class analogy/principal components analysis (SIMCA/PCA) showed nearly the same classification success.

Principal component analysis of physical, color, and sensory characteristics of chicken breasts deboned at two, four, six, and twenty-four hours postmortem.

The effects of various postchill deboning times on functional, color, yield, and sensory attributes of broiler breast meat were determined. Broiler breast muscles were deboned at 2, 4, 6, and 24 h postmortem, and pH, color change, cooking yield, shear force values, and sensory traits of the breast meat were recorded. Data were examined by multivariate data analysis, namely principal component analysis (PCA). Averages of 13 variables (pH, delta a*, shear force, and sensory attributes of cardboardy, wet feathers, springiness, cohesiveness, hardness, moisture release, particle size, bolus size, chewiness, and metallic aftertaste-afterfeel) decreased gradually as deboning time increased from 2 to 24 h, especially for shear values after 4 h of postmortem aging. Univariate correlation coefficients among 24 variables indicated several significant correlations. Warner-Bratzler shear force had high positive correlations with 5 sensory texture attributes (cohesiveness, hardness, particle size, bolus size, and chewiness). The parameters of pH, delta L*, delta a*, delta b*, and cooking yield were not obviously correlated with shear force values or any of the 18 sensory characteristics. PCA score plot showed no clear separation of the breast muscles deboned at different postmortem times, but it was still possible to differentiate them. The loading biplot suggested that 18 variables were effective in sample differentiation, including delta L*, shear force, cooking yield, 6 sensory flavor attributes (brothy, cardboardy, wet feathers, blood/serumy, salty, and sour), all sensory texture attributes except springiness, and all afterfeel-aftertaste properties.

Effect of intestinal content contamination on broiler carcass Campylobacter counts.

Intestinal contents may contaminate broiler carcasses during processing. The objective of this study was to determine what effect various levels of intestinal contents had on the numbers of Campylobacter detected in broiler carcass rinse samples. Eviscerated broiler carcasses were collected from the shackle line in a commercial processing plant immediately after passing through an inside/outside washer. Broiler carcasses were cut longitudinally into contralateral halves using a sanitized saw. Cecal contents from the same flock were collected, pooled, homogenized, and used to contaminate carcass halves. Paired carcass halves were divided into groups of eight each, and then cecal contents (2, 5, 10, 50, or 100 mg) were placed onto one randomly selected half of each carcass, while the corresponding half of the same broiler carcass received no cecal contents. Campylobacter counts from carcass halves with cecal contamination were compared to the uncontaminated halves of the same carcasses using a paired t test. Carcass halves with 5 mg or more of surface cecal contamination had significantly higher numbers of Campylobacter than those without (P < 0.01). Carcass halves contaminated with only 5 mg of cecal contents had an average of 3.3 log CFU Campylobacter per ml of rinse, while corresponding uncontaminated carcass halves had 2.6 log CFU Campylobacter per ml of rinse. These data indicate that even small (5 mg) amounts of cecal contents can cause a significant increase in the numbers of Campylobacter on eviscerated broiler carcasses. Therefore, it is important to keep such contamination to a minimum during processing.

Effect of vitamin C addition to ground beef from grass-fed or grain-fed sources on color and lipid stability, and prediction of fatty acid composition by near-infrared reflectance analysis.

