Effects of two wheat cultivars on physico-chemical properties of wheat flours and digesta from two broiler chicken lines (D+ and D-) differing in digestion capacity.

1. The current experiment is the second part of a study about the effects of wheat quality on digestibility of pelleted diets for broiler chickens. In the first part, it was shown that a hard cultivar resulted in a negative effect on starch digestibility in two divergent lines of chickens (D+ and D-) selected for digestion capacity. The aim of this second part was to investigate the reasons for this negative effect of a hard cultivar (Baltimor) compared to a soft one (Scipion) in D+ and D- lines. 2. Proventriculus pepsin activity and pancreas proteolytic and amylolytic activities were estimated in 4 pools of birds: 'D+ line (Baltimor fed)', 'D+ line (Scipion fed)', 'D- line (Baltimor fed)' and 'D- line (Scipion fed)'. Results suggested the greatest amount of pepsin units per g BW for D+ birds and the lowest amount of pancreas proteolytic units per g BW for D+ birds fed Scipion wheat. Pancreas showed very similar alpha-amylase activities among treatments. 3. In vitro hydrolyses of wheat gluten proteins with proventriculus extracts from pools of D+ and D- birds did not show any differences between hard and soft cultivars, whatever the origin of pools. 4. Pepsin hydrolysis of fine (300 to 425 microm) and coarse (1180 to 1600 microm) fractions from wheat flours (Baltimor or Scipion) showed that the 30 min proteolysis rate was highest for the fine fraction in both cultivars. No difference was observed with extended hydrolysis time. 5. In vitro digestion simulation of whole wheat flours confirmed the results previously obtained in vivo, with a negative effect of hard cultivar on starch digestion rate and no effect on protein digestion. 6. Laser particle size analyses showed that ileum digesta from birds fed with hard wheat cultivar showed the highest proportion of coarse particles. 7. Microscopic analyses of D+ ileum digesta revealed that the concentration of undigested starch granules in the subaleurone area of wheat bran particles was the highest with hard cultivar. 8. The results suggested that physical entrapment of starch granules in coarse particles was a major explanation for decreased starch digestibility values in chickens fed hard wheat diets.

Characterisation and foaming properties of hydrolysates derived from rapeseed isolate.

Two hydrolysis methods used to obtain rapeseed isolate derivates were compared: chemical hydrolysis performed under alkaline conditions and pepsic proteolysis performed under acidic conditions. The mean molecular weights obtained for the hydrolysates varied from 26 to 2.5 kDa, depending on the level of hydrolysis. Further characterisation showed that, at the same level of hydrolysis, the chemical hydrolysates differed by their charges and hydrophobicity from those derived from enzymatic digestion. Analysis of the foaming properties showed, for both cases, that a limited degree of hydrolysis, around 3%, was sufficient to optimise the foaming properties of the isolate despite the different physicochemical properties of the peptides generated. The study of foaming properties at basic, neutral and acidic pHs showed that the hydrolysate solutions yielded dense foams which drained slowly and which maintained a very stable volume under the three pH conditions tested.

Large scale purification of rapeseed proteins (Brassica napus L.).

Rapeseed (Brassica napus L.) cruciferin (12S globulin), napin (2S albumin) and lipid transfer proteins (LTP) were purified at a multi-g scale. The procedure developed was simple, rather fast and resolutive; it permitted the recovery of these proteins with a good yield, such as 40% for cruciferin and 18% for napin. Nanofiltration eliminated the major phenolic compounds. The remaining protein fraction was fractionated by cation exchange chromatography (CEC) on a streamline SP-XL column in alkaline conditions. The unbound neutral cruciferin was polished by size exclusion chromatography. The alkaline napin isoforms and LTP, adsorbed on the beads, were eluted as a whole fraction and further separated by an other CEC step at acidic pH. Napins were polished by hydrophobic interaction chromatography (HIC). The fractions were characterized by reverse phase HPLC, electrophoresis, N-terminal sequencing and mass spectrometry. All the fractions contained less than 5% of impurities.

The influence of the albumin fraction on the bioavailability and postprandial utilization of pea protein given selectively to humans.

Pulse seed proteins such as those found in peas (Pisum sativum) contain fractions of very dissimilar composition and properties, which may therefore be differently utilized by the human body. To analyze the nutritional value of the soluble protein fractions of pea seed, human volunteers ingested a mixed meal of 30 g of raw purified pea protein either as [15N]-globulins (G, n = 9) or as a mix of [15N]-globulins and [15N]-albumins (GA, n = 7) in their natural proportions (22:8). Dietary and endogenous nitrogen fluxes at the terminal ileum were assessed using a tube perfusion technique with an isotopic dilution method. Systemic dietary amino acid availability and the retention of dietary amino acids were determined using 15N enrichment in plasma amino acids and deamination products in blood and urine for 8 h postprandially. The results showed that the pea albumin fraction had the following effects: 1) significantly lowered the real ileal digestibility of pea protein (94 +/- 2.5% for G vs. 89.9 +/- 4% for GA), probably because of a direct effect of trypsin inhibitors; 2) did not promote acute intestinal losses of endogenous nitrogen; and 3) did not significantly improve the postprandial biological value of pea protein (76.5 +/- 3.9% for G vs. 78.7 +/- 3.6% for GA), despite the fact that it corrected the globulin deficiency in sulfur amino acids. We conclude that both G and GA are of good nutritional value for humans and show that cysteine-rich albumins have a far more modest effect on the efficiency of postprandial dietary protein utilization than would be expected from the amino acid scores.

