Air-classified faba bean protein fraction as a substitute to soybean meal in pelleted and extruded broiler diets.

1. The hypothesis that air-classified faba bean protein fraction (FBP) can replace soybean meal (SBM) in pelleted or extruded broiler diets without adverse effect on performance or nutrient digestibility was tested.2. At 17 d of age, male broilers were randomly distriibuted among four dietary treatments consisting of either SBM or FBP (main dietary protein source) and pelleting or extrusion as processing methods. Treatments had 10 replicate pens containing five birds each.3. Compared to SBM, birds fed FBP had significantly lower feed intake, less weight gain and had poorer feed conversion.4. Pellet durability was high (above 92%) for all diets. In pelleted diets, FBP was harder than SBM whereas extruded diets had similar hardness. Pelleting increased water stability compared to extrusion. FBP diets were more water stable than the SBM diets.5. Gizzard content weight was 2.2-fold higher (P = 0.002) for birds given FBP compared to those fed SBM. The weight of the jejunum and ileum with contents was 1.4-fold lower for the FBP diets, and this effect was larger (P < 0.05) for the extruded FBP diet.6. Birds fed FBP diets had significantly higher nitrogen digestibility in the lower jejunum and ileum compared to those given SBM diets, while the starch digestibility coefficient was above 0.980 in all treatments.7. The high nutrient digestibility of FBP diets indicates that the poor performance of the FBP group was due to lower feed intake which was not explained by the differences in pellet durability or hardness. The reduced palatability of the FBP and the longer retention of the FBP diets in the upper gut are more likely to have depressed feed intake.

Interactions between starch source and gelatinisation degree on performance and small intestinal digestion in broiler chickens.

1. A 2 × 2 factorial arrangement was used to test the hypothesis that, in pelleted diets, legume starch is digested less rapidly and to a lesser extent than cereal starch, and that increased gelatinisation through extrusion would eliminate the differences between the starch sources. In addition, the trial examined whether a lower ratio of starch to nitrogen disappearance rate (SNDR) could improve feed conversion ratio (FCR).2. At 17 d of age, male broilers were randomly distributed among four dietary treatments, consisting of either wheat or faba bean starch-rich fraction (FBS) as the sole starch source and pelleting or extrusion as processing methods. Each treatment had 10 replicate pens containing five birds each.3. Extrusion resulted in a more extensive starch gelatinisation compared to pelleting, as expected.4. No difference in weight gain at 29 d of age was observed between birds fed starch sources. However, birds fed wheat tended (P = 0.080) to have better FCR than those fed FBS, while the effect of processing methods was insignificant. Thus, there was no interaction between starch source and processing method on FCR.5. In pelleted diets, FBS had lower and slower starch digestibility compared to wheat in all intestinal segments (P < 0.05). The interaction between starch source and processing method in all intestinal segments (P < 0.001) demonstrated that FBS responded more to gelatinisation through extrusion than did wheat. Thus, differences in starch digestibility between the wheat and FBS were eliminated with extrusion.6. Feeding extruded diets significantly increased the upper jejunal expression of GLUT1, GLUT2 and SGLT1 compared to pelleted diets, which suggested that glucose absorption was less likely to be a limiting factor for starch utilisation.7. Pelleting resulted in a lower ratio (P < 0.001) of SNDR compared to extrusion (on average 1.4-fold) but did not improve FCR.