Research was conducted to determine the effect of postmortem vitamin C addition (VITC) versus no VITC (CONTROL) to ground beef from grass-fed (GRASS) or grain-fed (GRAIN) sources on color and lipid stability during 8 days of illuminated display at 4 °C. The use of near-infrared reflectance (NIR) spectroscopy to predict the fatty acid composition of ground beef and its potential to discriminate samples from different nutritional backgrounds were also evaluated. Total lipid content of ground beef was 53% lower (P<0.05) for GRASS than GRAIN. Ground beef from GRASS had greater (P<0.01) percentages of saturated (SFA) and polyunsaturated (PUFA) fatty acids, and lower (P<0.01) percentages of monounsaturated (MUFA) fatty acids than GRAIN. For GRAIN, VITC reduced (P<0.01) lipid oxidation, and resulted in darker (P<0.01) and redder (P<0.01) color of the ground beef from 2 to 8 days of display compared to CONTROL. For GRASS, lipid oxidation did not differ (P>0.05) for VITC and CONTROL. VITC improved (P<0.01) color stability by prolonging more red color in GRASS during 8 days of display. Results from partial least squares modeling showed accurate predictions using NIR for total saturated [standard error of performance (SEP=1.16%), coefficient of determination on the validation set (r(2)=0.87)] and unsaturated (SEP=1.18% and r(2)=0.90) fatty acid contents of ground beef, as well as the composition of stearic, oleic, and linolenic (SEP=1.2%, 1.27%, and 0.07%; r(2)=0.91, 0.92, and 0.93, respectively). However, the composition of other individual fatty acids was poorly predicted. VITC was effective in retarding pigment oxidation in ground beef from both GRAIN and GRASS; however, VITC reduced lipid oxidation in GRAIN samples only, despite higher PUFA percentages in GRASS. NIR can be used to predict accurately the content of total saturated and unsaturated, and stearic, oleic, and linolenic fatty acids in ground beef. NIR showed potential to discriminate meat samples originating from different feeding production systems.

Acid phosphatase activity and color changes in consumer-style griddle-cooked ground beef patties.

The U.S. Department of Agriculture and the Food and Drug Administration have issued temperature requirements to help consumers cook beef patty products that are free of pathogens. Verification of end-point temperature (EPT) is needed in cooked meat products due to concerns over outbreaks of Escherichia coli O157:H7. Acid phosphatase (ACP) activity was studied as a potential method for determination of EPT in ground beef patties cooked nonfrozen, patties frozen 7 days and thawed at room temperature 4 h in a refrigerator or by microwave, and patties made from ground beef frozen in store packages, then thawed in a refrigerator overnight. Pressed-out meat juices were analyzed from patties (n = 314) cooked to 57.2 degrees C (135 degrees F). 65.6 degrees C (150 degrees F), 71.1 degrees C (160 degrees F), and 79.4 degrees C (175 degrees F) target EPTs. Expressed meat juice and internal meat patty color decreased in redness as EPT increased. Freezing whole packs with slow refrigerator or room temperature thawing caused significantly greater loss of redness in expressed cooked meat juice than did other handling methods. Log10 ACP had a significant linear (R2 = 0.99) response to EPT. Results show that the 3- to 5-min ACP test could be used to verify EPT in griddle-cooked hamburger patties.

Rapid methods to determine potentially mineralizable nitrogen in broiler litter.

Although broiler (chicken, Gallus gallus domesticus) litter has long been used as a fertilizer, estimating the rate required to supply a desired amount of plant-available N is still hampered by the lack of rapid methods to estimate potentially mineralizable nitrogen (PMN). Previous research has suggested that near infrared reflectance spectroscopy (NIRS) and certain poultry litter characteristics, such as water-soluble organic nitrogen (WSON), may be useful for estimating PMN. The objectives of this study were to evaluate NIRS and WSON as tools to estimate PMN in broiler litter. Sixty sieved (2 mm) and freeze-dried broiler litter samples were mixed with Cowarts sandy loam soil (fine-loamy, kaolinitic, thermic Typic Kanhapludult) and incubated at 25 degrees C for 112 d. Cumulative net N mineralized with time was fitted to a single-pool exponential model to determine PMN for each broiler litter sample. The PMN values obtained were regressed against NIRS (780 to 2500 nm) and WSON measurements. We found strong relationships between measured- and NIRS-predicted PMN (R2 = 0.82), and between measured PMN and WSON (R2 = 0.87). These results demonstrate the feasibility of using either of these two methods to estimate PMN in broiler litter. Future work should further test both methods for their ability to estimate mineralizable N in whole, moist broiler litter under field conditions.

The microbiological profile of chilled and frozen chicken.