Ultrafiltration to fractionate wheat polypeptides.

An ultrafiltration process allowing the fractionation of two kinds of polypeptides issued from limited chymotryptic hydrolysis of wheat gliadins was applied to wheat gluten hydrolysates. Hydrophilic and poorly charged polypeptides were well transmitted through an inorganic ZrO2-based membrane at acidic pH, whereas hydrophobic and positively charged polypeptides were highly retained. By combining reversed-phase and cation-exchange chromatography (CEC), it was proved that the fractionation of the polypeptides was based on electrostatic repulsion of the charged polypeptides by the positively charged membrane. After a continuous diafiltration process, retentates containing 75 to 88% of hydrophobic polypeptide and permeates containing 84 to 90% of hydrophilic polypeptides were recovered, depending on the size of membrane used. Even if the ultrafiltration fractions were less purified than fractions issued from CEC, it was shown that they exhibited very different foaming properties: permeate did not produce nor stabilize foams, whereas retentate was more efficient than the whole hydrolysates and BSA.

Fractionation of gliadin hydrolysates in water-ethanol by ultrafiltration with modified or unmodified membranes.

Ultrafiltration was applied to the fractionation of neutral vs. charged peptides of similar size. The peptides, produced from gliadins, a major fraction of wheat storage proteins, were obtained by limited hydrolysis with alpha-chymotrypsin in water-ethanol 80/20 (v/v). Peptides, according to their elution by RP-HPLC, were quasineutral (repetitive peptides) irrespective of pH, or positively charged (nonrepetitive peptides) at pH below 5. The transmission through the membranes of the nonrepetitive peptides was less (until sevenfold) than that of the repetitive ones, because of the role of electrostatic repulsion involved in the retention of charged solutes. The difference of transmission was more efficient at acidic pH (3) and low ionic strength with inorganic membranes and in a wider range of pH and ionic strength with membranes modified by coating of positively charged polymers (polyvinylimidazole PVI, polyethyleneimine PEI). A continuous diafiltration process using an inorganic membrane of low molecular cut-off permitted the selective enrichment of the retentate in nonrepetitive peptides (up to 80%) and of the permeate in repetitive peptides (up to 80%) from hydrolysate feed containing about 60/40% of repetitive and nonrepetitive peptides, respectively, with a diafiltration volume of 4.

Acetylation of pea isolate in a torus microreactor.

Acetylation, which acts on the amino groups of proteins, allows to increase the solubility and the emulsifying properties of pea isolate. Acetylation by acetic anhydride was carried out in a torus microreactor in semibatch and continuous conditions. The mixing characteristics, obtained by a residence time distribution (RTD) method, are the same in batch and continuous processes. The maximum acetylation degree reached by the torus reactor is higher than with the stirred reactor. Torus reactors are more efficient than stirred ones as shown by a conversion efficiency, defined by the quantity of modified lysine groups by consumed acetic anhydride. (c) 1997 John Wiley & Sons, Inc. Biotechnol Bioeng 53: 409-414, 1997.

Large scale procedure for fractionation of albumins and globulins from pea seeds.

The buffer extractable proteins of pea, albumins and globulins, were successively extracted in a large amount at a pilot scale. In order to preserve as much as possible the native structure of proteins, a selective solubilization step procedure was performed. Firstly, albumins were extracted with acetate buffer and secondly globulins with phosphate buffer of high ionic strength. Each extract was desalted by diafiltration without protein precipitation. From 15 kg of flour, 380 g of albumin fraction and 1000 g of globulin fraction were obtained with a protein content of 86.0% and 90.7% of dry matter respectively. The characterisation of albumin and globulin fractions by electrophoresis, ultracentrifugation and anion-exchange chromatography, showed that the cross-contamination of these two fractions was minimal.

Effects of diets containing casein and rapeseed on enzyme secretion from the exocrine pancreas in the pig.

The effect of dietary protein on enzyme activity of pancreatic juice was studied in ten growing, castrated, Large White male pigs. Animals, fitted with permanent cannulas in the pancreatic duct and in the duodenum, were divided into two groups receiving either casein or rapeseed concentrate as a protein source. After a 15 d adaptation period to the experimental diet, the volume of pancreatic secretion was significantly higher, whereas the protein concentration was lower in the casein group compared with the rapeseed group. No statistical difference was observed in the daily protein output between groups. Total secreted activities of carboxypeptidase A (EC 3.4.17.1), and elastase (EC 3.4.21.36) were higher in the casein group during the nocturnal period, whereas total activities of trypsin (EC 3.4.21.4), chymotrypsin (EC 3.4.21.1), carboxypeptidase B (EC 3.4.17.2) and amylase (EC 3.2.1.1) in pancreatic secretions during the post-prandial periods were increased by the ingestion of the rapeseed diet. It is concluded that the pancreatic enzyme secretion is sensitive to the nature of the protein ingested.