To determine the effect of different refrigeration and freezer temperatures on the microbiological profile of chicken, 50 commercially processed broiler chickens were each split in half on the day of processing. Equal groups were held at 4, 0, -4, -12, and -18 degrees C (40, 32, 26, 10, and 0 degrees F), respectively for 7 days. One half of each group was then transferred to a 0 degrees F holding chamber for an additional 7 days. Carcass halves were rinse sampled with 100 ml of phosphate-buffered saline and the diluent sampled for mesophilic, psychrotropic, coliform, and salmonellae counts after the initial 7 days at different temperatures and after 7 additional days at -18 degrees C. Ten carcass halves were sampled on the day of processing to give baseline counts. Mesophilic bacteria counts/ml were about log 4.6 on day 0, increased by 2 log after 7 days on carcasses held at 4 degrees C, and were unchanged at all other storage temperatures. Psychrotropic counts/ml were about log 3.6 on day 0 and increased during the initial 7 days by about 3.9, 1.9, and 1.4 logs, respectively on carcasses held at 4, 0, and -4 degrees C and had less than 1 log increase at -12 and -18 degrees C. Coliform counts were about log 2.2/ml on day 0 and had declined to about log 1.5/ml or less by day 7 for all storage temperatures. Escherichia coli counts/ml were about log 2 on day 0 and were reduced about 1 log or more at other storage days. Salmonellae counts were about log 1.5 on salmonellae-positive carcasses and did not change appreciably at any storage temperature. No counts for any organism significantly changed after placement at -18 degrees C.

Effect of method of analysis on iron content of beef from advanced meat recovery systems.

A field survey was conducted by the USDA, Food Safety Inspection Service (FSIS) to provide analytical data on meat obtained from beef cervical vertebrae processed by advanced meat recovery (AMR) systems. As a result, an added iron performance standard was proposed to limit the amount of marrow in AMR products. The performance standard was based on iron content of hand boned lean compared to AMR lean. Iron content was determined by a hydrochloric wet ash digestion method. The same samples were then analyzed using dry ash digestion. The objectives of the study were to determine differences in iron content of the survey samples due to the digestion method and the impact of this difference on the added iron performance standard. Iron values by the dry ash method were approximately double those of the wet ash method. The difference was a result of incomplete volatilization of the organic matrix by hydrochloric acid in the wet ash procedure. The performance standards developed from the wet and dry ash methods were 1.8 and 3.2 mg added iron 100(-1) g, respectively. Added iron levels from the dry ash method greater than 3.2 mg 100(-1) g were present in 60% of the AMR lean indicating that some marrow was present or that factors other than amount of iron in hand boned lean should be considered before a performance standard is established.

Exploring the relationship between reflectance red edge and chlorophyll concentration in slash pine leaves.

Chlorophyll concentration is related positively to the point of maximum slope in the reflectance spectra of leaves and this point is termed the red edge. The reflectance spectra of slash pine (Pinus elliottii Engelm.) needles were measured in the field and the chlorophyll concentrations of the same needles were measured in the laboratory. The measurement errors for red edge and chlorophyll concentration were determined to be 2.2 nm (3% of mean) and 0.35 mg g(-1) (19% of mean), respectively. The red edge-chlorophyll concentration relationship was strong (r(2) = 0.82, n = 152). A red edge-chlorophyll concentration relationship for n = 100 was used with red edge measurements to estimate chlorophyll concentration with an rms error of 0.31 mg g(-1) (17% of mean, n = 52). The entire red edge-chlorophyll concentration relationship for n = 152 was also used with red edge measurements to estimate the chlorophyll concentration of samples from an earlier experiment with an rms error of 0.47 mg g(-1) (30% of mean, n = 38). We conclude that measures of red edge can be used to estimate the chlorophyll concentration of detached needles in the field with an accuracy similar to that obtained by conventional laboratory measurements.

Physical degradation of lignified stem tissues by ruminal fungi.

Ruminal bacteria or fungi were selected by the addition of cycloheximide or streptomycin and penicillin, respectively, to ruminal fluid, and the weakening and degradation of lignified tissues in alfalfa and Bermuda grass stems by these treatments and whole ruminal fluid were evaluated in vitro. Dry weight loss in alfalfa was similar for whole ruminal fluid and streptomycin-penicillin treatment, whereas that with streptomycin-penicillin treatment was significantly higher (P

Determination of acid-detergent fiber and crude protein in forages by near-infrared reflectance spectroscopy: collaborative study.

A collaborative study was conducted to determine the standard error of difference among laboratories for near-infrared reflectance spectroscopic (NIRS) determination of acid-detergent fiber (ADF) and crude protein in forages. The 6 participating laboratories were members of the USDA/ARS National Near-Infrared Reflectance Spectroscopy Forage Research Project. The NIRS calibration equations were developed in the Associate Referee's laboratory for crude protein and ADF and were transferred to the instrument in each of the other collaborating laboratories. The calibration set included over 650 diverse forage samples with crude protein and ADF calibration data; the validation set included 94 samples of bermudagrass. Among-laboratory reproducibility for the NIRS method, calculated as the relative standard deviation for reproducibility (RSDR), was 1.14% for ADF and 0.42% for crude protein. The variance component for among-laboratory variation (coefficient of variation) was 2.54% for ADF and 2.89% for crude protein. These results confirm that it is possible to calibrate, validate, and transfer (NIRS) equations and data among laboratories for the accurate determination of ADF and crude protein, and thereby demonstrate that NIRS can be used as a standard method for the analysis of forages. The method has been adopted official first action.

Rumen fungi: morphological types from Georgia cattle and the attack on forage cell walls.

Fungal colonies developing in anaerobic media from zoospores in rumen fluid from cows eating Cynodon dactylon or Medicago sativa included types showing monocentric and polycentric growth. High energy supplements added to diets of Sorghum bicolor silage increased fungal numbers in the rumen, but increases were also affected by the history and predisposition of the animal. Mixed fungal types in rumen fluid and pure cultures of isolates showing monocentric and polycentric growth degraded and weakened lignocellulosic tissues and penetrated the cuticle of C. dactylon leaf blades. By weakening or degrading recalcitrant structures in forages, rumen fungi may alter physical parameters of plants that influence utilization of fibre by ruminants.

Rumen fungi and forage fiber degradation.

The role of anaerobic rumen fungi in in vitro forage fiber degradation was determined in a two forage x two inoculum source x five treatment factorial design. Forages used as substrates for rumen microorganisms were Coastal bermuda grass and alfalfa; inoculum sources were rumen fluid samples from a steer fed Coastal bermuda grass hay or alfalfa hay; treatments were whole rumen fluid (WRF), WRF plus streptomycin (0.2 mg/ml of rumen fluid) and penicillin (1.25 mg/ml of fluid), WRF plus cycloheximide (0.5 mg/ml of fluid), WRF plus streptomycin, penicillin, and cycloheximide, and McDougall buffer. Populations of fungi as shown by sporangial development were greater on bermuda grass leaves than on alfalfa leaflets regardless of inoculum source. However, endogenous fungal populations were greater from the alfalfa hay inoculum. Cycloheximide inhibited the fungi, whereas streptomycin and penicillin, which inhibit bacterial populations, resulted in an increase in numbers of sporangia in the alfalfa inoculum, suggesting an interaction between bacteria and fungi. Bacteria (i.e., WRF plus cycloheximide) were equal to the total population in degrading dry matter, neutral-detergent fiber (NDF), acid-detergent fiber (ADF), and cellulose for both inocula and both forages. Degradation of dry matter, NDF, ADF, and cellulose by anaerobic fungi (i.e., WRF plus streptomycin and penicillin) was less than that due to the total population or bacteria alone. However, NDF, ADF, and cellulose digestion was 1.3, 2.4, and 7.9 percentage units higher, respectively, for bermuda grass substrate with the alfalfa versus bermuda grass inoculum, suggesting a slight benefit by rumen fungi. No substantial loss of lignin (72% H(2)SO(4) method) occurred due to fungal degradation. The most active fiber-digesting population in the rumen was the bacteria, even when streptomycin and penicillin treatment resulted in an increase in rumen fungi over untreated WRF. The development of large numbers of sporangia on fiber may not indicate a substantial role as digesters of forage.